NHTSA owner reports · September 18, 2026 snapshot.
Equipment complaints
14 reportsClear category filter131,330 miles · Sep 11, 2008
EquipmentPower Train
THE SHIFTER WOULD APPEAR TO BE IN PARK AND YOU COULD TAKE KEYS OUT OF CAR. THE NEXT MORNING I WENT TO START MY CAR IT WOULD NOT START, I CHECKED ALL THE USUAL STUFF , GAS LEVEL ,BATTERY THEN IT DAWNED ON ME TO CHECK THE SHIFTER SINCE I WAS UNABLE IN THE PAST TO START OTHER CARS IT MUST BE IN A PARK POSITION (WAS MARRIED TO AN A…
Read full complaint
THE SHIFTER WOULD APPEAR TO BE IN PARK AND YOU COULD TAKE KEYS OUT OF CAR. THE NEXT MORNING I WENT TO START MY CAR IT WOULD NOT START, I CHECKED ALL THE USUAL STUFF , GAS LEVEL ,BATTERY THEN IT DAWNED ON ME TO CHECK THE SHIFTER SINCE I WAS UNABLE IN THE PAST TO START OTHER CARS IT MUST BE IN A PARK POSITION (WAS MARRIED TO AN ASE CERTIFIED MECHANIC WHO DID LOSS OF RESTORATIONS) I PULLED THE LEVEL FORWARD AND THE CAR STARTED IMMEDIATELY. OVER TIME THE SHIFTING FROM P,R,N,D BECAME MORE AND MORE DIFFICULT TO WHERE IT STUCK IN 3RD GEAR (WHICH I NEVER USE) WHEN I HAD THE CAR TOWED THE FLOOR SHIFTER REMAINED STUCK . YET WE WERE ABLE TO PUSH THE CAR OUT OF THE DRIVEWAY AS EASY AS PIE. 383.44 LATER IT WAS THE FLOOR SHIFTER AND CABLE. *TR
NHTSA ODI #10241853
78,000 miles · Feb 15, 2008
Engine And Engine CoolingEquipmentService Brakes, Hydraulic
TL*THE CONTACT OWNS A 1999 CHRYSLER CONCORDE. THE CONTACT STATED THAT THE ABS LIGHT ILLUMINATED AND SHE HEARD A NOISE IN THE ENGINE COMPARTMENT. THE MECHANIC STATED THAT THE PUMP MOTOR CIRCUIT FOR THE ABS FAILED AND CAUSED THE LIGHT TO ILLUMINATE. THE APPROXIMATE COST TO REPAIR THE VEHICLE WAS BETWEEN $1,500 TO $2,000. THE F…
Read full complaint
TL*THE CONTACT OWNS A 1999 CHRYSLER CONCORDE. THE CONTACT STATED THAT THE ABS LIGHT ILLUMINATED AND SHE HEARD A NOISE IN THE ENGINE COMPARTMENT. THE MECHANIC STATED THAT THE PUMP MOTOR CIRCUIT FOR THE ABS FAILED AND CAUSED THE LIGHT TO ILLUMINATE. THE APPROXIMATE COST TO REPAIR THE VEHICLE WAS BETWEEN $1,500 TO $2,000. THE FRONT ROTORS WERE REPLACED IN APRIL OF 2006 AND IN SEPTEMBER OF 2007. IN JANUARY OF 2007, THE FRONT DRIVER SIDE BEARING WAS REPLACED. THE MECHANIC STATED THAT THE FAILURE WAS DUE TO POOR DESIGN AND CHEAP PARTS. THE AIR CONDITIONER ALSO BEGAN TO LEAK. THE MECHANIC STATED THAT THERE WAS A HOLE IN THE SUCTION LINE BECAUSE OF THE DESIGN, AND IT RUSTED AND RUBBED THROUGH ANOTHER PART OF THE VEHICLE. THE AIR CONDITIONING SUCTION LINE WAS REPLACED IN SEPTEMBER OF 2007. THE LEAK COULD HAVE POTENTIALLY CAUSED A FIRE. THE MECHANIC STATED THAT THE POWER STEERING KIT NEEDED TO BE REPLACED. THE VEHICLE COULD EASILY RUST INTO THE FRAME AND CONDENSATION COULD COLLECT. THE VEHICLE IS CURRENTLY HESITATING AND SURGING. THE CURRENT MILEAGE WAS 78,100 AND FAILURE MILEAGE WAS 78,000. UPDATED 03-04-08 *BF THE LEAK OF THE POWER STEERING HOSE COULD CAUSE A FIRE. UPDATED
NHTSA ODI #10218384
79,000 miles · Apr 23, 2005
Engine And Engine CoolingEquipment
I HAVE A 1999 CHRYSLER CONCORDE THAT HAS BEEN AT THE ATLANTA DODGE DEALERSHIP SINCE MARCH 26. THE ENGINE HAS SLUDGE BUILD-UP AND WILL NEED TO BE REPLACED. THE AIR CONDITIONER WAS SERVICED BEFORE MY TRIP TO ATLANTA, YET I STILL EXPERIENCED THE UNIT MAKING NOISES THE DAY AFTER WE ARRIVED. (THANKFULLY, WE ARRIVED). WITHIN AN HOUR O…
Read full complaint
I HAVE A 1999 CHRYSLER CONCORDE THAT HAS BEEN AT THE ATLANTA DODGE DEALERSHIP SINCE MARCH 26. THE ENGINE HAS SLUDGE BUILD-UP AND WILL NEED TO BE REPLACED. THE AIR CONDITIONER WAS SERVICED BEFORE MY TRIP TO ATLANTA, YET I STILL EXPERIENCED THE UNIT MAKING NOISES THE DAY AFTER WE ARRIVED. (THANKFULLY, WE ARRIVED). WITHIN AN HOUR OF THE AC UNIT MAKING NOISES, THE ENGINE DIED ON I-20 WEST. I HAD THE CAR TOWED TO THE DEALERSHIP. I LIVE IN FLORIDA AND PURCHASED THE VEHICLE ONLY 6 MONTHS OLD AGO, IT HAS ABOUT 79,000 MILES. I HAD 3 REGULAR OIL CHANGES DURING THOSE 6 MONTHS, AND ONE MONTH BEFORE MY BUSINESS TRIP, I HAD A DIAGNOSIS TEST DONE AT GOODYEAR BECAUSE THE OIL LIGHT WAS FLASHING ON-AN-OFF. GOODYEAR ALSO CHANGED THE OIL THAT 3RD TIME. NOTHING WAS DISCOVERED. AS A SINGLE PARENT OF 4 KIDS, I WAS TRYING TO REBUILD MY CREDIT AFTER A SERIES OF JOB LAYOFFS. I HAVE HAD AUTO RENTALS FOR THE 5TH WEEK NOW AND SEE NO END IN SIGHT. LUCKILY, I DID PURCHASE AN EXTENDED WARRANTY, BUT NO ONE IS ASSUMING RESPONSIBILITY FOR THE DEFECT, NO ONE-- THE WARRANTY PEOPLE, THRIFTY DEALERSHIP (WHERE PURCHASED) OR CHRYSLER! I AM SINKING FURTHER INTO DEBT. THIS IS SO UNFAIR TO THE CONSUMER. I AM MORE THAN ANGRY. I WILL NEVER PURCHASE A CAR AGAIN WITHOUT CHECKING ?MYCARSTATS? (I DID A VERY GENERIC ONLINE SEARCH AND HAD CARFAX). AND WILL NEVER PURCHASE A DODGE OR CHRYSLER AGAIN. I AM NOW SEARCHING FOR A MECHANIC?S SPECIAL TO GET AROUND TOWN AND TO WORK. *JB
NHTSA ODI #10118298
Mileage unknown · Apr 4, 2005
Equipment
AIR CONDITIONER HAS TO BE RECHARGED PERIODICALLY DUE TO A LEAK.*AK
NHTSA ODI #10117395
75,000 miles · Jan 29, 2005
Equipment
A/C HEATER PROBLEMS SINCE CAR WAS NEW, CONTROL HEAD REPLACED THREE TIMES. ENTIRE A/C SYSTEM REPLACED BY REPUTABLE INDEPENDANT AUTO/TRUCK A/C COMPANY @ 60K MILES. THIS INDEPENDANT COMPANY INDICATES THAT IT'S WIDELY KNOWN IN THE INDUSTRY THAT CHRYSLER A/C SYSTEMS ARE EXPECTED TO FAIL @ 60K MILES, AND WE CAN REASONABLY EXPECT NEWLY…
Read full complaint
A/C HEATER PROBLEMS SINCE CAR WAS NEW, CONTROL HEAD REPLACED THREE TIMES. ENTIRE A/C SYSTEM REPLACED BY REPUTABLE INDEPENDANT AUTO/TRUCK A/C COMPANY @ 60K MILES. THIS INDEPENDANT COMPANY INDICATES THAT IT'S WIDELY KNOWN IN THE INDUSTRY THAT CHRYSLER A/C SYSTEMS ARE EXPECTED TO FAIL @ 60K MILES, AND WE CAN REASONABLY EXPECT NEWLY INSTALLED SYSTEM TO PERFORM FOR 60K MILES. WE'VE SPENT OVER $2000 ON THE A/C, LAST MONTH REPLACED WITH CONTROL HEAD #3 @ CHRYSLER DEALER $300.00, STILL NOT WORKING RIGHT... CLEAR THAT CHRYSLER REALLY HAS NO CLUE... SYSTEM IS CLEARLY DEFECTIVE. PROBLEM VERY WIDESPREAD, ASK ANYONE. MOST FOLKS JUST GIVE UP, JUNK OR TRADE. *AK
NHTSA ODI #10108203
Mileage unknown · Nov 16, 2004
Electrical SystemEquipmentInjury
WHILE REPLACING THE BATTERY THE JACK BROKE AND VEHICLE FELL TO THE GROUND AND CONSUMER WAS UNDER THE VEHICLE. CONSUMER SUSTAINED MAJOR INJURIES AND WAS TRANSPORTED TO A HOSPITAL. CONSUMER WILL CONTACT THE MANUFACTURER IN THE NEAR FUTURE. *AK
NHTSA ODI #10101114
55,000 miles · Aug 3, 2004
EquipmentVehicle Speed Control
I HAVE HAD MY 1999 CHRYSLER CONCORDE LXI FOR ABOUT A YEAR AND A HALF. IT NOW HAS 76,000 MILES ON IT. I WAS PULLING OUT OF THE PARKING LOT AND FIRST NOTICED THE SPEEDOMETER WASN'T WORKING. AT THAT POINT I KEPT DRIVING. AS I PULLED OUT ONTO THE ROAD AND HAD TO ACCELERATE I NOTICED MY RPM'S WERE A LITTLE HIGH. THE CAR SEEMED T…
Read full complaint
I HAVE HAD MY 1999 CHRYSLER CONCORDE LXI FOR ABOUT A YEAR AND A HALF. IT NOW HAS 76,000 MILES ON IT. I WAS PULLING OUT OF THE PARKING LOT AND FIRST NOTICED THE SPEEDOMETER WASN'T WORKING. AT THAT POINT I KEPT DRIVING. AS I PULLED OUT ONTO THE ROAD AND HAD TO ACCELERATE I NOTICED MY RPM'S WERE A LITTLE HIGH. THE CAR SEEMED TO BE STUCK IN LOW GEAR. I CHECKED THE TRANSMISSION FLUID AND THE FUSE FOR THE TRANSMISSION CONTROLLER. BOTH WERE FINE. I HAD THE CAR TOWED. I GOT ONLINE AND STARTING RESEARCHING THE CAR. IT TURNS OUT THAT SPEED SENSORS IN THIS CAR FAIL QUITE OFTEN. I SPOKE TO THE PREVIOUS OWNER OF THE VEHICLE. HE TOLD ME HE ALREADY HAD THE SPEED SENSOR REPLACED ONCE JUST BEFORE I BOUGHT THE CAR FROM HIM. MY CAR IS FIVE YEARS OLD, HAS 76,000 MILES ON IT, AND HAS HAD THE SAME PART REPLACED TWICE ALREADY. THIS IS RIDICULOUS. CHRYSLER SHOULD PAY TO FIX THEIR FAULTY PRODUCT, NOT ME REPEATEDLY.*AK
NHTSA ODI #10086077
Mileage unknown · Jul 21, 2004
Electrical SystemEquipmentService Brakes, Hydraulic
SINCE I PURCHASED A 1999 CHRYSLER CONCORDE NEW, I HAVE HAD THE CAR IN THE DEALER OVER 20 TIMES. I HAVE NUMEROUS ELECTRICAL ISSUES, I HAVE BEEN STRANDED NUMEROUS TIMES AND I HAVE INCURRED COSTS OVER THE LAST 4 YEARS THAT NOT ONLY FORCED ME TO RENT A CAR OVER AND OVER, BUT THE TIME LOST FROM WORK IS INEXCUSABLE. I HAVE HAD BRAKE …
Read full complaint
SINCE I PURCHASED A 1999 CHRYSLER CONCORDE NEW, I HAVE HAD THE CAR IN THE DEALER OVER 20 TIMES. I HAVE NUMEROUS ELECTRICAL ISSUES, I HAVE BEEN STRANDED NUMEROUS TIMES AND I HAVE INCURRED COSTS OVER THE LAST 4 YEARS THAT NOT ONLY FORCED ME TO RENT A CAR OVER AND OVER, BUT THE TIME LOST FROM WORK IS INEXCUSABLE. I HAVE HAD BRAKE FAILURE ALMOST RESULTING IN A CAR CRASH. NOW, MY CAR IS IN THE DEALERSHIP DUE TO SMOKE SMELL BURNING WIRES AND A COMPUTER AND ELECTRICAL ISSUE. CHRYSLER STATES THEY DON'T KNOW IF THEY WILLL PAY FOR THIS PROBLEM. THIS HAS BEEN HAPPENING SINCE DAY ONE AND IT'S DANGEROUS. I AM IN FEAR FOR THE SAFETY OF MY FAMILY RIDING IN THIS CAR. IT IS A DEATH TRAP. THIS CAR SHOULD HAVE BEEN DEEMED RECALLED UNDER THE LEMON LAW. I KNOW VARIOUS PEOPLE WHO HAVE THE SAME CAR AND THEY HAVE HAD THE SAME PROBLEMS THAT CHRYSLER IGNORES AND FAILS TO DEAL WITH IT. *LA
NHTSA ODI #10082363
73,000 miles · Feb 5, 2004
Engine And Engine CoolingEquipment
DRIVING DOWN INTERSTATE 265 AT 55 MPH, ENGINE JUST QUIT, CAUSING A POTENTIALLY DEADLY SITUATION. WHEN THE ENGINE QUIT, IT LOST POWER STEERING AND BRAKES. CAR ONLY HAS 70,000 MILES. AIR CONDITIONING QUIT WORKING IN MAY OF 2003. *JB
NHTSA ODI #10056567
28,399 miles · Jan 15, 2004
Engine And Engine CoolingEquipmentPower Train
AIR CONDITIONING CONTINUALLY GOES OUT. AS CAR HAS EXPIRED WARRANTY, CHRYSLER SAYS THEY HAVE NO OBLIGATION TO REPAIR. I DISAGREE. I BELIEVE THAT CHRYSLER, AND IN MY PARTICULAR SITUATION, HAS A FAULTY A/C SYSTEM.
NHTSA ODI #10068789
Official recalls
4Jan 13, 2004
ON CERTAIN PASSENGER VEHICLES, THE FLOOR SHIFTER IGNITION-PARK INTERLOCK MAY FAIL AND ALLOW THE SHIFTER TO BE MOVED OUT OF THE PARK POSITION WITH THE KEY REMOVED. AN INOPERATIVE INTERLOCK MAY ALSO ALLOW THE KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE PARK POSITION.
Consequence & remedy
Consequence: EITHER CIRCUMSTANCE MAY RESULT IN THE VEHICLE ROLLING AWAY WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL A NEW LOAD-LIMITING PUSH ROD INTO THE FLOOR SHIFTER LEVER OF THE AFFECTED VEHICLES. OWNER NOTIFICATION BEGAN ON JUNE 14, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Feb 5, 2003
ON CERTAIN PASSENGER VEHICLES, SEAT BACK RECLINER BOLT BREAKAGE CAN OCCUR RESULTING IN THE SEAT BACK RECLINING UNEXPECTEDLY.
Consequence & remedy
Consequence: IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE RECLINER BOLTS. OWNER NOTIFICATION BEGAN ON APRIL 23, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Apr 11, 2001
VEHICLE DESCRIPTION: CERTAIN VAN, WAGON, PICKUP TRUCKS, PASSENGER AND SPORT UTILITY VEHICLES, FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE FRONT SEAT BELT RETRACTOR MAY NOT COMPLY WITH THE REQUIREMENTS OF THE STANDARD.
Consequence & remedy
Consequence: IF THE RETRACTOR DOES NOT WORK PROPERLY, IT WILL NOT ADEQUATELY PROTECT OCCUPANTS IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SEAT BELT RETRACTOR. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Feb 4, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SEAT BELT SHOULDER HEIGHT ADJUSTABLE TURNING LOOP (ATL) TOP MOUNTING BOLT WAS INADEQUATELY MANUFACTURED.
Consequence & remedy
Consequence: THE AFFECTED MOUNTING BOLTS MAY NOT WITHSTAND SUFFICIENT FORCE TO FUNCTION PROPERLY IN CERTAIN IMPACT SITUATIONS, INCREASING THE RISK OF INJURY TO A BELTED OCCUPANT.
Remedy: DEALERS WILL REPLACE THE SHOULDER BELT HEIGHT ADJUSTER MOUNTING BOLTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA03011 · Auto Trans IGNITION-PARK Interlock
Opened Jul 17, 2003 · Closed Jan 30, 2004
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Additional source detail variants (2)
Power Train:automatic Transmission
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
PE03010 · Throttle Control Failure
Opened Feb 27, 2003 · Closed Sep 2, 2003
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal; Vehicle Speed Control:cables; Vehicle Speed Control:linkages
BASED ON THE LOW FAILURE RATE, THE ABSENCE OF FAILURES OVER THE PAST YEAR, THE ABSENCE OF INJURIES, AND ODI'S FIELD INVESTIGATION OF INCIDENT VEHICLES, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (4)
Vehicle Speed Control:accelerator Pedal
BASED ON THE LOW FAILURE RATE, THE ABSENCE OF FAILURES OVER THE PAST YEAR, THE ABSENCE OF INJURIES, AND ODI'S FIELD INVESTIGATION OF INCIDENT VEHICLES, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Vehicle Speed Control:cables
BASED ON THE LOW FAILURE RATE, THE ABSENCE OF FAILURES OVER THE PAST YEAR, THE ABSENCE OF INJURIES, AND ODI'S FIELD INVESTIGATION OF INCIDENT VEHICLES, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Vehicle Speed Control
BASED ON THE LOW FAILURE RATE, THE ABSENCE OF FAILURES OVER THE PAST YEAR, THE ABSENCE OF INJURIES, AND ODI'S FIELD INVESTIGATION OF INCIDENT VEHICLES, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Vehicle Speed Control:linkages
BASED ON THE LOW FAILURE RATE, THE ABSENCE OF FAILURES OVER THE PAST YEAR, THE ABSENCE OF INJURIES, AND ODI'S FIELD INVESTIGATION OF INCIDENT VEHICLES, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Illustration