IllustrationTAKATA RECALL CAR CAUGHT FIRE IN THE FRONT OF THE CAR (DEFROST VENTS) I WENT INSIDE THE STORE WHILE MY CAR WAS PARKED ON THE STREET WHEN I CAME BAC MY CAR WAS SMOKING. FIRE DEPARTMENT SAID IT WAS CAUSED BY FAN MOTOR FAIL.
1999 Chrysler Concorde
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1999 Chrysler Concorde do not stand out strongly from the model-year median of 168.
About this comparison →How this year compares
Owner complaints by model year
Compare all Concorde years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
60–25K
3325–50K
6450–75K
5475–100K
38100–150K
10150K+
205 reports with mileage · 128 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 164 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
25 crash reports2 fire reports23 injury reports
Electrical System complaints
17 reportsSINCE 2010, THE CAR HAS HAD MANY ELECTRICAL ISSUES THAT HAVE RESULTED IN OVER 5,000 DOLLARS IN REPAIRS AND THE PROBLEMS CONTINUE TO PERSIST. IN 2010, THE CAR BEGAN HAVING INTERMITTENT LIGHTING ISSUES AND FAILURE OF THE TRUNK LATCH OPENING MECHANISM. IN AUG 2010, THE BCM WAS FIXED/REPLACED. SINCE THEN, THE A/C HAS BECOME THE …
Read full complaint
SINCE 2010, THE CAR HAS HAD MANY ELECTRICAL ISSUES THAT HAVE RESULTED IN OVER 5,000 DOLLARS IN REPAIRS AND THE PROBLEMS CONTINUE TO PERSIST. IN 2010, THE CAR BEGAN HAVING INTERMITTENT LIGHTING ISSUES AND FAILURE OF THE TRUNK LATCH OPENING MECHANISM. IN AUG 2010, THE BCM WAS FIXED/REPLACED. SINCE THEN, THE A/C HAS BECOME THE PROBLEM THAT HAS LED TO THOUSAND OF DOLLARS OF REPAIRS. THE PROBLEM IS THAT INTERMITTENTLY THE A/C WILL NOT RESPOND TO CHANGES IN THE TEMPERATURE CONTROLS AND ONLY 180 DEGREE AIR COMES OUT. THE DEALER HAS REPLACED ALMOST ALL MECHANICAL PARTS OF THE A/C AND THE ELECTRICAL CONTROLS WITH THE EXCEPTION OF THE BCM. THE PROBLEM CONTINUES AND NOW THE SO CALL NEW BCM IS NO LONGER UNDER WARRANTY. *TR
TL*THE CONTACT OWNS A 1999 CHRYSLER CONCORDE. WHILE DRIVING 35 MPH, THE VEHICLE HESITATED, VIBRATED, AND THEN SHUT OFF. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND DROVE TO A MECHANIC. THE MECHANIC STATED THAT THE ENGINE CAUSED THE FAILURE. AS OF DECEMBER 10, 2007, THE MECHANIC HAD NOT REPAIRED THE VEHICLE. THE CURRENT …
Read full complaint
TL*THE CONTACT OWNS A 1999 CHRYSLER CONCORDE. WHILE DRIVING 35 MPH, THE VEHICLE HESITATED, VIBRATED, AND THEN SHUT OFF. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND DROVE TO A MECHANIC. THE MECHANIC STATED THAT THE ENGINE CAUSED THE FAILURE. AS OF DECEMBER 10, 2007, THE MECHANIC HAD NOT REPAIRED THE VEHICLE. THE CURRENT AND FAILURE MILEAGES WERE 83,000. UPDATED 3/11/08 *CN THE CONSUMER STATED WHILE DRIVING THE HEADLIGHTS BLINK WITHIN THE FIRST 5-10MINS AND THE DEALER WILL NOT FIX THE DEFECT WHICH THE CONSUMER WAS INFORMED THE COMPUTER WAS THE PROBLEM. UPDATED 03/11/08 *TR
