NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
298 reports49,000 miles · Jun 23, 2004
Structure
2001 DODGE CARAVAN WITH 49000 HAS A CRACKED FRAME. I HAVE NEVER HAD A COLLISION IN THIS VEHICLE. THE CAR IS UNSAFE TO DRIVE. MY VEHICLE HAS ONLY BEEN SERVICED BY DODGE SINCE BOUGHT IN DEC 2001. DODGE REFERRED ME TO AN AUTO BODY SHOP FOR REPAIR, AND SAID IF REPAIRS WERE EXPENSIVE TO TURN THE CAR OVER TO MY INSURANCE COMPANY. …
Read full complaint
2001 DODGE CARAVAN WITH 49000 HAS A CRACKED FRAME. I HAVE NEVER HAD A COLLISION IN THIS VEHICLE. THE CAR IS UNSAFE TO DRIVE. MY VEHICLE HAS ONLY BEEN SERVICED BY DODGE SINCE BOUGHT IN DEC 2001. DODGE REFERRED ME TO AN AUTO BODY SHOP FOR REPAIR, AND SAID IF REPAIRS WERE EXPENSIVE TO TURN THE CAR OVER TO MY INSURANCE COMPANY. I EMAILED DODGE AND THEY REPLIED THAT BECAUSE MY VEHICLE IS OVER 3YRS OLD OR 36,000 MILES I AM NOT COVERED.*AK
NHTSA ODI #10078701
Mileage unknown · Jun 23, 2004
Air Bags
CLOCK SPRING FAILURE. AIRBAG LIGHT CONSTANTLY GOING OFF AND ON. CONTACTED MANUFACTURER-STATED THAT NO RECALL ON MY VEHICLE, BUT THERE WERE SOME RECALLS FOR THAT YEAR AND MODEL, BUT MINE WAS NOT MANUFACTURED DURING THAT TIME FRAME. (???) TOLD THAT THE AIRBAG WOULD NOT WORK WHEN LIGHT WAS ON. RECALL NEEDED!!!!*AK
NHTSA ODI #10078671
40,000 miles · May 30, 2004
Visibility
BOTH THE DRIVER SIDE AND PASSENGER SIDE POWER WINDOWS HAVE FAILED WITH LESS THAN 51000 MILES AND 3 YEARS OF SERVICE ON THE VAN. THE WINDOWS START OFF BEING INTERMITTENT AND SLOW THEN EVENTUALLY FAIL, THE AMOUNT OF TIME FROM FIRST PROBLEM TO TOTAL FAILURE IS ABOUT A YEAR, BY THAT TIME THE WARRANTY RUNS OUT! *LA
NHTSA ODI #10074499
26,078 miles · May 29, 2004
Service Brakes, Hydraulic
STARTED 2001 GRAND CARAVAN EX AFTER SHOPPING RUN,ABS AND TRACTION CONTROL CHECK LIGHTS REMAINED ON. PULLED OVER TWICE AND RESTARTED,SAME LIGHTS STAYED ON. VEHICLE HAD 26,078 MILES ON IT WHEN THIS OCCURRED. CHECKED BRAKE FLUID LEVEL,O.K. LUCKILY FOR OUR FAMILY,THE VEHICLE STILL HAD ENOUGH BRAKE PEDAL PRESSURE,THOUGH COMPROMIS…
Read full complaint
STARTED 2001 GRAND CARAVAN EX AFTER SHOPPING RUN,ABS AND TRACTION CONTROL CHECK LIGHTS REMAINED ON. PULLED OVER TWICE AND RESTARTED,SAME LIGHTS STAYED ON. VEHICLE HAD 26,078 MILES ON IT WHEN THIS OCCURRED. CHECKED BRAKE FLUID LEVEL,O.K. LUCKILY FOR OUR FAMILY,THE VEHICLE STILL HAD ENOUGH BRAKE PEDAL PRESSURE,THOUGH COMPROMISED (SQUISHY,NOT FIRM, SECURE AND CONTROLLED AS IT WAS PRIOR TO THE OCCURRENCE), AND THE BRAKES COULD STILL BE USED TO STOP VEHICLE. CHECK THE VEHICLE AGAIN AFTER A FEW HOURS(CHECKED BRAKE FLUID AGAIN, ABS FUSE CHECKED-OUT O.K.,STARTED VEHICLE)NO CHANGE. NO CHANGE THE NEXT DAY. *LA
