1994 Dodge Dakota

FRONT LEFT DOOR SNAPPED OFF. I CAN'T OPEN THE DRIVERS DOOR FROM THE INSIDE. ALSO, BOTH SEAT BELTS SNAPPED, THE AIR AND HEAT DOESN'T WORK, THE BRAKES LOCKED UP, WHICH AFFECTED THE STEERING. THE TRANSMISSION WAS REPLACED THREE TIMED, THE VEHICLE WOULD LOOSE POWER AND THE ENGINE WOULD DIE. THE CATALYTIC CONVERTER RATTLED. THERE WAS A ROUGH IDLE AND THEN THE VEHICLE WOULD STALL. THE CRUISE CONTROL WAS INOPERATIVE, THE TIRES WORE OUT PREMATURELY. ALSO, I HAD DIFFICULTY GETTING THE VEHICLE OUT OF PARK. THE IDLER ARM IS IN THE PROCESS OF BREAKING, THE IGNITION BROKE AFTER THE KEYS BECAME STUCK, THE FUEL PUMP FAILED AND THE BEARING AND BUSHING NEEDS TO BE REPLACED.

NIGHT DRIVING, SMELLED ELECTRICAL SMOKE IN CAB. HEADLAMPS WENT OFF THEN CAME BACK ON AFTER 5 TO 10 SECONDS. MOVED HEADLAMP SWITCH IN AND OUT BUT CONDITION STILL PERSISTED. LUCKILY I WAS LESS THAN ONE MILE FROM HOME ON DIVIDED HWY WITH NO TRAFFIC. IF LAMP SWITCH IS OFF THEN THERE IS NO SMELL OF ELECTRICAL SMOKE. WHEN LAMP SWITCH IS IN EITHER THE PARKING OR THE HEADLAMP POSITION, CAN SMELL ELECTRICAL SMOKE AND LIGHT WORK INTERMITTENTLY. THIS IS SECOND FAILURE IN 2 YEARS. LAMP SWITCH FAILED. *JB

SUDDEN NEAR-COMPLETE BRAKE FAILURE DUE TO DEFECTIVE BOLT HOLDING MASTER CYLINDER IN PLACE TO HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR. ON 05-14-2005, MY 18 YEAR OLD SON COMPLETED HIS SHIFT AT WORK. HE WENT OUT TO OUR 1994 DODGE DAKOTA PICKUP AND STARTED THE ENGINE. AS HE DEPRESSED THE BRAKE PEDAL HE HEARD A METALLIC NOISE AS IF SOMETHING HAD BROKEN. HE DROVE TO OUR NEARBY RESIDENCE AT VERY LOW SPEED. THERE WAS NO COLLISION, BUT HE REPORTED SIGNIFICANTLY REDUCED BRAKE PERFORMANCE. AT OUR RESIDENCE, MY MECHANIC AND I INSPECTED THE VEHICLE. I AM A 21-YEAR EXPERIENCED POLICE COLLISION INVESTIGATOR. WE FOUND THAT THE LEFT (DRIVER SIDE) BOLT HOLDING THE MASTER BRAKE CYLINDER TO THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR (AKA: HYDROBOOST) HAD BROKEN OFF. THE BOLT APPEARS TO BE A LOW GRADE STUD THAT IS PRESSED INTO THE FORWARD COVER OF THE HYDROBOOST UNIT. THE BOLT / STUD IS OF SMALL DIAMETER FOR SUCH A CRITICAL COMPONENT. IT APPEARED TO BE OVER-TIGHTENED AT THE FACTORY (MOST LIKELY), OR WORE OUT DUE TO METAL FATIGUE (LESS LIKELY AS THE VEHICLE ONLY HAS APPROXIMATELY 51,000 MILES ON IT). THERE IS A SECOND BOLT HOLDING THE MASTER CYLINDER TO THE HYDROBOOST. THE SECOND BOLT HELD IN PLACE, ALLOWING REDUCED BRAKING ABILITY. THE MASTER CYLINDER WAS FALLING DOWN AND TO THE RIGHT AT ABOUT A 35 DEGREE ANGLE. HAD THIS DEFECT OCCURRED AT HIGHWAY SPEEDS, OR WHEN PULLING A LOAD, A CATASTROPHIC COLLISION WOULD HAVE LIKELY OCCURRED. THE TWO BOLTS APPEAR TO BE TOO SMALL IN DIAMETER FOR ANY VEHICLE, PARTICULARLY A LIGHT PICKUP TRUCK. ALTHOUGH THIS VEHICLE IS A 1994 MODEL YEAR, IT IS STILL IN EXCELLENT CONDITION. I LIVE IN A SEMI-ARID AREA, SO THERE IS NO RUST. THE VEHICLE HAS ALSO NEVER BEEN IN A COLLISION AND IS PARKED IN A GARAGE WHEN NOT IN USE. I PURCHASED THE VEHICLE NEW AND HAVE BEEN THE ONLY OWNER. THE VEHICLE HAS BEEN OTHERWISE EXTREMELY RELIABLE.

WHILE DRIVING 40 MPH A DEER APPEAR OUT OF NO WHERE AND WAS HIT BY CONSUMER'S VEHICLE. IT WAS BADLY DAMAGED AND KNOCKED OFF THE ROAD. UPON IMPACT, DRIVER'S AIR BAG FAILED TO DEPLOY. STEERING WHEEL SEPARATED AND CAUSED SEVERE DAMAGE TO DRIVER'S RIGHT LEG. DRIVER WAS HOSPITALIZED. VEHICLE HAD OLD ENGINE REPLACED. THE DAKOTA SPORT WAS TOTALED.*AK THE CONSUMER STATED THAT THE ABOVE INFORMATION IS INCORRECT AND SENT AN UPDATED VERSION WHICH IS AS FOLLOWS: THE CONSUMER WAS DRIVING AND A DEER JUMPED ONTO HIS VEHICLE. THE VEHICLE CROSSED THE ROAD TO THE LEFT INTO A DITCH AND FLIPPED THE VEHICLE OVER. AIRBAGS DID NOT DEPLOY. THE STEERING COLUMN BROKE FROM UNDER THE DASH INJURING THE CONSUMER. *TC