2010 Dodge Caravan

MY 2010 DODGE GRAND CARAVAN STALLS 5 TO 10 TIMES PER WEEK. IT STALLS AT ANY SPEED AND AT ANY TIME (WARM OR COLD). SINCE THE DODGE DEALERSHIP COULD NOT FIND THE ISSUE (HATS OFF TO THEIR INEPTITUDE), AFTER FURTHER RESEARCH, I LEARNED THE ISSUE IS DUE TO FAILURE OF THE TOTALLY INTEGRATED POWER MODULE (TIPM) AND AFFECTS OTHER DODGE/CHRYSLER PRODUCTS . SEE NHTSA ACTION NUMBER: DP14004. HOWEVER, NHTSA STANCE ON THIS IS 'EXCEPT INSOFAR AS THE PETITIONER'S CONTENTIONS RELATE TO THE DEFECT CONDITION ADDRESSED BY THE CHRYSLER RECALLS, THE FACTUAL BASES OF THE PETITIONER'S CONTENTIONS THAT ANY FURTHER INVESTIGATION IS NECESSARY ARE UNSUPPORTED. IN OUR VIEW, ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS ALLEGED BY THE PETITIONER AT THE CONCLUSION OF THE REQUESTED INVESTIGATION. THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED'. THIS WILL ONLY BE RESOLVED WHEN SOMEONE DIES OR THE NHTSA TAKES OUR 'CONTENTIONS' SERIOUSLY.

I HAVE RECEIVED A RECALL NOTICE 3 TIMES. I HAVE CONTACTED THE DEALER NEMOURS TIMES TRYING TO RESOLVE THE ISSUE. THEY ARE TELLING ME THAT PARTS ARE NOT AVAILABLE. ALSO I HAVE REPLACED THE BREAKS 4 TIMES THE FIRST TIME WAS AT 17,659 MILES. I ALSO HAD TO REPLACE THE UPPER COOLING LINES. I JUST NOTICED THAT THE LOWER COOLING PIPE IS RUSTING VERY BAD TO THE POINT OF FAILURE. WE HAD TROUBLE WITH THE ELECTRONICS SINCE THE PURCHASE OF THE VAN. WE PURCHASED THE VAN BRAND NEW. THE DOORS WERE LOCKING BY THERE SELF THE HEATING/COOLING CONTROLS HAD TO BE REPLACED. I WOULD LIKE TO RESOLVE THESE ISSUES.

SEPTEMBER 7, 2015, WAS ENTERING INTERSTATE, CAR CONTINUED TO ACCELERATE WITH ACCELERATOR DEPRESSED, PRESSING ON BRAKE WAS MINIMALLY FUNCTIONAL, MANAGED TO GET CAR ON OFFRAMP AND TO PARKING LOT, HOWEVER BRAKES WERE EXTREMELY HOT AND BRAKE LIGHT WAS ON. TURNED OFF THE IGNITION, AND RESTARTED CAR. ACCELERATOR WAS STILL DEPRESSED SO TURNED CAR OFF. CAME BACK AFTER TWO HOURS AND CAR FUNCTIONED NORMALLY. TOOK CAR TO DODGE SERVICE REPAIR, SHOWED A CODE P2299, BRAKE PEDAL POSITION-ACCELERATOR POSITION, AND CODE C0021 BRAKE BOOSTER PERFORMANCE. MECHANIC CLEARED CODES, STATED THAT HANDICAPPED HAND CONTROLS WERE ENGINEERED IMPROPERLY AND ALLOWED BOTH BRAKES AND ACCELERATOR TO BE USED AT SAME TIME. SERVICE MANAGER STATED THEY HAD NEVER HEARD OF A WIRELESS THROTTLE BODY CONTROL PROBLEM AND THAT I WAS THE FIRST TO COMPLAIN. LATER STATED THAT SEVERAL OTHER HAND CONTROL UNITS THEY HAD WORKED ON FUNCTIONED IMPROPERLY. IT WAS EXTREMELY EVIDENT THEY WERE COVERING A STUCK THROTTLE BODY PROBLEM THAT HAS BEEN SEEN BY A NUMBER OF NON-DODGE AUTHORIZED MECHANICS.

THE CAR STARTED SHUTTING OFF IN THE MIDDLE OF AN OFF RAMP OR JUST GOING DOWN A STREET OR COMING TO A STOP. LEFT ME WITHOUT POWER STEERING OR BRAKES. VERY SCARY. I HAVE TAKEN IT INTO THE DEALER AND AT FIRST THEY SAID IT WAS A GUNKY THROTTLE, BUT PAID FOR IT, BROUGHT IT HOME AND IT DIED AGAIN THAT SAME DAY. MECHANIC TOOK IT OUT AND HE SAID HE WAS GOING 30 MILES AN HOUR AND IT DIED ON HIM AND HE ALMOST WRECKED MY CAR. NO CODES ARE SHOWING OR NO CHECK ENGINE LIGHT, SO THEY HAVE NOT BEEN ABLE TO FIGURE OUT WHAT IS GOING ON WITH IT. PLUS THE TRANSMISSION SLAMS INTO MY FRONT END IF I AM GOING NORMAL SPEED AND COME TO A STOP AT THE BOTTOM OF MY HILL AND TOLD THEM ABOUT THIS LAST YEAR AND WAS TOLD THAT WAS NORMAL FOR THAT CAR(I DON'T THINK SO). I AM AT A LOSS AND ON A FIXED INCOME. WHERE DO I GO FROM HERE?

