NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
354 reports89,000 miles · Feb 14, 2015
Steering
VEHICLE VERY HARD TO STEER. LOUD NOISE WHEN SHIFT OUT OF PARK. HARD TO STEER AT LOW SPEED, TOOK TO DEALERSHIP THEY KEPT MY VEHICLE REFUSED TO PROVIDE LOANER CAR UNTIL DIAGNOSED TWO DAYS LATER. DROPPED OFF ON A FRIDAY DEALER SAYS REPAIR TO STEERING WON'T BE DONE UNTIL TUESDAY. RESEARCHED ONLINE AND FOUND THIS PROBLEM ON MANY CHE…
Read full complaint
VEHICLE VERY HARD TO STEER. LOUD NOISE WHEN SHIFT OUT OF PARK. HARD TO STEER AT LOW SPEED, TOOK TO DEALERSHIP THEY KEPT MY VEHICLE REFUSED TO PROVIDE LOANER CAR UNTIL DIAGNOSED TWO DAYS LATER. DROPPED OFF ON A FRIDAY DEALER SAYS REPAIR TO STEERING WON'T BE DONE UNTIL TUESDAY. RESEARCHED ONLINE AND FOUND THIS PROBLEM ON MANY CHEVY TRAVERSE FORUMS. THIS CAR NEEDS TO BE RECALLED BEFORE SOMEONE IS INJURED. *TR
NHTSA ODI #10683508
Mileage unknown · Feb 2, 2015
Air Bags
TL*THE CONTACT OWNS A 2012 CHEVROLET TRAVERSE. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V118000 (AIR BAGS). THE CONTACT STATED THAT THE PART NEEDED TO REPAIR THE VEHICLE WAS UNAVAILABLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
NHTSA ODI #10680596
53,345 miles · Dec 30, 2014
Steering
ON 24 DEC 2014 AT AROUND 11:45AM, I WAS PULLING OFF A MAIN ROAD (WITH MY YOUNG DAUGHTER) INTO THE PARKING LOT OF MY DOCTOR'S BUSINESS, WHEN MY STEERING WHEEL LOCKED COMPLETELY WHILE I WAS STILL IN MOTION. AFTER BRAKING, I WAS ABLE TO JIGGLE THE STEERING WHEEL FREE AND PULLED THE CAR INTO A PARKING SPACE. I CONTACTED MY DEALERS…
Read full complaint
ON 24 DEC 2014 AT AROUND 11:45AM, I WAS PULLING OFF A MAIN ROAD (WITH MY YOUNG DAUGHTER) INTO THE PARKING LOT OF MY DOCTOR'S BUSINESS, WHEN MY STEERING WHEEL LOCKED COMPLETELY WHILE I WAS STILL IN MOTION. AFTER BRAKING, I WAS ABLE TO JIGGLE THE STEERING WHEEL FREE AND PULLED THE CAR INTO A PARKING SPACE. I CONTACTED MY DEALERSHIP IMMEDIATELY TO REPORT THE INCIDENT. AS IT WAS CHRISTMAS EVE, THEY WERE CLOSING WITHIN MINUTES AND I WAS TOLD TO BRING IN THE CAR ON FRIDAY, DEC 26TH..WHICH I DID. AFTER AN ASSESSMENT WAS COMPLETED AND THE SERVICE DEPARTMENT "COULD NOT DUPLICATE CUSTOMER'S COMPLAINT OF LOSS OF POWER STEERING", I WAS TOLD THERE WAS NOTHING ELSE THEY COULD DO FOR ME UNTIL THE PROBLEM HAPPENED AGAIN AND WITH MORE REGULARITY. THE SERVICE REPS DID SHARE THAT THERE HAS BEEN REPORTED INCIDENTS WITH THE TRAVERSE REGARDING LOSS OF POWER STEERING, BUT NO FURTHER INFORMATION WAS SHARED WITH ME. UPON DRIVING OUT OF THE DEALERSHIP, I PROMPTLY CONTACTED GM WHO OPENED UP A CASE REPORT. I HAVE REQUESTED THAT GM AND THE DEALERSHIP CONDUCT A MORE THOROUGH DIAGNOSIS OF THE STEERING SYSTEM