NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
7 reportsClear category filterMileage unknown · Feb 7, 2024
Electrical SystemEngineSteering
Tried to start car. When start button was pressed the dash lit up like a Christmas tree. Multiple error messages. FCW unavailable, power steering unavailable, fuel door open, park brake unavailable, park sense unavailable, Service hybrid electric system, power steering unavailable. The gear indication, both on dash and by shifte…
Read full complaint
Tried to start car. When start button was pressed the dash lit up like a Christmas tree. Multiple error messages. FCW unavailable, power steering unavailable, fuel door open, park brake unavailable, park sense unavailable, Service hybrid electric system, power steering unavailable. The gear indication, both on dash and by shifter was flashing. The car would not turn off. I had to open hood and disconnect 12v battery for the car to power off. Waited 10 seconds and connected 12v and it power on, but the check engine light is still active
NHTSA ODI #11570442
Mileage unknown · Oct 28, 2022
Electrical SystemSteeringUnknown Or Other
I was driving on a local road and car suddenly stopped running; accelarator unresponsive; power steering not working either. I was able to pull to side. Car said shift P to start , gear change didn't do anything and blinking, check engine light came up. And “check charging system” light came on. It was very dangerous. After 3…
Read full complaint
I was driving on a local road and car suddenly stopped running; accelarator unresponsive; power steering not working either. I was able to pull to side. Car said shift P to start , gear change didn't do anything and blinking, check engine light came up. And “check charging system” light came on. It was very dangerous. After 3-4 minutes I was able to get my car turn off and on and then it drove normal. So I decided to take it in nearby open parking area. It would restart but not do anything even if switched into drive or reverse. Check charging system light on and no power steering again. I had to get it to get it towed the next day from that lot. First tow truck unable to tow due to steering being locked. 2nd tow truck needed help to move car due to steering. Been at dealer for 30 days. They changed charging port but it didn’t work. Now they are changing battery. I don’t want this car back and don’t want to keep making payments on it either. It’s not a safe car.
NHTSA ODI #11491259
Mileage unknown · Apr 17, 2019
SteeringSuspension
FIAT/CHRYSLER WILL NOT GIVE ME A TIME FRAME AS TO WHEN RECALL V15 (RIGHT BALL JOINT ISSUE). I HAVE CALLED SEVERAL DEALERSHIPS AND CHRYSLER CORPORATE AND THEY CANNOT GIVE ME ANY MORE INFORMATION OTHER THAN "WE WILL LET YOU KNOW". THERE IS NO TIME FRAME WHATSOEVER. CURRENTLY MY VANS BALL JOINT IS BAD AND MAKING CLUNKING NOISE…
Read full complaint
FIAT/CHRYSLER WILL NOT GIVE ME A TIME FRAME AS TO WHEN RECALL V15 (RIGHT BALL JOINT ISSUE). I HAVE CALLED SEVERAL DEALERSHIPS AND CHRYSLER CORPORATE AND THEY CANNOT GIVE ME ANY MORE INFORMATION OTHER THAN "WE WILL LET YOU KNOW". THERE IS NO TIME FRAME WHATSOEVER. CURRENTLY MY VANS BALL JOINT IS BAD AND MAKING CLUNKING NOISES AND THEY WILL NOT ADDRESS THIS CONCERN REGARDING A TIME FRAME FOR A FIX FOR IT.
