1999 Chrysler Concorde

THE ENGINE IN OUR 1999 CHRYSLER CONCORD BLEW AT ONLY 38000 MILES, IT WAS THE FAMOUS FLAWED 2.7, CHRYSLER REFUSED TO REPLACE THE ENGINE - TOLD US WE MUST NOT HAVE CHANGED THE OIL OFTEN ENOUGH! MY HUSBAND IS A DISTRICT SUPERVISOR FOR A OIL CHANGE CHAIN HERE IN MICHIGAN, THE OIL WAS CHANGED RELIGIOUSLY WITH SYNTHETIC BLEND, AN OIL FAR SUPERIOR TO THE BASIC FACTORY RECOMMENDATIONS. WE REPLACED THE ENGINE OURSELVES AT OUR OWN EXPENSE WITH A 3.2 AT A COST OF $3000. CHRYSLER REFUSES TO ADMIT ANY DEFECTS IN THEIR 2.7 MOTORS, YET OTHER COMPANIES WHOM USED THIS ENGINE HAVE VOLUNTARILY RECALLED IT! *TR

HERE IS A COPY OF OUR SALES TICKET THAT EXPLAINS ALL OF THE UPDATES THAT WE PERFORM ON THIS ENGINE. HOPEFULLY THIS WILL HELP YOU. IF YOU HAVE ANY FURTHER QUESTIONS FEEL FREE TO CONTACT OUR CUSTOMER SERVICE DEPARTMENT AT 1-800-827-7450. --OIL STARVATION IS A PROBLEM WITH THIS ENGINE, SO JASPER INSTALLS THE NEWEST DESIGN OIL LINE WHICH HAS A LARGER DIAMETER PIPE TO ALLOW MORE OIL FLOW AND BETTER LUBRICATION. THE NEWER DESIGN PIPE HAS ONE GENTLE BEND OPPOSED TO THE ORIGINAL WHICH HAD TWO 90-DEGREE BENDS WHICH TENDS TO RESTRICT TO OIL FLOW. --TO PREVENT BEARING FAILURE JASPER INSTALLS ALUMINUM ROD & MAIN BEARINGS INSTEAD OF TRI-METAL BEARINGS. THE ALUMINUM BEARINGS CONFORM TO THE MATING SURFACE MORE COMPLETELY, WHICH PROVIDES MORE EXACT CLEARANCES. THE ALUMINUM BEARINGS ARE ALSO MORE CORROSION RESISTANT. THE ORIGINAL TRI-METAL BEARINGS WERE PRONE TO NOT CONFORM WELL, WHICH LED TO DIRT AND DEBRIS BECOMING LODGED IN THE BEARING DUE TO EXCESSIVE BEARING CLEARANCES. --WATER PUMPS ON THIS ENGINE HAVE BEEN KNOWN TO LEAK OR FAIL. ONE OF THE ISSUES LEADING UP TO THIS WAS DUE TO THE TIMING CHAIN TENSIONER. IT WOULD APPLY MORE TENSION TO THE CHAIN THEN WAS NEEDED, CAUSING STRESS ON THE WATER PUMP. JASPER INSTALLS A LATER DESIGN TENSIONER, WHICH APPLIES THE RIGHT AMOUNT OF TENSION ON THE TIMING CHAIN AND REDUCES THE STRESS ON THE WATER PUMP. JASPER INSTALLS THE NEWEST DESIGN OE WATER PUMP & WATER PUMP GASKET WHICH WILL SEAL TO THE BLOCK BETTER THAN THE ORIGINAL OE DESIGN. --WITH THE USE OF AN MLS GASKET, THE STANDARDS FOR MACHINING ON THE HEAD AND BLOCK HAVE BEEN INCREASED TO INSURE THAT THE GASKET CAN SEAL PROPERLY. THIS IS TO HELP PREVENT COOLANT FROM ENTERING THE OIL CAVITIES CAUSING DAMAGE TO THE ENGINE. ----JASPER DOES NOT INSTALL THE CAM GEAR BALANCER DUE TO A BULLETIN FROM CHRYSLER EFFECTIVE 12/14/01 STATING IT IS NOT NEEDED AND NOT SERVICED FROM THIS TIME FORWARD. --DO NOT REMOVE FROM CORE AND INSTALL ON JASPER'S ENGINE. --LIVE RUN TESTED OIL. *TR

