IllustrationWHEEL BEARINGS KEEP GOING OUT. THIS TIME IT AFFECTED MY GEAR SHIFT.
2003 Chrysler Pt Cruiser
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2003 Chrysler Pt Cruiser do not stand out strongly from the model-year median of 202.
About this comparison →How this year compares
Owner complaints by model year
Compare all Pt Cruiser years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
550–25K
4225–50K
3850–75K
2075–100K
21100–150K
13150K+
189 reports with mileage · 69 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 45 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 35 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 35 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
22 crash reports15 fire reports14 injury reports
Wheels complaints
11 reportsREPEATED WHEEL FAILURES CAUSING TIRE SEALS TO LEAK AIR. MULTIPLE TIRE REPLACEMENTS (5), MULTIPLE SEAL FAILURES RESULTING IN AIR REPLACEMENT. I AM FORCED TO CHECK MY TIRE PRESSURE EVERY TIME I USE MY VEHICLE SINCE I CANNOT TRUST THAT THE SEALS HAVE HELD OR FAILED AT ANY GIVEN TIME. EVERY AUTO REPAIR AND TIRE SPECIALIST I HAVE SPO…
Read full complaint
REPEATED WHEEL FAILURES CAUSING TIRE SEALS TO LEAK AIR. MULTIPLE TIRE REPLACEMENTS (5), MULTIPLE SEAL FAILURES RESULTING IN AIR REPLACEMENT. I AM FORCED TO CHECK MY TIRE PRESSURE EVERY TIME I USE MY VEHICLE SINCE I CANNOT TRUST THAT THE SEALS HAVE HELD OR FAILED AT ANY GIVEN TIME. EVERY AUTO REPAIR AND TIRE SPECIALIST I HAVE SPOKEN WITH IS WELL AWARE OF THIS ISSUE. SO FAR I HAVE SPOKEN TO 3 DIFFERENT AUTO REPAIR SPECIALISTS AND 4 TIRE SPECIALISTS. THE "WHEN DID THIS HAPPEN" OPTION BELOW ONLY AFFORDS ME 1 ENTRY, BUT, THIS HAS BEEN HAPPENING SINCE I PURCHASED THE VEHICLE IN 2013.
2003 CHRYSLER PT CRUISER FACTORY CHROME RIMS 17" CORRODING AND FLAKE OFF CAUSING THE AIR PRESSURE TO DROP OVERNIGHT. CAUSING AN UNSAFE CONDITION RESULTING IN LOSE OF CONTROL AND UNUSUAL TIRE WEAR. *TR
OEM 17" CHROME WHEELS ON 2003 CHRYSLER PT CRUISER GT CORRODE, FLAKE OFF, AND TIRES LOSE PRESSURE OVERNIGHT. LOW TIRE PRESSURE CAN CAUSE THE VEHICLE TO GO OUT OF CONTROL OR SKID. THE CONSUMER IS FORCED TO CHECK TIRE PRESSURE TWICE A DAY. FORGETTING TO DO THIS, EVEN ONCE, CAN LEAD TO AN UNSAFE DRIVING CONDITION. *TR
TL*THE CONTACT OWNS A 2003 CHRYSLER PT CRUISER. THE CONTACT STATED THAT ALL OF THE ORIGINAL RIMS ARE RUSTING AND FLAKING ON THE INSIDE. THE RIMS DESTROY ANY TIRE THAT IS PLACED ON THE VEHICLE. THE DEALER STATED THAT NOTHING COULD BE DONE. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE WAS 62,000 AND FAILURE MILEAGE WAS …
Read full complaint
TL*THE CONTACT OWNS A 2003 CHRYSLER PT CRUISER. THE CONTACT STATED THAT ALL OF THE ORIGINAL RIMS ARE RUSTING AND FLAKING ON THE INSIDE. THE RIMS DESTROY ANY TIRE THAT IS PLACED ON THE VEHICLE. THE DEALER STATED THAT NOTHING COULD BE DONE. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE WAS 62,000 AND FAILURE MILEAGE WAS 42,000.
TL*THE CONTACT OWNS A 2003 CHRYSLER PT CRUISER. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE RIM WAS ROTTING FROM THE INSIDE OUT AND CAUSING EXCESSIVE WEAR ON THE TIRE. AS A RESULT, HE HAS PLACED AIR IN THE TIRE AT LEAST ONCE A DAY FOR THE PAST FOUR MONTHS. THE DEALER AND MANUFACTURER WERE NOTIFIED. THE CURRENT MILEAGE W…
Read full complaint
TL*THE CONTACT OWNS A 2003 CHRYSLER PT CRUISER. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE RIM WAS ROTTING FROM THE INSIDE OUT AND CAUSING EXCESSIVE WEAR ON THE TIRE. AS A RESULT, HE HAS PLACED AIR IN THE TIRE AT LEAST ONCE A DAY FOR THE PAST FOUR MONTHS. THE DEALER AND MANUFACTURER WERE NOTIFIED. THE CURRENT MILEAGE WAS 84,655 AND FAILURE MILEAGE WAS 80,000. THE CONSUMER STATED NOW HAS A 2ND TIRE THAT HE HAS TO MAINTAIN AIR IN EVERY OTHER DAY. THE CONSUMER STATED THE PROBLEM IS THE CENTER HUB COVER BECAUSE IT SNAPS IN PLACE AND LEAVES SPACE FOR SAIL AND OTHER MATERIALS TO ENTER. UPDATED 10/23/07 *TR
THE VEHICLE HAS OEM CHROME ALLOY WHEELS. DUE TO CORROSION THE TIRES WILL NOT PROPERLY SEAL AND THE TIRES CONSTANTLY LEAK AIR PRESSURE. DUE TO CORROSION THE NUTS AND LUGS DO NOT SCREW ON/OFF WITH NORMAL TORQUE. DUE TO CORROSION THE CENTER CAPS WILL NOT STAY SECURELY ON THE WHEEL.*AK
DT*: THE CONTACT STATED A DEFLATED TIRE WAS NOTICED ON THE VEHICLE. AFTER INFLATING THE TIRE, IT WAS DRIVEN TO THE DEALER WHO DETERMINED OXIDATION ON THE RIMS CAUSED SLOW LEAKS IN ALL FOUR TIRES AND SUGGESTED REPLACING THE RIMS.