NHTSA ODI #11196961
250 miles · Oct 2, 2018
EngineService BrakesSteering
BRAND NEW, 5 DAY OLD HYBRID PACIFICA WITH 250 MILES STALLED OUT WHILE SLOWING DOWN TO COMPLETE A 3 POINT TURN ON A TWO LANE ROAD. PRIOR TO STALL BRAKES WERE 'MUSHY' AND NOT AS REAPONSIVE, HOWEVER DURING THE TURN BREAKS FAILED COMPLETELY, AND POWER STEERING WENT OUT. FORCED TO SLAM ON BREAKS WHILE FORCING STEERING WHEEL TO COMPLE…
Read full complaint
BRAND NEW, 5 DAY OLD HYBRID PACIFICA WITH 250 MILES STALLED OUT WHILE SLOWING DOWN TO COMPLETE A 3 POINT TURN ON A TWO LANE ROAD. PRIOR TO STALL BRAKES WERE 'MUSHY' AND NOT AS REAPONSIVE, HOWEVER DURING THE TURN BREAKS FAILED COMPLETELY, AND POWER STEERING WENT OUT. FORCED TO SLAM ON BREAKS WHILE FORCING STEERING WHEEL TO COMPLETE TURN. INITIALLY THOUGHT EMERGENCY BREAKING ENGAGED TO STOP CAR THAT WAS NOW HEADED TOWARDS A CURB AND PEDESTRIANS BUT MORE LIKELY HIT THE CURB CAUSING THE CAR TO STOP HARD. CAR REMAINED PURPENDICULAR TO ONCOMING TRAFFIC FOR APPROXIMATELY 2-4 MINUTES WHILE I TRIED TO RESTART ENGINE. 7-8 CARS BEGAN TO BACK UP ON EACH SIDE OF CAR CONTINUING TO CAUSE A INCREASINGLY DANGEROUS SITUATION. HAD NOT EXPERIENCED ANY ISSUE UNTIL 'MUSHY BREAKS' ABOUT 1 BLOCK PRIOR TO 3 POINT TURN AND STALLING. INCREDIBLY DANGEROUS! PURCHASED THIS CAR BASED ON SAFETY RATINGS AND HYBRID FEATURE WITH HOPES OF DRIVING IT FOR A MINIMUM OF 5 YEARS. COMPLETELY TERRIFIED TO PUT MY FAMILY BACK IN THE CAR AS THEY COULD HAVE BEEN SERIOUSLY INJURED OR KILLED DUE ONLY TO CAR MALFUNCTION, AS COULD HAVE THOSE THAT WERE IN THE PATH OF UNRESPONSIVE CAR. UNDER THE CALIFORNIA LEMON LAW I AM EXPECTED TO PUT MY FAMILY BACK INTO A CAR THAT IS DANGEROUS ONLY TO PROVE THAT IT ONCE AGAIN PUT MY FAMILY IN A LIFE THREATENING SITUATION. THIS IS WHY PEOPLE TAKE THESE DANGEROUS CARS TO CAR MAX OR SELL THEM PRIVATELY, WITHOUT FULL DISCLOSURE, SO THEY DON'T HAVE TO PUT THEIR LOVED ONES AT RISK WITHOUT COMPLETELY LOSING $50,000. DANGEROUS CAR! DANGEROUS LAW!
NHTSA ODI #11132868
11,000 miles · Aug 22, 2018
EngineFuel/propulsion SystemSteering
INCIDENT #1 (7/17/2018) - WHILE BREAKING TOWARDS A TRAFFIC LIGHT THAT TURNED FROM RED TO GREEN, I ATTEMPTED TO ACCELERATE BUT HEARD A LOUD POPPING NOISE, FELT THE VAN LURCH, AND IMMEDIATELY LOST ALL POWER TO THE VEHICLE. NUMEROUS WARNING LIGHTS APPEARED ON THE DASHBOARD INCLUDING ENGINE LIGHT & POWER/HYBRID PLUG-IN FAILURE. I WA…
Read full complaint
