IllustrationIT WAS IN THE WINTER TIME WHEN THEY STOP WORKING. BOTH THE POWER WINDOWS HAVE STOPPED WORKING I HAVE REPLACE THE DRIVERS SIDE WINDOW MOTOR AND IT STOP WORK FOR SECOND TIME. *TR
2001 Chrysler Voyager
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Voyager years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
40–25K
1425–50K
950–75K
775–100K
6100–150K
1150K+
41 reports with mileage · 39 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports0 fire reports1 injury reports
Visibility complaints
6 reportsDT: ON 6/7/05 CAR WAS PARKED IN PARKING LOT WITH OTHER CARS WHEN APPROACHING THE VEHICLE DRIVER NOTICED THAT SLIDING DOOR WAS SHATTERED. THERE WAS NO INDICATING FACTORS AROUND THE VEHICLE SUCH AS ROCKS, OR BRICKS THAT COULD HAVE BROKEN THE VEHICLE. THE GLASS FELL AT LEAST 3 FEET FROM VEHICLE. NO OTHER PROBLEMS WITH VEHICLE WHIC…
Read full complaint
DT: ON 6/7/05 CAR WAS PARKED IN PARKING LOT WITH OTHER CARS WHEN APPROACHING THE VEHICLE DRIVER NOTICED THAT SLIDING DOOR WAS SHATTERED. THERE WAS NO INDICATING FACTORS AROUND THE VEHICLE SUCH AS ROCKS, OR BRICKS THAT COULD HAVE BROKEN THE VEHICLE. THE GLASS FELL AT LEAST 3 FEET FROM VEHICLE. NO OTHER PROBLEMS WITH VEHICLE WHICH IS REGULARLY SERVICED. FILE NUMBER FROM DAIMLER CHRYSLER 13644870. *AK
2001 CHRYSLER VOYAGER WINDSHIELD: THE WINDSHIELD CRACKED IN A U-SHAPED PATTERN CENTERED OVER THE MID-DASH DEFROSTER VENT. THE DEFROSTER HAD BEEN TURNED ON (FULL FAN SPEED, FULL TEMPERATURE SETTING, DEFROSTER ONLY SETTING) FOR APPROXIMATELY 10 MINUTES, THE CAR WAS UP TO NORMAL OPERATING TEMPERATURE. OUTSIDE TEMPERATURE WAS APPROX…
Read full complaint
2001 CHRYSLER VOYAGER WINDSHIELD: THE WINDSHIELD CRACKED IN A U-SHAPED PATTERN CENTERED OVER THE MID-DASH DEFROSTER VENT. THE DEFROSTER HAD BEEN TURNED ON (FULL FAN SPEED, FULL TEMPERATURE SETTING, DEFROSTER ONLY SETTING) FOR APPROXIMATELY 10 MINUTES, THE CAR WAS UP TO NORMAL OPERATING TEMPERATURE. OUTSIDE TEMPERATURE WAS APPROXIMATE 20 DEGREES FAHRENHEIT. VEHICLE HAD BEEN PARKED OUTSIDE ALL DAY UNDER THESE CONDITIONS. LATER COLD SOAK AND WARM UP UNDER SIMILAR CONDITIONS, BUCKLING SOUNDS EMANATED FROM WINDSHIELD AS DEFROSTER WAS APPLIED AND CRACK LINES GREW IN LENGTH. APPEARS OUTSIDE LAYER OF WINDSHIELD ASSEMBLY CRACKED WHILE INSIDE LAYER REMAINED INTACT. NO EVIDENCE OF AN IMPACT EITHER OUTSIDE OR INSIDE. NO KNOWN IMPACT WAS EXPERIENCED. *LA
WHILE DRIVING ON THE INTERSTATE A GOLF BALL SIZE PIECE OF DEBRIS FELL OFF A TRUCK AND HIT THE WINDSHIELD ON THE PASSENGER SIDE. CONSUMER NOTICED SLIVERS OF GLASS ON THE PASSENGER SEAT.*AK
WHILE DRIVING 50 MPH ON THE HIGHWAY, ROCKS FELL FROM THE BED OF A TRUCK, A ROCK HIT THE CONSUMER'S WINDSHIELD. THE GLASS ON THE INSIDE OF THE VEHICLE SHATTERED, AND LANDED AND THE PASSENGER SEAT. *AK *TS *JB
I BOUGHT THE ABOVE MENTIONED BRAND NEW CHRYSLER VOYAGER LX '02 MINIVAN ON THE CHRISTMAS EVE, 2001. I DID NOT DRIVE MUCHAT AT THE BEGINING BUT AFTER 5/6 MONTHS WHEN I MADE A INTERSTATE TRIP TO CT, I WAS SHOCKED AND NARROWLY ESCAPED A SERIOUS ACCIDENT BY "AN IMMAGE OF A SPINNING DISCLIKE STAFF APPEARED ON WINDSHIELD AT PASSANGER …
