Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
70–25K
2025–50K
5650–75K
3975–100K
46100–150K
17150K+
185 reports with mileage · 444 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine And Engine Cooling. Review the 135 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 103 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 99 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
45 crash reports23 fire reports26 injury reports
What owners actually said
629 reports
Mileage unknown · Jan 16, 2001
Service Brakes, HydraulicVisibility
WE BOUGHT THIS VAN IN JANUARARY 1, 2000 WE HAVE HAD THIS VAN FOR A YEAR NOW AND HAVE HAD THE BRAKES DONE ON IT 8 TIMES. THE BRAKES GET SO HOT THAT IT MELTS THE VALVE STEMS. ALSO WHEN WE BOUGHT THIS VAN THE YELLOW LIGHTS ON THE FRONT DASH FOR THE REAR WINDOW WIPER AND THE OTHER LIGHTS SURROUNDING THAT LIGHT KEEP BLINKING AND WO…
Read full complaint
WE BOUGHT THIS VAN IN JANUARARY 1, 2000 WE HAVE HAD THIS VAN FOR A YEAR NOW AND HAVE HAD THE BRAKES DONE ON IT 8 TIMES. THE BRAKES GET SO HOT THAT IT MELTS THE VALVE STEMS. ALSO WHEN WE BOUGHT THIS VAN THE YELLOW LIGHTS ON THE FRONT DASH FOR THE REAR WINDOW WIPER AND THE OTHER LIGHTS SURROUNDING THAT LIGHT KEEP BLINKING AND WONT STOP BLINKING UNTIL DRIVING ON THE FREEWAY FOR ABOUT 10 TO 15 MINUTES. THE DEALERSHIP DIDN'T KNOW HOW TO MAKE THE LIGHTS STOP BLINKING. *AK
NHTSA ODI #739432
Mileage unknown · Jan 12, 2001
Tires
CONSUMER HAD NOTICED THAT TIRES STARTED SEPARATING, AND WOULD LIKE TO REPLACE THEM. THESE TIRES WERE NOT UNDER RECALL, BUT CONSUMER WAS CONCERNED FOR SAFETY. MICHELIN, TOURING, 215/65R16. *AK
NHTSA ODI #878158
Mileage unknown · Jan 12, 2001
Engine And Engine Cooling
DEFECTIVE ENGINE HEAD GASKET CAUSED ENGINE LEAK. *AK
NHTSA ODI #878156
Mileage unknown · Jan 12, 2001
Engine And Engine CoolingSteering
WHILE DRIVING DEFECTIVE TIMING BELT AND IDLER ARM BROKE WHICH CAUSE VEHICLE TO STALL UNEXPECTEDLY, ALMOST CAUSING A CRASH. PLEASE PROVIDE FURTHER INFORMATION. *AK
NHTSA ODI #878090
Mileage unknown · Jan 10, 2001
Power Train
MANY PEOPLE I HAVE SPOKEN WITH, INCLUDING THE EMPLOYEES AT KENNEDY TRANSMISSION, HAVE SAID THESE TRANSMISSION HAVE A REPUTATION OF GOING OUT AROUND 60-70,000 MILES. OUR DIFFERENTIAL WAS ALSO DAMAGED. THE PARTS NEEDED FOR THIS REPAIR, I WAS TOLD, IS ON A NATIONAL BACKORDER BECAUSE THIS IS SUCH A COMMON OCCURANCE. SHOULDN'T THE C…
Read full complaint
MANY PEOPLE I HAVE SPOKEN WITH, INCLUDING THE EMPLOYEES AT KENNEDY TRANSMISSION, HAVE SAID THESE TRANSMISSION HAVE A REPUTATION OF GOING OUT AROUND 60-70,000 MILES. OUR DIFFERENTIAL WAS ALSO DAMAGED. THE PARTS NEEDED FOR THIS REPAIR, I WAS TOLD, IS ON A NATIONAL BACKORDER BECAUSE THIS IS SUCH A COMMON OCCURANCE. SHOULDN'T THE CONSUMER BE FORWARNED ABOUT HAVE A $2800 REPAIR AFTER 60,000 MILES? OTHERWISE, SHOULDN'T THEY PUT IN A DIFFERENT TRANSMISSION IN THESE MINI-VANS?*AK
NHTSA ODI #739172
Mileage unknown · Jan 8, 2001
Interior Lighting
REAR DOOR INDICATOR LIGHT WAS STAYING ON DURING TRAVELING, CAUSING OVERHEAD LIGHT TO STAY ON . *AK THE PROBLEM HAS TO DO POSSILY WITH THE LATCH. JUST HAVE TO KEEP RESLAMMING THE DOOR DOWN TO TURN OFF THE LIGHTS. *YH
NHTSA ODI #877617
Mileage unknown · Jan 8, 2001
Power Train
TRANSMISSION PREMATURLY FAILED WHILE DRIVING THROUGH INTERSECTION. CAUSE UNKNOWN. *AK THE TRANSMISSION DRIVE WORKS BUT CONSTANTLY SLIPS IN AND OUT OF GEAR. *YH
