THE FRONT TIRE ON THE VAN STARTED LOSING AIR. I CHECKED TO SEE WHERE THE LEAK WAS AND FOUND TWO CRACKS IN THE WHEEL THAT WERE LEAKING. THERE IS NO SIGN OF IMPACT ON THE WHEEL AND THE CRACKS ARE NOT PARALLEL TO THE BEAD. THE CRACKS RUN 90 DEGREES FROM THE WHEEL BEAD. THESE ARE THE 17 INCH CHROME WHEELS. NO DAMAGE CAUSED BUT I WIL…
Read full complaint
THE FRONT TIRE ON THE VAN STARTED LOSING AIR. I CHECKED TO SEE WHERE THE LEAK WAS AND FOUND TWO CRACKS IN THE WHEEL THAT WERE LEAKING. THERE IS NO SIGN OF IMPACT ON THE WHEEL AND THE CRACKS ARE NOT PARALLEL TO THE BEAD. THE CRACKS RUN 90 DEGREES FROM THE WHEEL BEAD. THESE ARE THE 17 INCH CHROME WHEELS. NO DAMAGE CAUSED BUT I WILL HAVE TO REPLACE THE WHEEL AT A QUOTED COST OF $625.00. I HAVE NOT CHECKED THE OTHER WHEELS YET.*JB
NHTSA ODI #10183573
Mileage unknown · Nov 15, 2005
Tires
DT: CONTACT STATES THERE WAS A FAILURE ON THE SIDEWALL OF THE TIRE THAT CAUSED COMPLETE LOSS OF TIRE PRESSURE. THE TIRE WAS A GOODYEAR INTEGRITY. HE HAD THE TIRE REPLACED WITH THE EXACT BRAND OF TIRE. DURING THE SAME MONTH, ANOTHER TIRE EXPERIENCED THE SAME PROBLEM. THE REPLACEMENT AGAIN, WAS THE SAME BRAND OF TIRE. THE TIRE…
Read full complaint
DT: CONTACT STATES THERE WAS A FAILURE ON THE SIDEWALL OF THE TIRE THAT CAUSED COMPLETE LOSS OF TIRE PRESSURE. THE TIRE WAS A GOODYEAR INTEGRITY. HE HAD THE TIRE REPLACED WITH THE EXACT BRAND OF TIRE. DURING THE SAME MONTH, ANOTHER TIRE EXPERIENCED THE SAME PROBLEM. THE REPLACEMENT AGAIN, WAS THE SAME BRAND OF TIRE. THE TIRE DEALER SAID THE FAILURES WERE NOT DUE TO A DEFECT IN THE TIRES. AFTER APPROXIMATELY 7 MONTHS ONE OF THE NEW TIRES STARTED EXPERIENCING THE SAME PROBLEM. *NM
NHTSA ODI #10142749
94,800 miles · Aug 12, 2005
Tires
DT: THE CONSUMER OBSERVED DEEP IMPRESSIONS ON THE TREAD OF TIRE LOCATED ON THE FRONT DRIVERS SIDE. THE TIRE DEFLATED BECASUE OF A NAIL. THE CONSUMER TOOK THE VEHICLE TO A DEALER TO BUY A NEW TIRE. GOODYEAR DID ALLOW A $30 ADJUSTMENT FOR THE DEFECT. THIS OCCURRED WHEN THE TIRE HAD 25000-30,000 MILES ON IT. THE SECOND INCIDENT…
Read full complaint
DT: THE CONSUMER OBSERVED DEEP IMPRESSIONS ON THE TREAD OF TIRE LOCATED ON THE FRONT DRIVERS SIDE. THE TIRE DEFLATED BECASUE OF A NAIL. THE CONSUMER TOOK THE VEHICLE TO A DEALER TO BUY A NEW TIRE. GOODYEAR DID ALLOW A $30 ADJUSTMENT FOR THE DEFECT. THIS OCCURRED WHEN THE TIRE HAD 25000-30,000 MILES ON IT. THE SECOND INCIDENT OCCURRED ON THE PASSENGER FRONT TIRE. THE CONSUMER'S WIFE WAS DRIVING ON A PAVED HIGHWAY ROAD IN RAINY CONDITIONS WHEN SHE BEGAN TO EXPERIENCE STEERING DIFFICULTIES AND A SHIMMY IN THE STEERING COLUMN. THE CONSUMER INSPECTED THE VEHICLE AND NOTED THERE WAS A LARGE BULGE ON THE SIDEWALL OF THE TIRE. THE VEHICLE WAS NOT DRIVEN AFTER THIS WAS NOTICED. OVERNIGHT THE TIRE WENT FLAT. THERE WAS 30-35,000 MILES ON THE TIRE AT TIME OF FAILURE. THE CONSUMER TOOK THE TIRE OFF THE VEHICLE AND TOOK THE TIRE TO DEALER. DEALER DID NOT HAVE ANOTHER TIRE TO REPLACE WITH SO THE VEHICLE IS CURRENTLY AWAITING A SPARE. CONSUMER HAD TO AWAIT FOR A TIRE FOR THE FIRST FAILURE AS WELL. GOODYEAR, EAGLE, SIZE 215/65R16. EAGLE LS. THESE TIRES WERE PURCHASED THROUGH THE DEALERSHIP FROM WHERE THE VEHICLE WAS PURCHASED. *AK *JB
NHTSA ODI #10128121
94,800 miles · Aug 12, 2005
Tires
