Electrical System. Review the 83 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Hybrid Propulsion System. Review the 75 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 63 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

3 crash reports12 fire reports1 injury reports

Fuel/propulsion System complaints

19 reports

Clear category filter

7,000 miles · May 25, 2019

EngineFuel/propulsion SystemVehicle Speed Control

Read full complaint

I WAS DRIVING THE VEHICLE WITH MY FAMILY. WE HAD ALREADY USED UP THE CHARGE FOR THE ELECTRIC ENGINE AND THE VEHICLE WAS OPERATING IN THE HYBRID ENGINE. I HAD THE ADAPTIVE CRUISE CONTROL SET AT 72 MPH AND I ACCELERATED TO 75 MPH TO CHANGE LANES TO THE RIGHT. AS I ACCELERATED, SEVERAL ALARMS AND WARNINGS APPEARED ON THE DRIVER'S DASHBOARD. THEY INCLUDED 'SERVICE HYBRID SYSTEM', A RED WRENCH WITH A RED LIGHTING BOLT THROUGH IT AND THE ORANGE ENGINE AND BATTERY ICONS. AFTER THE ALARMS SOUNDED, A MESSAGE APPEARED SAYING 'SHIFT VEHICLE TO PARK'. WHEN I TRIED TO PRESS THE ACCELERATOR, NOTHING HAPPENED AND IT SEEMED THAT THE ENGINE HAD STALLED. I WAS ABLE TO COAST TO THE SHOULDER OF THE HIGHWAY, BREAK THE VEHICLE AND TURN ON MY FLASHERS. AFTER WE STOPPED, I PUT THE VEHICLE IN PARK, SHUT THE VEHICLE OFF, AND RESTARTED IT. AFTER RESTARTING THE VEHICLE, THE ORANGE ENGINE WARNING LIGHT REMAINED ON. MY FAMILY AND I WERE ABLE TO TRAVEL BACK HOME BUT TOOK BACK ROADS RATHER THAN THE HIGHWAY.

NHTSA ODI #11209982

2,000 miles · May 13, 2019

Electrical SystemFuel/propulsion SystemPower Train

Read full complaint

SIMILAR FRUSTRATING EXPERIENCE HERE FOR THE 2019 PACIFICA HYBRID LIMITED. BOUGHT BRAND NEW IN DEC. 2018. NOW ONLY 2,000 MILES ON IT, THE MINIVAN RATTLED ON STARTUP (WITH 60% CHARGED) AND COULD BARELY ACCELERATE WHEN I TRIED MERGING INTO A MAIN ROAD. THE VEHICLE PUT ITSELF INTO A LOW-SPEED MODE (AKA THE FAMOUS 'RED TURTLE MODE'), AND THEN WOULD NO LONGER ACCELERATE AT ALL! FORTUNATELY, I WAS ABLE TO PULL OVER INTO A PARKING LOT. UNABLE TO FIX THE ISSUE BY PUTTING INTO 'P' GEAR, HAD TO COMPLETELY TURN OFF, LOCK THE VEHICLE, THEN CAME BACK TO START THE VEHICLE TO RECOVER THE POWER. HOWEVER, THE ENGINE LIGHT STILL LEFT ON. AFTER VISITING THE DEALERSHIP, THEY DECIDED TO REPLACE THE HIGH VOLTAGE BATTERY. IT TOOK MORE THAN 40 DAYS FOR THE WHOLE PROCESS. IT'S FAR FROM THE ENDING OF THIS TERRIBLE EXPERIENCE SINCE MULTIPLE FAULTS CAME AFTER PICKING UP THE VEHICLE. WITHIN ONE WEEK AFTER PICKING UP THE VEHICLE, WE EXPERIENCED ANOTHER ENGINE LIGHT ON AND ONE NEW WARNING LIGHT 'SERVICE HYBRID ELECTRIC VEHICLE SYSTEM' (A RED ELECTRICAL WRENCH SYMBOL). BOTH LIGHTS ENDED UP WITH DISAPPEARING THEMSELVES AFTER DRIVING SOME DISTANCE. LASTLY, WE EXPERIENCED MORE THAN THREE TIMES ENTERTAINMENT SYSTEMS AUTOMATICALLY TURNED OFF THEN BACK ON WITHOUT ANY CLUE. THESE HAPPENED TWICE WHILE I WAS CRUISING ON THE HIGHWAY, AND ONCE HAPPENED IN THE PARKING LOT WHILE I WAS BACKING INTO THE PARKING LOT.

