IllustrationSTRUTS CAME UNDONE AND FELL OFF WHILE DRIVING. VEHICLE HAS HAD CONTINUOUS PROBLEMS WITH THE STRUTS AND STRUT MOUNTS. DEALER HAS SERVICED 8 TIMES. STRUTS HAVE TO BE CONSTANTLY TIGHTENED EVERY 6000-9000 MILES.*AK
2001 Dodge Caravan
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2001 Dodge Caravan do not stand out strongly from the model-year median of 182.
About this comparison →How this year compares
Owner complaints by model year
Compare all Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
250–25K
3425–50K
3150–75K
1875–100K
14100–150K
13150K+
135 reports with mileage · 122 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
9 crash reports3 fire reports12 injury reports
Suspension complaints
32 reportsI RECENTLY SENT THIS LETTER TO CHRYSLER IN AN E-MAIL. I AM CONTACTING THIS AGENCY TO SEE IF I CAN GET SOME JUSTICE. MY VEHICLE WAS UNSAFE. HOWEVER, I STILL DO NOT FEEL THAT IT IS PERFORMING CORRECTLY. I WOULD LIKE ASSISTANCE AND DIRECTION. THANKS. RECENTLY MY 2001 NEEDED THE RACK AND PINION, LOWER AND UPPER CONTROL ARM AND…
Read full complaint
I RECENTLY SENT THIS LETTER TO CHRYSLER IN AN E-MAIL. I AM CONTACTING THIS AGENCY TO SEE IF I CAN GET SOME JUSTICE. MY VEHICLE WAS UNSAFE. HOWEVER, I STILL DO NOT FEEL THAT IT IS PERFORMING CORRECTLY. I WOULD LIKE ASSISTANCE AND DIRECTION. THANKS. RECENTLY MY 2001 NEEDED THE RACK AND PINION, LOWER AND UPPER CONTROL ARM AND COMPLETE FRONT SUSPENSION REPAIR AT ANTWERPEN DODGE IN RANDALLSTOWN, MD. THEY REALLY GAVE ME A PROBLEM WITH THE TIME TO COMPLETE THE JOB AND THEY KEPT SAYING THAT THE RACK AND PIN WAS A "STAR PART". I THEN TOOK IT BACK TO THE DEALER, AND THEY COULD NOT BE DEFINITIVE. HOWEVER, THERE WAS NO CHARGE, THEREFORE NO WORK ORDER. ALL I WANT IS A SMOOTH RIDING VEHICLE THAT'S NOT SHAKING RATTLING AND ROLLING DOWN THE STREET. I DRIVE 50 MILES ONE WAY TO WORK AND MOST OF THE DRIVE IS HIGHWAY DRIVING. YOU CAN FEEL EVERY LITTLE BUMP.I FOUND THIS ARTICLE IN USA TODAY. IT READS: "APRIL 25, 2001 '' THE CHRYSLER ARM OF DAIMLERCHRYSLER ANNOUNCED WEDNESDAY A VOLUNTARY RECALL OF SOME NEW MINIVANS, CITING A POSSIBLE FRONT SUSPENSION PROBLEM. NEARLY 11,000 CUSTOMERS ARE AFFECTED BY THE RECALL OF THE 2001 CHRYSLER TOWN & COUNTRY, CHRYSLER VOYAGER, DODGE CARAVAN AND DODGE GRAND CARAVAN MINIVANS BUILT BETWEEN MARCH 22 AND APRIL 21 OF 2001. OWNERS OF RECALLED VEHICLES ARE URGED NOT TO DRIVE THEM. THE AUTOMAKER SAID A BOLT ON THE LOWER CONTROL ARM OF THE FRONT SUSPENSION CAN BREAK, RESULTING IN A LOSS OF VEHICLE CONTROL." NO ONE MENTIONED THAT THIS WAS A RECALL ITEM. SO I AM STILL TRYING TO FIX THIS SHAKE RATTLE AND ROLL PROBLEM. THIS 2001 SUSPENSION IS TRULY JUNK. NOW THE BOTTOM-LINE OR SHOULD I SAY " BOTTOM OUT" IS WHAT CAN I DO TO GET A SMOOTH RIDE? I HAVE AN EXTENDED WARRANTY, BUT THE MECHANICS NEED TO KNOW WHAT TO DO AND BE RIGHT. THIS COULD BE A FLUKE IN THE ASSEMBLY LINE, BUT I DOUBT IT. THERE ARE TOO MANY OTHER OWNERS WITH THE SAME COMPLAINT. IF YOU HAVE ANY INFLUENCE WITH ANTWERPEN DODGE IN RANDALLSTOWN, MD, PLEASE HELP ME TO SOLVE THIS PUZZLE.
