IllustrationShift to Park alert. Vehicle does not think it's in park when it is actually in park.
2017 Chevrolet Volt
Owner reports · Recalls · Investigations
More warning signs than most Volt years
Owner complaints for the 2017 Chevrolet Volt are substantially higher than the model-year median of 169.
About this comparison →How this year compares
Owner complaints by model year
Compare all Volt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
720–25K
10725–50K
3850–75K
2175–100K
11100–150K
1150K+
250 reports with mileage · 447 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 310 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 233 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 219 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports9 fire reports10 injury reports
What owners actually said
697 reportsCheck engine light came on during highway driving and dash showed "Propulsion Power Is Reduced". Dealer said bad EGR valve and/or EGR cooler caused fuse to blow. Replacing fuse did not resolve the issue as it occurred again. EGR failure is a common issue with this vehicle and there is a GM service bulletin 18-NA-089 issues in Ma…
Read full complaint
Check engine light came on during highway driving and dash showed "Propulsion Power Is Reduced". Dealer said bad EGR valve and/or EGR cooler caused fuse to blow. Replacing fuse did not resolve the issue as it occurred again. EGR failure is a common issue with this vehicle and there is a GM service bulletin 18-NA-089 issues in March 2018. Driving with this condition can cause the engine to overheat as well as cause increased emissions due to the EGR being non-functional. This condition can be dangerous if the engine overheats and shuts down during highway driving. Emissions control systems such as EGR should be covered by the manufacturer but I had to pay out of pocket for this repair.
Shift to park notification after being placed in park. Used to only happen occasionally, but is almost every time I turn my car off now
The contact owns a 2017 Chevrolet Volt. The contact stated that occasionally at start-up or while driving at various speeds, the "Propulsion Power Reduced," warning message would appear on the instrument panel. Once the warning message would appear, the vehicle would not shift out of first gear. The contact had taken the vehicle…
Read full complaint
The contact owns a 2017 Chevrolet Volt. The contact stated that occasionally at start-up or while driving at various speeds, the "Propulsion Power Reduced," warning message would appear on the instrument panel. Once the warning message would appear, the vehicle would not shift out of first gear. The contact had taken the vehicle to the dealer on numerous occasion; however, the code reader could not diagnose the failure. The manufacturer was notified of the failure and the contact was given a case number. The vehicle had yet to be diagnosed or repaired. The failure mileage was approximately 33,000.
EGR Valve in 2017 Volts is faulty/defective 1) Right from the time the car was brand new, smell of exhaust in Cabin when engine warms up 2) When EGR Completely failed a) Loss of Propulsion b) Strong burning smell in cabin - like plastic burning No such problems with new EGR installed Here are lots of other peop…
Read full complaint
EGR Valve in 2017 Volts is faulty/defective 1) Right from the time the car was brand new, smell of exhaust in Cabin when engine warms up 2) When EGR Completely failed a) Loss of Propulsion b) Strong burning smell in cabin - like plastic burning No such problems with new EGR installed Here are lots of other people's similar problems with the EGR Valve https://www.gm-volt.com/threads/2017-interesting-egr-valve-failure.328621/ https://www.gm-volt.com/threads/2017-egr-valve-walk-home-fuse-saga-update.339078/ https://www.gm-volt.com/threads/17-volt-w-68k-miles-p0401.338840/ https://www.gm-volt.com/threads/2017-premier-25k-reduced-propulsion-power-overheated.338864/ https://www.gm-volt.com/threads/2017-fuse-f3-blown-egr-valve-part-12691147-is-out-of-stock.339131/ https://www.gm-volt.com/threads/2017-egr-problem-at-25k-miles.334723/ https://www.gm-volt.com/threads/2017-engine-not-available-yikes.339067/ https://www.gm-volt.com/threads/egr-valve-being-replaced-2017-volt.340639/#post-5063406 https://www.gm-volt.com/threads/replacing-egr-value-yourself.341033/#post-5068080
Went into a store to pick up a snack and the cashier noticed that my driver side door was on fire. The entire indoor panel was melted and burned. It looked like the fire started on the inside of the door panel where the wiring is. The car was turned off at the time of fire
Car couldn't be turned off. Dash would say "shift to park" when it was already in park. The problem was intermittent but the number of times needed to get the car to shut off was increasing. GM was aware of the problem but said it hadn't risen to Recall status. I saw over 500 of the same complaint online. They charged $800…
Read full complaint
Car couldn't be turned off. Dash would say "shift to park" when it was already in park. The problem was intermittent but the number of times needed to get the car to shut off was increasing. GM was aware of the problem but said it hadn't risen to Recall status. I saw over 500 of the same complaint online. They charged $800 to replace the switch and wiring. GM has stopped making Volts, so that could be why no recall???
I am having a shift to park error message when I am in park
The car suddenly started starting problem, then the electrical charging component to refuel the power from an electrical charging outlet was unable to charge. Now it does not start at all. I brought the 2017 Chevy Volt to a dealer, it has been more than a week and they said that the part to fix the problem is not available yet …
Read full complaint
The car suddenly started starting problem, then the electrical charging component to refuel the power from an electrical charging outlet was unable to charge. Now it does not start at all. I brought the 2017 Chevy Volt to a dealer, it has been more than a week and they said that the part to fix the problem is not available yet and I have to wait. They do not have any idea when they will get the part.
When I put the car in park the vehicle tells me I need to shift to park even though it is shift to park. Vehicle will not shut down and drain itself.
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE23022 · Loss Of Motive Power Due To The Battery Energy Control Module
Opened Nov 29, 2023 · Closed Mar 3, 2025
Status: closed (inferred from source dates) · Electrical System; Electrical System:propulsion System; Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Electrical System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.