2017 Chevrolet Volt

I got a warning from my car a little over a week ago (around 6/1, unsure of exact date) that I needed to service the battery charging system, but then the check engine indicator light shut off and so did the warning light. The hybrid battery took a charge with no issues after that. Then, I left work the evening of 6/9 and drove home. On my way home, the check engine light came back on, followed by warnings that I needed to shift to park. Before I could pull over, my car stopped moving. Cars had to stop abruptly behind me and navigate around me into incoming traffic. I shifted to park, then tried to turn my car off and on again. I tried to switch between the gas engine and the battery, I tried to move my vehicle in any way. I couldn't get it into neutral to push it out of traffic. I turned on my hazard lights and a person came out from his house to assist in directing traffic away from my car for about an hour while I waited for a tow truck to arrive. The kind bystander who directed traffic and I were very concerned about a car accident happening due to my stopped vehicle. A police officer stopped by to check on us and try and get my vehicle into neutral but he was unable and said he was on his way to a 911 dispatch so he did not write a report of any kind that I could see. He told me the vehicle placement was not safe and I agreed with him. The tow truck came as he was leaving. The dealership I sent my car to said it is likely a short circuit in the 12v battery but I know the BECM in the Chevy Volt is known to cause similar behavior. Dealership refused to service the BECM when asked about it.

While driving the vehicle, the car shut down. Thankfully I was coming to a yield at a round about after exiting the Interstate. I was finally able to get it to restart and proceeded on my way. If this had happened on the Interstate myself, and other drivers would be at risk due to unassisted steering and braking. I also have experienced intermittent periods of "Reduction of Power" while on the interstate and other 55MPH plus highways. This presents a hazard to myself and other drivers as well. These issues ARE covered for similar vehicles under Special Warranty Coverage N232432680 as required by NHTSA on March 6, 2024. My vehicle also exhibits all of the primary symptoms described in that coverage, but GM claims that my vehicle is NOT covered. CEL is on. Can't charge condition Reduced power No start condition

More than two weeks ago, my 2017 Chevrolet Volt LT showed BECM codes. The local dealership service center said they would order the parts for a complete replacement. The work and parts are covered under warranty as this has been a common issue. The BECM and coolant arrived within a few days, but the remaining parts are back ordered! After two weeks of waiting GM has failed to send the parts and I and my family are in need of our vehicle for both work and safety reasons. The part number for the parts that still need to be sent is: 11517042. The warranty coverage number from Chevrolet's bulletin in regards to this failure is: N232432680.

There was a recall for the HPCM2 where the propulsion power reduced warning would come on whenever the car's cell battery was depleted. This happened with my car and there were several times it slowed on the freeway and on exit ramps as I tried to safely get my car off the road. It first happened on 4/13/25. I took my car to a regular mechanic who charged me 3k of repairs on basic maintenance, new tires, etc but were unable to fix this issue. They advised it was a manufacturer issue and to go to a hybrid specialist or a dealership. I called a hybrid specialist who found the faulty code and advised the same. I took my car to Felix Chevrolet (3330 S. Figueroa St. LA, CA 90007) and they offered to do many maintenance service items that I had done earlier this week in an attempt to fix the HPCM2 software bug. After I told them that the maintenance items were complete, they called me back an hour later to tell me I needed other maintenance repairs that are less common. When I gave them the description of the recall and re-explained this is identical to my car's symptoms and that this manufacturing issue may have affected other vehicles like mine that were outside of the recall batch, they told me it was impossible to apply this diagnosis as long as my VIN number was outside of the recall batch. Can you please add my VIN to this recall or have my car reviewed by someone who can debug the software?

I am submitting this complaint regarding a recurring and potentially hazardous issue in my Chevrolet Volt 2017.The vehicle frequently displays a “Shift to Park” warning message even when the gear shifter is correctly in the Park position. This malfunction prevents the car from shutting off properly, posing both safety and operational concerns. This issue is widely reported among Chevrolet Volt owners, and General Motors has acknowledged it in Technical Service Bulletin (TSB 19-NA-206). Despite this, no formal recall has been issued to ensure a permanent solution for affected drivers. My Volt currently has 138000miles, and although it is outside of the Voltec Warranty period, this is clearly a manufacturer defect—not a result of normal wear and tear. The problem affects the safe operation of the vehicle and may lead to battery drain, inability to power down the car, and driver confusion. I strongly urge the National Highway Traffic Safety Administration (NHTSA) to investigate this issue and consider initiating a recall to protect drivers and ensure accountability. Thank you for your time and attention to this matter.