STEERING VIBRATION AT LOW SPEEDS AND GRINDING NOISE FROM UNDER FRONT OF VEHICLE.*JB
VEHICLE VIBRATED WHILE DRIVING. *AK
LEFT FRONT STRUT WAS FRACTURED AND DRAGGING TO THE GROUND WHEN DRIVER WAS BACKING OUT OF DRIVERWAY. TIRE WAS MAKING A GRINDING SOUND DUE TO TIRE RUBBING AGAINST IT. *AK *JB
SEVERE SHUTTERING STEERING WHEEL. *AK
AT 35MPH CONTROL ARM SNAPPED, CAUSING CONSUMER TO LOSE CONTROL. . DEALER NOTIFIED. *AK
WHEN DRIVING AT HIGHWAY SPEEDS VEHICLE WILL WANDER TO THE RIGHT. DEALER HAS SEEN VEHICLE 6 OR 7 TIMES, AND HAS TRIED TO ALIGN VEHICLE AND TIRES. AFTER DEALER FIXED VEHICLE, IT WOULD PULL TO OPPOSITE DIRECTION.*AK CONSUMER HAS FILED FOR ARBITRATION. MANUFACTURER NOTIFIED.THERE IS REAR BUMPER DAMAGE. THE REAR DOOR IS INOPE…
Read full complaint
WHEN DRIVING AT HIGHWAY SPEEDS VEHICLE WILL WANDER TO THE RIGHT. DEALER HAS SEEN VEHICLE 6 OR 7 TIMES, AND HAS TRIED TO ALIGN VEHICLE AND TIRES. AFTER DEALER FIXED VEHICLE, IT WOULD PULL TO OPPOSITE DIRECTION.*AK CONSUMER HAS FILED FOR ARBITRATION. MANUFACTURER NOTIFIED.THERE IS REAR BUMPER DAMAGE. THE REAR DOOR IS INOPERATIVE WHEN USING REMOTE OR INTERIOR BUTTON. LEFT SLIDING DOOR RATTLE WHEN DRIVING OVER 40 MPH. DEALER REPLACED SLIDING DOOR PANEL MOLDING AND CLIPS THAT WERE BROKEN. DASH RATTLE IN FRONT DRIVER AREA OVER 40. DEALER COULD NOT DUPLICATE. PASSENGER FLOOR GETS WET FROM EXTENDED DRIVE WITH A/C ON. DEALER CLEANED DRAIN WITH COMPRESSED AIR. *TT
WHILE DRIVING 5-10 MPH A CONSTANT RATTLING ON FRONT OF THE VEHICLE DUE TO DAMAGED INNER TIE ROD. MECHANIC REPLACED TIE ROD. HOWEVER, RATTLING NOISE STILL OCCURRING AFTER THE REPLACEMENT OF NEW TIE ROD . *AK
ALL SEEM TO BE RELATED TO A HANDLING PROBLEM. THE VAN/MOTORHOME VIOLENTLY WANDERS AT HIGHWAY SPEEDS, 60 + MPH. IT IS EXTREMLY DIFFICULT TO HANDLE THE VEHICLE. WHEN YOU PAY $60K PLUS FOR A VEHICLE, YOU EXPECT A BETTER HANDLING VECHICLE THAN THIS VAN/MOTORHOME. I'M VERY DISAPOINTED WITH DODGE. THE REAR SWAY BAR WAS REPLACED, …
Read full complaint
ALL SEEM TO BE RELATED TO A HANDLING PROBLEM. THE VAN/MOTORHOME VIOLENTLY WANDERS AT HIGHWAY SPEEDS, 60 + MPH. IT IS EXTREMLY DIFFICULT TO HANDLE THE VEHICLE. WHEN YOU PAY $60K PLUS FOR A VEHICLE, YOU EXPECT A BETTER HANDLING VECHICLE THAN THIS VAN/MOTORHOME. I'M VERY DISAPOINTED WITH DODGE. THE REAR SWAY BAR WAS REPLACED, BUT WITH NO IMPROVEMENT IN THE HANDLING. THE HANDLING IS EVEN WORSE WHEN THERE'S A SLIGHT SIDE WIND. I DON'T KNOW MUCH ABOUT THE "LEMON LAW" BUT IF I COULD RETURN THE VECHICLE TO DODGE AND GET THE PURCHASE PRICE BACK, I WOULD DO IT AS SOON AS POSSIBLE. I DON'T KNOW WHAT IT MIGHT TAKE TO FIX THE HANDLING PROBLEM, STRONGER FRONT SPRINGS, DIFFERENT TIRES, DIFFERENT STEERING BOX, DIFFERENT STEERING RODS AND ARMS, BUT SOMETHING NEEDS TO GET CHANGED AT DODGE'S EXPENSE.*AK
Official recalls
304V531000 · Equipment:electrical:radio/tape Deck/cd Etc.
Nov 2, 2004
ON CERTAIN MINI VANS, CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DROP THROUGH VENT HOLES IN THE TOP OF THE RADIO AND RESULT IN A SHORT CIRCUIT THAT SUBSEQUENTLY SENDS DIRECT CURRENT TO THE REAR SPEAKERS.
Consequence & remedy
Consequence: THIS COULD RESULT IN A SPEAKER FIRE.
Remedy: DEALERS WILL ADD A SPECIAL TAPE TO THE TOP OF THE RADIO TO PREVENT THE POTENTIAL OF WATER INTRUSION. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
03V094000 · Structure
Mar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
01V152000 · Suspension:front:control Arm:lower Arm
May 8, 2001
VEHICLE DESCRIPTION: MINIVANS. THE LOWER CONTROL ARM PIVOT BOLT COULD FRACTURE.
Consequence & remedy
Consequence: IF THE BOLT FRACTURES, THE LOWER CONTROL ARM COULD SEPARATE FROM THE CROSSMEMBER, CAUSING A LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT LOWER CONTROL ARM BOLTS AND NUTS. OWNER NOTIFICATION BEGAN APRIL 30, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA05009 · Headlight Malfunction
Opened Jun 1, 2005 · Closed May 2, 2006
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (3)
Electrical System
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
PE05004 · Headlight Malfunction
Opened Feb 2, 2005 · Closed Jun 1, 2005
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.