← New search

2004 Dodge Caravan

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2004 Dodge Caravan do not stand out strongly from the model-year median of 182.

About this comparison →

How this year compares

Owner complaints by model year

Other model years Selected year
Compare all Caravan years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

All reported categories

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

50 reports with mileage · 15 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Fuel/propulsion System. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel System, Gasoline. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

2 crash reports3 fire reports2 injury reports

Engine And Engine Cooling complaints

4 reports
Clear category filter
Mileage unknown · May 12, 2016
Engine And Engine CoolingFuel System, Gasoline

2004 DODGE CARAVAN. CONSUMER WRITES IN REGARDS TO FUEL TANK EXTENDED WARRANTY COVERAGE THAT APPLIES TO VEHICLE STALLING AFTER REFUELING. *SMD THE CONSUMER STATED THE VEHICLE BEGAN STALLING SHORTLY AFTER IT WAS PURCHASED AND HAS SINCE CONTINUED. THE STALLING OCCURRED AT HIGHWAY SPEEDS AND WHILE MAKING LEFT TURNS. ALSO, THE CH…

Read full complaint

2004 DODGE CARAVAN. CONSUMER WRITES IN REGARDS TO FUEL TANK EXTENDED WARRANTY COVERAGE THAT APPLIES TO VEHICLE STALLING AFTER REFUELING. *SMD THE CONSUMER STATED THE VEHICLE BEGAN STALLING SHORTLY AFTER IT WAS PURCHASED AND HAS SINCE CONTINUED. THE STALLING OCCURRED AT HIGHWAY SPEEDS AND WHILE MAKING LEFT TURNS. ALSO, THE CHECK ENGINE LIGHT ILLUMINATED. THE DEALER REPLACED THE EGR SENSOR.*JB

NHTSA ODI #10864907

Mileage unknown · Apr 22, 2009
Engine And Engine Cooling

EVAPORATOR CORE LEAKS ALLOWING FREON TO LEAK OUT INTO SEALED INTERIOR PASSENGER COMPARTMENT. DESIGN FLAW DUE TO LOCATION OF TEMPERATURE PROBE THROUGH THE MIDDLE OF THE CORE. EVAPORATOR CORE IS VERY DIFFICULT TO REPLACE. *TR

NHTSA ODI #10266421

55,500 miles · Dec 19, 2006
Engine And Engine Cooling

TL*- THE CONTACT'S 2004 DODGE CARAVAN IS STALLING. THE CURRENT MILEAGE IS 55,000. THE FIRST INCIDENT OCCURRED ON DECEMBER 8, 2006 AND SECOND INCIDENT OCCURRED ON DECEMBER 14, 2006. THE CAR HAS STALLED WHILE DRIVING 30-35 MILES PER HOUR EACH TIME THE INCIDENT OCCURS, IT HAS NOT STALLED AT HIGHWAY SPEEDS. THE CONTACT TOOK THE…

Read full complaint

TL*- THE CONTACT'S 2004 DODGE CARAVAN IS STALLING. THE CURRENT MILEAGE IS 55,000. THE FIRST INCIDENT OCCURRED ON DECEMBER 8, 2006 AND SECOND INCIDENT OCCURRED ON DECEMBER 14, 2006. THE CAR HAS STALLED WHILE DRIVING 30-35 MILES PER HOUR EACH TIME THE INCIDENT OCCURS, IT HAS NOT STALLED AT HIGHWAY SPEEDS. THE CONTACT TOOK THE VEHICLE TO THE DEALER ON DECEMBER 15, 2006 AND THEY COULD NOT DIAGNOSE THE VEHICLE'S PROBLEM BASED ON THE COMPUTER DIAGNOSTICS. THE INCIDENT HASN'T HAPPENED SINCE 12/14/06 . THE FIRST INCIDENT OCCURRED WHILE MAKING A LEFT TURN, THERE WERE NO WARNING LIGHTS PRESENT IN THE VEHICLE. EACH THE DEALER GAVE CONTACT NO ADDITIONAL DIAGNOSE ON THE VEHICLE.

NHTSA ODI #10176573

21,000 miles · Apr 5, 2005
Engine And Engine Cooling

NINE TIMES THE CAR HAS STOPPED RUNNING FOR NO APPARENT REASON. IT SEEMS TO OCCUR WHEN THE FOOT IS LIFTED OFF THE ACCELERATOR. SO FAR NO ACCIDENT. MY WIFE HAS BEEN ABLE TO GUIDE THE CAR TO THE SIDE OF THE ROAD. AFTER WAITING A FEW SECONDS THE CAR STARTS WITHOUT DIFFICULTY AND SHE CAN PRECEED ON HER WAY. THIS HAS AOCCURRED IN THE …

