NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
113 reportsClear category filterMileage unknown · Jan 10, 2026
Fuel/propulsion SystemUnknown Or OtherVehicle Speed Control
Experiencing intermittent propulsion system failure with multiple simultaneous warning messages on 2017 Chevrolet Volt at approximately 59,000 miles. WARNINGS DISPLAYED: - "Propulsion Power Reduced" message - "Check Tire Pressure Monitoring System" (false alert - all tires properly inflated and recently replaced) - Multiple da…
Read full complaint
Experiencing intermittent propulsion system failure with multiple simultaneous warning messages on 2017 Chevrolet Volt at approximately 59,000 miles. WARNINGS DISPLAYED: - "Propulsion Power Reduced" message - "Check Tire Pressure Monitoring System" (false alert - all tires properly inflated and recently replaced) - Multiple dashboard warning lights including exclamation point indicators - Vehicle exhibits abnormal driving characteristics PATTERN: Issue occurs intermittently while driving. Vehicle can be restarted and may operate normally afterward, then fault returns unpredictably. SAFETY CONCERN: This matches documented Battery Energy Control Module (BECM) failure pattern referenced in GM investigation N232432680/PE23022 and Customer Satisfaction Program 17228 recall N172096420 for reduced propulsion power in 2016-2018 Volts. Review of owner complaints shows other 2017 Volt owners experiencing sudden complete loss of propulsion while driving at highway speeds, creating dangerous situations requiring evasive action by other drivers. RISK: Loss of propulsion power while driving with dependent passengers creates serious crash risk. Vehicle is used for daily transportation of minor children. REQUEST: Vehicle exhibits known defect pattern but manufacturer has not extended recall coverage. Request investigation into whether recall should be expanded to cover additional affected vehicles.
NHTSA ODI #11710156
Mileage unknown · Oct 9, 2025
EngineFuel/propulsion SystemUnknown Or Other
My EGR system caused a check engine light. P0401 This is an extremely well documented issue on Gen2 Volts, especially 2017 models. Simply searching "EGR" on the Volt subreddit or forums returns hundreds of related threads. This issue can lead to a clogged EGR valve, causing further damage. A temporary resolution is unplugging th…
Read full complaint
My EGR system caused a check engine light. P0401 This is an extremely well documented issue on Gen2 Volts, especially 2017 models. Simply searching "EGR" on the Volt subreddit or forums returns hundreds of related threads. This issue can lead to a clogged EGR valve, causing further damage. A temporary resolution is unplugging the EGR valve, which i have not yet done. But this leaves the CEL illuminated, and without daily scanner, I wouls not know if other issues arise, causing a significant safety hazard.
NHTSA ODI #11692401
Mileage unknown · Jul 10, 2025
Electrical SystemPower TrainUnknown Or Other
Vehicle: 2017 Chevrolet Volt Purchased: March 2017, new from Quality Chevrolet, Escondido, CA I am reporting a persistent and worsening issue with the “Shift to Park” system in my 2017 Chevy Volt. The problem began approximately three months after purchase (mid-2017) and has continued to worsen over time. Initially, the issue o…
Read full complaint
Vehicle: 2017 Chevrolet Volt Purchased: March 2017, new from Quality Chevrolet, Escondido, CA I am reporting a persistent and worsening issue with the “Shift to Park” system in my 2017 Chevy Volt. The problem began approximately three months after purchase (mid-2017) and has continued to worsen over time. Initially, the issue occurred intermittently, but it now happens every time I attempt to turn off the vehicle. The vehicle fails to recognize that it is in Park, displaying a “Shift to Park” message on the dashboard even when the gear selector is correctly positioned. This prevents the car from shutting off properly and poses a safety and battery drain risk. I brought the vehicle to Quality Chevrolet for service on the following dates: June 2017 April 2018 August 2020 Despite these visits, the dealership failed to diagnose or resolve the issue. On July 9, 2025, I returned to the same dealership, and they finally diagnosed the problem as a faulty jumper harness and switch contact, quoting $586 plus tax for the repair. I requested a goodwill repair from GM, given that the issue began within the warranty period and has been ongoing for years, but my request was denied. This is a known and widespread issue affecting many GM vehicles, and I believe it represents a design or manufacturing defect that should be subject to a recall or broader investigation. I am requesting that NHTSA investigate this issue further to ensure consumer safety and accountability.
NHTSA ODI #11672449
Mileage unknown · Jun 13, 2025
Unknown Or Other
I was attempting to purchase this vehicle from Payless Used car sales in Anchorage Alaska. I noticed odometer discrepancies between the mechanic reported odometer in 2022 and the present odometer in 2025. The 2022 reported odometer was 60000, and now in 2025 it is 47000. When I made this concern to the salesman he asked me to le…
Read full complaint
I was attempting to purchase this vehicle from Payless Used car sales in Anchorage Alaska. I noticed odometer discrepancies between the mechanic reported odometer in 2022 and the present odometer in 2025. The 2022 reported odometer was 60000, and now in 2025 it is 47000. When I made this concern to the salesman he asked me to leave. I left and won’t consider purchasing from this dealership in the future.