NHTSA ODI #11207371

2,000 miles · Feb 19, 2019

Electrical SystemFuel/propulsion SystemStructure

Read full complaint

GAS DOOR OPENS VIA A PUSHBUTTON. PUSH THE BOTTON, AND IT CHECKS FOR PRESSURE IN THE SYSTEM, THEN RELEASES DOOR. WHEN CLOSED, AND THE STARTER ACTIVATED, DOOR RE-OPENS. MUST EXIT VEHICLE TO RE-CLOSE. IT STAYS SHUT UNTIL NEXT OPENED WITH BUTTON. CLOSE DOOR, HIT STARTER, DOOR RE-OPENS. DOES NOT REOPEN UNTIL NEXT OPENED WITH BUTTON. DEALER, FCA FIELD TECH UNABLE TO FIX, 45 DAYS IN SHOP. VEHICLE STATIONARY AT EACH OCCURRENCE.PCM, BCM, OTHER COMPONENTS REPLACED, WIRING HARNESS INSPECTED; SEE ATTACHED. ISSUE NOTED ON DECEMBER ROAD TRIP, TAKEN TO DEALER ONCE HOME. PLACED IN SHOP 8 OR 9 JANUARY 2019. GAS DOOR RELEASE DESCRIBED AND PROBLEM IS DESCRIBED IN ATTACHED DOCUMENT.

NHTSA ODI #11181118

100 miles · Jan 26, 2019

Electrical SystemFuel/propulsion SystemUnknown Or OtherFire

CAR STALLED AND BEGAN SMOKING PROFUSELY WHEN ATTEMPTING TO ACCELERATE AFTER BEING STOPPED AT A RED LIGHT. CAR WAS REPAIRED AS PER RECALL (WHICH WAS KNOWN ABOUT AT THE TIME BUT WE WERE TOLD IT SHOULD NOT HAVE AFFECTED OUR CAR). CAR CONTINUED TO SMELL OF SMOKE AFTER TRANSITION FROM ELECTRIC TO GAS MODE. DEALER WAS UNABLE TO PINPOI…

Read full complaint

NHTSA ODI #11172281

5,492 miles · Jan 21, 2019

EngineFuel/propulsion SystemHybrid Propulsion System

Read full complaint

WHILE DRIVING AT 60MPH ON FREEWAY, VEHICLE LOST ENGINE POWER WITHOUT WARNING AND WAS NO LONGER RESPONSIVE TO GAS PEDAL. NOT ENOUGH TIME TO MANEUVER OUT OF TRAFFIC. FIRST OCCURRED 2 WEEKS AFTER NEW VEHICLE PURCHASE. OUT OF SERVICE FOR 15 DAYS THEN RETURNED TO OWNER AFTER SOFTWARE UPDATE. SAME PROBLEM OCCURRED AGAIN 3 MONTHS LATER, DRIVING ON FREEWAY AT 60MPH. HAS CURRENTLY BEEN OUT OF SERVICE FOR 19 DAYS. DEALERSHIP SERVICE DEPARTMENT HAS ORDERED NEW POWER INVERTER MODULE (HYBRID MOTOR). *BF.. *TR