INCIDENT #1 (7/17/2018) - WHILE BREAKING TOWARDS A TRAFFIC LIGHT THAT TURNED FROM RED TO GREEN, I ATTEMPTED TO ACCELERATE BUT HEARD A LOUD POPPING NOISE, FELT THE VAN LURCH, AND IMMEDIATELY LOST ALL POWER TO THE VEHICLE. NUMEROUS WARNING LIGHTS APPEARED ON THE DASHBOARD INCLUDING ENGINE LIGHT & POWER/HYBRID PLUG-IN FAILURE. I WAS ABLE TO STEER TO THE SIDE OF THE ROAD AND BREAK TO A STOP, AND RESTART 1-2 MINUTES LATER. BROUGHT TO CHRYSLER DEALER ON 7/20 AND WAS TOLD ON 7/21 UPON PICKUP THAT THE ISSUE HAD BEEN RECTIFIED VIA SOFTWARE UPDATE. INCIDENT #2 (7/23/2018) - WHILE MOVING SLOWLY IN TRAFFIC, I ATTEMPTED TO ACCELERATE AS THE VEHICLES AHEAD OF ME MOVED AND AGAIN LOST ALL POWER WITH THE SAME SET OF ERRORS/WARNINGS MENTIONED IN INCIDENT #1. ONCE AGAIN, AFTER 1-2 MINUTES I WAS ABLE TO RESTART THE VEHICLE. I BROUGHT TO A DIFFERENT LOCAL CHRYSLER DEALER THAT SAME DAY. PICKED UP THE VEHICLE ON 7/24 AND WAS TOLD THAT AFTER THOROUGH MULTI-POINT MECHANICAL INSPECTION WITH THE FCA ENGINEERS, THE COMPANY BELIEVED THE PREVIOUS DEALER HAD INCORRECTLY APPLIED THE SOFTWARE UPDATE. DEALER TEST DROVE THE VEHICLE FOR 20 MILES AND COULD NOT RECREATE THE ISSUE. INCIDENT #3 (8/21/2018) - WHILE AGAIN MOVING IN TRAFFIC, MY WIFE (WITH OUR 1 YEAR OLD IN THE BACK) AGAIN SUDDENLY LOST ALL POWER AS MENTIONED IN INCIDENT #1 AND #2 ABOVE, EXCEPT SHE ALSO HAD THE STEERING COMPLETELY LOCK UP ON HER. SHE WAS ABLE TO BREAK TO A STOP MID-TRAFFIC AND RESTARTED THE VEHICLE 1-2 MINUTES LATER. SOON THEREAFTER I CALLED FCA CORPORATE DIRECTLY AND HAVE REQUESTED A FULL REPURCHASE OF THE VEHICLE AND PLAN TO PURSUE LEMON LAW REMEDIATION IF THAT DOESN'T LEAD TO RESOLUTION. ALL THREE INCIDENTS ARE LIFE THREATENING IN NATURE AND HAVE NOT BEEN DIAGNOSABLE BY MULTIPLE CHRYSLER DEALERSHIPS WORKING IN CONJUNCTION WITH FCA ENGINEERS. (IMAGE PROVIDED FROM INCIDENT #2) *TT
NHTSA ODI #11121677
500 miles · Jul 31, 2018
EngineFuel/propulsion SystemSteering
WE WERE DRIVING CAR AT 25 MPH ON BUSY CITY ROAD IN GAS MODE (NOT ELECTRIC MODE) WHEN THE POWER STEERING AND ACCELERATOR STOPPED WORKING. THE CHECK ENGINE AND BATTERY INDICATOR LIGHTS LIT UP, AND A MESSAGE SAYING "CAR MUST BE IN PARK TO CONTINUE DRIVING" SHOWED UP ON THE DASHBOARD. THE BRAKES WORKED, AND WE COASTED TO A STOP AND …
Read full complaint
WE WERE DRIVING CAR AT 25 MPH ON BUSY CITY ROAD IN GAS MODE (NOT ELECTRIC MODE) WHEN THE POWER STEERING AND ACCELERATOR STOPPED WORKING. THE CHECK ENGINE AND BATTERY INDICATOR LIGHTS LIT UP, AND A MESSAGE SAYING "CAR MUST BE IN PARK TO CONTINUE DRIVING" SHOWED UP ON THE DASHBOARD. THE BRAKES WORKED, AND WE COASTED TO A STOP AND WERE STUCK IN THE MIDDLE OF AN INTERSECTION ON A BUSY ARTERY. WHEN WE PUT THE CAR IN PARK, IT WOULD NOT THEN GO BACK INTO DRIVE OR REVERSE; THE "D" AND "R" GEAR LIGHTS WERE FLASHING. THE CAR WOULD NOT TURN OFF, IT WOULD STAY IN RUN MODE WHEN WE TRIED TO TURN IT OFF. BATTERY OPERATED FUNCTIONS, LIKE POWER SLIDING DOORS, STOPPED WORKING. EARLIER IN THE DAY, THE CAR HAD A ROUGH IDLE WHILE IN GAS MODE.
