IllustrationThe engine light came on, but the car would run and so took it to the dealer. They determined that the EGR valve had failed and would cost $2400 to repair. Apparently, this is a common failure point for Generation 2 Chevy Volts. If it might trigger a forced recall, I'd like to add this to the list.
2016 Chevrolet Volt
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2016 Chevrolet Volt do not stand out strongly from the model-year median of 169.
About this comparison →How this year compares
Owner complaints by model year
Compare all Volt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
110–25K
2625–50K
1050–75K
775–100K
3100–150K
3150K+
60 reports with mileage · 109 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 77 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 63 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 51 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports1 fire reports1 injury reports
Engine complaints
48 reportsComponent/System Failed: The engine of my 2016 Chevrolet Volt experienced a sudden internal crack, leading to complete engine failure. The engine is available for inspection upon request. Safety Risk: The engine failure rendered the vehicle completely inoperable, posing potential risk if it had occurred while driving. Sudden los…
Read full complaint
Component/System Failed: The engine of my 2016 Chevrolet Volt experienced a sudden internal crack, leading to complete engine failure. The engine is available for inspection upon request. Safety Risk: The engine failure rendered the vehicle completely inoperable, posing potential risk if it had occurred while driving. Sudden loss of engine power could have caused a crash or left me stranded in traffic, endangering myself and others. Problem Reproduction / Confirmation: The failure was confirmed by a GM dealership, which performed a full inspection and documented the engine crack. The dealership verified that the crack was sudden and not caused by negligence or improper maintenance. Inspections by Others: The vehicle has been inspected by the dealership, and all reports are available. I have also submitted the issue to GM corporate for warranty review. No police or insurance representatives have reviewed this, as this was a mechanical failure with no collision. Warning Lamps or Symptoms: No warning lights, messages, or unusual symptoms appeared prior to the failure. The engine appeared to operate normally until the sudden failure. Upon failure, low oil and low propulsion error message appeared on dash. Current no dash lights are on in the vehicle. Assessment of Cause: Based on dealership inspection and documentation, the failure appears sudden and possibly related to a defect in emissions-related engine components. No external damage or user error contributed to the failure.
While driving the car displayed “reduced propulsion power” on the dash and then I lost all drive power and could not switch the plug in hybrid from electric to gas engine mode. The vehicle had to be towed to the dealer who stated that the battery electronics control module and perhaps the battery needed to be replaced. The che…
Read full complaint
While driving the car displayed “reduced propulsion power” on the dash and then I lost all drive power and could not switch the plug in hybrid from electric to gas engine mode. The vehicle had to be towed to the dealer who stated that the battery electronics control module and perhaps the battery needed to be replaced. The check engine light came on slightly before the incident.
Becm failure Car suddenly stopped driving and or starting Had to have it towed home
On [XXX] the check engine light turned on in my 2016 Chevy Volt (VIN: [XXX] miles 145,xxx). I was 2 hours from home in the freezing cold snow but thankfully the vehicle allowed me to drive home without any issues (no reduced propulsion power). When I returned to the vehicle to have a diagnostic check the error light disappeared…
Read full complaint
On [XXX] the check engine light turned on in my 2016 Chevy Volt (VIN: [XXX] miles 145,xxx). I was 2 hours from home in the freezing cold snow but thankfully the vehicle allowed me to drive home without any issues (no reduced propulsion power). When I returned to the vehicle to have a diagnostic check the error light disappeared and I was unable to check for error codes. Still no issues driving under EV/gasoline. Later that day, the car stopped going completely, no shifting out of park either. EV range was reporting 0 miles despite having full charge. I plugged in the charger but it would not work (first time this happened), " Not able to Charge" message displayed. After cycling power the EV range was full range and I was able to shift into drive again. These issues were intermittent over 3 weeks, frequently standing me temporarily. After cycling power, opening and closing the door, cycling power again, the car would function normally and I could drive under battery or gasoline power. I managed to capture these error codes while the MIL light was on: U2603, U2604, U2605, U2606, U2617, U2618, U2619, U2620, U2621, U2622, U2623, U2624 [XXX] my vehicle no longer drives or shifts out of park, "Not able to charge" message displayed, CEL light on. A class action lawsuit revealed a technical service bulletin 18-NA-261 released in 2018 (see attached) accusing GM of continuing support of the known faulty module. The result of the case was Special Coverage Bulletin N232432680 which acknowledges and addresses the above mentioned issues by replacing a faulty BECM common to ALL Chevy Volt models years 2016-2018. My VIN is EXCLUDED from coverage due to being a CARB compliant vehicle despite exhibiting the same behaviors, error codes, and sharing the same faulty BECM. Of the 60,000 Volts sold in 2016-2018, only 19,000 (~33%) qualify under the special coverage terms. 100% of the vehicles that qualify for coverage are NON-CARB compliant. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552
BECM failure leaving car stranded in traffic with no ability to move under its own power.
EGR valve has failed leaving me stranded on side of the road. Problem was confirmed by a Chevrolet dealership. Engine light came on moments before it happened.
Shift to park message & audible alarm. Display while in motion pulling into home driveway. Vehicle stalled midway while in motion. Halfway in the street & half driveway. Displaying propulsion power reduced & Engine not available service soon. After 30 minutes of starting & restarting was able to move out of the street. H…
Read full complaint
Shift to park message & audible alarm. Display while in motion pulling into home driveway. Vehicle stalled midway while in motion. Halfway in the street & half driveway. Displaying propulsion power reduced & Engine not available service soon. After 30 minutes of starting & restarting was able to move out of the street. However vehicle will NOT move. Transmission will shift, however will not move. Shift to park keeps popping up.
Faulty micro-switch from factory, causes power surge. Flawed microswitch in transaxle shift cable. Incomplete connection of microswitch resulting higher voltage to PCM.(power control module) This irregularity, shows a DTC code reducing power propulsion during movement. The car will loose power & ability to shift. During driv…
Read full complaint
Faulty micro-switch from factory, causes power surge. Flawed microswitch in transaxle shift cable. Incomplete connection of microswitch resulting higher voltage to PCM.(power control module) This irregularity, shows a DTC code reducing power propulsion during movement. The car will loose power & ability to shift. During driving movement. Quite a safety concern. A "shift to park" error displays on driver display screen. An OBD2 scanner will clear code & after a few attempts remain operational. However intermittent & unpredictable when to expect the loss of traction power.
The vehicle loses power when trying to accelerate when driving in electric mode, and the gas engine kicks on after a second at which point acceleration returns. It occurs when the battery power is high or low. Sometimes a warning pops up on the dash saying speed is limited to a specific MPH.
Official recalls
117V621000 · Air Bags:frontal
Oct 5, 2017
General Motors LLC (GM) is recalling certain 2015-2016 GMC Canyon and Chevrolet Colorado, and 2016 Chevrolet Volt vehicles. The driver's frontal air bag may improperly inflate during second-stage deployment in the event of a high speed crash.
Consequence & remedy
Consequence: An improperly inflated air bag increases the risk of injury in a crash.
Remedy: GM will notify owners, and dealers will replace the driver's frontal air bag module, free of charge. The recall began November 8, 2017. Owners may contact Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17387.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE23022 · Loss Of Motive Power Due To The Battery Energy Control Module
Opened Nov 29, 2023 · Closed Mar 3, 2025
Status: closed (inferred from source dates) · Electrical System; Electrical System:propulsion System; Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Electrical System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.