NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
164 reportsClear category filter96,500 miles · Jun 30, 2005
Engine And Engine Cooling
I WAS TOLD BY MY MECHANIC THAT I HAVE BEEN BURNING OIL EXTEMELY FAST. HE SUGGESTED A HEAVIER WEIGHTED OIL AND ENGINE RESTORE. HE ALSO RECOMMENDED THAT I GET A QUOTE ON HAVING MY ENGINE REBUILT SINCE THE CAR PROBABLY HAS LOOSE RINGS AND VALVES. (I WAS QUOTED A PRICE IN THE $4K-$5K RANGE). I THINK CHRYSLER SHOULD BUILD ENGINES THA…
Read full complaint
I WAS TOLD BY MY MECHANIC THAT I HAVE BEEN BURNING OIL EXTEMELY FAST. HE SUGGESTED A HEAVIER WEIGHTED OIL AND ENGINE RESTORE. HE ALSO RECOMMENDED THAT I GET A QUOTE ON HAVING MY ENGINE REBUILT SINCE THE CAR PROBABLY HAS LOOSE RINGS AND VALVES. (I WAS QUOTED A PRICE IN THE $4K-$5K RANGE). I THINK CHRYSLER SHOULD BUILD ENGINES THAT LAST LONGER THAN 97,000 MILES. I WAS DRIVING HOME THE OTHER DAY AND WHEN I WENT TO ACCELERATE FROM A STOP LIGHT AND THE CAR JUST DIED. THANK FULLY I WAS ON A HILL & WAS ABLE TO COAST OFF TO THE SIDE. I MANGAGED TO GET IT STARTED AGAIN, HOWEVER IN A DIFFERENT SITUATION IT COULD HAVE CAUSED AN ACCIDENT. IT ALSO HAPPENED TO MY 16 YEAR OLD SON, WHO IS NO LONGER ALLOWED TO DRIVE THE CAR, SINCE I FEEL IT IS UNSAFE.
NHTSA ODI #10127184
65,045 miles · Jun 7, 2005
Engine And Engine Cooling
WHILE DRIVING THE CAR SHUT DOWN WITH OUT WARNING OR LIGHTS. TOTAL SHUTDOWN WITHOUT POWER STEERING ON BUSY ROAD. THE ENGINE LOCKED UP DUE TO ENGINE SLUDGE. THE ENGINE HAD TO BE REPLACED WITH NEW BLOCK BECAUSE THE POORLY DESIGNED ENGINE COULD NOT BE REBUILT DUE TO THE FACT THAT THE CYLINDER WALLS ARE TOO THIN. USED ENGINES ARE…
Read full complaint
WHILE DRIVING THE CAR SHUT DOWN WITH OUT WARNING OR LIGHTS. TOTAL SHUTDOWN WITHOUT POWER STEERING ON BUSY ROAD. THE ENGINE LOCKED UP DUE TO ENGINE SLUDGE. THE ENGINE HAD TO BE REPLACED WITH NEW BLOCK BECAUSE THE POORLY DESIGNED ENGINE COULD NOT BE REBUILT DUE TO THE FACT THAT THE CYLINDER WALLS ARE TOO THIN. USED ENGINES ARE NOT AVAILABLE BECAUSE THE PROBLEM IS SO WIDESPREAD.