NHTSA ODI #11114767
3,300 miles · Apr 11, 2018
Electrical SystemExterior LightingSteering
I WAS PASSING A SLOW MOVING MOTOR HOME ON STATE ROAD 19 OCALA NATIONAL FOREST . IN THE MIDDLE OF MY PASS THE ENGINE CUT OFF. I HAD ENOUGH SPEED TO FINISH MY PASS SAFELY AND PULL TO THE SIDE OF ROAD. ALL THE PANEL LIGHTS WERE FLASHING AND THE CAR WOULD NOT RESTART. I CALLED ROADSIDE ASSISTANCE CHRYSLER AND AFTER FOUR HOURS THE VE…
Read full complaint
I WAS PASSING A SLOW MOVING MOTOR HOME ON STATE ROAD 19 OCALA NATIONAL FOREST . IN THE MIDDLE OF MY PASS THE ENGINE CUT OFF. I HAD ENOUGH SPEED TO FINISH MY PASS SAFELY AND PULL TO THE SIDE OF ROAD. ALL THE PANEL LIGHTS WERE FLASHING AND THE CAR WOULD NOT RESTART. I CALLED ROADSIDE ASSISTANCE CHRYSLER AND AFTER FOUR HOURS THE VEHICLE WAS TOWED TO THE NEAREST CHRYSLER DEALER. THE CAR HAS BEEN AT BECK PALATKA FLORIDA, CHRYSLER SINCE APRIL FIRST. THEY INFORMED AFTER FIVE DAYS THAT THEY WERE NOT EQUIPPED TO HANDLE REPAIRS BECAUSE OF THE NEW TECHNOLOGY ON THIS VEHICLE. I HAVE NOW BEEN INFORMED THAT I WILL HAVE TO PAY FOR TOWING FROM DEALER IN PALATKA TO THE ST. AUGUSTINE DEALER. I FEEL CONCERN FOR MY SAFETY DRIVING THIS NEW CHRYSLER HYBRID IF IT CAN BE REPAIRED. WE COULD HAVE HAD LOSS OF LIFE HAD ANOTHER VEHICLE STRUCK OUR VEHICLE APPROACHING HEAD ON. I HAD NO ACCELERATION IN THE MIDDLE OF MY PASSING, AND WITH MY WIFE AND GRANDCHILDREN IN THE CAR, THIS SITUATION COULD HAVE BEEN TRAGIC. MY CASE NUMBER IS 33839387 AND I HAVE BEEN INFORMED THAT IT IS GOING TO BE TRANSFERRED TO ANOTHER PERSON! PLEASE ADVISE AS TO MY NEXT STEP IN THIS PROCESS.
NHTSA ODI #11084554
Official recalls
6Jul 18, 2024
Chrysler (FCA US, LLC) is recalling certain 2017-2018 Pacifica Plug-In Hybrid Electric (PHEV) vehicles that received a software update remedy under NHTSA recall number 22V-077. The battery pack may cause a vehicle fire when parked, even with the ignition in the "Off" position.
Consequence & remedy
Consequence: A vehicle fire increases the risk of injury.