DT: CONSUMER OBSERVED DEEP IMPRESSIONS ON THE TREAD ON THE FRONT DRIVER SIDE TIRE. THE TIRE DEFLATED BECAUSE OF A NAIL IN THE EDGE OF THE TIRE. THE CONSUMER TOOK THE TIRE TO VEHICLE DEALER AND BOUGHT A NEW TIRE AND RECEIVED AN ADJUSTMENT OF $30 FROM GOODYEAR FOR THE DEFECT. THERE WAS ABOUT 25-30,000 MILES ON THE TIRE WHEN THE …
Read full complaint
DT: CONSUMER OBSERVED DEEP IMPRESSIONS ON THE TREAD ON THE FRONT DRIVER SIDE TIRE. THE TIRE DEFLATED BECAUSE OF A NAIL IN THE EDGE OF THE TIRE. THE CONSUMER TOOK THE TIRE TO VEHICLE DEALER AND BOUGHT A NEW TIRE AND RECEIVED AN ADJUSTMENT OF $30 FROM GOODYEAR FOR THE DEFECT. THERE WAS ABOUT 25-30,000 MILES ON THE TIRE WHEN THE DEFECT OCCURRED. THE SECOND INCIDENT OCCURRED ON THE PASSENGER FRONT. THE TIRE DEVELOPED A LARGE BULGE ON THE SIDEWALL. CONSUMER STOPPED DRIVING THE SECOND IT WAS NOTICED. AND OVERNIGHT IT WENT FLAT. THIS WAS DISCOVERED AFTER EXPERIENCING STEERING DIFFICULTIES AND AN ABNORMAL SHIMMY IN THE STEERING COLUMN. THE WAS DRIVING ON THE HIGHWAY PAVED ROAD IN RAINY CONDITIONS. THE MILEAGE ON TIRE AT THIS TIME 30-35,00 0. CONSUMER TOOK THE TIRE OFF VEHICLE AND TOOK IT TO THE VEHICLE DEALER. THE DEALER DID NOT ANOTHER TIRE TO REPLACE IT WITH SO VEHICLE IS CURRENTLY AWAITING A SPARE, THIS HAPPENED THE FIRST TIME AS WELL. NO REPLACEMENTS AT THIS TIME. GOODYEAR MAKE, MODEL EAGLE, SIZE 215/65/R16. EAGLE MS. *JB *TT
NHTSA ODI #10128112
31,840 miles · Feb 7, 2005
Tires
MICHELIN MX4 TIRES ON 2001 DODGE GRAND CARAVAN SPORT, VEHICLE HAS ONLY 31,840 MILES ON IT AND TIRES THREAD ARE WORN SEVERELY AND METAL FROM RADIAL IS EXPOSED. I ALREADY HAD TO REPLACE 1 TIRES BECAUSE OF SIDE THREAD WORN, THIS NOW MAKES 3 (1ST TIRE REPLACED UNDER 25,000 MILES. THIS IS A REAL SAFETY ISSUE FOR OUR FAMILY VEHICLE A…
Read full complaint
MICHELIN MX4 TIRES ON 2001 DODGE GRAND CARAVAN SPORT, VEHICLE HAS ONLY 31,840 MILES ON IT AND TIRES THREAD ARE WORN SEVERELY AND METAL FROM RADIAL IS EXPOSED. I ALREADY HAD TO REPLACE 1 TIRES BECAUSE OF SIDE THREAD WORN, THIS NOW MAKES 3 (1ST TIRE REPLACED UNDER 25,000 MILES. THIS IS A REAL SAFETY ISSUE FOR OUR FAMILY VEHICLE AND ACTION SHOULD BE TAKEN. *JB
ON CERTAIN MINI VANS, CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DROP THROUGH VENT HOLES IN THE TOP OF THE RADIO AND RESULT IN A SHORT CIRCUIT THAT SUBSEQUENTLY SENDS DIRECT CURRENT TO THE REAR SPEAKERS.
Consequence & remedy
Consequence: THIS COULD RESULT IN A SPEAKER FIRE.
Remedy: DEALERS WILL ADD A SPECIAL TAPE TO THE TOP OF THE RADIO TO PREVENT THE POTENTIAL OF WATER INTRUSION. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
VEHICLE DESCRIPTION: MINIVANS. THE LOWER CONTROL ARM PIVOT BOLT COULD FRACTURE.
Consequence & remedy
Consequence: IF THE BOLT FRACTURES, THE LOWER CONTROL ARM COULD SEPARATE FROM THE CROSSMEMBER, CAUSING A LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT LOWER CONTROL ARM BOLTS AND NUTS. OWNER NOTIFICATION BEGAN APRIL 30, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (3)
Electrical System
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
EA04031 · Power Liftgate Latch
Opened Nov 22, 2004 · Closed Apr 7, 2005
Status: closed (inferred from source dates) · Latches/locks/linkages; Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Additional source detail variants (2)
Latches/locks/linkages
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
2001 Dodge Grand Caravan Problems, Complaints & Recalls | Skip That Year
Illustration