I AM EXPERIENCING CORROSION PENETRATION OF THE DRIVER'S SIDE STRUT TOWER ON MY 2000 CHRYSLER TOWN AND COUNTRY LIMITED MINIVAN. THE BODY OF THE VAN INCLUDING THE PASSENGER SIDE STRUT TOWER IS ABSENT OF ANY CORROSION. I JUST BECAME AWARE OF A SERVICE BULLETIN CHRYSLER ISSUED ON OCTOBER 14, 2002 FOR CORRECTING THIS PROBLEM (BULLE…
Read full complaint
I AM EXPERIENCING CORROSION PENETRATION OF THE DRIVER'S SIDE STRUT TOWER ON MY 2000 CHRYSLER TOWN AND COUNTRY LIMITED MINIVAN. THE BODY OF THE VAN INCLUDING THE PASSENGER SIDE STRUT TOWER IS ABSENT OF ANY CORROSION. I JUST BECAME AWARE OF A SERVICE BULLETIN CHRYSLER ISSUED ON OCTOBER 14, 2002 FOR CORRECTING THIS PROBLEM (BULLETIN # 23-044-02). IT SEEMS APPARENT TO ME THAT CHRYSLER HAS BEEN AWARE OF THIS ISSUE FOR SOME TIME AND SHOULD HAVE AS A MINIMUM ALERTED OWNERS TO THIS POTENTIAL PROBLEM BEFORE IT MAGNIFIED ITSELF. I BELIEVE CHRYSLER NOW SHOULD INCUR THE COST FOR REPAIR OF THIS OBVIOUS DEFECT.*JB
NHTSA ODI #10153353
Mileage unknown · Jan 22, 2006
Suspension
2000 CHRYSLER TOWN AND COUNTRY THE STRUT TOWER ON THE DRIVERS SIDE HAS SEVERE RUSTING AND I BELIEVE THAT IF THE STRUT TOWER FAILS, THE VEHICLE WILL BECOME UNSAFE. *NM
NHTSA ODI #10148323
Mileage unknown · Jan 12, 2006
Suspension
DRIVERS SIDE STRUT TOWER IS RUSTING OUT. *JB
NHTSA ODI #10147633
100 miles · Feb 3, 2005
Engine And Engine CoolingSteeringSuspension
THE FRONT DRIVER SIDE TOP STRUT IS COMING THROUGH THE CHASSIS. THE POWER STEERING FAILED WHEN MAKING A RIGHT TURN. THE DRIVER SIDE GETS WET AND THE DRIVER SHOULDER HARNESS IS GETTING WET, AND MOLDING, AND THE ANCHORAGE IS RUSTING. .
NHTSA ODI #10109666
Mileage unknown · Dec 2, 2004
Suspension
THE STRUT TOWERS ARE RUSTING . *AK
NHTSA ODI #10100962
74,000 miles · Nov 24, 2004
Suspension
WHILE THE VEHICLE WAS AT A BODY SHOP, THE MECHANIC INFORMED THE CONSUMER THAT THE FRONT STRUT AND THE STRUT TOWER NEEDED TO BE REPLACED. THE DEALER WAS NOT NOTIFIED. *NM
NHTSA ODI #10101635
Mileage unknown · Jan 15, 2004
EquipmentSuspensionVisibility
NOT KNOWING HOW FAST YOUR DRIVING CAN BE DANGEROUS. I'VE BEEN HAVING THIS PROBLEM WITH MY VAN STARTING WAY BACK IN SEPTEMBER 2001 WITH 13,000 MILES ON IT AND AM STILL HAVING THE SAME PROBLEM. THE PROBLEM IS THE ABS LIGHT COMES ON ALL THE TIME, DASHBOARD LIGHTS FLICKER, THE SPEEDOMETER, ODOMETER AND RPM'S RANDOMLY GO UP AND DO…
Read full complaint
NOT KNOWING HOW FAST YOUR DRIVING CAN BE DANGEROUS. I'VE BEEN HAVING THIS PROBLEM WITH MY VAN STARTING WAY BACK IN SEPTEMBER 2001 WITH 13,000 MILES ON IT AND AM STILL HAVING THE SAME PROBLEM. THE PROBLEM IS THE ABS LIGHT COMES ON ALL THE TIME, DASHBOARD LIGHTS FLICKER, THE SPEEDOMETER, ODOMETER AND RPM'S RANDOMLY GO UP AND DOWN AND SOMETIMES DON'T WORK AT ALL. THEY HAVE TRIED TO FIX THIS PROBLEM MANY TIMES, IT HAS BEEN IN THE SHOP SOMETIMES FOR 2 WEEKS AT A TIME. THEY HAVE REPLACED THE COMPUTER, HARNESS (TWICE), IGNITION SWITCH, FUSES, ETC. THEY JUST HAD IT LAST WEEK AND TODAY I STILL HAVE THE SAME PROBLEM. BASICALLY IT IS AN ELECTRICAL PROBLEM. BY THE WAY, I HAVE BEEN TAKING IT TO A CHRYSLER SHOP IN NANUET, NY. I CALLED THE CHRYSLER CUSTOMER SERVICE 800 NUMBER AND THEY SAID BASICALLY ALL THAT THEY COULD DO IS TO TRY TO HELP THE SERVICE CENTER GET THE RIGHT INFORMATION TO HELP THEM FIX IT. BUT AGAIN, THEY JUST HAD THE CAR LAST WEEK AFTER I CALLED AND THE PROBLEM IS STILL HERE. I HAVE HAD TO RENT CARS AND BORROW CARS TO USE WHILE IT HAS BEEN IN THE SHOP. I REALLY HASN'T COST ME ALL THAT MUCH MONEY BECAUSE THEY ARE FIXING IT (TRYING TO FIX IT) UNDER WARRANTY. I'VE ONLY HAD RENTAL CAR EXPENSES. THE BIG INCONVENIENCE IS GETTING THE CAR TO THE SHOP, ETC... IT HAS BEEN VERY FRUSTRATING TO SAY THE LEAST.
