Electrical SystemEngine And Engine CoolingPower Train
TRANSMISSION SLIPS AFTER SITTING WHEN FIRST STARTING OUT;HORN HONKS OCCASIONALLY WHILE DRIVING; POWER SLIDING DOOR ON DRIVER'S SIDE WON'T OPEN/CLOSE WHEN ACTIVATED BY BUTTON OR REMOTE SWITCHES; HARD STARTS AFTER DRIVING AND SITTING BRIEFLY (ESPECIALLY AFTER HIGHWAY DRIVING--TRIED DIFFERENT GAS STATIONS GASSES). TAKEN TO TWO …
Read full complaint
TRANSMISSION SLIPS AFTER SITTING WHEN FIRST STARTING OUT;HORN HONKS OCCASIONALLY WHILE DRIVING; POWER SLIDING DOOR ON DRIVER'S SIDE WON'T OPEN/CLOSE WHEN ACTIVATED BY BUTTON OR REMOTE SWITCHES; HARD STARTS AFTER DRIVING AND SITTING BRIEFLY (ESPECIALLY AFTER HIGHWAY DRIVING--TRIED DIFFERENT GAS STATIONS GASSES). TAKEN TO TWO DIFFERENT DEALERS MOSTLY ABOUT TRANSMISSION AND THEY CLAIM UNLESS THE CHECK ENGINE LIGHT COMES ON, THEY CAN'T DO ANYTHING ABOUT IT. GOING TO TAKE BACK AND HAVE IT STAY THERE UNTIL THEY REPRODUCE THIS WEEK. *AK
NHTSA ODI #10045436
58,000 miles · Nov 2, 2003
Power Train
MY 2001 VENTURE LT WAS PURCHASE 6/21/01 NEW. BEGINNING AROUND 25,000 MILES I BEGAN TO EXPERIENCE AN INTERMITTENT TRANSMISSION PROBLEM WHERE WHEN THE CAR WAS IN DRIVE THE ENGINE WOULD ACCELERATE BUT NO POWER WAS TRANSFER TO THE TRANSMISSION AND THEN THE TRANSMISSION WOULD ENGAGE AND THE CAR WOULD LURCH FORWARD. DESPITE THIS CO…
Read full complaint
MY 2001 VENTURE LT WAS PURCHASE 6/21/01 NEW. BEGINNING AROUND 25,000 MILES I BEGAN TO EXPERIENCE AN INTERMITTENT TRANSMISSION PROBLEM WHERE WHEN THE CAR WAS IN DRIVE THE ENGINE WOULD ACCELERATE BUT NO POWER WAS TRANSFER TO THE TRANSMISSION AND THEN THE TRANSMISSION WOULD ENGAGE AND THE CAR WOULD LURCH FORWARD. DESPITE THIS COMPLAINT AND 3 TRIPS TO THE DEALERSHIP AT 28,000, 41,000, AND 52,000 THEY COULD NOT REPLICATE OR FIX THE PROBLEM. AT 58,000 THE TRANSMISSION EXPERIENCED A CATASTROPHIC FAILURE. ADDITIONALLY, I PERSONALLY KNOW OF ANOTHER OWNER WITH A CATASTROPHIC TRANSMISSION FAILURE AT LESS THAN 30,000 MILES. *LA
NHTSA ODI #10045264
Mileage unknown · Oct 17, 2003
Power TrainVisibility
FRONT WINDSHIELD LEAKS. VEHICLE IS EXPERIENCING AN OIL LEAK FROM THE SEAL. WARRANTY EXPIRED. *AK
NHTSA ODI #10044209
44,800 miles · Aug 24, 2003
Power Train
PREMATURE FAILURE OF AUTOMATIC TRANSMISSION ON 2001CHEVROLET VENTURE MINIVAN. BELIEVE KNOWN ENGINEERING OR MATERIALS DEFECT CAUSES SUN GEAR/THRUST BEARING ON INPUT SHAFT TO PREMATURELY FAIL (44,000 MILES IN MY CASE). IF FAILED UNDER SPEED COULD CAUSE ACCIDENT AS ALL FORWARD AND REVERSE POWER TO WHEELS WAS LOST. MANY COMPLAIN…
Read full complaint
PREMATURE FAILURE OF AUTOMATIC TRANSMISSION ON 2001CHEVROLET VENTURE MINIVAN. BELIEVE KNOWN ENGINEERING OR MATERIALS DEFECT CAUSES SUN GEAR/THRUST BEARING ON INPUT SHAFT TO PREMATURELY FAIL (44,000 MILES IN MY CASE). IF FAILED UNDER SPEED COULD CAUSE ACCIDENT AS ALL FORWARD AND REVERSE POWER TO WHEELS WAS LOST. MANY COMPLAINTS ON WEB ABOUT PRE-MATURE CHEVROLET VENTURE TRANSMISSION FAILURES. GM ALSO HAS HAD A SERVICE BULLETIN OUT FOR SOME TIME ON THE FAILING SUN GEAR/THRUST BEARING. SEEMS PRETTY EARLY IN MODEL YEAR LIFE TO BE PUBLISHING WHAT IS APPARENTLY A COMMON PROBLEM SHOWING UP AT REPAIR SITES. REQUEST RECALL INVESTIGATION. *AK