Read full complaint
I BOUGHT THE ABOVE MENTIONED BRAND NEW CHRYSLER VOYAGER LX '02 MINIVAN ON THE CHRISTMAS EVE, 2001. I DID NOT DRIVE MUCHAT AT THE BEGINING BUT AFTER 5/6 MONTHS WHEN I MADE A INTERSTATE TRIP TO CT, I WAS SHOCKED AND NARROWLY ESCAPED A SERIOUS ACCIDENT BY "AN IMMAGE OF A SPINNING DISCLIKE STAFF APPEARED ON WINDSHIELD AT PASSANGER SIDE". SINCE THEN I REALIZED THAT THERE WAS VERY VISIBLE IMMAGE/REFLECTION OF A SPINNING DISK ON WIND SHIELD.I IMMEDIATELY CONTACTED DAIMLERCHRYSLER AND THE DEALER (MAJOR CHRYSLER PLYMOUTH JEEP EAGLE, NY). THEY INSPECTED AND CONFIRMED/CERTIFIED MY CLAIM. THEN THEY DECIDED TO REPLACE THE WINDSHIELD. AFTER CHANGING THE WIND SHIELD THE PROBLEM STILL REMAIN THE SAME. THE DEALER FINALLY SAID THAT NOTHING MUCH THEY COULD HELP. BACK AND FORTH FOR 4 MONTHS I JUST REPORTED DIAMLERCHRYSLER THAT THE DEALER COULD NOT HELP FURTHER AND NOW THE ISSUE WAS WITH THEM. EITHER THEY SHOULD RESOLVE THE ISSUE WITH ME AS SOONEST OR I WILL TAKE APPROPRIATE ACTION. THIS IS SERIUOS SAFETY HAZARD, WHEN DRIVING WITH FULL PERMISSIBLE SPEED THE IMMAGE IS DAMAGING. THREREFORE, I CAN NOT DRIVE THE VEHICLE SAFELY. IT IS A NIGHTMARE FOR ME. THAT IMMAGE DETORIATE THE HAZARD ON SUNNY DAY. AS I UNDERSTAND, NOT ALL VEHICLES OF THAT BATCH/MODEL ARE NOT WITH THIS DEFECT (DIAMLERCHRYSLER/MAJOR MENTIONED) BUT THIS PARTICULAR VEHICLE IS. IT IS NOT FAIR, AFTER SPENDING OVER $27000 I HAVE TO LIVE WITH FARE AND DISCOMFORT FOR THIS VEHICLE. IT IS ALSO NOTED THAT THE VEHICLE CAME WITH IT'S REGULAR 1 YEAR FULL AND 3 YEARS LIMITED WARRANTY. I DEMAND FULL REFUND OR REPLACE WITH A SIMILAR SAFE VEHICLE.*AK
Official recalls
204V531000 · Equipment:electrical:radio/tape Deck/cd Etc.
Nov 2, 2004
ON CERTAIN MINI VANS, CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DROP THROUGH VENT HOLES IN THE TOP OF THE RADIO AND RESULT IN A SHORT CIRCUIT THAT SUBSEQUENTLY SENDS DIRECT CURRENT TO THE REAR SPEAKERS.
Consequence & remedy
Consequence: THIS COULD RESULT IN A SPEAKER FIRE.
Remedy: DEALERS WILL ADD A SPECIAL TAPE TO THE TOP OF THE RADIO TO PREVENT THE POTENTIAL OF WATER INTRUSION. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
01V152000 · Suspension:front:control Arm:lower Arm
May 8, 2001
VEHICLE DESCRIPTION: MINIVANS. THE LOWER CONTROL ARM PIVOT BOLT COULD FRACTURE.
Consequence & remedy
Consequence: IF THE BOLT FRACTURES, THE LOWER CONTROL ARM COULD SEPARATE FROM THE CROSSMEMBER, CAUSING A LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT LOWER CONTROL ARM BOLTS AND NUTS. OWNER NOTIFICATION BEGAN APRIL 30, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA05009 · Headlight Malfunction
Opened Jun 1, 2005 · Closed May 2, 2006
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (3)
Electrical System
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
PE05004 · Headlight Malfunction
Opened Feb 2, 2005 · Closed Jun 1, 2005
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.