NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
15 reportsClear category filterMileage unknown · Nov 10, 2021
Electrical SystemPower TrainService Brakes
UNKNOWN, I first bought my Chevy Traverse Ltz in April of 2020, and about 2 weeks of driving it, I noticed that all(4)of my wheels/brakes instantly locked up while driving in traffic, almost causing a pile-up collision. The rotors and brakes releases alot of smoke as the wheels scrub and the suv doesn't move forward nor backward…
Read full complaint
UNKNOWN, I first bought my Chevy Traverse Ltz in April of 2020, and about 2 weeks of driving it, I noticed that all(4)of my wheels/brakes instantly locked up while driving in traffic, almost causing a pile-up collision. The rotors and brakes releases alot of smoke as the wheels scrub and the suv doesn't move forward nor backward. I reported it to the car lot/dealership where i purchased it from and was told to take it to a certain auto shop. I arrived there, just to be told that he doesn't fix those type of problems. The dealership where i bought it from didn't look at it either. So, from that time til now in 2021, I have been dealing with the same exact problems being terrified with my children in the car, not knowing if/when the next time the wheels lock up for no reason, if it will be fatal for me and my children or other drivers. I've contacted GM about it, taken it to Chevy dealership a few times, even a couple of auto shops, and no one seems to know what the problem is. I recently had the transmission serviced to see if that was the issue and turns out, it wasn't. I don't know what to do, I am still financing it and the warranty only covers the transmission and engine, half the cost of the repair and the other half is my responsibility it states. I've been trying to prevent any fatal accidents best I can, sometimes by not driving it at all and having to ride with family members and friends. I was recently told by my warranty company that there is pretty much nothing they can do about it.
NHTSA ODI #11440011
10,700 miles · Mar 1, 2021
EngineService BrakesVehicle Speed Control
I WAS DRIVING ON ST [XXX] AND IT WAS RAINING I ALMOST HYDROPLANE AND MY TRACTION LIGHT CAME ON AND MY CAR STARTED ACCELERATING ON IT'S OWN I HAD TO PASS TWO CARS SO I WOULDN'T HIT THEM AND LUCKILY NO ONE WAS COMING TOWARDS ME MY CAR KEPT ACCELERATING FASTER UP TO 100 MPH I SLAMMED ON MY BRAKES BUT MY CAR WOULDN'T SLOW DOWN IT …
Read full complaint
I WAS DRIVING ON ST [XXX] AND IT WAS RAINING I ALMOST HYDROPLANE AND MY TRACTION LIGHT CAME ON AND MY CAR STARTED ACCELERATING ON IT'S OWN I HAD TO PASS TWO CARS SO I WOULDN'T HIT THEM AND LUCKILY NO ONE WAS COMING TOWARDS ME MY CAR KEPT ACCELERATING FASTER UP TO 100 MPH I SLAMMED ON MY BRAKES BUT MY CAR WOULDN'T SLOW DOWN IT TOOK 5MINS TO SLOW.DOWN TO 20 MPH I HAD SMOKE ALL AROUND ME MY CAR WAS REVVING UP THE RPMS AND MY TEMPERATURE GAUGE WAS HOTI SEEN A ROAD [XXX] AND I TURNED AND I PUT MY VEHICLE IN PARK AND TRIED TO SHUT IT OFF AND IT WOULDN'T SO I THREW IT BACK INTO DRIVE AND THEN PARK AND SHUT MY IGNITION OFF AND TRIED TO RESTART THE ENGINE AND IT WOULDN'T START AFTER 10 MINS OF IT OFF I TRIED THE IGNITION AND IT STARTED BUT MY BRAKES HAD A AIR SOUND WHEN I PUSHED ON BRAKE PADS AND MY BF DROVE MY CAR BACK HOME THIS CAR IS DANGEROUS I LOOKED ONLINE AND SEEN IT HAPPENED TO OTHER VEHICLES AND I'M SCARED TO DRIVE MY CAR NOW I'M LUCKY I DIDNT DIE OR KILL SOMEONE ELSE PLEASE ASSIST ME BC I DONT KNOW WHAT TO DO THE VEHICLE IT'S NOT SAFE FOR ME TO DRIVE SINCE THAT HAPPENED PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA ODI #11398461