NHTSA ODI #11171161

680 miles · Jan 14, 2019

Electrical SystemFuel/propulsion SystemService Brakes

Read full complaint

THIS MORNING MY 2018 HYBRID LIMITED WAS DEAD. I PURCHASED IT NEW THREE WEEKS AGO. IT HAD BEEN PLUGGED IN OVERNIGHT USING THE 110 CHARGER THAT CAME WITH THE VAN. IT WOULD NOT START, AND BRIEFLY FLASHED SOME KIND OF SERVICE NEEDED WARNING ON THE SCREEN. THEN THE SCREEN TURNED OFF AND THE VEHICLE REPEATEDLY MADE A CLICKING SOUND. THE VAN WAS COMPLETELY UNRESPONSIVE. I NOTICED THE WINDSHIELD WIPERS WERE EVER SO SLOWLY IN MOTION BACK AND FORTH. I CHECKED THE SWITCH BUT THE WIPER WAS SET TO THE 'OFF' POSITION. NONE OF THE WIPER CONTROLS WOULD CHANGE THE SETTING. THE DEALERSHIP SET ME UP WITH A NUMBER FOR CHRYSLER TOW. I WAS ON THE PHONE ABOUT 20FT AWAY WHEN SUDDENLY THE VAN STARTED ROLLING BACKWARD DOWN THE DRIVEWAY AND INTO THE STREET! I RAN OVER AND CHECKED IT AND STILL EVERYTHING WAS UNRESPONSIVE, THE WIPERS NO LONGER MOVING HOWEVER THE PARKING BRAKE BUTTON, AND SHIFTER BUTTONS, AND OVERHEAD LIGHTS WERE FLASHING. WE HAD THE VAN TOWED TO THE DEALERSHIP. THEY SAID THE BATTERY WAS BAD AND REPLACED IT. BELOW IS A POST ABOUT MY EXPERIENCE WITH MORE INFORMATION AND VIDEOS: HTTPS://WWW.PACIFICAFORUMS.COM/FORUM/433-2017-CHRYSLER-PACIFICA-PHEV-HYBRID-GENERAL-DISCUSSION/41697-BATTERY-DIES-PACIFICA-HYBRID-ROLLS-OUT-DRIVEWAY-INTO-STREET.HTML ALSO HERE IS VIDEO TAKEN IMMEDIATELY AFTER IT ROLLED. NOTE THE INTERIOR LIGHTS ACTIVELY FLASHING INCLUDING THE PARKING BRAKE INDICATOR AS WELL AS THE DIGITAL SHIFTER KNOB LIGHTS. HTTPS://YOUTU.BE/6_LY7BLNJNS HTTPS://YOUTU.BE/JFCP0IDBFQI ALSO, AFTER RESEARCHING ONLINE I FOUND SOMEONE ELSE WHO ALSO HAD THE BRAKES DISENGAGE WITH 12V BATTERY ISSUE.. HER EXPERIENCE CAN BE FOUND HERE (SEE POST #3): HTTPS://WWW.PACIFICAFORUMS.COM/FORUM/433-2017-CHRYSLER-PACIFICA-PHEV-HYBRID-GENERAL-DISCUSSION/40261-BRAND-NEW-HYBRID-COMPLETELY-DIED.HTML CHRYSLER NEEDS TO ADDRESS THIS SERIOUS AND DANGEROUS ISSUE!

NHTSA ODI #11169945

1,400 miles · Oct 21, 2018

EngineFuel/propulsion System

Read full complaint

MY FAMILY AND I WERE RIDING ALONG AT 70 MPH AND SUDDENLY, THE LEFT SIDE ENERGY CONSUMPTION METER STARTED BOUNCING UP AND DOWN. SOME BURNT RUBBER SMELL CAME THROUGH THE VENTS AND THEN THE CAR JUST START SLOWING DOWN. I WAS LUCKY THERE WERE NO CARS AROUND ME AND WAS ABLE TO MAKE IT ACROSS 4 LANES TO THE RIGHT HAND SIDE SHOULDER. ALL OF THE LIGHTS ON MY DASH WERE LIT BUT THE ENGINE DEPARTMENT OBVIOUSLY DEAD. I POWERED THE CAR DOWN AND TRIED TO CRANK IT AGAIN BUT THE COMPUTER WAS CONFUSED ABOUT WHICH GEAR I WAS IN. NOW, THE DASH ONLY SHOWED THE ENGINE LIGHT AND BATTERY LIGHT. AFTER TRYING THIS SEVERAL MORE TIMES, I GAVE UP AND CALLED THE FCA TOW TRUCK WHICH WAS A HORROR STORY ALL ON ITS OWN. TOOK ME LONGER TO GET AND FCA REP ONLINE AND CONVERSATION FINALIZED (30 MIN) THAN IT TOOK THE TOW TRUCK TO GET TO MY LOCATION (15 MIN). BEFORE THE TOW TRUCK GOT TO MY LOCATION, I WAS ABLE TO START THE CAR IN GAS MODE AFTER IT DIED 45 MINUTES AGO AND HOBBLED OVER TO A GAS STATION A 200 FEET AWAY. THE SMELL WAS STILL PREVALENT AT THIS POINT. THE TOW TRUCK TOWED THE VAN TO THE SERVICE DEPARTMENT WHERE I BOUGHT THE VAN (COVERT IN AUSTIN) WHICH JUST HAPPENED TO COINCIDE WITHIN THE 10 MILES TOWING LIMIT FOR MY CASE. THIS HAPPENED 10/6/2018. IT'S BEEN 9 DAYS AND MY VAN HASN'T BEEN LOOKED AT YET. APPARENTLY THERE AREN'T ENOUGH HYBRID TECHS TO GO AROUND. COVERT WHICH IS A LARGER FCA DEALERSHIP IN THE AUSTIN AREA ONLY HAS 2 TECHS. IN THE MEAN TIME, COVERT LENT ME A LOANER SINCE THE DAY I DROPPED THE VAN OFF. NOT SURE WHAT THE PROBLEM IS OR WHEN IT WILL BE FIX. BUT THIS DOESN'T LOOK PROMISING.