MY WIFE'S 1999 CHRYSLER CONCORDE (2.7 MOTOR) SHUT DOWN UP AT WAL MART. I GOT A CALL FROM MY BUDDY WHO SAID HE THINKS SHE NEEDS A BATTERY. I GO UP THERE, BUY A BATTERY, PUT IT IN, START THE CAR AND IT IS KNOCKING TO HIGH HEAVENS. I PULL THE DIPSTICK AND THERE IS A GREASE LIKE SUBSTANCE ON IT. I IMMEDIATELY GO INTO WAL MART AND BUY OIL. I FILL THE CRANK CASE UP AND HAVE HER START IT UP AGAIN. I KNOCKS FOR ABOUT FIFTEEN SECONDS THEN SOUNDS SOMEWHAT NORMAL. I INSTRUCT HER TO DRIVE HOME AND I WILL FOLLOW HER. IT IS ABOUT FOUR MILES TO HOME. SHE MAKES IT THREE MILES AND THE CAR JUST SHUTS OFF AND SHE STRUGGLES AND GETS IT OFF THE ROAD. THIS OCCURRED ABOUT TWO HUNDRED YARDS FROM AN EXIT AND A RED LIGHT. I CALLED A TOW TRUCK IN AND HAD IT TOWED TO THE DEALER WHERE I BOUGHT IT. THEY CALLED THE NEXT DAY AND WE WENT UP TO SEE THEM. THEY NEVER ONCE MENTIONED ANY PROBLEMS WITH THIS ENGINE. THEY SIMPLY SUGGESTED WE EITHER REPLACE THE ENGINE WHICH IS VERY EXPENSIVE OR BUY A NEW CAR FROM THEM. WE BOUGHT A CAR BECAUSE SHE AND I WORK AND BOTH OF US WORK THIRTY PLUS MILES FROM HOME. TO BOOT, THEY SOLD US ANOTHER CONCORDE!!! UNBELIEVABLY I FOUND OUT ABOUT THIS WIDESPREAD PROBLEM WITH THESE ENGINES TODAY, 8-18-08 AT A DEALERSHIP. THEY WERE OFFERING US VERY LITTLE FOR A FOUR YEAR OLD CONCORDE AND STATED THAT ENGINE AS THE REASONING. I WAS FURIOUS. WE TRADED IT OFF, LOST OUR TAILS-AGAIN- AND MOVED ONTO A MORE RELIABLE FOREIGN NAMED VEHICLE. I STARTED SURFING AROUND TO MAKE SURE THAT THIS FOREIGN DEALERSHIP WAS NOT LYING ABOUT THE ENGINE AND FOUND THOUSANDS OF COMPLAINTS. I FIGURED I SHOULD DO MY PART AGAINST THESE ROBBER BARONS AND ENTER THE ARENA AS WELL. THE WORST PART OF THIS WHOLE THING IS WE REFINANCE OUR HOUSE YEARS AGO AND PAID OFF THAT 99 CONCORDE TO GET AHEAD. IT BLOWS UP MONTHS LATER AND WE ARE BACK TO SQUARE ONE AND ACTUALLY WORSE OFF BECAUSE THE 04 WASN'T WORTH ANYTHING EITHER. *TR

TIMING CLUTCH BROKE. RUINED ENGINE. 100,000 MILES. OTHERWISE IN PERFECT CONDITION. TOO EXPENSIVE TO REPLACE WITH A NEW ENGINE. ESPECIALLY WITH THE MECHANICAL HISTORY OF THIS SPECIFIC ENGINE. THE ONLY OFFER I HAVE RECEIVED TO SELL THIS VEHICLE IS THE SALVAGE YARD. $100 IF I BING IT TO THEM. $50 IF THEY COME GET IT. THIS IS RIDICULOUS. ALL OTHER PARTS IN PERFECT CONDITION. *TR

