Illustration2003 PT CRUISER SWAY ARM LINK BAR BROKE.*MR THE VEHICLE WAS 2231 MILES OVER THE WARRANTY WHEN THIS OCCURRED. THE DEALER TOLD THE CONSUMER THAT THIS FAILURE LIKELY OCCURRED DUE TO A DESIGN FLAW. *NM
2003 Chrysler Pt Cruiser
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2003 Chrysler Pt Cruiser do not stand out strongly from the model-year median of 202.
About this comparison →How this year compares
Owner complaints by model year
Compare all Pt Cruiser years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
550–25K
4225–50K
3850–75K
2075–100K
21100–150K
13150K+
189 reports with mileage · 69 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 45 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 35 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 35 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
22 crash reports15 fire reports14 injury reports
Suspension complaints
35 reports2003 PT CRUISER WAS PURCHASED NEW IN 03 AND SHORTLY AFTER HAD TO HAVE TRANSMISSION WORK DONE. NOW I HAVE FRONT END GROANING NOISES THAT, AFTER 5 VISITS TO THE DEALER, CANNOT BE FIXED. CAR SOUNDS LIKE AN ANTIQUE WHEN GOING OVER BUMPS. CAR ALSO DOES NOT HANDLE WELL AND FEELS UNSURE. GALEANA CHRYSLER IN COLUMBIA, SC HAS TRIED 5 TIM…
Read full complaint
2003 PT CRUISER WAS PURCHASED NEW IN 03 AND SHORTLY AFTER HAD TO HAVE TRANSMISSION WORK DONE. NOW I HAVE FRONT END GROANING NOISES THAT, AFTER 5 VISITS TO THE DEALER, CANNOT BE FIXED. CAR SOUNDS LIKE AN ANTIQUE WHEN GOING OVER BUMPS. CAR ALSO DOES NOT HANDLE WELL AND FEELS UNSURE. GALEANA CHRYSLER IN COLUMBIA, SC HAS TRIED 5 TIMES (AS OF 9/8/04) TO FIX PROBLEM, HAS VERIFIED A PROBLEM, BUT CANNOT LOCATE IT. TO DATE, STRUTS, STRUT MOUNTS, TIE ROD ENDS, SWAY BAR BUSHINGS, AND GREASING HAS BEEN REPLACED OR TAKEN PLACE...ALL TO NO AVAIL.*AK
THE FRONT END OF MY 2003 PT CRUISER IS SET TOO LOW. EVEN WITH CARE, THE UNDERSIDE OF THE FRONT BUMPER SNAGS ON PARKING BUMPERS. IT HAS NOW CAUSED THE ENTIRE FRONT SECTION (FROM THE HEADLIGHTS FORWARD) TO CRACK IN THE SIDE AREA AND IS NOW FLOPPING BACK AND FORTH. IS THIS A DESIGN FLAW OR, OR IS THIS SUPPOSED TO BE AN AN ACCEPTABL…
Read full complaint
THE FRONT END OF MY 2003 PT CRUISER IS SET TOO LOW. EVEN WITH CARE, THE UNDERSIDE OF THE FRONT BUMPER SNAGS ON PARKING BUMPERS. IT HAS NOW CAUSED THE ENTIRE FRONT SECTION (FROM THE HEADLIGHTS FORWARD) TO CRACK IN THE SIDE AREA AND IS NOW FLOPPING BACK AND FORTH. IS THIS A DESIGN FLAW OR, OR IS THIS SUPPOSED TO BE AN AN ACCEPTABLE HEIGHT ON THIS FRONT END. *AK
I PURCHASED A 2003 PT CRUISER GT, AFTER TRADING IN MY 2002 PT CRUISER TOURING EDITION. MY '02 HAD A REAR STABILIZER BAR MY '03 DOES NOT. IT IS LISTED ON THE WINDOW STICKER, IT IS SHOWN IN THE 2003 FACTORY SERVICE MANUAL, IT IS SHOWN IN THE 2003 PARTS MANUAL. MY 2003 HAS A LOT MORE BODY ROLL THAN THE 2002 DID. CHRYSLER STATES THE…
Read full complaint
I PURCHASED A 2003 PT CRUISER GT, AFTER TRADING IN MY 2002 PT CRUISER TOURING EDITION. MY '02 HAD A REAR STABILIZER BAR MY '03 DOES NOT. IT IS LISTED ON THE WINDOW STICKER, IT IS SHOWN IN THE 2003 FACTORY SERVICE MANUAL, IT IS SHOWN IN THE 2003 PARTS MANUAL. MY 2003 HAS A LOT MORE BODY ROLL THAN THE 2002 DID. CHRYSLER STATES THEY UPGRADED THE "TWIST BEAM" AND EXTERNAL BAR WAS NOT NEEDED, AND IF INSTALLED COULD BE DANGEROUS, AND VOID SUSPENSION WARRANTY, ACCORDING TO THE SERVICE AND GENERAL MANAGER OF ANTWERPEN MOTOR CARS IN MARYLAND. IF THIS IS TRUE WHY WOULD CHRYSLER OFFER PARTS FOR SALE? I AM CONCERNED OF OTHER SHORT-CUTS THAT MAY HAVE BEEN TAKEN TO SAVE MONEY. A TOP HEAVY VEHICLE LIKE THE PT NEEDS TO CONTROL BODY ROLL FOR SAFETY AND COMFORT OF OCCUPANTS. LIKE I STATED, I OWNED A 2002 MODEL YEAR AND "UPGRADED" TO A 2003. THANKS. *LA
THE COMPLAINT INVOLVES A MISSING PART, THE REAL STABILIZER BAR. THIS MODEL STATES ON THE WINDOW STICKER THAT A REAR STABILIZER BAR IS INCLUDED. THIS CAR DOES NOT HAVE A REAL STABILIZER BAR. THE DEALER SAID THAT HE COULD INSTALL ONE FOR $520. CHRYSLER WOULD NOT REIMBURSE THE DEALER BECAUSE THEY CLAIM THAT THEY BEEFED UP THE R…
Read full complaint
THE COMPLAINT INVOLVES A MISSING PART, THE REAL STABILIZER BAR. THIS MODEL STATES ON THE WINDOW STICKER THAT A REAR STABILIZER BAR IS INCLUDED. THIS CAR DOES NOT HAVE A REAL STABILIZER BAR. THE DEALER SAID THAT HE COULD INSTALL ONE FOR $520. CHRYSLER WOULD NOT REIMBURSE THE DEALER BECAUSE THEY CLAIM THAT THEY BEEFED UP THE REAL AXLE AND THAT IS THEIR STABILIZER BAR. I CONTEND THAT THIS IS MISLEADING THE PUBLIC, PARTICULARLY AN INFORMED PUBLIC THAT KNOWS WHAT A STABILIZER BAR IS. THEY CONTINUE TO PRODUCE THIS MODEL WITH THIS MISLEADING INFORMATION ON THE WINDOW STICKERS. I ASK WHY DO THEY SHOW A REAR STABILIZER BAR IN THEIR PARTS COMPUTER THAT THE DEALER LOCATED AND OFFERED TO INSTALL FOR $520 IF WHAT THEY CLAIM IS TRUE. THE SERVICE MANAGER AGREED THAT THIS WAS MISLEADING BUT REFUSED TO ABSORB THE COSTS. OTHER OWNERS WITH SAME MODEL REPORT THAT THEIR CARS ARE MISSING THIS PART AS WELL. I HOPE THAT YOU CAN CORRECT THIS SITUATION BY REQUIRING CHRYSLER TO INSTALL THE PART AT NO COST TO THE OWNERS. DT
Official recalls
204V268000 · Steering:hydraulic Power Assist:hose, Piping, And Connections
Jun 3, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4L NON-TURBOCHARGED ENGINES AND AUTOMATIC TRANSAXLES, THE POWER STEERING PRESSURE HOSE MAY CONTACT THE AUTOMATIC TRANSAXLE DIFFERENTIAL COVER, POTENTIALLY DAMAGING THE HOSE.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSPECT AND RELOCATE, OR REPLACE AS NECESSARY, THE POWER STEERING HOSE AND CONFIRM TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END. THE RECALL BEGAN ON SEPTEMBER 20, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
03V076000 · Power Train:clutch Assembly
Mar 10, 2003
ON CERTAIN PASSENGER VEHICLES, MANUAL TRANSMISSION MODELS ONLY, A WELDED PIN INTERNAL TO THE DUAL-MASS FLYWHEEL (DMF) ASSEMBLY CAN UNSEAT AND BECOME LODGED BETWEEN THE FLYWHEEL AND THE CLUTCH DISC.
Consequence & remedy
Consequence: IF THIS OCCURS, THE CLUTCH MAY NOT DISENGAGE WHEN THE CLUTCH PEDAL IS DEPRESSED.
Remedy: DEALERS WILL REPLACE THE FLYWHEEL AND CLUTCH ASSEMBLIES WITH THE UPDATED DESIGN PARTS. OWNER NOTIFICATION BEGAN ON APRIL 14, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE04028 · Engine Compartment Fires
Opened Mar 15, 2004 · Closed Jun 18, 2004
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Additional source detail variants (4)
Steering
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:hose, Piping, And Connections
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist System
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.