IllustrationCLOCK SPRING. HORN, CRUISE CONTROL STOP WORKING. AIRBAG LIGHT ON. CHRYSLER WILL NOT ACKNOWLEDGE, AS WELL AS LOCAL DEALER AS A PROBLEM AND/OR A SAFETY NOR A RECALL ISSUE.
2001 Dodge Grand Caravan
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2001 Dodge Grand Caravan do not stand out strongly from the model-year median of 284.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
130–25K
5325–50K
5150–75K
4175–100K
31100–150K
11150K+
200 reports with mileage · 98 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
9 crash reports1 fire reports8 injury reports
Air Bags complaints
48 reportsTHE AIRBAG WARNING LIGHT STAYS ON ALL THE TIME. AT THE SAME TIME THE SPEED CONTROL STOPPED WORKING AND THE HORN DOES NOT WORK
TL* THE CONTACT OWNS A 2001 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT CONTINUOUSLY ILLUMINATED. ALSO, THE CONTACT MENTIONED THAT THE BUTTONS ON THE STEERING WHEEL WOULD NOT WORK. THE DEALER STATED THAT THE FAILURE MIGHT BE DUE TO A DEFECTIVE CLOCK SPRING. IF A CRASH OCCURRED, THE AIR BAG COULD POTEN…
Read full complaint
TL* THE CONTACT OWNS A 2001 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT CONTINUOUSLY ILLUMINATED. ALSO, THE CONTACT MENTIONED THAT THE BUTTONS ON THE STEERING WHEEL WOULD NOT WORK. THE DEALER STATED THAT THE FAILURE MIGHT BE DUE TO A DEFECTIVE CLOCK SPRING. IF A CRASH OCCURRED, THE AIR BAG COULD POTENTIALLY NOT DEPLOY. THE VEHICLE HAD NOT BEEN REPAIRED AND THE MANUFACTURER HAD NOT BEEN NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 138,000.
TL* THE CONTACT OWNS A 2001 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS, THE AIR BAG WARNING LIGHT ILLUMINATED INTERMITTENTLY AND WHENEVER THE CONTACT WOULD ATTEMPT A TURN. THE LIGHT REMAINED ILLUMINATED AS THE FAILURE PROGRESSED. THE CONTROLS ON THE STEERING WHEEL FAILED AND LATER, THE HORN ALSO FA…
Read full complaint
TL* THE CONTACT OWNS A 2001 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS, THE AIR BAG WARNING LIGHT ILLUMINATED INTERMITTENTLY AND WHENEVER THE CONTACT WOULD ATTEMPT A TURN. THE LIGHT REMAINED ILLUMINATED AS THE FAILURE PROGRESSED. THE CONTROLS ON THE STEERING WHEEL FAILED AND LATER, THE HORN ALSO FAILED. AFTER PERFORMING EXTENSIVE RESEARCH, THE CONTACT CONCLUDED THAT THE CLOCK SPRING FAILED. THE DEALER AND MANUFACTURER WERE BOTH NOTIFIED AND NEITHER OFFERED ANY ASSISTANCE TO THE CONTACT. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 151,000 AND THE CURRENT MILEAGE WAS 166,000.
OWN A 2001 DODGE GRAND CARAVAN. PASSENGER SIDE AIRBAG DEPLOYED IMMEDIATLEY AFTER VAN PLACED IN PARK AND IGNITION TURNED OFF. ONE MONTH LATER, DRIVER'S SIDE AIRBAG ALSO DEPLOYED IMMEDIATELY AFTER BEING PLACED IN PARK AND IGNITION TURNED OFF. NO PREVIOUS WARNING LIGHTS OR INDICATORS.
THERE WAS NO EVENT LEADING TO THIS FAILURE, MY AIRBAG LIGHT HAS BEEN CONTINUOUSLY ON FOR A FEW DAYS, AND NOW MY HORN AND CRUISE CONTROL DO NOT WORK. AFTER RESEARCHING THIS PROBLEM I HAVE COME ACROSS A RECALL FOR THE CLOCK-SPRING, WHICH ONLY INCLUDES 1998-2000 MODELS. BUT HAVE ALSO READ NUMEROUS COMPLAINTS OF IT ON THE 2001 MOD…
Read full complaint
THERE WAS NO EVENT LEADING TO THIS FAILURE, MY AIRBAG LIGHT HAS BEEN CONTINUOUSLY ON FOR A FEW DAYS, AND NOW MY HORN AND CRUISE CONTROL DO NOT WORK. AFTER RESEARCHING THIS PROBLEM I HAVE COME ACROSS A RECALL FOR THE CLOCK-SPRING, WHICH ONLY INCLUDES 1998-2000 MODELS. BUT HAVE ALSO READ NUMEROUS COMPLAINTS OF IT ON THE 2001 MODEL AS WELL. I HAVE SENT AN EMAIL TO DAIMLER CHRYSLER AND HAVE NOT GOTTEN A RESPONSE YET. I HOPE IT DOES NOT TAKE A SERIOUS INJURY OR A DEATH TO HAVE THIS PART OF THE ORIGINAL RECALL. *TR
AIR BAG LIGHT COMES ON INTERMITTENTLY. THIS HAS BEEN GOING ON FOR AT LEAST THREE YEARS. I TOOK IT TO MY MECHANIC WHO SAID THERE WAS A RECALL ON MY MODEL BUT ONLY UP TO YEAR 2000(FIGURES). MECHANIC REPLACED "CLOCKSPRING" BUT PROBLEM PERSISTS. MECHANIC SAID IF LIGHT ON DURING AN IMPACT, AIR BAGS WILL NOT DEPLOY. I SUPPOSE SOMEONE …
Read full complaint