TL*THE CONTACT OWNS A 1999 CHRYSLER CONCORDE. THE CONTACT STATED THAT THE ABS LIGHT ILLUMINATED AND SHE HEARD A NOISE IN THE ENGINE COMPARTMENT. THE MECHANIC STATED THAT THE PUMP MOTOR CIRCUIT FOR THE ABS FAILED AND CAUSED THE LIGHT TO ILLUMINATE. THE APPROXIMATE COST TO REPAIR THE VEHICLE WAS BETWEEN $1,500 TO $2,000. THE FRONT ROTORS WERE REPLACED IN APRIL OF 2006 AND IN SEPTEMBER OF 2007. IN JANUARY OF 2007, THE FRONT DRIVER SIDE BEARING WAS REPLACED. THE MECHANIC STATED THAT THE FAILURE WAS DUE TO POOR DESIGN AND CHEAP PARTS. THE AIR CONDITIONER ALSO BEGAN TO LEAK. THE MECHANIC STATED THAT THERE WAS A HOLE IN THE SUCTION LINE BECAUSE OF THE DESIGN, AND IT RUSTED AND RUBBED THROUGH ANOTHER PART OF THE VEHICLE. THE AIR CONDITIONING SUCTION LINE WAS REPLACED IN SEPTEMBER OF 2007. THE LEAK COULD HAVE POTENTIALLY CAUSED A FIRE. THE MECHANIC STATED THAT THE POWER STEERING KIT NEEDED TO BE REPLACED. THE VEHICLE COULD EASILY RUST INTO THE FRAME AND CONDENSATION COULD COLLECT. THE VEHICLE IS CURRENTLY HESITATING AND SURGING. THE CURRENT MILEAGE WAS 78,100 AND FAILURE MILEAGE WAS 78,000. UPDATED 03-04-08 *BF THE LEAK OF THE POWER STEERING HOSE COULD CAUSE A FIRE. UPDATED

TL*THE CONTACT OWNS A 1999 CHRYSLER CONCORDE. WHILE DRIVING 45 MPH, THE OIL LIGHT ILLUMINATED INTERMITTENTLY THEN THE ENGINE SHUT OFF. THE CONTACT STATED THAT THE VEHICLE HAD AN OIL CHANGE THE MONTH BEFORE THE FAILURE. THE MECHANIC STATED THAT THE ENGINE WAS SEIZED IT NEEDED TO BE REPLACED. THE CURRENT AND FAILURE MILEAGES WERE 107,000 MILES.

TL*THE CONTACT OWNS A 1999 CHRYSLER CONCORDE. WHILE DRIVING 35 MPH, THE VEHICLE CAME TO A COMPLETE STOP WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT THE TIMING CHAIN TENSIONER FAILED. THE TIMING CHAIN KIT WAS REPLACED. WHEN THE OIL PAN WAS REMOVED TO MAKE THE REPAIR, THERE WAS A LOT OF OIL SLUDGE BUILD UP. THE CURRENT AND FAILURE MILEAGES WERE 118,000. UPDATED 3/11/08 *CN UPDATED 03/11/08 *TR

ENTERING ON-RAMP TO INTERSTATE. CAR STARTS CLUNKING, VIBRATING, CLICKING. CAR DIES ON THE ON RAMP ON AN INTERSTATE. CAR DIED AT 5:30 PM, IT'S DARK OUT AND ALMOST HIT BY NUMEROUS CARS SPEEDING UP TO MERGE ONTO THE INTERSTATE. 2 SMALL CHILDREN IN THE BACKSEAT. CANNOT REMOVE UNTIL HELP ARRIVES BECAUSE IT IS 5 DEGREES ABOVE ZERO OUTSIDE. TOWED CAR TO LOCAL REPAIR SHOP. TIMING CHAIN TENSIONER NEEDED REPLACEMENT. CLEAN SLUDGE FROM OIL PAN. FOUND OIL SLUDGE AND METAL SHAVINGS IN THE OIL PAN AND THE OIL SCREEN. $834 IN REPAIRS AND NOW ENGINE HAS VERY LOUD KNOCK. REPAIR SHOP TELLS ME THE ENGINE IS BASICALLY SHOT AND NOTHING CAN BE DONE TO FIX OR SALVAGE. *TR