NHTSA ODI #10033402
43,000 miles · Apr 17, 2003
EquipmentPower Train
WHILE MY VEHICLE WAS PARKED AND TURNED OFF, MY 4 YEAR OLD KNOCKED IT OUT OF GEAR, COME TO FIND OUT THAT IT GOES FROM THE PARKED STATUS TO THE 1ST GEAR WITHOUT HAVING TO HAVE KEY IN OR PUSH THE BRAKE PETAL TO TAKE IT OUT OF GEAR IT IS FREE FLOWING, AND VERY DANGEROUS. I WAS VERY FORTUNATELY LOADING SOME GROCERIES WHEN IT HAPP…
Read full complaint
WHILE MY VEHICLE WAS PARKED AND TURNED OFF, MY 4 YEAR OLD KNOCKED IT OUT OF GEAR, COME TO FIND OUT THAT IT GOES FROM THE PARKED STATUS TO THE 1ST GEAR WITHOUT HAVING TO HAVE KEY IN OR PUSH THE BRAKE PETAL TO TAKE IT OUT OF GEAR IT IS FREE FLOWING, AND VERY DANGEROUS. I WAS VERY FORTUNATELY LOADING SOME GROCERIES WHEN IT HAPPENED AND WITH THE ASSISTANCE OF A VERY NICE PERSON WALKING BY, WERE ABLE TO GET IT BACK INTO PARK AND NO INJURIES ACCRUED, I DREAD TO THINK OF WHAT WOULD HAVE HAPPENED IF ONE OF MY TWO YOUNG CHILDREN WOULD HAVE BEEN IN MY POSITION, WHAT THE OUTCOME COULD HAVE BEEN. *NLM
NHTSA ODI #10016141
Mileage unknown · Mar 13, 2003
Power Train
THE VEHICLE TO ACCELERATE, WHEN TRYING TO PULL OF FROM A LIGHT. *JB
NHTSA ODI #10011628
Mileage unknown · Sep 17, 2002
Power Train
WHEN ON A DOWNWARD INCLINE AND VEHICLE WAS IN PARK IT WILL SLIP OUT OF PARK GEAR, AND WILL START TO ROLL BACK. IT COULD HAVE CAUSE AN ACCIDENT. DEALER NOTIFIED. *AK
NHTSA ODI #8018857
Mileage unknown · Jul 31, 2002
Power TrainCrash
THIS HAS HAPPENED 4 TIMES SAME PROBLEM, 1ST TIME VAN WAS NOT RUNNING POPPED OUT OF GEAR WENT DOWN THE ROAD BACKWARDS AND HIT A HOME NOT MUCH DAMAGE TO EITHER THE HOUSE OR THE VAN. NOT MOVING FAST ENOUGH, THE SECOND TIME MOVED ABOUT A FOOT ON LEVEL GROUND , 3RD TIME RUNNING IN A FLAT DRIVEWAY NO ONE NEAR DRIVERS SEAT CAR WENT OUT…
Read full complaint
THIS HAS HAPPENED 4 TIMES SAME PROBLEM, 1ST TIME VAN WAS NOT RUNNING POPPED OUT OF GEAR WENT DOWN THE ROAD BACKWARDS AND HIT A HOME NOT MUCH DAMAGE TO EITHER THE HOUSE OR THE VAN. NOT MOVING FAST ENOUGH, THE SECOND TIME MOVED ABOUT A FOOT ON LEVEL GROUND , 3RD TIME RUNNING IN A FLAT DRIVEWAY NO ONE NEAR DRIVERS SEAT CAR WENT OUT OF GEAR MOVED FORWARD AND HIT A PARKED CARS MIRROR, DIDN'T DAMAGE THE MIRROR BUT DISTROYED THE FENDER ON THE VAN. , THE 4TH TIME WENT OUT OF GEAR WHILE PARKED NO ONE IN OR NEAR CAR. DIDN'T MOVE BECAUSE THE EMERGANCY BRAKE WAS SET. IS BEING INVESTIGATED BY GENERAL MOTORS.*AK
NHTSA ODI #764994
Mileage unknown · Mar 12, 2002
Power Train
WHILE TRANSMISSION IS ON DRIVE AND GOING UP A HILL COULD TAKE OFF FOOT FROM BRAKES TO ACCELERATOR AND VEHICLE WILL ROLL BACKWARD. BUT THE SAME MOTION HAD HAPPENED WHEN DRIVING DOWN A HILL WILL ROLL FOWARD WHEN TRYING TO REVERSE. DEALER WAS CONTACTED, PLEASE PROVIDE MORE INFORMATION.*AK
NHTSA ODI #8005524
Mileage unknown · Jan 28, 2002
Power TrainInjury