NHTSA ODI #11141628

11,000 miles · Aug 22, 2018

EngineFuel/propulsion SystemSteering

Read full complaint

INCIDENT #1 (7/17/2018) - WHILE BREAKING TOWARDS A TRAFFIC LIGHT THAT TURNED FROM RED TO GREEN, I ATTEMPTED TO ACCELERATE BUT HEARD A LOUD POPPING NOISE, FELT THE VAN LURCH, AND IMMEDIATELY LOST ALL POWER TO THE VEHICLE. NUMEROUS WARNING LIGHTS APPEARED ON THE DASHBOARD INCLUDING ENGINE LIGHT & POWER/HYBRID PLUG-IN FAILURE. I WAS ABLE TO STEER TO THE SIDE OF THE ROAD AND BREAK TO A STOP, AND RESTART 1-2 MINUTES LATER. BROUGHT TO CHRYSLER DEALER ON 7/20 AND WAS TOLD ON 7/21 UPON PICKUP THAT THE ISSUE HAD BEEN RECTIFIED VIA SOFTWARE UPDATE. INCIDENT #2 (7/23/2018) - WHILE MOVING SLOWLY IN TRAFFIC, I ATTEMPTED TO ACCELERATE AS THE VEHICLES AHEAD OF ME MOVED AND AGAIN LOST ALL POWER WITH THE SAME SET OF ERRORS/WARNINGS MENTIONED IN INCIDENT #1. ONCE AGAIN, AFTER 1-2 MINUTES I WAS ABLE TO RESTART THE VEHICLE. I BROUGHT TO A DIFFERENT LOCAL CHRYSLER DEALER THAT SAME DAY. PICKED UP THE VEHICLE ON 7/24 AND WAS TOLD THAT AFTER THOROUGH MULTI-POINT MECHANICAL INSPECTION WITH THE FCA ENGINEERS, THE COMPANY BELIEVED THE PREVIOUS DEALER HAD INCORRECTLY APPLIED THE SOFTWARE UPDATE. DEALER TEST DROVE THE VEHICLE FOR 20 MILES AND COULD NOT RECREATE THE ISSUE. INCIDENT #3 (8/21/2018) - WHILE AGAIN MOVING IN TRAFFIC, MY WIFE (WITH OUR 1 YEAR OLD IN THE BACK) AGAIN SUDDENLY LOST ALL POWER AS MENTIONED IN INCIDENT #1 AND #2 ABOVE, EXCEPT SHE ALSO HAD THE STEERING COMPLETELY LOCK UP ON HER. SHE WAS ABLE TO BREAK TO A STOP MID-TRAFFIC AND RESTARTED THE VEHICLE 1-2 MINUTES LATER. SOON THEREAFTER I CALLED FCA CORPORATE DIRECTLY AND HAVE REQUESTED A FULL REPURCHASE OF THE VEHICLE AND PLAN TO PURSUE LEMON LAW REMEDIATION IF THAT DOESN'T LEAD TO RESOLUTION. ALL THREE INCIDENTS ARE LIFE THREATENING IN NATURE AND HAVE NOT BEEN DIAGNOSABLE BY MULTIPLE CHRYSLER DEALERSHIPS WORKING IN CONJUNCTION WITH FCA ENGINEERS. (IMAGE PROVIDED FROM INCIDENT #2) *TT