NHTSA ODI #877610
Mileage unknown · Jan 8, 2001
Engine And Engine CoolingFire
VEHICLE LOST POWER AND MADE A FUNNY NOISE, THEN STALLED COMPLETELY, CONSUMER LOOKED UNDER THE HOOD AND VEHICLE EXPERIENCED FIRE IN ENGINE COMPARTMENT, CLAIM 08-5050-945. *SLC
NHTSA ODI #6900638
Mileage unknown · Jan 4, 2001
Engine And Engine Cooling
WHEN DRIVING SERPENTINE BELT WOULD KEEP COMING OFF. THIS HAPPENED WHETHER IT WAS WET OR DRY. WENT TO DEALERSHIP 3 TIMES & WAS INFORMED A FLAW IN DESIGN OF BELT. HAD BELT REPLACED 5 TIMES & HAD BEEN SHREDDED 5 TIMES. *AK
NHTSA ODI #877467
Mileage unknown · Dec 29, 2000
Engine And Engine Cooling
ENGINE COOLANT LEAK NOTED FROM FRONT OF VEHICLE. DEALER PERFORMED COOLING SYTEM PRESSURE TEST. DIAGNOSED REAR HEAD GASKET AS FAULTY. *AK
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN MINIVANS, SOME TRIM MATERIAL CAN LOOSEN AND DROP INTO THE REAR OUTBOARD SEAT BELT ASSEMBLY, CAUSING THE SEAT BELT TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE TRIM WITH FOAM BLOCKERS AND INSPECT AND REPLACE ALL 3RD ROW SEAT BELT ASSEMBLIES. OWNER NOTIFICATION BEGAN JUNE 3, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT WEBBING WAS INCORRECTLY ROUTED AROUND THE METAL REINFORCEMENT BAR ON THESE SEATS.
Consequence & remedy
Consequence: THE CHILD SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED IN THE EVENT OF A COLLISION.
Remedy: DEALERS WILL INSPECT THE ROUTING OF THE SHOULDER BELT WEBBING AND ANY FOUND INCORRECT WILL BE PROPERLY ROUTED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7
EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
RQ04001 · Driver Air Bag Clockspring Failure
Opened Jan 28, 2004 · Closed Jun 4, 2004
Status: closed (inferred from source dates) · Air Bags:frontal
COMPLAINTS REPORT AIR BAG WARNING LIGHT ILLUMINATES, AND THIS MAY BE ACCOMPANIED WITH A NON-FUNCTIONING HORN AND/OR CRUISE CONTROL (IF EQUIPPED).THIS IS INDICATIVE OF AN OPEN-CIRCUIT CLOCKSPRING FAILURE (RESULTS IN NON-FUNCTIONING DRIVER'S AIR BAG), SIMILAR TO THE FAILURE CONDITION THAT WAS THE SUBJECT OF DAIMLERCHRYSLER'S RECALL OF MODEL YEAR 1996-1998.5 MINIVANS (RECALL NO. 02V-293).THIS RECALL QUERY HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-013).
PE02004 · Rear Seat Belt Malfunction
Opened Jan 16, 2002 · Closed Mar 11, 2002
Status: closed (inferred from source dates) · Seat Belts:rear/other
THIS INVESTIGATION WAS OPENED JANUARY 16, 2002, BASED ON SEVEN REPORTS ALLEGING THE THIRD ROW SEAT BELT RETRACTORS FAILED ON CERTAIN 1997 AND 1998 MODEL YEAR CARAVAN AND VOYAGER VEHICLES.THE REPORTS INDICATED A TAR LIKE SUBSTANCE ENTERED THE RETRACTOR MECHANISM, THUS CAUSING THE RETRACTOR TO JAM OR BIND.IN THIS CONDITION THE SEAT BELT IS RENDERED INOPERABLE, AS THE WEBBING CANNOT RETRACT OR BE WITHDRAWN FROM THE RETRACTORS FOR USE.RECALL SCOPE:THE AFFECTED VEHICLES ARE 1997 THROUGH 1999 DODGE CARAVAN, PLYMOUTH VOYAGER, AND CHRYSLER TOWN & CONTRY BUILT ON A SHORT WHEEL BASE CHASSIS.THE INCLUSIVE DATES OF PRODUCTION ARE JUNE 1996 THROUGH OCTOBER 31, 1999.RECALL REMEDY: DAIMLERCHRYSLER DEALERS WILL REPLACE THE MASTIC SOUND BARRIER PATCHES WITH FOAM BLOCKERS, AS WELL AS, INSPECT AND REPLACE ALL THIRD ROW REAR SEAT BELT ASSEMBLIES CONTAMINATED BY THE MASTIC PATCH.
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
1998 Dodge Caravan Problems, Complaints & Recalls | Skip That Year
Illustration