VEHICLE WAS PARKED IN DRIVEWAY WITH ENGINE RUNNING, DRIVER REPORTEDLY PUT VEHICLE IN PARK, CHILD IN CHILD SEAT IN REAR SEAT, DRIVER CARRIED PACKAGE IN HOUSE, VEHICLE WENT DOWN DRIVEWAY FORWARD ACROSS HIGHWAY AND INTO DITCH. DRIVER FOUND VEHICLE RUNNING, SHIFT LEVER IN PARK AND INSTRUMENT PANEL INDICATOR SHOWING DRIVE. SUBMITTED…
Read full complaint
VEHICLE WAS PARKED IN DRIVEWAY WITH ENGINE RUNNING, DRIVER REPORTEDLY PUT VEHICLE IN PARK, CHILD IN CHILD SEAT IN REAR SEAT, DRIVER CARRIED PACKAGE IN HOUSE, VEHICLE WENT DOWN DRIVEWAY FORWARD ACROSS HIGHWAY AND INTO DITCH. DRIVER FOUND VEHICLE RUNNING, SHIFT LEVER IN PARK AND INSTRUMENT PANEL INDICATOR SHOWING DRIVE. SUBMITTED BY DAVID DAUBERT, P.E. *YD
ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).
Consequence & remedy
Consequence: A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence & remedy
Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
ON CERTAIN PASSENGER, SPORT UTILITY VEHICLES AND MINI VANS, SOME OF THESE VEHICLES HAVE A PASSENGER AIR BAG THAT WAS MANUFACTURED WITHOUT A CHECK VALVE PIN. AN AIR BAG WITHOUT THE CHECK VALVE PIN COULD PRODUCE INCREASED PRESSURE AT THE ONSET OF THE AIR BAG DEPLOYMENT AND REDUCED PRESSURE AFTERWARD.
Consequence & remedy
Consequence: THIS COULD INCREASE THE SEVERITY OF INJURY TO A PERSON WHO WAS NOT PROPERLY RESTRAINED AND WHO WAS CLOSE TO THE PASSENGER AIR BAG AT THE TIME OF DEPLOYMENT. IT COULD ALSO REDUCE THE AB8ILITY OF THE AIR BAG TO PROTECT A RESTRAINED FRONT SEAT PASSENGER.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE PASSENGER AIR BAG. OWNER NOTIFICATION BEGAN DECEMBER 16, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OLDSMOBILE AT 1-800-442-6537, OR SATURN AT 1-800-553-6000, PROMPT #3.
VEHICLE DESCRIPTION: CERTAIN MINI VANS BUILT WITH SECOND ROW 50/50 SPLIT BENCH SEATS OR CAPTAIN'S CHAIRS, FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE SEAT LATCH ANCHOR WIRE DIAMETER IS GREATER THAN 6.1 MM.
Consequence & remedy
Consequence: IF THE CONNECTOR FOR A LATCH-TYPE CHILD RESTRAINT IS NOT ATTACHED CORRECTLY TO THE ANCHORAGE POINTS, THE RESTRAINT WILL NOT PROPERLY PROTECT A CHILD IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSPECT THE LATCH ANCHOR WIRES AND REPAIR THOSE WITH AN IMPROPER DIAMETER. OWNER NOTIFICATION BEGAN APRIL 10, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
VEHICLE DESCRIPTION: 1997-2001 CHEVROLET VENTURE, PONTIAC MONTANA/TRANSPORT, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS THAT WERE SERVICED IN CAMPAIGN 01013 (01V-067) FROM APRIL TO AUGUST 2001. ALSO 2001 CHEVROLET VENTURE, PONTIAC MONTANA, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS ASSEMBLED IN JANUARY THROUGH APRIL 2001. THESE VEHICLES HAVE INADEQUATE FRONT WELDS. IF A FRONT WELD FAILS, THE ACTUATOR CAN JAM IN THE UNLATCHED POSITION AND, WHEN THE SLIDING DOOR CLOSES, IT WILL NOT BE LATCHED.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE. AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSPECT AND, IF REQUIRED, INSTALL A NEW POWER SLIDING DOOR UNLATCH ACTUATOR ASSEMBLY. OWNER NOTIFICATION BEGAN ON OCTOBER 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE.