NHTSA ODI #10124521
Mileage unknown · Jun 2, 2005
Engine And Engine Cooling
DT: THE CONSUMER OWNS A 1999 CHRYSLER CONCORDE. WHILE DRIVING, THE VEHICLE BEGAN TO MAKE A NOISE AND THE ENGINE JUST SHUT OFF. PRIOR TO THIS INCIDENT THE BLOWER WORKED BUT THERE WAS NO HEAT. THE MECHANIC SAID THE ENGINE WAS BAD AND THIS WAS A BAD YEAR FOR THESE ENGINES. *TT
NHTSA ODI #10123987
55,178 miles · May 3, 2005
Engine And Engine Cooling
WHILE DRIVING, THE ENGINE FAILED. PREVIOUSLY THERE WAS A KNOCKING NOISE. AFTER GETTING OFF THE ROAD IT DID START AGAIN. THIS WAS THE FIRST TIME THIS HAD EVER HAPPENED. THE CONSUMER TOOK TO THE VEHICLE TO THE DEALER AND MECHANIC SAID THE ROD BEARINGS WERE GONE. *JB
NHTSA ODI #10119615
80,500 miles · May 3, 2005
Engine And Engine Cooling
CONTACT STATES: CONTACT MAINTAINS CAR REGULARLY, WITHOUT ANY WARNING THE CAR MADE A CLICKING SOUND AND STOPPED. WILL NOT START AND HAD TO HAVE TIT OWED. NOW FINDING OUT THAT THE TIMING BELT BROKE, AND THERE WAS SO MUCH ENGINE DAMAGE THAT A NEW ENGINE IS REQUIRED DUE TO DAMAGE OF SLUDGE BUILD UP.*AK
NHTSA ODI #10119513
95,000 miles · Apr 26, 2005
Engine And Engine Cooling
1999 CHRYSLER CONCORDE DIED AFTER THE MOTOR STARTED KNOCKING.*MR *NM
NHTSA ODI #10119339
79,000 miles · Apr 23, 2005
Engine And Engine CoolingEquipment
I HAVE A 1999 CHRYSLER CONCORDE THAT HAS BEEN AT THE ATLANTA DODGE DEALERSHIP SINCE MARCH 26. THE ENGINE HAS SLUDGE BUILD-UP AND WILL NEED TO BE REPLACED. THE AIR CONDITIONER WAS SERVICED BEFORE MY TRIP TO ATLANTA, YET I STILL EXPERIENCED THE UNIT MAKING NOISES THE DAY AFTER WE ARRIVED. (THANKFULLY, WE ARRIVED). WITHIN AN HOUR O…
Read full complaint
I HAVE A 1999 CHRYSLER CONCORDE THAT HAS BEEN AT THE ATLANTA DODGE DEALERSHIP SINCE MARCH 26. THE ENGINE HAS SLUDGE BUILD-UP AND WILL NEED TO BE REPLACED. THE AIR CONDITIONER WAS SERVICED BEFORE MY TRIP TO ATLANTA, YET I STILL EXPERIENCED THE UNIT MAKING NOISES THE DAY AFTER WE ARRIVED. (THANKFULLY, WE ARRIVED). WITHIN AN HOUR OF THE AC UNIT MAKING NOISES, THE ENGINE DIED ON I-20 WEST. I HAD THE CAR TOWED TO THE DEALERSHIP. I LIVE IN FLORIDA AND PURCHASED THE VEHICLE ONLY 6 MONTHS OLD AGO, IT HAS ABOUT 79,000 MILES. I HAD 3 REGULAR OIL CHANGES DURING THOSE 6 MONTHS, AND ONE MONTH BEFORE MY BUSINESS TRIP, I HAD A DIAGNOSIS TEST DONE AT GOODYEAR BECAUSE THE OIL LIGHT WAS FLASHING ON-AN-OFF. GOODYEAR ALSO CHANGED THE OIL THAT 3RD TIME. NOTHING WAS DISCOVERED. AS A SINGLE PARENT OF 4 KIDS, I WAS TRYING TO REBUILD MY CREDIT AFTER A SERIES OF JOB LAYOFFS. I HAVE HAD AUTO RENTALS FOR THE 5TH WEEK NOW AND SEE NO END IN SIGHT. LUCKILY, I DID PURCHASE AN EXTENDED WARRANTY, BUT NO ONE IS ASSUMING RESPONSIBILITY FOR THE DEFECT, NO ONE-- THE WARRANTY PEOPLE, THRIFTY DEALERSHIP (WHERE PURCHASED) OR CHRYSLER! I AM SINKING FURTHER INTO DEBT. THIS IS SO UNFAIR TO THE CONSUMER. I AM MORE THAN ANGRY. I WILL NEVER PURCHASE A CAR AGAIN WITHOUT CHECKING ?MYCARSTATS? (I DID A VERY GENERIC ONLINE SEARCH AND HAD CARFAX). AND WILL NEVER PURCHASE A DODGE OR CHRYSLER AGAIN. I AM NOW SEARCHING FOR A MECHANIC?S SPECIAL TO GET AROUND TOWN AND TO WORK. *JB
NHTSA ODI #10118298
Mileage unknown · Apr 5, 2005
