IllustrationFor approximately 4 months, after shifting the vehicle to park and attempting to shut the vehicle off, I get a warning message to “Shift to Park” even though the vehicle is already in park. The vehicle will not shut off unless I shift the vehicle into reverse and then back into park.
2017 Chevrolet Volt
Owner reports · Recalls · Investigations
More warning signs than most Volt years
Owner complaints for the 2017 Chevrolet Volt are substantially higher than the model-year median of 169.
About this comparison →How this year compares
Owner complaints by model year
Compare all Volt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
720–25K
10725–50K
3850–75K
2175–100K
11100–150K
1150K+
250 reports with mileage · 447 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 310 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 233 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 219 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports9 fire reports10 injury reports
What owners actually said
697 reportsThe contact owns a 2017 Chevrolet Volt. The contact stated while driving 65 MPH, the vehicle loss motive power with an unknown warning light illuminated. The contact was able to restart the vehicle. However, the vehicle would lose motive power whenever the vehicle exceeded 60 MPH. The vehicle was taken to the dealer, but the dea…
Read full complaint
The contact owns a 2017 Chevrolet Volt. The contact stated while driving 65 MPH, the vehicle loss motive power with an unknown warning light illuminated. The contact was able to restart the vehicle. However, the vehicle would lose motive power whenever the vehicle exceeded 60 MPH. The vehicle was taken to the dealer, but the dealer informed the contact that the warranty had expired and there were no appointments available. The vehicle was taken to another dealer, Keyes Chevrolet (5949 Van Nuys Blvd, Sherman Oaks, CA 91401) and the dealer informed the contact that the warranty was expired and could not assist the contact without the contact paying the diagnostic fee. The vehicle was not diagnosed nor repaired. The manufacturer was made aware of the failure and informed the contact that they would escalate it to the legal department. The failure mileage was approximately 114,000.
Unknown what caused the fire per fire department. I drove to my bosses house and parked the car for about 15 minutes. I was about to leave in the car right before the fire started. At 12:05PM on 09/22/21 the car started smoking and fire appearing under the car. My safety and other by standers was put at risk by the thick black s…
Read full complaint
Unknown what caused the fire per fire department. I drove to my bosses house and parked the car for about 15 minutes. I was about to leave in the car right before the fire started. At 12:05PM on 09/22/21 the car started smoking and fire appearing under the car. My safety and other by standers was put at risk by the thick black smoke and flying debris from the car. Thankfully I was not driving when the car caught fire. There were 4 different explosions two of which I believe were the two front tires and the gas tank. The Saint Louis County police and West County EMS & Fire protection both took a report but I do not have a copy of it. No warning signs or lights on the car when I parked it.
When the vehicle is placed in park and shut off, the alert on the dash states to put vehicle in park to turn off.
Car started giving message “Place car in park”, even though car is in Park. Thus not allowing me to turn my car off. I have to move it from Park to Drive multiple times before it registers and I can turn my car off. This happens at least once a day, but seems to be getting worse and worse… looking online many others are having s…
Read full complaint
Car started giving message “Place car in park”, even though car is in Park. Thus not allowing me to turn my car off. I have to move it from Park to Drive multiple times before it registers and I can turn my car off. This happens at least once a day, but seems to be getting worse and worse… looking online many others are having same issue across many Chevy models.
I place the car in park and I receive a warning on dash that says “action required shift to park”. The car will not shut off. I have had to leave it running twice. I googled and others have had similar problem
SHIFT TO PARK. INDICATOR ON DASH "said ""shift to park " but is parked and car turned off . ?? [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
After putting the vehicle in park, a warning comes up that says “action shift to park” and the vehicle will not turn off or recognize that it is in park. Also the heater doesn’t work at all at times in the winter and only blows cold air, finally after driving for two weeks only once a message that said service heater came on but…
Read full complaint
After putting the vehicle in park, a warning comes up that says “action shift to park” and the vehicle will not turn off or recognize that it is in park. Also the heater doesn’t work at all at times in the winter and only blows cold air, finally after driving for two weeks only once a message that said service heater came on but that was in the summer. The cruise control intermittently stops working. I have asked CarMax to service when it was under warranty and they couldn’t find anything wrong with it apparently. It has happened numerous times since and now it’s not under their warranty of course. I have photos of it happening and a video of the cruise control problem as well. These things have happened multiple times not just once so to put in a date of the incident I do not have enough dates that I can even put in. I have added my three photos. The additional photos are other peoples comments about the same cruise control problem when I researched if this was a common problem.
After parking the car and moving the shifter to the "park" position, I tried to turn off the vehicle. The message "Action Required: Shift to Park" appeared, and the vehicle would not turn off. After the problem began, it happened more and more frequently, sometimes requiring 3-5 attempts to shut off the car before it successfull…
Read full complaint
After parking the car and moving the shifter to the "park" position, I tried to turn off the vehicle. The message "Action Required: Shift to Park" appeared, and the vehicle would not turn off. After the problem began, it happened more and more frequently, sometimes requiring 3-5 attempts to shut off the car before it successfully turned off and I could leave it parked. After this happened almost every time I drove for two months, I took the car to a Chevrolet dealer, where they confirmed the issue and replaced the shifter. The problem has since ceased, but it was a very expensive repair for a problem that seems to be very common in Volts.
When turning off vehicle the vehicle states to put shifter into park even though it's in park. Sometimes have to turn vehicle on and off multiple times and get ride of message. Other times just moving the shifter will cause it to go away.
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE23022 · Loss Of Motive Power Due To The Battery Energy Control Module
Opened Nov 29, 2023 · Closed Mar 3, 2025
Status: closed (inferred from source dates) · Electrical System; Electrical System:propulsion System; Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Electrical System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.