Read full complaint

NINE TIMES THE CAR HAS STOPPED RUNNING FOR NO APPARENT REASON. IT SEEMS TO OCCUR WHEN THE FOOT IS LIFTED OFF THE ACCELERATOR. SO FAR NO ACCIDENT. MY WIFE HAS BEEN ABLE TO GUIDE THE CAR TO THE SIDE OF THE ROAD. AFTER WAITING A FEW SECONDS THE CAR STARTS WITHOUT DIFFICULTY AND SHE CAN PRECEED ON HER WAY. THIS HAS AOCCURRED IN THE LAST THREE MONTS. THE SERVICE DEPARTMENT HAS SAID THERE S NOTHING STORED IN THE COMPUTOR SO THEY CAN NOT DIAGNOSE THE PROBLEM. I AM CONCERNED WHE WILL NOT SAFELY GET TO THE SIDE THE NEXT TIME.*AK

NHTSA ODI #10116380

Official recalls

1

04V386000 · Steering:hydraulic Power Assist:hose, Piping, And Connections

Aug 5, 2004

ON CERTAIN MINIVANS EQUIPPED WITH 3.3 OR 3.8L V-6 ENGINE, THE UPPER POWER STEERING COOLER HOSE MAY SPLIT AND CAUSE A FLUID LEAK.

Consequence & remedy

Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDER HOOD FIRE.

Remedy: DEALERS WILL REPLACE THE UPPER POWER STEERING COOLER HOSE. THIS RECALL BEGAN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

1

DP14002 · Engine Stall After Refueling

Opened Sep 5, 2014 · Closed Apr 6, 2015

Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly

This defect petition evaluates July 7, 2014 allegations from an owner of a model year (MY) 2007 Dodge Grand Caravan minivan that engine stall occurs in these vehicles without warning after refueling.The petitioner's vehicle is a Chrysler RS platform minivan.The RS platform includes MY 2003 through 2007 Dodge Grand Caravan, Dodge Caravan, Chrysler Town and Country and Chrysler Voyager minivans.NHTSA evaluated the petition by analyzing consumer complaints submitted to the Agency, analyzing field data, reviewing technical information provided in Chrysler's response to an Agency information request and testing an RS minivan identified by its owner as experiencing post-refuel engine stalls.After completing this evaluation, NHTSA has concluded that further investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists.The stalls occurring in these vehicles only occur immediately after filling up the fuel tank and happen at low engine speeds. The failure rate is low, even after 8 to 13 years of the vehicles being in service, and there are no reports of crashes or injuries resulting from the stall condition.In the Agency's view, additional investigation is unlikely to result in finding the existence of a safety-related defect in the subject vehicles.Given the need to allocate and prioritize NHTSA's limited resources to best accomplish the Agency's safety mission, the petition is denied.This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency will take further action if warranted by future circumstances. More details concerning our review can be found in the Federal Register Notice for this action.The following 161 VOQs are included in the petition evaluation: 10209242, 10229468, 10240708, 10260923, 10275939, 10276532, 10296487, 10298175, 10328669, 10330144, 10346517, 10349789, 10354758, 10363689, 10372112, 10372368, 10372514, 10378031, 10379764, 10382938, 10387448, 10394063, 10398877, 10413918, 10418652, 10420924, 10427063, 10437525, 10445392, 10446902, 10470028, 10471249, 10473733, 10502231, 10503114, 10504260, 10509862, 10511988, 10512120, 10512385, 10512650, 10513147, 10538154, 10549841, 10551763, 10555188, 10555418, 10556754, 10565367, 10574012, 10574398, 10586555, 10587212, 10587559, 10593433, 10607841, 10607913, 10608922, 10615810, 10622468, 10628141, 10632112, 10632128, 10632172, 10632175, 10632231, 10632262, 10632266, 10632270, 10632305, 10632316, 10632326, 10632370, 10632385, 10632399, 10632492, 10632542, 10632765, 10632833, 10632928, 10633197, 10633281, 10633409, 10633421, 10633483, 10633507, 10637752, 10637804, 10637950, 10637975, 10638032, 10638289, 10638290, 10638401, 10638968, 10639218, 10639623, 10641157, 10641603, 10641614, 10641836, 10644339, 10644705, 10649713, 10649895, 10649932, 10650313, 10652590, 10653147, 10653783, 10654533, 10655226, 10658900, 10659679, 10660320, 10662588, 10662645, 10662662, 10663473, 10667056, 10667437, 10668081, 10668094, 10668131, 10668612, 10668969, 10668970, 10669584, 10669678, 10669729, 10669775, 10669866, 10669895, 10669992, 10670422, 10670506, 10676348, 10676732, 10677120, 10679795, 10679934, 10680057, 10680290, 10680342, 10680714, 10681512, 10682584, 10682906, 10683022, 10683114, 10683549, 10683620, 10683697, 10683743, 10689898, 10690761, 10691284, 10691556, 10691751, 10693061, 10694300