Remedy: Owners are advised not to charge their vehicles, and to park outside and away from structures, until they are repaired. Dealers will update the high voltage battery pack control module (BPCM) software. In addition, dealers will inspect and if necessary, replace the battery pack assembly. Repairs will be performed free of charge. Interim notification letters, notifying owners of the safety risk, were mailed August 1, 2024. Owner notification letters were mailed December 12, 2024. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is 73B. Vehicles previously repaired under recall 22V-077 will need to have the new remedy completed.
Feb 11, 2022
Chrysler (FCA US, LLC) is recalling certain 2017-2018 Pacifica Plug-In Hybrid Electric Vehicles (PHEV). A vehicle fire can occur when parked, even with the ignition in the "Off" position.
Consequence & remedy
Consequence: A vehicle fire increases the risk of injury.
Remedy: Owners are advised not to recharge their vehicles, and to park outside and away from structures, until they are repaired. Dealers will update the high voltage battery pack control module (BPCM) software. In addition, dealers will inspect and if necessary, replace the battery pack assembly. Repairs will be performed free of charge. Interim letters, informing owners of the safety risk were mailed on February 25, 2022. Final owner notification letters were mailed October 6, 2022. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is Z11. This recall is superseded by NHTSA recall 24V-538.
Jun 9, 2020
Chrysler (FCA US LLC) is recalling certain 2017-2020 Pacifica Plug-in Hybrid Electric Vehicles ("PHEV"). The 12 volt isolator post located behind the driver's seat may develop high resistance.
Consequence & remedy
Consequence: A high resistance electrical connection may result in the connection overheating, increasing the risk of a fire with the vehicle on or off.
Remedy: FCA will conduct a voluntary safety recall on affected vehicles to increase the torque and install a waterproof gasket to the 12v isolator post, the post will also be inspected for signs of contamination. In the event the post is compromised, the 12v isolator post and associated cables will be replaced. Until the final remedy is available, customers should bring their vehicles to dealers for an interim inspection of this joint. The recall remedy is currently under development. FCA US LLC will notify owners, and dealers will perform an interim inspection of this joint. If the inspection indicates the joint is compromised, owners will receive a loaner vehicle, until a final remedy is developed. Interim notifications are expected to begin around June 22, 2020. The recall began July 30, 2020. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is W46. Note: Consumers are advised to exercise the following precautions until the vehicle has the final repair completed: do not park these vehicles inside of buildings or structures, or near other vehicles. Additionally, keep liquids out of the backseat area, including but not limited to beverages, wet items, umbrellas, or bottled liquids that may leak.
Additional source detail variants (2)
Electrical System:wiring:interior/under Dash
Chrysler (FCA US LLC) is recalling certain 2017-2020 Pacifica Plug-in Hybrid Electric Vehicles ("PHEV"). The 12 volt isolator post located behind the driver's seat may develop high resistance.
Consequence: A high resistance electrical connection may result in the connection overheating, increasing the risk of a fire with the vehicle on or off.
Remedy: FCA will conduct a voluntary safety recall on affected vehicles to increase the torque and install a waterproof gasket to the 12v isolator post, the post will also be inspected for signs of contamination. In the event the post is compromised, the 12v isolator post and associated cables will be replaced. Until the final remedy is available, customers should bring their vehicles to dealers for an interim inspection of this joint. The recall remedy is currently under development. FCA US LLC will notify owners, and dealers will perform an interim inspection of this joint. If the inspection indicates the joint is compromised, owners will receive a loaner vehicle, until a final remedy is developed. Interim notifications are expected to begin around June 22, 2020. The recall began July 30, 2020. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is W46. Note: Consumers are advised to exercise the following precautions until the vehicle has the final repair completed: do not park these vehicles inside of buildings or structures, or near other vehicles. Additionally, keep liquids out of the backseat area, including but not limited to beverages, wet items, umbrellas, or bottled liquids that may leak.
Electrical SYSTEM:12V/24V/48V Battery:cables
Chrysler (FCA US LLC) is recalling certain 2017-2020 Pacifica Plug-in Hybrid Electric Vehicles ("PHEV"). The 12 volt isolator post located behind the driver's seat may develop high resistance.