NHTSA ODI #10074475
55,138 miles · May 19, 2004
Latches/locks/linkagesPower TrainService Brakes, Hydraulic
1. THERE WERE NO WARNING SIGNS, ACCORDING TO THE MECHANIC IT WASN'T GOING BAD IT JUST WENT. 2. I WAS PULLING OUT OF A PARKING LOT INTO TRAFFIC WHEN SUDDENLY THE VEHICLE JUST STOPPED MOVING. I WAS MERGING INTO TRAFFIC AND INSTEAD OF GETTING OUT AND GOING I GOT OUT AND ALMOST GOT HIT. THE CAR COMING TOWARDS ME SLAMMED ON THE …
Read full complaint
1. THERE WERE NO WARNING SIGNS, ACCORDING TO THE MECHANIC IT WASN'T GOING BAD IT JUST WENT. 2. I WAS PULLING OUT OF A PARKING LOT INTO TRAFFIC WHEN SUDDENLY THE VEHICLE JUST STOPPED MOVING. I WAS MERGING INTO TRAFFIC AND INSTEAD OF GETTING OUT AND GOING I GOT OUT AND ALMOST GOT HIT. THE CAR COMING TOWARDS ME SLAMMED ON THE BREAKS AND WAS ABLE TO SWERVE AROUND ME. 3. THE REAR PLANITARY GEAR WELD FAILED, THIS FAILURE WAS DESCRIBED AS A SUDDEN CATASTROPHIC FAILOR. THE VEHICLE COULD NOT BE PUT INTO PARK. IT WAS TOWED INTO THE DEALERSHIP THEY SAID THE FLUID WAS BAD AND THE FILTER CLOGGED. THE VEHICLE HAS 55,000 MILES THEY SAY THE 7/70 WARRENTY DIDNT APPLY TO MY MODEL. THE SECOND MECHANIC SAID THERE WAS NOTHING WRONG WITH THE FILTER OR THE FLUID THAT THEY HAVE TO REPLACE A LOT OF THESE PART THE WELDS FAIL ALOT. I CALLED DIAMLER/CHRYSLER AND TOLD THEM WHAT THE MECHANIC SAID THAT I WANTED TO SEND THEM BACK THE PART THAT SHOWED THAT THE FAILURE WAS MANUFACTURER'S DEFECT THEY EXPLAINED TO ME THAT IT DIDN'T MATTER THAT IT WHY IT FAILED JUST THAT IT WAS OUT OF WARRANTY AND THEY DON'T WANT TO SEE THE PART. I WAS LUCKY THE NEXT PERSON MAY NOT BE. THE VEHICLE IS 2001 DODGE GRAND CARAVAN SPORT. SO FAR THE HATCH DOESN'T WORK WHEN THIS PART FAILED I WAS ALSO NOTIFIED THAT THE WHEEL CYLINDER ON THE REAR BRAKES FAILED AND THAT COULD HAVE CAUSED FIRE TO THE VEHICLE THE DEALERSHIP WANTED 4.000 PLUS TAX TO FIX THESE PROBLEMS. THE ENTIRE REAR BRAKING SYSTEM HAD TO BE REDONE AND THE TRANSMISSION HAD TO BE REBUILT. I HAVE DECIDED NOT TO DEAL WITH FIXING THE HATCH SO IT OPENS.*AK
NHTSA ODI #10072905
Mileage unknown · May 19, 2004
Seat Belts
THE RELEASE BUCKLES ON THE 2ND AND 3RD ROW SEATS OF 2001 DODGE GRAND CARAVAN ARE ABOVE THE BUCKLE AND CAN UNLATCH THE SEAT BELT BY OCCUPANTS ARMS OR OBJECTS IN THE SEAT IN AN ACCIDENT. THIS IS A DANGEROUS SITUATION AND NEEDS TO BE RECALLED ON ALL MODELS WITH THESE GEN3 CHRYSLER BELT BUCKLES. THE MINIVANS USUALLY CARRY CHILDREN…