DT: THE WHEELS ARE CAST ALUMINUM WITH A METAL CHROME PLATE PUT ON IT, ALLOWING AIR LEAKAGE AROUND THE RIMS. THERE WAS CORROSION BETWEEN THE WHEELS AND AXLE. A MECHANIC TOLD THE CONSUMER THAT HE HAD SEEN OTHER SIMILAR VEHICLES WITH THE SAME PROBLEM. THERE WAS A HIGH CHANCE THAT THE WHEEL AND AXLE WILL SEPARATE. THE PROBLEM F…
Read full complaint
DT: THE WHEELS ARE CAST ALUMINUM WITH A METAL CHROME PLATE PUT ON IT, ALLOWING AIR LEAKAGE AROUND THE RIMS. THERE WAS CORROSION BETWEEN THE WHEELS AND AXLE. A MECHANIC TOLD THE CONSUMER THAT HE HAD SEEN OTHER SIMILAR VEHICLES WITH THE SAME PROBLEM. THERE WAS A HIGH CHANCE THAT THE WHEEL AND AXLE WILL SEPARATE. THE PROBLEM FIRST STARTED ON DECEMBER OF 2004. THERE HAVE BEEN NO ACCIDENTS AS OF YET. *AK UPDATED 12/07/05. *JB
DT: THE SPARE TIRE DID NOT FIT ON THE RIM OF THE FRONT TIRES. THE CAR HAS BEEN TAKEN TO THE DEALERSHIP AND THEY WOULD NOT REPLACE THE TIRE. THE MANUFACTURER HAS BEEN CONTACTED ALSO AND THEY WERE NOT ANY HELP EITHER. THE OWNER HAS TRIED TO PUT THE SPARE TIRE ON THE FRONT WHEN SHE HAD A FLAT, BUT THAT DID NOT WORK. THE SPARE ALS…
Read full complaint
DT: THE SPARE TIRE DID NOT FIT ON THE RIM OF THE FRONT TIRES. THE CAR HAS BEEN TAKEN TO THE DEALERSHIP AND THEY WOULD NOT REPLACE THE TIRE. THE MANUFACTURER HAS BEEN CONTACTED ALSO AND THEY WERE NOT ANY HELP EITHER. THE OWNER HAS TRIED TO PUT THE SPARE TIRE ON THE FRONT WHEN SHE HAD A FLAT, BUT THAT DID NOT WORK. THE SPARE ALSO DOESN'T FIT THE FRONT. THIS HAS BEEN A PROBLEM SINCE 2004, WHEN THE OWNER NOTICED IT. THE OWNER WENT AND BOUGHT BRAND NEW TIRES, BUT DID NOT BUY A 5TH TIRE TO MAKE A NEW SPARE. IT IS THE RIM THAT IS THE PROBLEM, NOT THE TIRE ITSELF. *NM
Official recalls
204V268000 · Steering:hydraulic Power Assist:hose, Piping, And Connections
Jun 3, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4L NON-TURBOCHARGED ENGINES AND AUTOMATIC TRANSAXLES, THE POWER STEERING PRESSURE HOSE MAY CONTACT THE AUTOMATIC TRANSAXLE DIFFERENTIAL COVER, POTENTIALLY DAMAGING THE HOSE.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSPECT AND RELOCATE, OR REPLACE AS NECESSARY, THE POWER STEERING HOSE AND CONFIRM TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END. THE RECALL BEGAN ON SEPTEMBER 20, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
03V076000 · Power Train:clutch Assembly
Mar 10, 2003
ON CERTAIN PASSENGER VEHICLES, MANUAL TRANSMISSION MODELS ONLY, A WELDED PIN INTERNAL TO THE DUAL-MASS FLYWHEEL (DMF) ASSEMBLY CAN UNSEAT AND BECOME LODGED BETWEEN THE FLYWHEEL AND THE CLUTCH DISC.
Consequence & remedy
Consequence: IF THIS OCCURS, THE CLUTCH MAY NOT DISENGAGE WHEN THE CLUTCH PEDAL IS DEPRESSED.
Remedy: DEALERS WILL REPLACE THE FLYWHEEL AND CLUTCH ASSEMBLIES WITH THE UPDATED DESIGN PARTS. OWNER NOTIFICATION BEGAN ON APRIL 14, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE04028 · Engine Compartment Fires
Opened Mar 15, 2004 · Closed Jun 18, 2004
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Additional source detail variants (4)
Steering
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:hose, Piping, And Connections
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist System
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.