Engine And Engine Cooling
WHILE DRIVING VEHICLE STALLLED. DRIVER WAS UNABLE TO RESTART VEHICLE, AND HA DIT TOWED TO THE DEALER FOR INSPECTION. MECHANIC DETERMINED THAT THE ENGINE NEEDED TO BE REPLACED DUE TO SLUDGE BUILD UP. *AK
NHTSA ODI #10117493
57,000 miles · Apr 4, 2005
Engine And Engine Cooling
I SUFFERED MAJOR LOSS IN VALU,E AND MY HUSBAND WAS IN A VERY DANGEROUS SITUATION DUE TO THE FAILURE OF THE 1999 CONCORD ENGINE. Y 1999 CHRYSLER CONCORD HAD UNDER 57,000 MILES, AND WAS DIAGNOSED AS NEEDING A REPLACEMENT ENGINE DUE TO OIL SLUDGE. DESPITE PROVIDING CHRYSLER WILL OIL CHANGE RECORDS SHOWING THE TIMELINESS OF MAINTEN…
Read full complaint
I SUFFERED MAJOR LOSS IN VALU,E AND MY HUSBAND WAS IN A VERY DANGEROUS SITUATION DUE TO THE FAILURE OF THE 1999 CONCORD ENGINE. Y 1999 CHRYSLER CONCORD HAD UNDER 57,000 MILES, AND WAS DIAGNOSED AS NEEDING A REPLACEMENT ENGINE DUE TO OIL SLUDGE. DESPITE PROVIDING CHRYSLER WILL OIL CHANGE RECORDS SHOWING THE TIMELINESS OF MAINTENANCE TO MY ENGINE, THEY CLAIMED NO RESPONSIBILITY. I WAS TOLD I NEEDED TO REPLACE MY ENGINE AND THAT IT WOULD COST APPROXIMATELY $9000!!! MY HUSBAND WAS DRIVING THE VEHICLE ON THE HIGHWAY AT A SPEED OF APPROXIMATELY 65 MPH WHEN THE ENGINE STARTED SMOKING, BOGGED DOWN AND STARTED TO "DIE". IN ORDER TO AVOID A POTENTIAL ACCIDENT, HE HAD TO IMMEDIATELY DRIVE OVER THE SHOULDER AND THROUGH THE GRASS SO HE COULD SAFELY GET THE CAR OFF THE HIGHWAY AND ONTO THE SIDE OF THE FEEDER ROAD.*AK THE COST TO REPLACE OR REPAIR THE ENGINE WAS MUCH MORE THAN THE BLUE BOOK VALUE OF THE VEHICLE. IN FACT, THE BLUE BOOK VALUE WAS DEFLATED AT LEAST IN PART TO FAILING ENGINES OF THE CONCORD. I HAD LITTLE CHOICE BUT TO SELL MY CAR "AS IS" FOR A MERE $1000!!! MY CAR WAS IN VERY GOOD CONDITION PRIOR THE ENGINE FAILURE AND I BELIEVE THE BLUE BOOK VALUE WAS APPROXIMATELY $7000
NHTSA ODI #10116374
64,200 miles · Mar 22, 2005
Engine And Engine Cooling
I HAVE A 1999 CHRYSLER CONCORD [XXX] WHICH I BOUGHT USED FROM BUD BROWN CHRSYLER. THE MILEAGE AT THE TIME I HAD BOUGHT WAS 55286. I HAD CHANGE THE OIL REGULAR. AT ABOUT MILEAGE 62400 MY ENGINE FAIL. I COME TO FIND OUT PRICING TO REPAIR THE ENGINE. MY CAR ENGINE IS KNOW TO GO OUT (2.7L). FROM WHAT I UNDERSTOOD WHEN BUILT THE OIL …
Read full complaint
I HAVE A 1999 CHRYSLER CONCORD [XXX] WHICH I BOUGHT USED FROM BUD BROWN CHRSYLER. THE MILEAGE AT THE TIME I HAD BOUGHT WAS 55286. I HAD CHANGE THE OIL REGULAR. AT ABOUT MILEAGE 62400 MY ENGINE FAIL. I COME TO FIND OUT PRICING TO REPAIR THE ENGINE. MY CAR ENGINE IS KNOW TO GO OUT (2.7L). FROM WHAT I UNDERSTOOD WHEN BUILT THE OIL PUMP WASN'T BIG ENOUGH TO CIRCULATE THE OIL AND CAUSE A SLUDGE BUILT UP. I WAS DRIVING BACK TO WORK WHEN MY WENT OUT AND WAS WITH OUT MY CAR FOR AN MONTH.*AK *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #10114453
Official recalls
4Jan 13, 2004
ON CERTAIN PASSENGER VEHICLES, THE FLOOR SHIFTER IGNITION-PARK INTERLOCK MAY FAIL AND ALLOW THE SHIFTER TO BE MOVED OUT OF THE PARK POSITION WITH THE KEY REMOVED. AN INOPERATIVE INTERLOCK MAY ALSO ALLOW THE KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE PARK POSITION.