Consequence: A high resistance electrical connection may result in the connection overheating, increasing the risk of a fire with the vehicle on or off.
Remedy: FCA will conduct a voluntary safety recall on affected vehicles to increase the torque and install a waterproof gasket to the 12v isolator post, the post will also be inspected for signs of contamination. In the event the post is compromised, the 12v isolator post and associated cables will be replaced. Until the final remedy is available, customers should bring their vehicles to dealers for an interim inspection of this joint. The recall remedy is currently under development. FCA US LLC will notify owners, and dealers will perform an interim inspection of this joint. If the inspection indicates the joint is compromised, owners will receive a loaner vehicle, until a final remedy is developed. Interim notifications are expected to begin around June 22, 2020. The recall began July 30, 2020. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is W46. Note: Consumers are advised to exercise the following precautions until the vehicle has the final repair completed: do not park these vehicles inside of buildings or structures, or near other vehicles. Additionally, keep liquids out of the backseat area, including but not limited to beverages, wet items, umbrellas, or bottled liquids that may leak.
Feb 28, 2019
Chrysler (FCA US LLC) is recalling certain 2018 Chrysler Pacifica and Pacifica hybrid vehicles. The right front lower control arm may separate from the steering knuckle.
Consequence & remedy
Consequence: A control arm separation could increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the right front knuckle and lower control arm for damage, replacing the components as necessary. The right front lower control arm knuckle pinch bolt will be replaced with a larger-diameter pinch bolt. These repairs will be performed free of charge. The recall began April 26, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V15.
Oct 19, 2018
Chrysler (FCA US LLC) is recalling certain 2017-2018 Chrysler Pacifica Plug-in Hybrid Electric vehicles (PHEV). After the vehicle has been operating in PHEV propulsion mode, the gas-fueled engine may not restart properly resulting in unburned fuel entering the exhaust catalyst.
Consequence & remedy
Consequence: The improperly started engine could result in a loss of motive power increasing the risk of a crash or the unburned fuel in the catalyst may ignite increasing the risk of a fire.
Remedy: FCA will notify owners, and dealers will update the powertrain controller module software, and inspect and replace the catalytic converter as necessary, free of charge. The recall began November 15, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U94.
Additional source detail variants (2)
Hybrid Propulsion System
Chrysler (FCA US LLC) is recalling certain 2017-2018 Chrysler Pacifica Plug-in Hybrid Electric vehicles (PHEV). After the vehicle has been operating in PHEV propulsion mode, the gas-fueled engine may not restart properly resulting in unburned fuel entering the exhaust catalyst.
Consequence: The improperly started engine could result in a loss of motive power increasing the risk of a crash or the unburned fuel in the catalyst may ignite increasing the risk of a fire.
Remedy: FCA will notify owners, and dealers will update the powertrain controller module software, and inspect and replace the catalytic converter as necessary, free of charge. The recall began November 15, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U94.
Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor
Chrysler (FCA US LLC) is recalling certain 2017-2018 Chrysler Pacifica Plug-in Hybrid Electric vehicles (PHEV). After the vehicle has been operating in PHEV propulsion mode, the gas-fueled engine may not restart properly resulting in unburned fuel entering the exhaust catalyst.
Consequence: The improperly started engine could result in a loss of motive power increasing the risk of a crash or the unburned fuel in the catalyst may ignite increasing the risk of a fire.
Remedy: FCA will notify owners, and dealers will update the powertrain controller module software, and inspect and replace the catalytic converter as necessary, free of charge. The recall began November 15, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U94.