AS I DEEM THIS INCIDENT MORE THAN JUST A "RANDOM" INCIDENT. THIS IS RATHER ALARMING AND I AND MY DAUGHTER ARE EXTREMELY LUCKY THAT THIS DID NOT HAPPEN MINUTES BEFORE WHEN WE WERE ON A MAJOR INTERSTATE DRIVING AT A HIGHER SPEED. NEEDLESS TO SAY, I FEEL VERY UNSAFE IN MY CAR NOW AND FEEL IT NECESSARY TO REPORT THE INCIDENT TO NHTSA IN THE EVENT OTHER 2012 TRAVERSE OWNERS HAVE REPORTED THE SAME. THANK YOU. *JS
NHTSA ODI #10669213
39,000 miles · Dec 22, 2014
Air Bags
TL* THE CONTACT OWNS A 2012 CHEVROLET TRAVERSE. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAILURE WAS UNABLE TO BE DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 39,000.
NHTSA ODI #10667643
53,000 miles · Dec 19, 2014
Electronic Stability Control (esc)
CAR STABILITY CONTROL FAULTED AND THROTTLED THE VEHICLE TO 15 MPH ON THE HWY. ALMOST KILLED MY WIFE AND CHILDREN AS SHE HAD TO GO ACROSS 3 LANES OF TRAFFIC TO PULL OFF THE HWY. *TR
NHTSA ODI #10667342
Mileage unknown · Dec 16, 2014
Seat Belts
2012 CHEVROLET TRAVERSE. RECALL ON THE FLEXIBLE STEEL CABLE THAT CONNECTS THE SAFETY BELT TO THE VEHICLE AT THE OUTSIDE OF THE FRONT OUTBOARD SEATING POSITIONS THAT CAN FATIGUE AND SEPARATE OVER TIME AS A RESULT OF OCCUPANT MOVEMENT INTO THE SEAT. *TA THE CONSUMER STATED THE RECALL, WAS COMPLETED. *JB
NHTSA ODI #10659554
28,000 miles · Oct 28, 2014
Electronic Stability Control (esc)EngineService Brakes
THE VEHICLE MAKES A GRINDING NOISE WHEN BRAKING. WHEN YOU HIT THE BRAKES YOU ALSO HEAR A CRUNCHING SOUND FROM THE INSIDE OF THE CAR. WHEN ATTEMPTING TO STOP YOU ALSO FEEL THE CAR JERKING. THE CAR HAS THE STABILITRAK LIGHT COME ON AND WHEN THAT HAPPENS IT ALSO SAYS YOU HAVE LOST TRACTION FOR THE VEHICLE. WHEN THIS HAPPENS THE CAR…
Read full complaint
THE VEHICLE MAKES A GRINDING NOISE WHEN BRAKING. WHEN YOU HIT THE BRAKES YOU ALSO HEAR A CRUNCHING SOUND FROM THE INSIDE OF THE CAR. WHEN ATTEMPTING TO STOP YOU ALSO FEEL THE CAR JERKING. THE CAR HAS THE STABILITRAK LIGHT COME ON AND WHEN THAT HAPPENS IT ALSO SAYS YOU HAVE LOST TRACTION FOR THE VEHICLE. WHEN THIS HAPPENS THE CAR FEELS LIKE ITS GLIDING AND HAS DIFFICULTY STOPPING. THE ENGINE IN MY CAR HAS A NOISE ON THE DRIVERS SIDE SINCE THE DAY I PURCHASED THE VEHICLE. AT TIMES YOU CAN EVEN HEAR THE NOISE WHILE DRIVING WITH YOUR WINDOWS UP. *TR
NHTSA ODI #10650843
61,000 miles · Oct 20, 2014
SteeringVehicle Speed Control
A WEEK AGO MY TRAVERSE STARTED MAKING A GRINDING NOISE, AND I THOUGHT IT WAS THE BRAKES SO I TOOK IT TO OUR MECHANIC WHO CHECKED ALL FOUR WHEELS AND DETERMINED THE BRAKES WERE FINE. HE SAID IT WAS POSSIBLY A ROCK OR SOMETHING CAUSING THE NOISE AND IT STOPPED FOR A FEW DAYS. THIS MORNING I WAS PULLING INTO A PARKING SPOT AT WOR…