NHTSA ODI #10070243
32,000 miles · Aug 7, 2003
Engine And Engine CoolingService Brakes, HydraulicSteering
VEHICLE LEAF SPRING HAS WEAKENED CAUSING THE REAR OF VEHICLE TO SIT AT AN ANGLE. PROBLEMS WITH FRONT WHEELS AND BRAKES. *MR THE DEALER WAS UNABLE TO REPAIR THE RE-OCCURRING PROBLEM WITH THE FRONT BRAKES, AND THE ROTORS. THE FRONT WHEELS AND OR BRAKES WERE SQUEAKING AGAIN, WHICH MEANT THAT NEW FRONT BRAKES WERE NEEDED AGAIN…
Read full complaint
VEHICLE LEAF SPRING HAS WEAKENED CAUSING THE REAR OF VEHICLE TO SIT AT AN ANGLE. PROBLEMS WITH FRONT WHEELS AND BRAKES. *MR THE DEALER WAS UNABLE TO REPAIR THE RE-OCCURRING PROBLEM WITH THE FRONT BRAKES, AND THE ROTORS. THE FRONT WHEELS AND OR BRAKES WERE SQUEAKING AGAIN, WHICH MEANT THAT NEW FRONT BRAKES WERE NEEDED AGAIN. (THIS WAS THE FOURTH TIME THE BRAKES WERE REPLACED) THE CONSUMER REQUESTED A FULL REFUND OF THE PURCHASE PRICE OF THE VEHICLE. OTHER PROBLEMS ARE AS FOLLOWED: THE LEFT REAR SHOCK HAD BLOWN AND A BOLT HAD BROKEN ON THE RIGHT SHOCK AND WERE REPLACED,THE BRAKE LIGHT WOULD COME ON WHEN GOING AROUND CORNERS, THE REAR VIEW MIRROR WAS LOOSE ALONG WITH THE RIGHT SIDE MIRROR(BOTH READJUSTED), NOISE IN THE STEERING AND WAS HARD TO STEER AT TIMES, THERE WAS A METAL SOUND IN THE FRONT STRUT ESPECIALLY WHEN THE TEMPERATURE WAS COLD, AND THERE WAS OVERHEATING SO THE ALL THE PARTS OF THE COOLING SYSTEM WERE REPLACED. *SCC
NHTSA ODI #10033853
Mileage unknown · Nov 8, 2001
Suspension
WHILE DRIVING UP A HILL HE HEARD A GRINDING SOUND COMING FROM FRONT OF VEHICLE. DEALER COULD NOT FIND A CAUSE. 3 DAYS LATER WHILE DRIVING DOWN HILL THERE WAS SAME GRINDING SOUND AGAIN. *AK
NHTSA ODI #898960
Mileage unknown · Apr 24, 2001
Suspension
GREASE IS ALL OVER BODY OF VEHICLE. SOMEONE TOLD CONSUMER IT WAS FRONT WHEEL BEARING. *AK NUMEROUS ATTEMPTS HAD BEEN MADE TO FIX THE GREASE PROBLEM, BUT THE PROBLEM CONTINUES TO EXIST. THE CONSUMER WAS CONCERNED ABOUT SAFETY. *YH
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
PE04017 · Overheating Of Seat Heaters
Opened Feb 18, 2004 · Closed Jun 21, 2004
Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler
ODI OPENED THIS INVESTIGATION BASED ON 24 COMPLAINTS ALLEGING THAT THE ELECTRICALLY HEATED DRIVER OR PASSENGER SEAT SPARKS/OVERHEATS.DAIMLERCHRYSLER BELIEVES THE FAILURE IS DUE TO ONE OF TWO FACTORS:THE STITCHING OPERATION ON THE SEAT COVER MAY CAUSE THE SEWING NEEDLE TO SEVER SOME STRANDS OF THE WIRE HEATING GRID IN THE SEAT, OR A POOR SOLDER JOINT/WIRE CONNECTOR FAILS DUE TO IMPROPER PROCESSING OR LONG TERM OVERSTRESSING.THE IGNITION SWITCH AND THE SEAT HEATER SWITCH MUST BOTH BE TURNED ON TO POWER THE SEAT HEATER.COMPLAINANTS REPORT THAT WHEN OVERHEATING OCCURS, SWITCHING THE HEATER OFF ALSO STOPS THE OVERHEATING.THE FAILURE CANNOT OCCUR IN AN UNATTENDED VEHICLE WITH THE IGNITION SWITCH OFF.ODI FINDS THAT THE 33 FIRE ALLEGATIONS ARE REPORTING VERY LOCALIZED OVERHEATING(PHOTOS OF DAMAGED SEATS SHOW HOLES THE SIZE OF A PENCIL OR LESS).THERE ARE NO REPORTS OF SUSTAINED COMBUSTION AND NO REPORTS OF OTHER FIRE DAMAGE TO THE VEHICLE.THE INJURY ALLEGATIONS ARE REPORTING MINOR INJURY.NO CONSUMERS REQUIRED MEDICAL TREATMENT (PHYSICIAN CARE).THERE ARE NO ALLEGATIONS OF LOSS OF VEHICLE CONTROL DUE TO FAILURE OF A HEATED SEAT.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
2000 Chrysler Town And Country Problems, Complaints & Recalls | Skip That Year
Illustration