AIR BAG LIGHT COMES ON INTERMITTENTLY. THIS HAS BEEN GOING ON FOR AT LEAST THREE YEARS. I TOOK IT TO MY MECHANIC WHO SAID THERE WAS A RECALL ON MY MODEL BUT ONLY UP TO YEAR 2000(FIGURES). MECHANIC REPLACED "CLOCKSPRING" BUT PROBLEM PERSISTS. MECHANIC SAID IF LIGHT ON DURING AN IMPACT, AIR BAGS WILL NOT DEPLOY. I SUPPOSE SOMEONE MUST DIE OR FILE SUIT BEFORE ANYTHING IS DONE FOR ALL OF US 2001 CARAVAN OWNERS. A RECALL TO FIX THIS SHOULD DEFINITELY BE CONSIDERED / INSTITUTED! *TR
I HAVE 2001 DODGE GRAND CARAVAN. THE CLOCKSPRING WENT BAD. THERE ARE RECALL ON MANY VEHICLE ON PREVIOUS YEAR. THE DEALER TOLD ME THAT 2001 IS NOT ON THE RECALL LIST AND IT WILL COST AROUND $250 TO REPAIR IT. IT HAS BEEN KNOWN THE CLOCKSPRING WAS A PROBLEM THEY MIGHT TRIED TO FIX THE PROBLEM IN 2001 MODEL BUT IT IS NOT PERFECT. 2…
Read full complaint
I HAVE 2001 DODGE GRAND CARAVAN. THE CLOCKSPRING WENT BAD. THERE ARE RECALL ON MANY VEHICLE ON PREVIOUS YEAR. THE DEALER TOLD ME THAT 2001 IS NOT ON THE RECALL LIST AND IT WILL COST AROUND $250 TO REPAIR IT. IT HAS BEEN KNOWN THE CLOCKSPRING WAS A PROBLEM THEY MIGHT TRIED TO FIX THE PROBLEM IN 2001 MODEL BUT IT IS NOT PERFECT. 2001 SHOULD BE IN THE RECALL LIST..... *TR
MY 2001 DODGE GRAND CARAVAN AIRBAG LIGHT IS ON. MY HORN AND CRUISE CONTROL DO NOT WORK AS A RESULT. CONTACT DODGE VIA EMAIL AND WAS TOLD THIS WAS NOT A RECALL ITEM FOR MY DODGE GRAND CARAVAN. THIS SEEMS TO BE A "CLOCKSPRING" ISSUE. THIS WAS A ISSUE ON THE 2000 DODGE CARAVAN- RECALL NUMBER 04V480000. *TR
AIRBAG LIGHT COMES ON INTERMITTENTLY, PARTICULARLY ON TURNS. TALKED WITH LOCAL CHRYSLER DEALER AND HIS ASSESSMENT POINTED TO THE CLOCKSPRING. RESEARCHED ON INTERNET AND IT CERTAINLY APPEARS THERE IS AN ISSUE WITH THIS ITEM. DEALER INDICATED IT IS NOT COVERED BY WARRANTIES OR RECALL AND WOULD COST IN EXCESS OF $200 TO REPLACE.…
Read full complaint
AIRBAG LIGHT COMES ON INTERMITTENTLY, PARTICULARLY ON TURNS. TALKED WITH LOCAL CHRYSLER DEALER AND HIS ASSESSMENT POINTED TO THE CLOCKSPRING. RESEARCHED ON INTERNET AND IT CERTAINLY APPEARS THERE IS AN ISSUE WITH THIS ITEM. DEALER INDICATED IT IS NOT COVERED BY WARRANTIES OR RECALL AND WOULD COST IN EXCESS OF $200 TO REPLACE. I BELIEVE THIS TO BE A MANUFACTURERS DEFECT AND SHOULD BE REPLACED AT NO COST TO THE CUSTOMER. NO ACCIDENTS OR ADVERSE EFFECTS ENCOUNTERED TO DATE. *TR
Official recalls
304V531000 · Equipment:electrical:radio/tape Deck/cd Etc.
Nov 2, 2004
ON CERTAIN MINI VANS, CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DROP THROUGH VENT HOLES IN THE TOP OF THE RADIO AND RESULT IN A SHORT CIRCUIT THAT SUBSEQUENTLY SENDS DIRECT CURRENT TO THE REAR SPEAKERS.
Consequence & remedy
Consequence: THIS COULD RESULT IN A SPEAKER FIRE.
Remedy: DEALERS WILL ADD A SPECIAL TAPE TO THE TOP OF THE RADIO TO PREVENT THE POTENTIAL OF WATER INTRUSION. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
03V094000 · Structure
Mar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
01V152000 · Suspension:front:control Arm:lower Arm
May 8, 2001
VEHICLE DESCRIPTION: MINIVANS. THE LOWER CONTROL ARM PIVOT BOLT COULD FRACTURE.
Consequence & remedy
Consequence: IF THE BOLT FRACTURES, THE LOWER CONTROL ARM COULD SEPARATE FROM THE CROSSMEMBER, CAUSING A LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT LOWER CONTROL ARM BOLTS AND NUTS. OWNER NOTIFICATION BEGAN APRIL 30, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA05009 · Headlight Malfunction
Opened Jun 1, 2005 · Closed May 2, 2006
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (3)
Electrical System
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
PE05004 · Headlight Malfunction
Opened Feb 2, 2005 · Closed Jun 1, 2005
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
EA04031 · Power Liftgate Latch
Opened Nov 22, 2004 · Closed Apr 7, 2005
Status: closed (inferred from source dates) · Latches/locks/linkages; Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Additional source detail variants (2)
Latches/locks/linkages
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.