THE BCM ON THE CAR HAS BEEN SHORTING OUT. THE LIGHTS TURN OFF THE DASH LIGHTS TURN OFF THE FUEL GAUGE DROPS OUT THE HEAT AND A/C WON'T WORK ALL AT ONCE. THE DEALERSHIP REPLACED THE BCM ONCE. THE PROBLEM CAME BACK LESS THAN A YEAR. NOW THE DEALER SAID THE BCM HAS SHORTED OUT THE JUNCTION BOX OR THE JUNCTION BOX SHORTED OUT TH…
Read full complaint
THE BCM ON THE CAR HAS BEEN SHORTING OUT. THE LIGHTS TURN OFF THE DASH LIGHTS TURN OFF THE FUEL GAUGE DROPS OUT THE HEAT AND A/C WON'T WORK ALL AT ONCE. THE DEALERSHIP REPLACED THE BCM ONCE. THE PROBLEM CAME BACK LESS THAN A YEAR. NOW THE DEALER SAID THE BCM HAS SHORTED OUT THE JUNCTION BOX OR THE JUNCTION BOX SHORTED OUT THE BCM. *NM
DT: IN APRIL 2005 OWNER PUT KEY IN THE IGNITION SWITCH AND IT GOT STUCK.THE KEY WOULD GET STUCK MORE AND MORE OFTEN, THEN WOULDN'T TURN AT ALL. THE KEY WOULD GET STUCK IN THE IGNITION, ALLOWING THE CAR TO BE LEFT WITH THE KEY IN IT. ONCE THE KEY WAS STUCK IN THE IGNITION FOR WEEKS, AND HAD TO BE REPAIRED BY A LOCKSMITH. THE LO…
Read full complaint
DT: IN APRIL 2005 OWNER PUT KEY IN THE IGNITION SWITCH AND IT GOT STUCK.THE KEY WOULD GET STUCK MORE AND MORE OFTEN, THEN WOULDN'T TURN AT ALL. THE KEY WOULD GET STUCK IN THE IGNITION, ALLOWING THE CAR TO BE LEFT WITH THE KEY IN IT. ONCE THE KEY WAS STUCK IN THE IGNITION FOR WEEKS, AND HAD TO BE REPAIRED BY A LOCKSMITH. THE LOCKSMITIH ADVISED CONSUMER THAT THIS WAS A COMMON PROBLEM WITH THESE TYPE OF CARS. IT WAS A 1999 CHRYSLER CONCORDE. THE PROBLEM RETURNED BECUASE THE KEY SOMETIMES GETTING STUCK. OWNER COULD NOT TURN THE KEY OVER.IF CONSUMER FIDDLED WITH THE KEY IT WILL TURN OVER. DEALERSHIP ADVISED CONSUMER THAT THE PIN INSIDE THE IGNITION INTERLOCK BROKE OFF AND THEN IT WONT WORK ANYMORE. THE IGNITION SWITCH WAS EVENTUALLY RECALLED 04V021000, BUT DEALERSHIP ADVISED THAT IT WAS NOT RELATED TO THIS PROBLEM WITH THE IGNITION. *AK
WHILE REPLACING THE BATTERY THE JACK BROKE AND VEHICLE FELL TO THE GROUND AND CONSUMER WAS UNDER THE VEHICLE. CONSUMER SUSTAINED MAJOR INJURIES AND WAS TRANSPORTED TO A HOSPITAL. CONSUMER WILL CONTACT THE MANUFACTURER IN THE NEAR FUTURE. *AK
SINCE I PURCHASED A 1999 CHRYSLER CONCORDE NEW, I HAVE HAD THE CAR IN THE DEALER OVER 20 TIMES. I HAVE NUMEROUS ELECTRICAL ISSUES, I HAVE BEEN STRANDED NUMEROUS TIMES AND I HAVE INCURRED COSTS OVER THE LAST 4 YEARS THAT NOT ONLY FORCED ME TO RENT A CAR OVER AND OVER, BUT THE TIME LOST FROM WORK IS INEXCUSABLE. I HAVE HAD BRAKE …
Read full complaint
SINCE I PURCHASED A 1999 CHRYSLER CONCORDE NEW, I HAVE HAD THE CAR IN THE DEALER OVER 20 TIMES. I HAVE NUMEROUS ELECTRICAL ISSUES, I HAVE BEEN STRANDED NUMEROUS TIMES AND I HAVE INCURRED COSTS OVER THE LAST 4 YEARS THAT NOT ONLY FORCED ME TO RENT A CAR OVER AND OVER, BUT THE TIME LOST FROM WORK IS INEXCUSABLE. I HAVE HAD BRAKE FAILURE ALMOST RESULTING IN A CAR CRASH. NOW, MY CAR IS IN THE DEALERSHIP DUE TO SMOKE SMELL BURNING WIRES AND A COMPUTER AND ELECTRICAL ISSUE. CHRYSLER STATES THEY DON'T KNOW IF THEY WILLL PAY FOR THIS PROBLEM. THIS HAS BEEN HAPPENING SINCE DAY ONE AND IT'S DANGEROUS. I AM IN FEAR FOR THE SAFETY OF MY FAMILY RIDING IN THIS CAR. IT IS A DEATH TRAP. THIS CAR SHOULD HAVE BEEN DEEMED RECALLED UNDER THE LEMON LAW. I KNOW VARIOUS PEOPLE WHO HAVE THE SAME CAR AND THEY HAVE HAD THE SAME PROBLEMS THAT CHRYSLER IGNORES AND FAILS TO DEAL WITH IT. *LA
PROBLEMS WITH VEHICLE'S HEATER, ENGINE MAKING KNOCKING NOISES AND SLOW ACCELERATION.*MR THE HEATER STOPPED WORKING INTERMITTENTLY WHICH LEAD TO A BUILD UP OF HEAT IN THE ENGINE CABIN, WHICH IN TURN LEAD TO A BUILD UP OF SLUDGE. DURING ACCELERATION, THE VEHICLE RATTLED AND VIBRATED AND IT DID NOT ACCELERATE SMOOTHLY…
Read full complaint
PROBLEMS WITH VEHICLE'S HEATER, ENGINE MAKING KNOCKING NOISES AND SLOW ACCELERATION.*MR THE HEATER STOPPED WORKING INTERMITTENTLY WHICH LEAD TO A BUILD UP OF HEAT IN THE ENGINE CABIN, WHICH IN TURN LEAD TO A BUILD UP OF SLUDGE. DURING ACCELERATION, THE VEHICLE RATTLED AND VIBRATED AND IT DID NOT ACCELERATE SMOOTHLY. THE CONSUMER WAS INFORMED THAT THE ENTIRE ENGINE BLOCK NEEDED TO BE REPLACED, WHICH WAS THE CAUSE OF THE PROBLEMS.*TS ALSO THE FRONT WINDOW AND POWER MIRROR WERE INOPERATIVE, THE DEALER FOUND A BAD WINDOW MOTOR. *JB
ON 6/12/03 I FILLED OUT A VEHICLE OWNERS QUESTIONNAIRE ON A 1999 CHRYSLER CONCORDE, VIN [XXX]. ON 8/02/02 I PURCHASED THIS CHRYSLER CONCORDE WITH 48,580 MILES.ON 8/15/02, I TOOK THE CAR BACK TO [XXX] BECAUSE OF ELECTRICAL PROBLEMS, CAR LEAKING OIL, BRAKES STICKING, AND AIR, HEATER,DEFROST,VENTILATION PROBLEMS.UPON ARRIVAL TO […
Read full complaint
ON 6/12/03 I FILLED OUT A VEHICLE OWNERS QUESTIONNAIRE ON A 1999 CHRYSLER CONCORDE, VIN [XXX]. ON 8/02/02 I PURCHASED THIS CHRYSLER CONCORDE WITH 48,580 MILES.ON 8/15/02, I TOOK THE CAR BACK TO [XXX] BECAUSE OF ELECTRICAL PROBLEMS, CAR LEAKING OIL, BRAKES STICKING, AND AIR, HEATER,DEFROST,VENTILATION PROBLEMS.UPON ARRIVAL TO [XXX] ON 8/15/02 TO DROP THE CAR OFF TO BE SERVICED THERE WERE 48,620 MILES ON THE ODOMETER. AFTER RECEIVING A PHONE CALL FROM [XXX] DEALERSHIP STATING "THAT THE CAR WAS READY." "AND HAD BEEN SERVICED." AFTER ARRIVING AND GETTING IN THE CAR, I NOTICED THAT THE ODOMETER HAD BEEN CHANGED, BECAUSE IT WAS NOW READING 48,883 MILES. I THEN QUESTIONED [XXX] ABOUT THE ADDITIONAL MILES AND WAS TOLD "BEEN EVERYTHING HAD FIXED." ON 4/15/03, I WAS BACK AT [XXX] HAVING ELECTRICAL PROBLEMS IN THE DASHBOARD. AND THE AIR CONDITIONER WAS BLOWING OUT HOT AIR. IN THE MONTH OF MAY 2003, I RECEIVED A RECALL NOTICE ABOUT THE DRIVER'S SEAT BOLT BEING DEFECTIVE, WHICH MAY BREAK CAUSING THE SEAT TO SUDDENLY RECLINE. I TOOK THE CAR IN ON 5/27/03 TO HAVE THE BOLT REPLACED. AFTER BEING AT THE DEALERSHIP FOR ABOUT TWO MINUTES I WAS TOLD THAT "THE CAR WAS READY TO GO." I ASKED IF THE BOLT HAD BEEN REPLACED? I DO NOT BELIEVE IT HAD BECAUSE IT WAS NOT GONE LONG ENOUGH. I ALSO HAD TO REQUEST A CUSTOMER'S COPY OF THE INVOICE. WHEN I RECEIVED THE INVOICE I NOTICE THAT THE INVOICE STATED THAT THE CAR WAS GRAY. THE CAR IS BLACK. PLEASE LOOK INTO THIS MATTER. THANK YOU [XXX] *AK *SCC INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
CAR HAS POPPING SOUND AROUND LEFT FRONT WHEEL,ALL BUT ONE WINDOW IS OFF TRACK AND CANT USE.HAVE TO BANG KEY ON END TO GET IT TO TURN IGNITION OVER.CAR SHAKES WHEN BRAKING.WONT STAY IN ALIGNMENT.USES OIL FROM FIRST DAY WE BOUGHT CAR.WHEN WINDOWS DID WORK THEY SNAPPED SHUT LOUDLY.THIS IS A SMOOTH RIDING CAR BUT HAS WAY TO MANY PRO…
Read full complaint
CAR HAS POPPING SOUND AROUND LEFT FRONT WHEEL,ALL BUT ONE WINDOW IS OFF TRACK AND CANT USE.HAVE TO BANG KEY ON END TO GET IT TO TURN IGNITION OVER.CAR SHAKES WHEN BRAKING.WONT STAY IN ALIGNMENT.USES OIL FROM FIRST DAY WE BOUGHT CAR.WHEN WINDOWS DID WORK THEY SNAPPED SHUT LOUDLY.THIS IS A SMOOTH RIDING CAR BUT HAS WAY TO MANY PROBLEMS.ALSO THE TV CABLE BROKE AND HAD TO BE REPLACED WHICH WAS THE ONLY COMPONENT THAT WASNT COVERED ON THE WARRANTY.KINDA STRANGE SINCE THE CAR WONT BUDGE WITHOUT IT..I AM SORRY I EVER BOUGHT THIS CAR.I AM PAYING FOR A VEHICLE THAT WILL BE TRASH BY THE TIME IT IS PAID FOR.*AK
Official recalls
404V021000 · Power Train:automatic Transmission:lever And Linkage:floor Shift
Jan 13, 2004
ON CERTAIN PASSENGER VEHICLES, THE FLOOR SHIFTER IGNITION-PARK INTERLOCK MAY FAIL AND ALLOW THE SHIFTER TO BE MOVED OUT OF THE PARK POSITION WITH THE KEY REMOVED. AN INOPERATIVE INTERLOCK MAY ALSO ALLOW THE KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE PARK POSITION.