103,666 miles · Jul 2, 2020
Electronic Stability Control (esc)Service Brakes
AFTER DRIVING ABOUT 500YARDS , SPEED NOT A FACTOR, MY ABS LIGHT AND TRACTION CONTROL LIGHT COME ON WHEN I PUT CODE READER IN OBD PORT IT SHOWS NO CODES. SHUT THE VEHICLE OFF FOR FEW MOMENTS. START IT BACK UP AND THE LIGHTS ARE STILL ON UNTIL I DRIVE IT ABOUT 25 YARDS AND THE LIGHTS GO OUT. THE ABS WORKS, I CAN FEEL IT IN THE PED…
Read full complaint
AFTER DRIVING ABOUT 500YARDS , SPEED NOT A FACTOR, MY ABS LIGHT AND TRACTION CONTROL LIGHT COME ON WHEN I PUT CODE READER IN OBD PORT IT SHOWS NO CODES. SHUT THE VEHICLE OFF FOR FEW MOMENTS. START IT BACK UP AND THE LIGHTS ARE STILL ON UNTIL I DRIVE IT ABOUT 25 YARDS AND THE LIGHTS GO OUT. THE ABS WORKS, I CAN FEEL IT IN THE PEDDLE WHEN APPLIED ABRUPTLY. I CAN ALSO HEAR A SLIGHT GROWLING FROM UNDER THE HOOD. I CONTINUE ON FOR ABOUT ANOTHER 500 YARDS AND BOTH LIGHTS COME BACK ON. I REPLACED BOTH WHEEL HUB ASSY IN THE FRONT, WHICH BOTH LOOKED GOOD . *TR
NHTSA ODI #11337275
Mileage unknown · Nov 11, 2019
Power TrainService BrakesSuspension
THE BRAKES HAVE NEVER BEEN FIXED EVEN THOUGH THEY SAID (THERE TIMES) THAT THEY HAVE BEEN REPLACED. THERE IS A LEAK IN THE SUSPENSION, STRUTS, CV/U JOINTS, OIL LEAKS, AND POSSIBLY THE COOLANT. THE ALIGNMENT IS OFF EVEN THOUGH THE DEALERSHIP STATED THEY FIX THE ALIGNMENT, BUT THEY CAN'T IF THERE'S A LEAK THEY WOULDN'T BE ABLE TO P…
Read full complaint
THE BRAKES HAVE NEVER BEEN FIXED EVEN THOUGH THEY SAID (THERE TIMES) THAT THEY HAVE BEEN REPLACED. THERE IS A LEAK IN THE SUSPENSION, STRUTS, CV/U JOINTS, OIL LEAKS, AND POSSIBLY THE COOLANT. THE ALIGNMENT IS OFF EVEN THOUGH THE DEALERSHIP STATED THEY FIX THE ALIGNMENT, BUT THEY CAN'T IF THERE'S A LEAK THEY WOULDN'T BE ABLE TO PROPERLY FIX IT. THE CHECK ENGINE LIGHT HAS NEVER GONE OFF EVEN THOUGH THEY SAID THEY FIXED IT BUT SAID THEY COULD NOT REPLICATE THE ISSUE. EVEN THOUGH EVERYTHING WAS SUPPOSED TO BE COVERED UNDER WARRANTY THEY NO LONGER RETURN OUR CALLS EVEN WHEN WE GO DOWN THERE, THEY'RE NOT AVAILABLE TO TALK TO US ABOUT THE WARRANTY. IT WAS NEVER DISCLOSED TO US THAT THIS WAS A PREVIOUS RENTAL VEHICLE. NOW THE BRAKES MAKE SOUNDS WHILE WE DRIVE AND WHILE PRESSING DOWN THE WHOLE VEHICLE SHAKES.
NHTSA ODI #11279402
125,000 miles · Aug 14, 2019
Service BrakesUnknown Or OtherWheels
TAKATA RECALL DRIVING DOWN THE ROAD AND TRACTION CONTROL OFF, STABILITRAK SERVICE, AND ABS LIGHT CAME ON. ENGINE LIGHT ALSO. SICK IN TIRED OF THROWING MONEY INTO THIS TRAVERSE. I LOVE THE SUV BUT I CAN'T AFFORD ALL OF THIS MECHANICAL ISSUES.
NHTSA ODI #11243933
124,000 miles · Jul 10, 2019
Electronic Stability Control (esc)Service BrakesVehicle Speed Control
I JUST PURCHASED THIS VEHICLE 2 WEEKS AGO FROM TAYLOR CHEVROLET. IT HAS ALREADY BEEN IN THE DEALERSHIP TWICE FOR SOME SENSOR ISSUES THAT THEY KNEW ABOUT WHEN IT WAS SOLD TO ME AND SAID THEY WERE GOING TO FIX WHEN "A PART CAME IN" THEY NEVER CALLED SO I HAD TO CONTACT THEM WHEN THE TRUCK STARTED HAVING ISSUES. THIS IS WHERE I HA…
Read full complaint