NHTSA ODI #11121677

500 miles · Jul 31, 2018

EngineFuel/propulsion SystemSteering

Read full complaint

WE WERE DRIVING CAR AT 25 MPH ON BUSY CITY ROAD IN GAS MODE (NOT ELECTRIC MODE) WHEN THE POWER STEERING AND ACCELERATOR STOPPED WORKING. THE CHECK ENGINE AND BATTERY INDICATOR LIGHTS LIT UP, AND A MESSAGE SAYING "CAR MUST BE IN PARK TO CONTINUE DRIVING" SHOWED UP ON THE DASHBOARD. THE BRAKES WORKED, AND WE COASTED TO A STOP AND WERE STUCK IN THE MIDDLE OF AN INTERSECTION ON A BUSY ARTERY. WHEN WE PUT THE CAR IN PARK, IT WOULD NOT THEN GO BACK INTO DRIVE OR REVERSE; THE "D" AND "R" GEAR LIGHTS WERE FLASHING. THE CAR WOULD NOT TURN OFF, IT WOULD STAY IN RUN MODE WHEN WE TRIED TO TURN IT OFF. BATTERY OPERATED FUNCTIONS, LIKE POWER SLIDING DOORS, STOPPED WORKING. EARLIER IN THE DAY, THE CAR HAD A ROUGH IDLE WHILE IN GAS MODE.

NHTSA ODI #11114767

Official recalls

24V536000 · Hybrid Propulsion System

Jul 18, 2024

Chrysler (FCA US, LLC) is recalling certain 2017-2018 Pacifica Plug-In Hybrid Electric (PHEV) vehicles that received a software update remedy under NHTSA recall number 22V-077. The battery pack may cause a vehicle fire when parked, even with the ignition in the "Off" position.

Consequence & remedy

Consequence: A vehicle fire increases the risk of injury.

Remedy: Owners are advised not to charge their vehicles, and to park outside and away from structures, until they are repaired. Dealers will update the high voltage battery pack control module (BPCM) software. In addition, dealers will inspect and if necessary, replace the battery pack assembly. Repairs will be performed free of charge. Interim notification letters, notifying owners of the safety risk, were mailed August 1, 2024. Owner notification letters were mailed December 12, 2024. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is 73B. Vehicles previously repaired under recall 22V-077 will need to have the new remedy completed.

22V077000 · Hybrid Propulsion System

Feb 11, 2022

Chrysler (FCA US, LLC) is recalling certain 2017-2018 Pacifica Plug-In Hybrid Electric Vehicles (PHEV). A vehicle fire can occur when parked, even with the ignition in the "Off" position.

Consequence & remedy

Consequence: A vehicle fire increases the risk of injury.

Remedy: Owners are advised not to recharge their vehicles, and to park outside and away from structures, until they are repaired. Dealers will update the high voltage battery pack control module (BPCM) software. In addition, dealers will inspect and if necessary, replace the battery pack assembly. Repairs will be performed free of charge. Interim letters, informing owners of the safety risk were mailed on February 25, 2022. Final owner notification letters were mailed October 6, 2022. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is Z11. This recall is superseded by NHTSA recall 24V-538.

20V334000 · Electrical SYSTEM:12V/24V/48V Battery:cables; Electrical System:wiring:interior/under Dash

Jun 9, 2020

Chrysler (FCA US LLC) is recalling certain 2017-2020 Pacifica Plug-in Hybrid Electric Vehicles ("PHEV"). The 12 volt isolator post located behind the driver's seat may develop high resistance.

Consequence & remedy

Consequence: A high resistance electrical connection may result in the connection overheating, increasing the risk of a fire with the vehicle on or off.