Read full complaint
A WEEK AGO MY TRAVERSE STARTED MAKING A GRINDING NOISE, AND I THOUGHT IT WAS THE BRAKES SO I TOOK IT TO OUR MECHANIC WHO CHECKED ALL FOUR WHEELS AND DETERMINED THE BRAKES WERE FINE. HE SAID IT WAS POSSIBLY A ROCK OR SOMETHING CAUSING THE NOISE AND IT STOPPED FOR A FEW DAYS. THIS MORNING I WAS PULLING INTO A PARKING SPOT AT WORK AND THE STEERING FROZE UP COMPLETELY AND THE BRAKES DID NOT WANT TO WORK EITHER. I ALMOST HIT THE CAR I WAS PARKING NEXT TO! I'M SO GLAD THAT DIDN'T HAPPEN IN THE MIDDLE OF TRAFFIC OR A MAIN STREET OR IT COULD HAVE BEEN A LOT WORSE. VERY SCARY, BUT WHAT WOULD CAUSE THIS? WILL GM BE LOOKING INTO THIS BEFORE SOMEONE GETS REALLY HURT OR HAS A MAJOR ACCIDENT? TAKING BACK TO THE MECHANIC WEDNESDAY TO CHECK THE STEERING PUMP.... NOT HAPPY. *TR
NHTSA ODI #10648825
4,500 miles · Oct 11, 2014
Equipment Adaptive/mobilityFuel/propulsion SystemSeat Belts
HELLO. I LEASED A 2012 TRAVERSE FOR 24 MONTHS AND HAD 3 OR WAS IT 4 URGENT/IMPORTANT RECALLS? I MISSED WORK 3 TIMES COSTING ME ALMOST $500.00 DOLLARS BECAUSE I HAD TO CALL OFF ALL BECAUSE "URGENT/IMPORTANT" TOOK THOSE WORDS FOR GRANTED RECALLS. I RECENTLY GOT A 24 MONTH NEW LEASE FROM CHEVY AGAIN AFTER TURNING MY TRAVERSE IN THI…
Read full complaint
HELLO. I LEASED A 2012 TRAVERSE FOR 24 MONTHS AND HAD 3 OR WAS IT 4 URGENT/IMPORTANT RECALLS? I MISSED WORK 3 TIMES COSTING ME ALMOST $500.00 DOLLARS BECAUSE I HAD TO CALL OFF ALL BECAUSE "URGENT/IMPORTANT" TOOK THOSE WORDS FOR GRANTED RECALLS. I RECENTLY GOT A 24 MONTH NEW LEASE FROM CHEVY AGAIN AFTER TURNING MY TRAVERSE IN THIS MONTH SHORTLY AFTER I WAS BILLED BY ALLY FINANCIAL ABOUT $600.00 FOR MINOR WEAR AND TEARS FOR THE TRAVERSE I TURNED IN ALMOST 2 WEEKS AGO. I TURNED THE TRUCK IN EARLY AND MADE THE LAST PAYMENT AND IT WAS 8K MILES UNDER. I'M SHOCKED AND APPALLED THAT WITH ALL THE URGENT RECALLS AND HAVING TO LOSE MONEY CALLING OFF WORK TO GET THESE SERIOUS URGENT RECALLS FIXED, ALLY OR CHEVY DID NOT EVEN OFFER ANY INCENTIVES?? THEY SAID REPAIRS FOR RECALLS ARE AT NO CHARGE...WELL OF COURSE THEY'RE RESPONSIBLE AND TO THINK OF MY KIDS AND DRIVING WITH THEM KNOWING A PRIOR URGENT RECALLS AND ONE BEING WAS WITH SAFETY BELTS??,? HMMM MAYBE I NEED TO TALK TO SOMEONE ABOUT THIS, I HAVE TO TAKE IT AS A SERIOUS MATTER. I LOST TIME AND MONEY AWAY FROM WORK TO FIX THE CHEVY RECALLS...SO MANY, AND ALLY FINANCIAL IS ASKING ME FOR ALMOST $600.00??? CHEVY NEGLECTED TO RELEASE THESE VEHICLES LIKE THE TRAVERSE WITH SEAT BELT ISSUES BEING DISCOVERED A YEAR AFTER I'VE BEEN DRIVING IT AND WITH THE FAMILY IN IT? WOW UNBELIEVABLE, AND THEN ALLY FINANCIAL ASKING ME FOR $600. FOR MINOR SCRATCHES, SOME