My Chevy Volt went into Reduced Propulsion System Power Mode, the Engine light came on and the vehicle stalled while sitting at a traffic light on [XXX] at [XXX] in Tyler Texas. Checking the computer and the complaints online I found that my 15 AMP #03 fuse (No Walk Home) had blown. I replaced the fuse and the next day on [XXX] the same thing happened again after driving 30 miles. The vehicle stalled at an intersection outside of Tyler Texas. The EGR Valve is known to cause the fuse to blow, so I had no choice but to unplug the EGR Valve and replaced the fuse and has not blown the fuse since. This is BOTH a safety issue and an emissions issue, but the replacement part cannot be found anywhere to purchase anymore so I am having to drive this vehicle with this ongoing safety issue. Due to the nature of the EGR Valve blowing the fuse all the time and that it affects the safety of the vehicle a nationwide recall needs to be done on these vehicles to force GM to start making the part again. This is a dangerous flaw that will cause the vehicle to stall and create a safety hazard. This has been ongoing for quite some time with these Volts, and something needs to be done about it ASAP. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2017 Chevrolet Volt. The contact stated while the vehicle was parked, the vehicle stalled; the contact stated that the vehicle was jumpstarted and the vehicle to returned to normal operation; however, the failure reoccurred on several occasions. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the Battery Energy Control Module (BECM) needed to be replaced. The vehicle was not repaired. The vehicle was towed to a dealer where it was diagnosed that the 12-volt battery needed to be replaced. The vehicle was repaired; however, the check engine warning light illuminated again. The manufacturer was not notified of the failure. The failure mileage was approximately 107,000.

When moving the shifter to the "P" position after parking, the car will refuse to turn off with the message on the dash: "Action Needed: Shift to Park". Shifter is in Park position but car will not recognize this and does not turn off. The issue can sometimes be resolved by pressing the shifter knob button repeatedly, or by pulling the shifter all the way back to drive and forth to park multiple times until the message is cleared. This happens about 4/10 times that I drive, There is currently a bulletin posted by Chevy for a fix. However, the fix is only covered under a "warranty" and the Chevy repair center at the dealership quoted $400 to complete the repair out of warranty.

I am lodging a complaint about General Motors in dealing with a warranty repair to my 2017 Chevrolet Volt. On 9/11/2024 had low propulsion warning and took the vehicle to a local dealer. I though it may have been the power module, but the Dealer stated: “The module would not be replaced because it is not failing. Your high voltage battery is made up of multiple sections that control the power of the vehicle, one of those sections of your battery has a failure so rather than replacing the whole high voltage battery, GM will usually authorize replacement of the failed section.” On 9/13 GM authorized replacement. Weeks passed and I was told the battery section would come Q4 (2024]. The dealer has been very responsive about keeping me with loaner vehicles. I have issues only with GM. I asked GM to buy back the vehicle in January 2025. The request was verbally denied since for some undisclosed reason it does not fall within the California Lemon Law parameters. Later I was told by GM the part is expected “Q2”. GM has a representative call em every week or so just to check in. This was a safety issue as the car went to low power and might have caused significant problems in traffic. All the while I have been unable to drive the car, sell the car, or otherwise enjoy freedom of ownership. Now we are looking at at least 6 months in the shop, potentially 7-9 months or more. This is an unreasonable timeframe for repairs and hence this complaint. Please advise how I might proceed from this point to get the matter resolved soon.

The contact owns a 2017 Chevrolet Volt. The contact stated while driving at approximately 35 MPH, the “Propulsion Power Reduced” message in the driver information center was illuminated. The contact stated that the vehicle was losing motive power. The contact stated that the failure was intermittent but had occurred at various speeds, and the vehicle lost motive power. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the Battery Energy Control Module (BECM) needed to be replaced and reprogrammed. The vehicle was not repaired. The contact stated that the vehicle was no longer operable. The manufacturer was informed of the failure. The contact researched and related the failure to a Customer Satisfaction Program for the BECM; however, the contact was advised by the manufacturer and the dealer that the vehicle was not covered under the CSP. The failure mileage was approximately 110,000.