Consequence & remedy
Consequence: EITHER CIRCUMSTANCE MAY RESULT IN THE VEHICLE ROLLING AWAY WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL A NEW LOAD-LIMITING PUSH ROD INTO THE FLOOR SHIFTER LEVER OF THE AFFECTED VEHICLES. OWNER NOTIFICATION BEGAN ON JUNE 14, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Feb 5, 2003
ON CERTAIN PASSENGER VEHICLES, SEAT BACK RECLINER BOLT BREAKAGE CAN OCCUR RESULTING IN THE SEAT BACK RECLINING UNEXPECTEDLY.
Consequence & remedy
Consequence: IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE RECLINER BOLTS. OWNER NOTIFICATION BEGAN ON APRIL 23, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Apr 11, 2001
VEHICLE DESCRIPTION: CERTAIN VAN, WAGON, PICKUP TRUCKS, PASSENGER AND SPORT UTILITY VEHICLES, FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE FRONT SEAT BELT RETRACTOR MAY NOT COMPLY WITH THE REQUIREMENTS OF THE STANDARD.
Consequence & remedy
Consequence: IF THE RETRACTOR DOES NOT WORK PROPERLY, IT WILL NOT ADEQUATELY PROTECT OCCUPANTS IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SEAT BELT RETRACTOR. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Feb 4, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SEAT BELT SHOULDER HEIGHT ADJUSTABLE TURNING LOOP (ATL) TOP MOUNTING BOLT WAS INADEQUATELY MANUFACTURED.
Consequence & remedy
Consequence: THE AFFECTED MOUNTING BOLTS MAY NOT WITHSTAND SUFFICIENT FORCE TO FUNCTION PROPERLY IN CERTAIN IMPACT SITUATIONS, INCREASING THE RISK OF INJURY TO A BELTED OCCUPANT.
Remedy: DEALERS WILL REPLACE THE SHOULDER BELT HEIGHT ADJUSTER MOUNTING BOLTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA03011 · Auto Trans IGNITION-PARK Interlock
Opened Jul 17, 2003 · Closed Jan 30, 2004
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Additional source detail variants (2)
Power Train:automatic Transmission
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
PE03010 · Throttle Control Failure
Opened Feb 27, 2003 · Closed Sep 2, 2003
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal; Vehicle Speed Control:cables; Vehicle Speed Control:linkages
BASED ON THE LOW FAILURE RATE, THE ABSENCE OF FAILURES OVER THE PAST YEAR, THE ABSENCE OF INJURIES, AND ODI'S FIELD INVESTIGATION OF INCIDENT VEHICLES, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (4)
Vehicle Speed Control:accelerator Pedal
BASED ON THE LOW FAILURE RATE, THE ABSENCE OF FAILURES OVER THE PAST YEAR, THE ABSENCE OF INJURIES, AND ODI'S FIELD INVESTIGATION OF INCIDENT VEHICLES, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Vehicle Speed Control:cables
BASED ON THE LOW FAILURE RATE, THE ABSENCE OF FAILURES OVER THE PAST YEAR, THE ABSENCE OF INJURIES, AND ODI'S FIELD INVESTIGATION OF INCIDENT VEHICLES, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Vehicle Speed Control
BASED ON THE LOW FAILURE RATE, THE ABSENCE OF FAILURES OVER THE PAST YEAR, THE ABSENCE OF INJURIES, AND ODI'S FIELD INVESTIGATION OF INCIDENT VEHICLES, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Vehicle Speed Control:linkages
BASED ON THE LOW FAILURE RATE, THE ABSENCE OF FAILURES OVER THE PAST YEAR, THE ABSENCE OF INJURIES, AND ODI'S FIELD INVESTIGATION OF INCIDENT VEHICLES, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Illustration