Consequence & remedy
Consequence: EITHER CIRCUMSTANCE MAY RESULT IN THE VEHICLE ROLLING AWAY WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL A NEW LOAD-LIMITING PUSH ROD INTO THE FLOOR SHIFTER LEVER OF THE AFFECTED VEHICLES. OWNER NOTIFICATION BEGAN ON JUNE 14, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
03V035000 · Seats:front Assembly:recliner
Feb 5, 2003
ON CERTAIN PASSENGER VEHICLES, SEAT BACK RECLINER BOLT BREAKAGE CAN OCCUR RESULTING IN THE SEAT BACK RECLINING UNEXPECTEDLY.
Consequence & remedy
Consequence: IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE RECLINER BOLTS. OWNER NOTIFICATION BEGAN ON APRIL 23, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
01V119000 · Seat Belts:front:retractor
Apr 11, 2001
VEHICLE DESCRIPTION: CERTAIN VAN, WAGON, PICKUP TRUCKS, PASSENGER AND SPORT UTILITY VEHICLES, FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE FRONT SEAT BELT RETRACTOR MAY NOT COMPLY WITH THE REQUIREMENTS OF THE STANDARD.
Consequence & remedy
Consequence: IF THE RETRACTOR DOES NOT WORK PROPERLY, IT WILL NOT ADEQUATELY PROTECT OCCUPANTS IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SEAT BELT RETRACTOR. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
00V034000 · Seat Belts
Feb 4, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SEAT BELT SHOULDER HEIGHT ADJUSTABLE TURNING LOOP (ATL) TOP MOUNTING BOLT WAS INADEQUATELY MANUFACTURED.
Consequence & remedy
Consequence: THE AFFECTED MOUNTING BOLTS MAY NOT WITHSTAND SUFFICIENT FORCE TO FUNCTION PROPERLY IN CERTAIN IMPACT SITUATIONS, INCREASING THE RISK OF INJURY TO A BELTED OCCUPANT.
Remedy: DEALERS WILL REPLACE THE SHOULDER BELT HEIGHT ADJUSTER MOUNTING BOLTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA03011 · Auto Trans IGNITION-PARK Interlock
Opened Jul 17, 2003 · Closed Jan 30, 2004
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Additional source detail variants (2)
Power Train:automatic Transmission
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
PE03010 · Throttle Control Failure
Opened Feb 27, 2003 · Closed Sep 2, 2003
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal; Vehicle Speed Control:cables; Vehicle Speed Control:linkages
BASED ON THE LOW FAILURE RATE, THE ABSENCE OF FAILURES OVER THE PAST YEAR, THE ABSENCE OF INJURIES, AND ODI'S FIELD INVESTIGATION OF INCIDENT VEHICLES, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (4)
Vehicle Speed Control:accelerator Pedal
BASED ON THE LOW FAILURE RATE, THE ABSENCE OF FAILURES OVER THE PAST YEAR, THE ABSENCE OF INJURIES, AND ODI'S FIELD INVESTIGATION OF INCIDENT VEHICLES, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Vehicle Speed Control:cables
BASED ON THE LOW FAILURE RATE, THE ABSENCE OF FAILURES OVER THE PAST YEAR, THE ABSENCE OF INJURIES, AND ODI'S FIELD INVESTIGATION OF INCIDENT VEHICLES, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Vehicle Speed Control
BASED ON THE LOW FAILURE RATE, THE ABSENCE OF FAILURES OVER THE PAST YEAR, THE ABSENCE OF INJURIES, AND ODI'S FIELD INVESTIGATION OF INCIDENT VEHICLES, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Vehicle Speed Control:linkages
BASED ON THE LOW FAILURE RATE, THE ABSENCE OF FAILURES OVER THE PAST YEAR, THE ABSENCE OF INJURIES, AND ODI'S FIELD INVESTIGATION OF INCIDENT VEHICLES, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.