Consequence & remedy
Consequence: AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSTALL A NEW UN-LATCH ACTUATOR ASSEMBLY TO THE POWER SLIDING DOOR. THIS RECALL HAS BEEN CONTINUED UNDER SAFETY RECALL 01V-264. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
VEHICLE DESCRIPTION: PASSENGER, SPORT UTILITY VEHICLES AND MINIVANS. THE PASSENGER AIR BAG INFLATOR MODULES WERE BUILT WITHOUT THE CORRECT AMOUNT OF GENERANT, WHICH PRODUCES THE GAS THAT FILLS THE AIR BAG. SOME WERE BUILT WITH A DOUBLE LOAD OF GENERANT AND SOME WERE BUILT WITHOUT GENERANT.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH THAT WOULD TRIGGER A PASSENGER AIR BAG DEPLOYMENT, A DOUBLE LOAD OF GENERANT CAN CAUSE THE INFLATOR MODULE TO EXPLODE. IF THE AIR BAG MODULE EXPLODES, METAL AND PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO VEHICLE OCCUPANT. A MODULE WITH NO GENERANT WOULD NOT INFLATE THE AIR BAG, AND THE OCCUPANTS COULD RECEIVE MORE SEVERE INJURIES.
Remedy: DEALERS WILL REPLACE THE PASSENGER AIR BAG MODULE. TELEPHONE CALLS WERE MADE TO OWNERS ON JANUARY 29, 2001. FOLLOW UP OWNER MAILING BEGAN ON APRIL 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR SATURN AT 1-800-553-6000.
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE04064 · POWER-SLIDING Door
Opened Sep 17, 2004 · Closed Dec 22, 2004
Status: closed (inferred from source dates) · Structure:body:door
SUBJECT VEHICLES ARE AVAILABLE WITH AN OPTIONAL POWER SLIDING DOOR.THE INTERIOR HANDLE IS ORIENTED IN THE VERTICAL POSITION IN THE DOOR PANEL AND LINES UP AT THE ELBOW LEVEL WHEN THE OCCUPANT IS SEATED IN THE 2ND-ROW OUTBOARD POSITION.IF THE OCCUPANT HOLDS THE INTERIOR HANDLE IN THE THUMB UP POSITION DURING POWER-ASSISTED OPENING, THE ARM/WRIST CAN BE PUSH BACK WITH FORCE AGAINST THE 2ND-ROW BUCKET SEAT OR CAPTAIN'S CHAIR SEAT BACK CREATING A RISK OF INJURY (OTHER SEATING CONFIGURATIONS HAVE AMPLE SEAT TO DOOR CLEARANCE TO AVOID ENTRAPMENT OF THE LOWER ARM).AMONG THE 103 TOTAL REPORTS, THERE WERE 102 ALLEGED INJURIES INCLUDING ARM/WRIST, THUMB AND SHOULDER INJURIES.A COUNT OF INJURIES REVEALS THAT 76 INJURIES WERE A FRACTURED OR A BROKEN ARM/WRIST REQUIRING AN IMMOBILIZING CAST FOR FOUR-TO-SIX WEEKS.ALL INJURIES INVOLVE THE RIGHT SIDE POWER SLIDING DOOR.THE LEFT SIDE POWER SLIDING DOOR IS ON FAR FEWER VEHICLES, BUT MORE IMPORTANTLY, IT PRODUCES LESS FORCE.GM NOTIFIED THE AGENCY BY LETTER DATED DECEMBER 21, 2004, THAT IT WILL RECALL MODEL YEAR 1997 THOUGH EARLY 2005 GM U-VAN VEHICLES EQUIPPED WITH A RIGHT SIDE POWER SLIDING DOOR AND WITH 2ND-ROW BUCKET SEATS OR CAPTAIN CHAIRS (NHTSA RECALL #04V597).AS PART OF THE RECALL REMEDY, GM WILL REPLACE THE DOOR HANDLE WITH A FLUSH MOUNTED HANDLE THAT WILL PREVENT AN OCCUPANT FROM GRASPING THE HANDLE WITH THE PALM BETWEEN THE HANDLE AND DOOR PANEL (THUMB UP ORIENTATION) AND THUS ELIMINATE THE POTENTIAL FOR ARM/WRIST ENTRAPMENT.THIS INVESTIGATION IS CLOSED.
2001 Chevrolet Venture Problems, Complaints & Recalls | Skip That Year
Illustration