TL*THE CONTACT OWNS A 2010 DODGE CARAVAN. THE CONTACT STATED THAT WHILE DRIVING AT 60 MPH, THE ENGINE STALLED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V373000 (AIR BAGS , ELECTRICAL SYSTEM). THE APPROXIMATE FAILURE MILEAGE WAS 56,000.

ORIGINAL OWNER OF THE VEHICLE. THIS IS ACTUALLY A REPORT OF 5-6 SEPARATE INCIDENTS OF THE SAME ISSUE WITHIN A WEEK'S SPAN. THE ENGINE OF THE VEHICLE SUDDENLY SHUTS OFF WHILE DRIVING. IT IS INSTANT AND SILENT, WITH NO PRE-WARNING. DRIVER LOSES ALL POWER STEERING / BRAKES DURING THE OCCURRENCE. LAST INCIDENT ALMOST CAUSED AN ACCIDENT WHEN THE VEHICLE'S ENGINE STALLED AND A FOLLOWING VEHICLE HAD TO TAKE ACTION TO AVOID A COLLISION. MY WIFE AND KIDS WERE IN THE VAN AT THE TIME OF THE INCIDENT. WHEN IT HAPPENS, THE VAN ALWAYS STARTS BACK UP, BUT IT HAS TO BE STATIONARY AND IN-PARK. VEHICLE WAS TAKEN TO THE DEALERSHIP ON 01/23/15 FOR REPAIR. DEALERSHIP INDICATED THE EGR VALVE AND TEMPERATURE SENSOR WAS FAULTY AND HAS BEEN A COMMON PROBLEM FOR DECADES. THIS IS THE SECOND TEMPERATURE SENSOR THAT HAS BEEN REPLACED BY THE DEALER. INTERNET SEARCH CONFIRMS MANY ISSUES SUCH AS THIS ARE EVIDENT ON THE ROAD. REPAIR MADE 01/23/15 AT A CONSUMER COST OF $513.41. OUR PURCHASED EXTENDED WARRANTY COVERED ALL OF IT, BUT $150.00. I CONSIDER THE ISSUE, IN REGARD TO A DFMEA FORMAT TO BE, LOSS OF FUNCTION WHICH SHALL BE A SEVERITY OF 10 AND AN INVERTED DELTA BY THE MANUFACTURER. I ASK THAT NHTSA INVESTIGATE THIS ISSUE AS MY FAMILIES WELL BEING WAS AT STAKE THIS MORNING WHICH DOES NOT SIT LIGHTLY WITH ME AS A HUSBAND / FATHER. *TR

WHILE DRIVING AT 55 MPH, MY VAN ALL OF A SUDDEN TURNED OFF. I LOST ALL POWER STEERING AND STRUGGLED TO GET THE VAN OFF THE ROAD. ONCE I GOT IT OFF THE ROAD, I WAS ABLE TO START THE VEHICLE AND DROVE ABOUT 2 MILES. THE VEHICLE DIED A SECOND TIME AS I WAS GETTING READY TO TURN ONTO THE STREET IN WHICH I LIVE. MY SPEED AT THAT TIME WAS AROUND 20 MPH. I PULLED INTO THE CARWASH, WHERE I WAS ABLE TO START THE VEHICLE AGAIN, AND THEN DROVE HOME. I WENT APROX. 1 MILE THAT TIME. WE PARKED THE VAN AND AS MY HUSBAND WAS GETTING OUT OF THE DRIVER SIDE, HE STRONGLY SMELLED SOMETHING ELECTRICAL BURNING. I WENT OVER TO THE DRIVER SIDE AND SMELLED THE SAME SMELL. THE VERY NEXT DAY I LEFT IN MY VAN AROUND NOON AND WITHIN A QUARTER OF MILE MY VAN DIED FOUR TIMES. I TURNED AROUND AND DROVE A QUARTER OF A MILE BACK, WITH THE VAN DYING THREE MORE TIMES. I FINALLY MADE IT HOME AND INFORMED THE DEALERSHIP OF THE PROBLEM. WITHIN 2 HOURS THEY BROUGHT ME A RENTAL. IT HAS BEEN EXACTLY TWO WEEKS THAT I HAVE BEEN WITHOUT MY VAN AND THEY ARE UNABLE TO FIX IT AS OF NOW. I CAN'T HELP BUT BELIEVE THAT MY VAN IS HAVING THE EXACT SAME ISSUES AS THE OTHER RECALLED 2010 DODGE CARAVANS. I HAVE THE EXACT SAME TESTIMONIES AS SOME OF THE OTHER PEOPLE THAT ACTUALLY HAVE A RECALL ON THEIR DODGE CARAVAN. PLEASE HELP! THIS VEHICLE WAS JUST BOUGHT ON 11-17-2014 THANKS IN ADVANCE. *TR

TL* THE CONTACT OWNS A 2010 DODGE CARAVAN. THE CONTACT STATED THAT THE ENGINE STARTED INDEPENDENTLY. THE CONTACT MENTIONED THAT THE REMOTE CAR STARTER MAY HAVE BEEN THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 14,400. UPDATED 12/9/14*CN UPDATED 10/1/2015*JS