Aug 9, 2018
Chrysler (FCA US LLC) is recalling certain 2018 Jeep Renegade, Compass and Grand Cherokee, RAM 1500 and Promaster, Fiat 500x, Dodge Journey, Challenger, Charger and Durango and Chrysler 300x vehicles, 2017-2018 Jeep Wrangler, Dodge Grand Caravan and Chrysler Town and Country vehicles and 2018-2019 Jeep Cherokee and 2018 Chrysler Pacifica and Pacifica Hybrid vehicles. The powertrain control module may be equipped with a voltage regulator chip in the circuit board that may fail, causing a stall or a no start condition.
Consequence & remedy
Consequence: A vehicle stall can increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the powertrain control module, free of charge. The recall began October 2, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U87.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE24028 · Electrical Arcing And Thermal Events, Potentially Leading To Fires, While Utilizing Enel X Way Usa, Llc's Juicebox Residential Charger.
Opened Oct 3, 2024 · Closed Jun 5, 2025
Status: closed (inferred from source dates) · Equipment:electrical
On October 3, 2024, the Office of Defects Investigations (ODI) opened PE24028 to investigate alleged failures of Enel X Way's JuiceBox Level 2 residential EV chargers. The allegations were described as thermal incidents and electrical malfunctions, which could trip the circuit breakers in Juicebox owners’ homes and disrupt electric vehicle charge cycles. On October 2, 2024, Enel X Way posted on its website that Enel X Way North America would cease operations in the United States and Canada on October 11, 2024. The closure would potentially impact the charging app and supporting software. ODI sent Enel X Way an Information Request (IR) letter on October 21, 2024. Enel X Way provided an incomplete response to the IR on December 9, 2024. Enel X Way later provided a complete response to the IR on January 24, 2025. ODI reviewed Enel X Way’s IR submissions to determine whether further action is required. Based on ODI’s analysis, there was no clear trend in the cause of the failures described in customer complaints and warranty reports. Additionally, there have been no recent reports alleging safety issues. The available information does not warrant further action at this time. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency will continue to monitor for any safety trends and reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in this Closing Resume, go to NHTSA.gov.
RQ24004 · Loss Of Motive Power Due To An Internal Wiring Connector Short.
Opened Feb 27, 2024 · No close date supplied
Status: open (inferred from source dates) · Electrical System:wiring
On July 22, 2022, the Office of Defects Investigation (ODI) opened investigation PE22-008 regarding complaints alleging a loss of motive power condition potentially due to a transmission malfunction in Model Years 2019-2021 Chrysler Pacifica Plug-In Hybrid Electric Vehicles (PHEV). On January 17, 2023, Fiat Chrysler Automobiles (FCA) issued safety recall (NHTSA Recall 23V-010) involving 2017-2023 Model Years (MY) Pacifica Plug-In Hybrid Electric Vehicles (PHEV) produced between August 12, 2016, through January 9, 2023. The recall states that the loss of motive power condition in these vehicles is caused by an internal transmission wiring connector that may short circuit, resulting in an unexpected engine shutdown. An unexpected engine shutdown can cause a loss of drive power, increasing the risk of a crash. In discussions with FCA on Recall 23V-010, ODI confirmed the recall was related to investigation PE22-008. The remedy for 23V-010 is to update the Power Inverter module (PIM) and/or Instrument Panel Cluster (IPC) software to provide drivers a message stating “Stop Safely - Vehicle Will Shut Off Soon” followed by a chime and MIL, PRNDL blinking (on cluster and shifter knob), low SOC (State of Charge) warning and reduced power mode. The recall remedy does not replace the defective hardware that was described in Recall 23V-010, and the wiring connector short still exists on these vehicles. To date, ODI has received 132 reports for the population of vehicles subject to recall 23V-010. These reports allege a loss of motive power condition that reduces the vehicles speed, followed by dashboard warning lamps displaying messages associated with recall 23V-010. The presence of these warning lamps and messages indicates the vehicle likely had the recall remedy applied. Follow up discussions with FCA confirm their remedy does not prevent a loss of motive power, but instead limits torque to the engine and after an unspecified number of miles or period of time, the engine will shut down. When this occurs, FCA relies on the owner to transport the vehicle to a dealership after they experience a loss of motive power condition, at which time the defective hardware is replaced. Furthermore, the dashboard messages introduced in the recall remedy may cause the driver to pull over in an unsafe location. Pulling over in an unsafe location may expose the occupants to undue harm. The Office of Defects Investigation is opening this Recall Query (RQ) to assess the adequacy, frequency, and safety consequence of the remedy for recall 23V-010. To review the ODI reports cited in the opening resume ODI report identification number document, go to NHTSA.gov.
