IllustrationWHILE DRIVING AND TURNING ON THE SEAT WARMER WITHIN FIFTEEN SECONDS CONSUMER'S SKIN BURNED. IT DIDN'T MATTER IF IT WAS ON HIGH OR LOW. CONSUMER WAS CONCERNED WITH ELECTRICAL PROBLEMS OR A POSSIBLE FIRE. *AK
2000 Chrysler Town And Country
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2000 Chrysler Town And Country do not stand out strongly from the model-year median of 216.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Town And Country years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
170–25K
1725–50K
4250–75K
3875–100K
29100–150K
25150K+
168 reports with mileage · 138 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 52 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 47 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
26 crash reports16 fire reports15 injury reports
Seats complaints
29 reportsTHE DRIVER AND PASSENGER HEATED SEAT MALFUNCTIONED AND STARTED MELTING AND SMOKING. *JB
WHILE USING THE HEATED DRIVER'S SEAT, SOME SPOTS BECAME VERY HOT. THEN, THE HEATER DID NOT WORK ANYMORE.
DRIVERS HEATER SEAT TO HOT TO USE. MAY START A FIRE IF LEFT ON.*AK
THE CONSUMER NOTICE AN UNUSUAL SMELL INSIDE THE VEHICLE. UPON FURTHER INSPECTION THE CONSUMER NOTICED THAT THE SEAT WARMER WAS ON AND A JACKET WAS IN THE SEAT. WHEN THE CONSUMER REMOVED THE JACKET FROM SEAT SHE SAW BURN HOLES IN THE SEAT AND JACKET. *NM
THE PASSENGER FRONT SEAT CAUGHT ON FIRE. THE OWNER PRESUMED THAT THE WIRING IN THE SEAT WAS DEFECTED. THE VEHICLE IS EQUIPPED WITH HEATED SEATS. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NM
DRIVER'S SIDE SEAT WARMER OVERHEATED AND BURNT THROUGH THE SEAT'S LEATHER AND DRIVER'S CLOTHING. THIS RESULTED IN THE DRIVER'S BACK BEING BURNT. *AK
I JUST READ ABOUT THE SEATBELT CONCERNS, AND I WOULD LIKE TO HELP GET THE BELTS RECALLED. I HAVE TWO CHILDREN AND HAVE NOT HAD AN INCIDENT AND WOULD LIKE TO PREVENT ONE ALSO. *AK
I HAVE A YEAR 2000 CHRYSLER TOWN & COUNTRY VAN THE SEAT HEATER SET FIRE TO THE LEATHER ON THE SEAT. THE DEALER WOULD NOT FIX THE SEAT DUE TO THE VAN BEING UNDER EXTENDED WARRANTY NOT THE FACTORY WARRANTY. FROM THE INFORMATION ON THE NET CHRYSLER KNEW ABOUT THIS PROBLEM IN 1999 AND IT LOOKS LIKE THEY DIDN'T BOTHER TO FIX IT IN …
Read full complaint
I HAVE A YEAR 2000 CHRYSLER TOWN & COUNTRY VAN THE SEAT HEATER SET FIRE TO THE LEATHER ON THE SEAT. THE DEALER WOULD NOT FIX THE SEAT DUE TO THE VAN BEING UNDER EXTENDED WARRANTY NOT THE FACTORY WARRANTY. FROM THE INFORMATION ON THE NET CHRYSLER KNEW ABOUT THIS PROBLEM IN 1999 AND IT LOOKS LIKE THEY DIDN'T BOTHER TO FIX IT IN THE VANS BUILT FOR THE YEAR 2000. HAVING TO PUT OUT A FIRE WHILE DRIVING IS NOT SOMETHING I BARGAINED FOR WHEN I BOUGHT THE VAN. WHAT WOULD HAVE HAPPENED IF NO ONE SAW THE FIRE AND LEFT THE VAN NEXT TO THE HOUSE? *LA
WHILE DRIVING AT 65 MPH AND WITH NO WARNING, THE AUTOMATIC TRANSMISSION FAILED. THE DEALER STATED THAT THE VEHICLE WAS ONLY COVERED UP TO 36000 MILES. *AK THE VEHICLE LURCHED FORWARD, SCREECHED AND THE TRANSMISSION HAD GONE OUT. ALSO, THE FRONT SEAT ADJUSTMENT MOTOR STOPPED WORKING IN THE UP AND DOWN POSITION. *SCC TH…
Read full complaint
WHILE DRIVING AT 65 MPH AND WITH NO WARNING, THE AUTOMATIC TRANSMISSION FAILED. THE DEALER STATED THAT THE VEHICLE WAS ONLY COVERED UP TO 36000 MILES. *AK THE VEHICLE LURCHED FORWARD, SCREECHED AND THE TRANSMISSION HAD GONE OUT. ALSO, THE FRONT SEAT ADJUSTMENT MOTOR STOPPED WORKING IN THE UP AND DOWN POSITION. *SCC THE DRIVER AND PASSENGER WINDOW MOTORS, AC COMPRESSOR,AND THE AUTOMATIC TAILGATE CLOSE LATCH ALL HAD TO BE REPLACED. *JB
Official recalls
204V480000 · Air Bags
Oct 6, 2004
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
00V268000 · Fuel System, Gasoline:fuel Injection System
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
PE04017 · Overheating Of Seat Heaters
Opened Feb 18, 2004 · Closed Jun 21, 2004
Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler
ODI OPENED THIS INVESTIGATION BASED ON 24 COMPLAINTS ALLEGING THAT THE ELECTRICALLY HEATED DRIVER OR PASSENGER SEAT SPARKS/OVERHEATS.DAIMLERCHRYSLER BELIEVES THE FAILURE IS DUE TO ONE OF TWO FACTORS:THE STITCHING OPERATION ON THE SEAT COVER MAY CAUSE THE SEWING NEEDLE TO SEVER SOME STRANDS OF THE WIRE HEATING GRID IN THE SEAT, OR A POOR SOLDER JOINT/WIRE CONNECTOR FAILS DUE TO IMPROPER PROCESSING OR LONG TERM OVERSTRESSING.THE IGNITION SWITCH AND THE SEAT HEATER SWITCH MUST BOTH BE TURNED ON TO POWER THE SEAT HEATER.COMPLAINANTS REPORT THAT WHEN OVERHEATING OCCURS, SWITCHING THE HEATER OFF ALSO STOPS THE OVERHEATING.THE FAILURE CANNOT OCCUR IN AN UNATTENDED VEHICLE WITH THE IGNITION SWITCH OFF.ODI FINDS THAT THE 33 FIRE ALLEGATIONS ARE REPORTING VERY LOCALIZED OVERHEATING(PHOTOS OF DAMAGED SEATS SHOW HOLES THE SIZE OF A PENCIL OR LESS).THERE ARE NO REPORTS OF SUSTAINED COMBUSTION AND NO REPORTS OF OTHER FIRE DAMAGE TO THE VEHICLE.THE INJURY ALLEGATIONS ARE REPORTING MINOR INJURY.NO CONSUMERS REQUIRED MEDICAL TREATMENT (PHYSICIAN CARE).THERE ARE NO ALLEGATIONS OF LOSS OF VEHICLE CONTROL DUE TO FAILURE OF A HEATED SEAT.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available