Engine And Engine CoolingService Brakes, HydraulicSteering
VEHICLE LEAF SPRING HAS WEAKENED CAUSING THE REAR OF VEHICLE TO SIT AT AN ANGLE. PROBLEMS WITH FRONT WHEELS AND BRAKES. *MR THE DEALER WAS UNABLE TO REPAIR THE RE-OCCURRING PROBLEM WITH THE FRONT BRAKES, AND THE ROTORS. THE FRONT WHEELS AND OR BRAKES WERE SQUEAKING AGAIN, WHICH MEANT THAT NEW FRONT BRAKES WERE NEEDED AGAIN…
Read full complaint
VEHICLE LEAF SPRING HAS WEAKENED CAUSING THE REAR OF VEHICLE TO SIT AT AN ANGLE. PROBLEMS WITH FRONT WHEELS AND BRAKES. *MR THE DEALER WAS UNABLE TO REPAIR THE RE-OCCURRING PROBLEM WITH THE FRONT BRAKES, AND THE ROTORS. THE FRONT WHEELS AND OR BRAKES WERE SQUEAKING AGAIN, WHICH MEANT THAT NEW FRONT BRAKES WERE NEEDED AGAIN. (THIS WAS THE FOURTH TIME THE BRAKES WERE REPLACED) THE CONSUMER REQUESTED A FULL REFUND OF THE PURCHASE PRICE OF THE VEHICLE. OTHER PROBLEMS ARE AS FOLLOWED: THE LEFT REAR SHOCK HAD BLOWN AND A BOLT HAD BROKEN ON THE RIGHT SHOCK AND WERE REPLACED,THE BRAKE LIGHT WOULD COME ON WHEN GOING AROUND CORNERS, THE REAR VIEW MIRROR WAS LOOSE ALONG WITH THE RIGHT SIDE MIRROR(BOTH READJUSTED), NOISE IN THE STEERING AND WAS HARD TO STEER AT TIMES, THERE WAS A METAL SOUND IN THE FRONT STRUT ESPECIALLY WHEN THE TEMPERATURE WAS COLD, AND THERE WAS OVERHEATING SO THE ALL THE PARTS OF THE COOLING SYSTEM WERE REPLACED. *SCC
NHTSA ODI #10033853
Mileage unknown · Dec 4, 2002
Electrical SystemEngine And Engine CoolingSteering
ALL 4 INCIDENTS HAPPENED ON A RAINY DAY (SPRING 1X (WIFE DRIVING AND TURNING FROM A STOP LIGHT 5-10 MPH), FALL 2X IN ONE DAY(30-40MPH), LAST INCIDENT 12/4/02 (30-40MPH)). WHEN BELT SLIPS OFF, POWER STEERING DISABLED, POWER BRAKE DISABLED, ALTERNATOR DISABLED, COOLING SYSTEM DISABLED, ENGINE OVERHEATS, STALLS WHEN BATTERY RUNS O…
Read full complaint
ALL 4 INCIDENTS HAPPENED ON A RAINY DAY (SPRING 1X (WIFE DRIVING AND TURNING FROM A STOP LIGHT 5-10 MPH), FALL 2X IN ONE DAY(30-40MPH), LAST INCIDENT 12/4/02 (30-40MPH)). WHEN BELT SLIPS OFF, POWER STEERING DISABLED, POWER BRAKE DISABLED, ALTERNATOR DISABLED, COOLING SYSTEM DISABLED, ENGINE OVERHEATS, STALLS WHEN BATTERY RUNS OUT. LOCAL DEALER (SPIRIT CHRYSLER, LUBBOCK) HAS NO IDEA WHY THE PROBLEM PERSIST. DT
NHTSA ODI #770436
Mileage unknown · Aug 8, 2002
Engine And Engine Cooling
MOUNTING BOLT FOR SERPENTINE BELT IDLER BROKE, COMPLETE LOSS OF POWER STEERING -NO ACCIDENT DUE TO LOW SPEED-WOULD HAVE BEEN DISASTER AT HIGHER SPEED. *AK
NHTSA ODI #765360
Mileage unknown · Jul 2, 2002
Engine And Engine Cooling
WHILE DRIVING 65 MPH VEHICLE LOST POWER STEERING AND POWER BRAKES. DEALER DETERMINED THAT SERPENTINE BELT HAD BROKEN. MILEAGE WAS 10000.*AK
NHTSA ODI #8013177
Mileage unknown · Jun 9, 2001
Engine And Engine CoolingPower TrainService Brakes, Hydraulic
ALL FAILURES OCCURRED WITHIN 2 HOURS. NO SAFETY DEFECT MENTIONED. *AK
NHTSA ODI #746608
Mileage unknown · Sep 18, 2000
Engine And Engine Cooling
ON THREE SEPARATE OCCASIONS CONSUMER EXPIENCED LOSS OF POWER WHILE TRAVELING AT 60 TO 65 MPH. *AK
NHTSA ODI #870807
Mileage unknown · Aug 15, 2000
Engine And Engine CoolingCrash
THE ENGINE "REVVED" DIRECTLY AHEAD OF ME WAS A TELEPHONE POLE, HAD MY FOOT ON THE BRAKES AT THAT TIME IT COULD NOT HOLD TO STOP THE CAR.
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
PE04017 · Overheating Of Seat Heaters
Opened Feb 18, 2004 · Closed Jun 21, 2004
Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler
ODI OPENED THIS INVESTIGATION BASED ON 24 COMPLAINTS ALLEGING THAT THE ELECTRICALLY HEATED DRIVER OR PASSENGER SEAT SPARKS/OVERHEATS.DAIMLERCHRYSLER BELIEVES THE FAILURE IS DUE TO ONE OF TWO FACTORS:THE STITCHING OPERATION ON THE SEAT COVER MAY CAUSE THE SEWING NEEDLE TO SEVER SOME STRANDS OF THE WIRE HEATING GRID IN THE SEAT, OR A POOR SOLDER JOINT/WIRE CONNECTOR FAILS DUE TO IMPROPER PROCESSING OR LONG TERM OVERSTRESSING.THE IGNITION SWITCH AND THE SEAT HEATER SWITCH MUST BOTH BE TURNED ON TO POWER THE SEAT HEATER.COMPLAINANTS REPORT THAT WHEN OVERHEATING OCCURS, SWITCHING THE HEATER OFF ALSO STOPS THE OVERHEATING.THE FAILURE CANNOT OCCUR IN AN UNATTENDED VEHICLE WITH THE IGNITION SWITCH OFF.ODI FINDS THAT THE 33 FIRE ALLEGATIONS ARE REPORTING VERY LOCALIZED OVERHEATING(PHOTOS OF DAMAGED SEATS SHOW HOLES THE SIZE OF A PENCIL OR LESS).THERE ARE NO REPORTS OF SUSTAINED COMBUSTION AND NO REPORTS OF OTHER FIRE DAMAGE TO THE VEHICLE.THE INJURY ALLEGATIONS ARE REPORTING MINOR INJURY.NO CONSUMERS REQUIRED MEDICAL TREATMENT (PHYSICIAN CARE).THERE ARE NO ALLEGATIONS OF LOSS OF VEHICLE CONTROL DUE TO FAILURE OF A HEATED SEAT.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
2000 Chrysler Town And Country Problems, Complaints & Recalls | Skip That Year
Illustration