NHTSA ODI #11666841
Mileage unknown · May 15, 2025
Unknown Or Other
Shifter malfunctions when shifted to PARK. Car does not recognize shifted to PARK and error message appears on dash. States, SHIFT TO PARK. Will not fully shut off vehicle.
NHTSA ODI #11661334
Mileage unknown · Apr 22, 2025
Electrical SystemUnknown Or OtherVehicle Speed Control
I am submitting this complaint regarding a recurring and potentially hazardous issue in my Chevrolet Volt 2017.The vehicle frequently displays a “Shift to Park” warning message even when the gear shifter is correctly in the Park position. This malfunction prevents the car from shutting off properly, posing both safety and operat…
Read full complaint
I am submitting this complaint regarding a recurring and potentially hazardous issue in my Chevrolet Volt 2017.The vehicle frequently displays a “Shift to Park” warning message even when the gear shifter is correctly in the Park position. This malfunction prevents the car from shutting off properly, posing both safety and operational concerns. This issue is widely reported among Chevrolet Volt owners, and General Motors has acknowledged it in Technical Service Bulletin (TSB 19-NA-206). Despite this, no formal recall has been issued to ensure a permanent solution for affected drivers. My Volt currently has 138000miles, and although it is outside of the Voltec Warranty period, this is clearly a manufacturer defect—not a result of normal wear and tear. The problem affects the safe operation of the vehicle and may lead to battery drain, inability to power down the car, and driver confusion. I strongly urge the National Highway Traffic Safety Administration (NHTSA) to investigate this issue and consider initiating a recall to protect drivers and ensure accountability. Thank you for your time and attention to this matter.
NHTSA ODI #11656069
Mileage unknown · Apr 8, 2025
Unknown Or Other
BECM is broken. Not covered under special warranty but have been told the PZEV warranty would cover it. Dealer & GM will not even discuss covering it. This should not be a VIN specific fix as the part is identical in all 2016-2018 Chevy Volts.
NHTSA ODI #11653569
Mileage unknown · Mar 18, 2025
Electrical SystemUnknown Or Other
When moving the shifter to the "P" position after parking, the car will refuse to turn off with the message on the dash: "Action Needed: Shift to Park". Shifter is in Park position but car will not recognize this and does not turn off. The issue can sometimes be resolved by pressing the shifter knob button repeatedly, or by pull…
Read full complaint
When moving the shifter to the "P" position after parking, the car will refuse to turn off with the message on the dash: "Action Needed: Shift to Park". Shifter is in Park position but car will not recognize this and does not turn off. The issue can sometimes be resolved by pressing the shifter knob button repeatedly, or by pulling the shifter all the way back to drive and forth to park multiple times until the message is cleared. This happens about 4/10 times that I drive, There is currently a bulletin posted by Chevy for a fix. However, the fix is only covered under a "warranty" and the Chevy repair center at the dealership quoted $400 to complete the repair out of warranty.
NHTSA ODI #11649108
Mileage unknown · Jan 5, 2025
Fuel/propulsion SystemUnknown Or Other
Propulsion Power Reduced and car had trouble breaking and would stall for a moment. Will not let me use the EV range even though the ev battery is at fully charge.
NHTSA ODI #11634142
Mileage unknown · Nov 20, 2024
Service BrakesUnknown Or Other
Been having issues with the dealership sierra chevy of monrovia. Brake fluid light came on. My car has been at the dealer for over two months now in counting. Closer to 3 months. First time was in July 24, 2024 for a check engine light. Fast forward to today Nov 19th, 2025. The car has been back at the dealer for the same issue …
Read full complaint
Been having issues with the dealership sierra chevy of monrovia. Brake fluid light came on. My car has been at the dealer for over two months now in counting. Closer to 3 months. First time was in July 24, 2024 for a check engine light. Fast forward to today Nov 19th, 2025. The car has been back at the dealer for the same issue the brake fluid light. Its now almost past 2 weeks. I have talked to the service manager and advisor a week ago. they told me they are having issues finding where the leak is coming from after having my vehicle there the past month. So I told them it was fine for the mechanic to drive the vehicle and figure it out. Now its almost another week and the service manager and advisor are not responding to my calls and texts. Left the service manager 2 voicemails already. Please help me get my car fixed and back to me. Service manager told me he would help me out with a rental since its a reoccurring issues . No communication from the dealership at all. No one is responding. After they claim to have fixed my vehicle the issue came back in less than a week. Dropped my car at the dealership on Nov 6th, 2024. Scared my vehicle's brakes will fail! Its still under warranty. Dont want the car back till its fixed properly. Just want my vehicle to be fixed
NHTSA ODI #11626466
NHTSA investigations
2PE23022 · Loss Of Motive Power Due To The Battery Energy Control Module
Opened Nov 29, 2023 · Closed Mar 3, 2025
Status: closed (inferred from source dates) · Electrical System; Electrical System:propulsion System; Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Electrical System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
Illustration