Remedy: FCA will conduct a voluntary safety recall on affected vehicles to increase the torque and install a waterproof gasket to the 12v isolator post, the post will also be inspected for signs of contamination. In the event the post is compromised, the 12v isolator post and associated cables will be replaced. Until the final remedy is available, customers should bring their vehicles to dealers for an interim inspection of this joint. The recall remedy is currently under development. FCA US LLC will notify owners, and dealers will perform an interim inspection of this joint. If the inspection indicates the joint is compromised, owners will receive a loaner vehicle, until a final remedy is developed. Interim notifications are expected to begin around June 22, 2020. The recall began July 30, 2020. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is W46. Note: Consumers are advised to exercise the following precautions until the vehicle has the final repair completed: do not park these vehicles inside of buildings or structures, or near other vehicles. Additionally, keep liquids out of the backseat area, including but not limited to beverages, wet items, umbrellas, or bottled liquids that may leak.

Additional source detail variants (2)

Electrical System:wiring:interior/under Dash

Chrysler (FCA US LLC) is recalling certain 2017-2020 Pacifica Plug-in Hybrid Electric Vehicles ("PHEV"). The 12 volt isolator post located behind the driver's seat may develop high resistance.

Consequence: A high resistance electrical connection may result in the connection overheating, increasing the risk of a fire with the vehicle on or off.

Remedy: FCA will conduct a voluntary safety recall on affected vehicles to increase the torque and install a waterproof gasket to the 12v isolator post, the post will also be inspected for signs of contamination. In the event the post is compromised, the 12v isolator post and associated cables will be replaced. Until the final remedy is available, customers should bring their vehicles to dealers for an interim inspection of this joint. The recall remedy is currently under development. FCA US LLC will notify owners, and dealers will perform an interim inspection of this joint. If the inspection indicates the joint is compromised, owners will receive a loaner vehicle, until a final remedy is developed. Interim notifications are expected to begin around June 22, 2020. The recall began July 30, 2020. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is W46. Note: Consumers are advised to exercise the following precautions until the vehicle has the final repair completed: do not park these vehicles inside of buildings or structures, or near other vehicles. Additionally, keep liquids out of the backseat area, including but not limited to beverages, wet items, umbrellas, or bottled liquids that may leak.

Electrical SYSTEM:12V/24V/48V Battery:cables

Chrysler (FCA US LLC) is recalling certain 2017-2020 Pacifica Plug-in Hybrid Electric Vehicles ("PHEV"). The 12 volt isolator post located behind the driver's seat may develop high resistance.

Consequence: A high resistance electrical connection may result in the connection overheating, increasing the risk of a fire with the vehicle on or off.

19V143000 · Suspension:front:control Arm:lower Arm

Feb 28, 2019

Chrysler (FCA US LLC) is recalling certain 2018 Chrysler Pacifica and Pacifica hybrid vehicles. The right front lower control arm may separate from the steering knuckle.

Consequence & remedy

Consequence: A control arm separation could increase the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the right front knuckle and lower control arm for damage, replacing the components as necessary. The right front lower control arm knuckle pinch bolt will be replaced with a larger-diameter pinch bolt. These repairs will be performed free of charge. The recall began April 26, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V15.

18V740000 · Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor; Hybrid Propulsion System

Oct 19, 2018

Chrysler (FCA US LLC) is recalling certain 2017-2018 Chrysler Pacifica Plug-in Hybrid Electric vehicles (PHEV). After the vehicle has been operating in PHEV propulsion mode, the gas-fueled engine may not restart properly resulting in unburned fuel entering the exhaust catalyst.

Consequence & remedy

Consequence: The improperly started engine could result in a loss of motive power increasing the risk of a crash or the unburned fuel in the catalyst may ignite increasing the risk of a fire.

Remedy: FCA will notify owners, and dealers will update the powertrain controller module software, and inspect and replace the catalytic converter as necessary, free of charge. The recall began November 15, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U94.

Additional source detail variants (2)

Hybrid Propulsion System

Consequence: The improperly started engine could result in a loss of motive power increasing the risk of a crash or the unburned fuel in the catalyst may ignite increasing the risk of a fire.

Remedy: FCA will notify owners, and dealers will update the powertrain controller module software, and inspect and replace the catalytic converter as necessary, free of charge. The recall began November 15, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U94.

Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor

Consequence: The improperly started engine could result in a loss of motive power increasing the risk of a crash or the unburned fuel in the catalyst may ignite increasing the risk of a fire.

18V524000 · Electrical System:wiring:front Underhood

Aug 9, 2018

Chrysler (FCA US LLC) is recalling certain 2018 Jeep Renegade, Compass and Grand Cherokee, RAM 1500 and Promaster, Fiat 500x, Dodge Journey, Challenger, Charger and Durango and Chrysler 300x vehicles, 2017-2018 Jeep Wrangler, Dodge Grand Caravan and Chrysler Town and Country vehicles and 2018-2019 Jeep Cherokee and 2018 Chrysler Pacifica and Pacifica Hybrid vehicles. The powertrain control module may be equipped with a voltage regulator chip in the circuit board that may fail, causing a stall or a no start condition.

Consequence & remedy

Consequence: A vehicle stall can increase the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will replace the powertrain control module, free of charge. The recall began October 2, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U87.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE24028 · Electrical Arcing And Thermal Events, Potentially Leading To Fires, While Utilizing Enel X Way Usa, Llc's Juicebox Residential Charger.

Opened Oct 3, 2024 · Closed Jun 5, 2025

Status: closed (inferred from source dates) · Equipment:electrical

On October 3, 2024, the Office of Defects Investigations (ODI) opened PE24028 to investigate alleged failures of Enel X Way's JuiceBox Level 2 residential EV chargers. The allegations were described as thermal incidents and electrical malfunctions, which could trip the circuit breakers in Juicebox owners’ homes and disrupt electric vehicle charge cycles. On October 2, 2024, Enel X Way posted on its website that Enel X Way North America would cease operations in the United States and Canada on October 11, 2024. The closure would potentially impact the charging app and supporting software. ODI sent Enel X Way an Information Request (IR) letter on October 21, 2024. Enel X Way provided an incomplete response to the IR on December 9, 2024. Enel X Way later provided a complete response to the IR on January 24, 2025. ODI reviewed Enel X Way’s IR submissions to determine whether further action is required. Based on ODI’s analysis, there was no clear trend in the cause of the failures described in customer complaints and warranty reports. Additionally, there have been no recent reports alleging safety issues. The available information does not warrant further action at this time. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency will continue to monitor for any safety trends and reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in this Closing Resume, go to NHTSA.gov.

RQ24004 · Loss Of Motive Power Due To An Internal Wiring Connector Short.

Opened Feb 27, 2024 · No close date supplied

Status: open (inferred from source dates) · Electrical System:wiring

On July 22, 2022, the Office of Defects Investigation (ODI) opened investigation PE22-008 regarding complaints alleging a loss of motive power condition potentially due to a transmission malfunction in Model Years 2019-2021 Chrysler Pacifica Plug-In Hybrid Electric Vehicles (PHEV). On January 17, 2023, Fiat Chrysler Automobiles (FCA) issued safety recall (NHTSA Recall 23V-010) involving 2017-2023 Model Years (MY) Pacifica Plug-In Hybrid Electric Vehicles (PHEV) produced between August 12, 2016, through January 9, 2023. The recall states that the loss of motive power condition in these vehicles is caused by an internal transmission wiring connector that may short circuit, resulting in an unexpected engine shutdown. An unexpected engine shutdown can cause a loss of drive power, increasing the risk of a crash. In discussions with FCA on Recall 23V-010, ODI confirmed the recall was related to investigation PE22-008. The remedy for 23V-010 is to update the Power Inverter module (PIM) and/or Instrument Panel Cluster (IPC) software to provide drivers a message stating “Stop Safely - Vehicle Will Shut Off Soon” followed by a chime and MIL, PRNDL blinking (on cluster and shifter knob), low SOC (State of Charge) warning and reduced power mode. The recall remedy does not replace the defective hardware that was described in Recall 23V-010, and the wiring connector short still exists on these vehicles. To date, ODI has received 132 reports for the population of vehicles subject to recall 23V-010. These reports allege a loss of motive power condition that reduces the vehicles speed, followed by dashboard warning lamps displaying messages associated with recall 23V-010. The presence of these warning lamps and messages indicates the vehicle likely had the recall remedy applied. Follow up discussions with FCA confirm their remedy does not prevent a loss of motive power, but instead limits torque to the engine and after an unspecified number of miles or period of time, the engine will shut down. When this occurs, FCA relies on the owner to transport the vehicle to a dealership after they experience a loss of motive power condition, at which time the defective hardware is replaced. Furthermore, the dashboard messages introduced in the recall remedy may cause the driver to pull over in an unsafe location. Pulling over in an unsafe location may expose the occupants to undue harm. The Office of Defects Investigation is opening this Recall Query (RQ) to assess the adequacy, frequency, and safety consequence of the remedy for recall 23V-010. To review the ODI reports cited in the opening resume ODI report identification number document, go to NHTSA.gov.

RQ24001 · Ignition-off High Voltage Battery Fire (remedy Effectiveness Of Recall 22V-077)

Opened Jan 16, 2024 · No close date supplied

Status: open (inferred from source dates) · Electrical System:propulsion System:traction Battery

On February 11, 2022, Fiat Chrysler Automobiles (FCA) issued a safety recall (NHTSA Recall 22V-077) on all 2017-2018 Pacifica Plug-In Hybrid Electric Vehicles (PHEV) produced between August 12, 2016 through August 7, 2018. The recall addresses ignition “OFF’ fires that originate at the high voltage (HV) battery pack assembly. An ignition ‘OFF’ vehicle fire can result in an increased risk of occupant injury, injury to persons outside the vehicle, and property damage, with little to no warning. At the time of the recall filing the root cause of the vehicle fires was unknown and under investigation by FCA and suppliers. A software remedy designed to improve thermal event detectability by monitoring battery diagnostics is currently being installed on subject vehicles as an interim remedy. As of November 23, 2023, the root cause of the battery failure is unknown. From December 2022 through December 2023, NHTSA has received four consumer complaints (VOQs) alleging vehicle thermal events involving recalled 2017 and 2018 Chrysler Pacifica PHEVs. Additional information collected from complainants confirmed a thermal event originating near or at the HV battery pack after the Recall 22V077 remedy had been applied to the vehicle. Follow up meetings with FCA and suppliers in November and December 2023 to discuss the ongoing root cause investigation and post-recall remedy incidents indicated a recent increase in HV battery thermal events. Furthermore, a review of NHTSA complaint data indicated the post-recall HV battery thermal event complaint rate now exceeds pre-recall levels. The Office of Defects Investigation (ODI) is opening this Recall Query (RQ) to review the effectiveness of the original recall remedy, understand the root cause of the battery fires, investigate additional reports of Pacifica PHEV HV battery fires, and to increase monitoring of the manufacturer root cause investigation. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

PE22008 · Transmission Fault Leading To Loss Of Motive Power

Opened Jul 22, 2022 · Closed Mar 27, 2024

Status: closed (inferred from source dates) · Power Train

On July 22, 2022, the Office of Defects Investigation (ODI) opened PE22008 to investigate allegation of loss of motive power, potentially due to transmission malfunction, in certain Chrysler Pacifica vehicles. In a January 17, 2023 letter to NHTSA, Fiat Chrysler Automobiles (FCA) submitted recall notice 23V-010 involving a transmission motor wiring defect in 67,118 model year (MY) 2017-2023 Chrysler Pacifica plug-in hybrid electric vehicles (PHEVs) manufactured from August 12, 2016 through January 9, 2023. FCA determined that an internal transmission connector short could result in an unexpected engine shutdown under certain conditions. Follow up correspondence with FCA confirmed this defect results in an electric motor position trouble code that was the basis for opening PE22008, therefore NHTSA is closing this investigation. The 23V-010 recall remedy is a software update to address the hardware failure associated with PE22008. When a hardware failure is detected, the vehicle limits motive power while instructing the driver to pull over to a safe location. NHTSA is concerned that drivers will pull over to an unsafe location when the warning message associated with the recall remedy displays on the dashboard. Due to the nature of the recall remedy and related reports, NHTSA has opened Recall Query RQ24004 to assess the recall remedy. The reports and failure report summary values included with this closing action are related to allegations of Recall 23V-010 remedy inadequacy. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.