RQ24001 · Ignition-off High Voltage Battery Fire (remedy Effectiveness Of Recall 22V-077)
Opened Jan 16, 2024 · No close date supplied
Status: open (inferred from source dates) · Electrical System:propulsion System:traction Battery
On February 11, 2022, Fiat Chrysler Automobiles (FCA) issued a safety recall (NHTSA Recall 22V-077) on all 2017-2018 Pacifica Plug-In Hybrid Electric Vehicles (PHEV) produced between August 12, 2016 through August 7, 2018. The recall addresses ignition “OFF’ fires that originate at the high voltage (HV) battery pack assembly. An ignition ‘OFF’ vehicle fire can result in an increased risk of occupant injury, injury to persons outside the vehicle, and property damage, with little to no warning. At the time of the recall filing the root cause of the vehicle fires was unknown and under investigation by FCA and suppliers. A software remedy designed to improve thermal event detectability by monitoring battery diagnostics is currently being installed on subject vehicles as an interim remedy. As of November 23, 2023, the root cause of the battery failure is unknown. From December 2022 through December 2023, NHTSA has received four consumer complaints (VOQs) alleging vehicle thermal events involving recalled 2017 and 2018 Chrysler Pacifica PHEVs. Additional information collected from complainants confirmed a thermal event originating near or at the HV battery pack after the Recall 22V077 remedy had been applied to the vehicle. Follow up meetings with FCA and suppliers in November and December 2023 to discuss the ongoing root cause investigation and post-recall remedy incidents indicated a recent increase in HV battery thermal events. Furthermore, a review of NHTSA complaint data indicated the post-recall HV battery thermal event complaint rate now exceeds pre-recall levels. The Office of Defects Investigation (ODI) is opening this Recall Query (RQ) to review the effectiveness of the original recall remedy, understand the root cause of the battery fires, investigate additional reports of Pacifica PHEV HV battery fires, and to increase monitoring of the manufacturer root cause investigation. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE22008 · Transmission Fault Leading To Loss Of Motive Power
Opened Jul 22, 2022 · Closed Mar 27, 2024
Status: closed (inferred from source dates) · Power Train
On July 22, 2022, the Office of Defects Investigation (ODI) opened PE22008 to investigate allegation of loss of motive power, potentially due to transmission malfunction, in certain Chrysler Pacifica vehicles. In a January 17, 2023 letter to NHTSA, Fiat Chrysler Automobiles (FCA) submitted recall notice 23V-010 involving a transmission motor wiring defect in 67,118 model year (MY) 2017-2023 Chrysler Pacifica plug-in hybrid electric vehicles (PHEVs) manufactured from August 12, 2016 through January 9, 2023. FCA determined that an internal transmission connector short could result in an unexpected engine shutdown under certain conditions. Follow up correspondence with FCA confirmed this defect results in an electric motor position trouble code that was the basis for opening PE22008, therefore NHTSA is closing this investigation. The 23V-010 recall remedy is a software update to address the hardware failure associated with PE22008. When a hardware failure is detected, the vehicle limits motive power while instructing the driver to pull over to a safe location. NHTSA is concerned that drivers will pull over to an unsafe location when the warning message associated with the recall remedy displays on the dashboard. Due to the nature of the recall remedy and related reports, NHTSA has opened Recall Query RQ24004 to assess the recall remedy. The reports and failure report summary values included with this closing action are related to allegations of Recall 23V-010 remedy inadequacy. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration