2017 Chevrolet Volt

I was driving in stop and go traffic on a relatively busy road when I was cut off. I braked hard to avoid a collision. Immediately afterwards, the car would not respond to the accelerator and would not go forward. I was in the middle of the road and the car would not respond. It could have caused an accident. I put the car into park and then back into drive and it seemed to work again. But I am now worried about the car.

Unknown My car has been accelerating and decelerating on it’s own while I’m driving.I got it checked with Fix Finder and states that my EGR Valve and ABS System failed. I brought it to a mechanic for a repair and I was told that the valve was unplugged so they plugged it back in and cleaned it , and said that everything was fine it said it might also be the cause of the failed ABS System but everything looks fine. After I got it fixed, it’s doing the same again and it’s worse this time. The car is accelerating on it’s own faster than what it did but the dashboard is saying 0mph. I was driving in the highway when it happened and it’s scary so I had to pull over.

Been having issues with the dealership sierra chevy of monrovia. Brake fluid light came on. My car has been at the dealer for over two months now in counting. Closer to 3 months. First time was in July 24, 2024 for a check engine light. Fast forward to today Nov 19th, 2025. The car has been back at the dealer for the same issue the brake fluid light. Its now almost past 2 weeks. I have talked to the service manager and advisor a week ago. they told me they are having issues finding where the leak is coming from after having my vehicle there the past month. So I told them it was fine for the mechanic to drive the vehicle and figure it out. Now its almost another week and the service manager and advisor are not responding to my calls and texts. Left the service manager 2 voicemails already. Please help me get my car fixed and back to me. Service manager told me he would help me out with a rental since its a reoccurring issues . No communication from the dealership at all. No one is responding. After they claim to have fixed my vehicle the issue came back in less than a week. Dropped my car at the dealership on Nov 6th, 2024. Scared my vehicle's brakes will fail! Its still under warranty. Dont want the car back till its fixed properly. Just want my vehicle to be fixed

SERVICE BRAKE BOOSTER EMITS A SEMI CONTINUOUS TAPPING/CLICKING NOISE. CHEVROLET STATE THAT IT IS NOT A SAFETY ISSUE AND DOES NOT REQUIRE REPAIR. HOWEVER, IT IS DIFFICULT TO HAVE CONFIDENCE IN THE BRAKING SYSTEM WHILE THIS SOUND PERSISTS AND IT IS A CONSTANT DISTRACTION WHILE DRIVING. PLUS, THE ABILITY TO SELL OR TRADE THE VEHICLE IN THIS CONDITION IS DIMINISHED. ELIMINATION OF THE NOISE INVOLVES COSTLY REMOVAL AND REPLACEMENT OF THE BRAKE BOOSTER ASSY. CHEVROLET FIXED AN APPARENTLY IDENTICAL ISSUE ON THE BOLT MODEL WITH A SOFTWARE UPDATE, BUT CURRENTLY HAVE NO INTENTION TO DO ANYTHING SIMILAR FOR THE VOLT MODEL.

My 2017 Chevy Volt has been making a clicking noise coming from the brake booster assembly since I have bought it. When your foot is released from the brake pedal, there is an audible click (3-4 times a second) inside of the cabin and I've decided to make a formal complaint as GM isn't taking the appropriate action to fix this issue. My reasoning is that this issue is not only common on the Chevy Volt, but also the Chevy Bolt as they share the exact same brake booster. For the Volt, dealers are instructed to replace the Brake Pedal Retainer - GM (39081933) and the Brake Master Cylinder - GM (84006919). This repair is often quoted in excess of $2,000 even though there is a very high likelihood of the issue returning even when the parts are replaced. For the Chevy Bolt, dealers were instructed to stop replacing the brake booster as they determined there was a software fix that could solve the issue. There was a TSB regarding this which details both the problem and the repair procedure (# [XXX]) [XXX] While GM fixed this issue on the Bolts, the Volts have the exact same issue and owners are being directed to spend $2,000+ to make a repair that won't even fix the issue. GM needs to release the software fix for the Volts so that the issue can be resolved properly. This burdens current Volt owners improperly, as GM has proven that a software release can fix this but has thus far refused to address and implement it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

BECM failure resulted in a situation where the vehicle drove with erratic surging power delivery throwing engine codes P1E00, U2603,U2604, U2605,U2606 Regen braking in this vehicle has a dedicated control on the steering wheel which applies only regen braking no friction brakes. When battery state of charge is high this can result in a situation where the regen braking button abruptly (i.e. during one extended activation of the button) delivers less brake force than the user is demanding.

Several times since I purchased the car in Jan 2022, the left and/or right front brakes have dragged without brake pedal actuation while I was driving in surface street traffic, typically with speed limits of 25 to 35 mph. This has resulted in overheating of the brake caliper, rotor, and wheel. Typically the car can be driven again without issue after two hours of cool-off time. This phenomenon has occurred during both battery/electric and gasoline engine operation of the plug-in hybrid car. There are no instrument indications of a brake malfunction when it happens. It first becomes perceptible as a pulsation through the steering wheel and requires increased throttle pedal pressure to maintain speed. I brought the car to my local Chevrolet dealer after the first two of these incidents. Their first recommendation was a new set of tires to remove the influence of one mismatched tire. The new tires did not resolve the issue, and the dealer has not performed any other corrective action beyond a recommendation to replace calipers and rotors. Due to the intermittent nature of the failure and the fact that it affects both of the front brakes, I believe this is an ABS system issue and not a caliper/rotor issue, and I have not replaced those parts yet. The car's adaptive cruise control does not work properly. It almost always fails to set and shows "Adaptive Cruise Temporarily Unavailable" regardless of road conditions. This condition is intermittent and is not reproducible on demand. This condition is dangerous because it overheats the brake, wheel, and steering components. The heat may have damaged the wheel bearing, steering components, and CV joints. The heat also creates a risk of sudden wheel and/or tire failure while driving. The unexpected application of the brakes affects vehicle response to throttle and steering inputs, and has the potential to reduce driver control of the vehicle.

I was driving on the highway at speeds greater than 60mph. Traffic came to a sudden stop and the pre-crash avoidance assisted with breaking. I resumed driving. The front right tire began smoking. I pulled over, the break was locked up and the rotor and pad were damaged. Overnight it releases. I take to service center and they are unable to replicate issue. I had to replace pads and rotors. A month later it locked up again, this time while driving. I became wary of the sighs now and pulled over immediately. Had the vehicle towed to service center. Again, they are unable to determine issue. They said there are no fault codes and no physical issues with breaking system. It is unfortunate the dealer does not know how to repair cars with complex computer operated systems. I don’t know what to do, right now we are in the stage of replacing random components to see if it fixes the issue. I can’t keep throwing money at this. I hope you can apply pressure to Chevy to help. I don’t know what to do, all I know is this isn’t safe. They had a similar recall for 2018 model year volts breaks locking up. But no recall issued for 2017 model year.

Late 2021 I noticed a strange noise and a slight stutter in my breaks that would only happen at the end of the breaking motion just before the car would completely stop. The sound and stutter, felt as though a clutch was trying to engaged. I scheduled a service appointment in January to have my tire replaced and car checked. The stabilitrack light came on while I was on vacation and also asked the dealership to check the stabilitrack. The dealership replaced my tires and inspected my car, but found nothing wrong with it. The tested the car and it appeared to be working just fine. I drove around another couple months with no incident. And then the notice and stutter came back, however it was intermittent. The stutter and noise slowly got worse and worse, but stilled continued to be an intermittent issue. On August 1st, while driving to work, my breaks completely failed and I almost got into an accident. I was pulling away from a red that just turned green. There was a red light ahead, I barely got up to 30-35mph before I started cruising towards the light. Started to press down on the breaks to stop and the pedal went straight to the floorboard with resistance and the breaks did not engage. I pumped the breaks frantically several times, with no change and quickly swerved and made a last minute right turn to avoid traffic. I continued to pump the breaks until it eventually did engage. I took the car to the dealership to have it serviced and inspected again, and was told it was the master cylinder that had failed. After it got replaced it was about another 2 weeks before I started to experience a similar issue again.

While using one pedal driving the brake lights do not engage unless brake pedal is used. This is a known issue by the company and was fixed in later models due to it being a problem. After speaking to the company I was advised to go to the dealer who informed me that the company has not offered any sort of update or repair option. If it was not deemed an issue why then did the company fix the issue in later models of the same vehicle? I have had many instances of very close calls with other vehicles. I truly believe if the company didn't believe it was an issue why then was it changed?