Read full complaint
THE RELEASE BUCKLES ON THE 2ND AND 3RD ROW SEATS OF 2001 DODGE GRAND CARAVAN ARE ABOVE THE BUCKLE AND CAN UNLATCH THE SEAT BELT BY OCCUPANTS ARMS OR OBJECTS IN THE SEAT IN AN ACCIDENT. THIS IS A DANGEROUS SITUATION AND NEEDS TO BE RECALLED ON ALL MODELS WITH THESE GEN3 CHRYSLER BELT BUCKLES. THE MINIVANS USUALLY CARRY CHILDREN WHO ARE ALL AT RISK. THE 2004 AND 2005 MODELS OF THE DODGE AND CHRYSLER MINIVANS NOW HAVE THE GEN4 BELT BUCKLES WITH THE RECESSED RELEASE BUCKLES IN THE 2ND AND 3RD ROW SEATS.*AK
NHTSA ODI #10072852
38,500 miles · May 17, 2004
Power Train
I HEARD A WHINING NOISE COMING FROM TRANSMISSION, WITHOUT WARNING THE TRANSMISSION COMPLETELY WENT OUT. I ONLY HAVE 38K MILES ON MY VAN. THE BRAKES WENT OUT AT 20K MILES AND THEY ALREADY NEED REPLACED. THE WINDOWS STICK INTERMITTENTLY, AND WON'T ROLL UP. *AK
NHTSA ODI #10072717
34,000 miles · May 7, 2004
Steering
I OWN A 2001 GRAND CARAVAN SPORT. AT 35,000 MILES I BROUGHT IT TO A DEALER FOR THE 30,000 MILE CHECK AND TO SERVICE A GRINDING NOISE IN THE AC UNIT AND A SHUDDER WHEN TURNING AT SLOW SPEEDS. THEY FIXED THE AC AND SHUDDER BY TRUING THE ROTORS AND NEW PADS, HOWEVER THEY ALSO SAID THERE WAS A BULLETIN OUT ON THE STEERING PUMP AND…
Read full complaint
I OWN A 2001 GRAND CARAVAN SPORT. AT 35,000 MILES I BROUGHT IT TO A DEALER FOR THE 30,000 MILE CHECK AND TO SERVICE A GRINDING NOISE IN THE AC UNIT AND A SHUDDER WHEN TURNING AT SLOW SPEEDS. THEY FIXED THE AC AND SHUDDER BY TRUING THE ROTORS AND NEW PADS, HOWEVER THEY ALSO SAID THERE WAS A BULLETIN OUT ON THE STEERING PUMP AND THE UNIT WAS ON BACK ORDER...WOULD CALL WHEN IT CAME IN...YEAH RIGHT. AFTER AN ATTEMPT ON MY PART 3 MONTHS LATER TO LOCATE THIS PUMP, I GAVE UP TRYING AND CONTINUED DRIVING. AT 54,000 MILES, I AGAING BROUGHT IN MY CAR BECAUSE THE AC COMPRESSOR FAILED DUE TO ANOTHER BULLETIN ON THE PCM UNIT. I INQUIRED ABOUT FIXING THE OLD PROBLEM WITH THE PUMP AND THEY ADMITTED THEY MADE A MISTAKE BY NOT ORDERING THE PUMP OR CONTACTING ME BUT THEY WOULD NOT HONOR THE REPAIR BECAUES IT WAS NOW OUT OF WARRANTY AND THEY WOULD HAVE TO PAY FOR IT...EVEN THOUGH IT WAS UNDER WARRANTY WHEN I BROUGHT IT IN AND THEY ADMIT TO THEIR MISTAKE!!! NEVER AGAIN FOR DODGE...IN FACT, WE ARE SELLING IT TO BUY A HONDA.*AK
NHTSA ODI #10068470
27,000 miles · Apr 26, 2004
EquipmentService Brakes, HydraulicVisibility
VEHICLE HAS 37000 MILES AND HAS HAD FRONT BRAKES REPLACED (25000 MILES) / NEW DRIVER SIDE POWER WINDOW MOTOR ASSY. INSTALLED (NOT UNDER WARRANTY @ COST OF $210 +) / FRONT SWAY BAR REPAIRED (NOT UNDER WARRANY EITHER) AND NOW THE AIR CONDITIONONG IS NOT WORKING.....DEALER SAYS IT WILL HAVE TO REPLACE THE COMPLETE SYSTEM...ESTIMATE…
Read full complaint
VEHICLE HAS 37000 MILES AND HAS HAD FRONT BRAKES REPLACED (25000 MILES) / NEW DRIVER SIDE POWER WINDOW MOTOR ASSY. INSTALLED (NOT UNDER WARRANTY @ COST OF $210 +) / FRONT SWAY BAR REPAIRED (NOT UNDER WARRANY EITHER) AND NOW THE AIR CONDITIONONG IS NOT WORKING.....DEALER SAYS IT WILL HAVE TO REPLACE THE COMPLETE SYSTEM...ESTIMATE IS FOR $1,284 PLUS TAX!!!) ARE YOU KIDDING ME! I HAVE NO FAITH IN THE DODGE GRAN CARAVAN PRODUCT. THIS IS A $30K VEHICLE. IT SHOULD NOT BE HAVING THESE KIND OF ISSUES W/ ONLY 37000 HIGHWAY MILES.*AK
NHTSA ODI #10067873
29,000 miles · Apr 23, 2004
Seat BeltsCrashInjury
WHEN INVOLVED IN AN ACCIDENT MY SONS SEAT BELT UNLATCHED CAUSING HIM TO BE THROWN FOWARD, LUCKLY HE SURVIVED THE ACCIDENT WITH ONLY BUMBS, CUTS AND BRUISES. THE REPAIR SHOP TOLD ME THE BELT SEAMED FINE, BUT I HAVE BEEN BOTHERED BY THIS EVER SINCE AND DID MY OWN RESEARCH TO DISCOVER THAT THIS IS A KNOW PROBLEM AND THEY NO LONGER…
Read full complaint
WHEN INVOLVED IN AN ACCIDENT MY SONS SEAT BELT UNLATCHED CAUSING HIM TO BE THROWN FOWARD, LUCKLY HE SURVIVED THE ACCIDENT WITH ONLY BUMBS, CUTS AND BRUISES. THE REPAIR SHOP TOLD ME THE BELT SEAMED FINE, BUT I HAVE BEEN BOTHERED BY THIS EVER SINCE AND DID MY OWN RESEARCH TO DISCOVER THAT THIS IS A KNOW PROBLEM AND THEY NO LONGER USE THIS TYPE OF BUCKLE. CRYSLER REFUSED TO CHANGE MY BUCKLES TO THE NEW KIND AND I FEAR IF IN ANOTHER ACCIDENT IT COULD BE FATAL.*AK
NHTSA ODI #10067735
NHTSA investigations
3EA05009 · Headlight Malfunction
Opened Jun 1, 2005 · Closed May 2, 2006
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (3)
Electrical System
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
PE05004 · Headlight Malfunction
Opened Feb 2, 2005 · Closed Jun 1, 2005
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
EA04031 · Power Liftgate Latch
Opened Nov 22, 2004 · Closed Apr 7, 2005
Status: closed (inferred from source dates) · Latches/locks/linkages; Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Additional source detail variants (2)
Latches/locks/linkages
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Illustration