NERVES. CHEVY NOT EVEN COMPENSATING NOTHING NOT EVEN A DOLLAR, HAH I JUST HOPE THAT VP [XXX] OF THE GLOBAL VEHICLE SAFETY REALIZES THIS WAS ONGOING THE SECOND MY FAMILY TRUCK TRAVERSE LEFT THE ASSEMBLY WITH THIS IMPORTANT/URGENT RECALL, ESPECIALLY THE SEAT BELT ONE. MY FAMILY RODE IN THIS TRUCK. NO COMPENSATIONS JUST AN APOLOGY, SURE YAH RIGHT GREAT CUSTOMER SERVICE...ALLY OWES ME AND CHEVY SHOULD PAY MY DEBT...THE NERVE! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10643991
30,000 miles · Oct 9, 2014
Service Brakes
TL* THE CONTACT OWNS A 2012 CHEVROLET TRAVERSE. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, THE BRAKES WERE ENGAGED AND A LOUD GRINDING SOUND EMITTED FROM THE VEHICLE. THE PROBLEM HAS RECURRED. THE VEHICLE WAS TAKEN TO DEALER. THE TECHNICIAN DIAGNOSED THAT THE BRAKES FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED B…
Read full complaint
TL* THE CONTACT OWNS A 2012 CHEVROLET TRAVERSE. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, THE BRAKES WERE ENGAGED AND A LOUD GRINDING SOUND EMITTED FROM THE VEHICLE. THE PROBLEM HAS RECURRED. THE VEHICLE WAS TAKEN TO DEALER. THE TECHNICIAN DIAGNOSED THAT THE BRAKES FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE PROBLEM RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000.
NHTSA ODI #10643685
Official recalls
5Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2010-2015, 2017 Buick Enclave, 2010-2019 Chevrolet Traverse, and 2011-2016 GMC Acadia vehicles. The side curtain air bags may not be properly attached.
Consequence & remedy
Consequence: Unsecured side curtain air bags may not perform as intended, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and, if necessary, realign or replace the weld nuts, free of charge. Owner notification letters were mailed on May 24, 2021. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N202321200.
Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
Apr 9, 2012
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011-2012 CHEVROLET TRAVERSE, BUICK ENCLAVE, AND GMC ACADIA VEHICLES CURRENTLY REGISTERED IN ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, WYOMING AND THE DISTRICT OF COLUMBIA. SNOW OR ICE BUILDUP ON THE WINDSHIELD OR ON THE WIPER MAY RESTRICT THE MOVEMENT OF THE WIPER ARM, CAUSING THE WIPER ARM TO LOOSEN AND CAUSE THE WIPER TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IF THIS OCCURS, DRIVER VISIBILITY COULD BE REDUCED, INCREASING THE RISK OF A CRASH.
Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL TIGHTEN THE WIPER ARM NUTS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 20, 2012.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Illustration