I JUST PURCHASED THIS VEHICLE 2 WEEKS AGO FROM TAYLOR CHEVROLET. IT HAS ALREADY BEEN IN THE DEALERSHIP TWICE FOR SOME SENSOR ISSUES THAT THEY KNEW ABOUT WHEN IT WAS SOLD TO ME AND SAID THEY WERE GOING TO FIX WHEN "A PART CAME IN" THEY NEVER CALLED SO I HAD TO CONTACT THEM WHEN THE TRUCK STARTED HAVING ISSUES. THIS IS WHERE I HAVE THE BIGGEST PROBLEM I ALMOST LOST MY LIFE TODAY WHEN A SEMI ALMOST HIT ME WHILE DRIVING BECAUSE THE STABILITRAK SYSTEM COMPLETELY WENT OUT WHICH APPARENTLY IS AN ISSUE ON THESE TRUCKS THAT IS NOT BEING ADDRESSED. THE CONTROL PANEL IS DISPLAYING SERVICE STABILITRAK AND ENGINE LOSING POWER. I LOST A DAY OF WORK SO FAR AND NEED MY VEHICLE TO MAINTAIN MY BILLS AND KEEP MY JOB. THIS ALL HAPPENED ONE DAY AFTER GETTING MY TRUCK BACK FROM BEING SERVICED
NHTSA ODI #11230856
180,000 miles · Jun 27, 2019
Electrical SystemService BrakesSuspension
WHILE MOVING THE VEHICLE JERKS AS IF SOMETHING IS GOING ON WITH TRANSMISSION. IT HAS BEEN CHECKED AND ALL IS OK. CHECK ENGINE GIVES CODES AND THEN THEY DISAPPEAR. THE LIGHTS FLICKER INSIDE AND OUT. THESE SYMPTOMS COME AND GO. SEVERAL MECHANICS HAVE CHECKED OUT THIS VEHICLE AND CANT FIND ANYTHING WRONG WITH VEHICLE. ALSO T…
Read full complaint
WHILE MOVING THE VEHICLE JERKS AS IF SOMETHING IS GOING ON WITH TRANSMISSION. IT HAS BEEN CHECKED AND ALL IS OK. CHECK ENGINE GIVES CODES AND THEN THEY DISAPPEAR. THE LIGHTS FLICKER INSIDE AND OUT. THESE SYMPTOMS COME AND GO. SEVERAL MECHANICS HAVE CHECKED OUT THIS VEHICLE AND CANT FIND ANYTHING WRONG WITH VEHICLE. ALSO TOOK VEHICLE BACK TO CHEVROLET. ALSO THE VEHICLE IS BEING ILLEGALLY MONITORED AND TRACKED. THIS COULD BE CAUSING ALL ISSUES WITH VEHICLE.
NHTSA ODI #11222945
70,000 miles · Mar 21, 2019
Electronic Stability Control (esc)EngineService Brakes
STABILITRAK/ TRACTION CONTROL TURNS OFF SUDDENLY WHILE DRIVING WITHOUT REASON. ABS BRAKES LIGHT COMES ON IN MESSAGE CENTER. VEHICLE SUDDENLY LOSES POWER AND ENGINE IDLES ROUGH. OCCURS SUDDENLY WITHOUT WARNING LEAVING DRIVER/PASSENGERS STRANDED IN DANGEROUS ROADWAYS. VEHICLE ONLY HAS 70,000 MILES AND IS SERVICED REGULARLY. VEHICL…
Read full complaint
STABILITRAK/ TRACTION CONTROL TURNS OFF SUDDENLY WHILE DRIVING WITHOUT REASON. ABS BRAKES LIGHT COMES ON IN MESSAGE CENTER. VEHICLE SUDDENLY LOSES POWER AND ENGINE IDLES ROUGH. OCCURS SUDDENLY WITHOUT WARNING LEAVING DRIVER/PASSENGERS STRANDED IN DANGEROUS ROADWAYS. VEHICLE ONLY HAS 70,000 MILES AND IS SERVICED REGULARLY. VEHICLE WAS SERVICED TWO MONTHS AGO FOR THIS PROBLEM, WHERE AN ALIGNMENT TEMPORARILY FIXED THE PROBLEM. TWO MONTHS LATER, PROBLEM RETURNED.
NHTSA ODI #11190451
85,154 miles · Dec 16, 2018
Electronic Stability Control (esc)Service Brakes
WHILE DRIVING , STOPPED AT LIGHT. STARTED TO DRIVE AND ABS TROUBLE LIGHT COMES ON AND THE BRAKES LOCK UP. I HAD TO DRIVE AS IF ALL MY BRAKES WHERE ON , THEY HEAT UP AND SMOKE. PARKED IN MY DRIVEWAY HUSBAND GO OUT TO CHECK AND TROUBLE IS GONE. ACK TO NORMAL . NO TROUBLE LOCKED IN AS IF NOTHING HAPPENED . DEALER SAID CAN'T DO ANYT…
Read full complaint
WHILE DRIVING , STOPPED AT LIGHT. STARTED TO DRIVE AND ABS TROUBLE LIGHT COMES ON AND THE BRAKES LOCK UP. I HAD TO DRIVE AS IF ALL MY BRAKES WHERE ON , THEY HEAT UP AND SMOKE. PARKED IN MY DRIVEWAY HUSBAND GO OUT TO CHECK AND TROUBLE IS GONE. ACK TO NORMAL . NO TROUBLE LOCKED IN AS IF NOTHING HAPPENED . DEALER SAID CAN'T DO ANYTHING UNLESS IT IS BROUGHT IN WITH TROUBLE. IT'S HAS BEEN HAPPENING ABOUT ONCE A MONTH . ALMOST GOT IN ACCIDENT . CHEVY. REDS TO ADDRESS AND FIX THIS PROBLEM. THERE ARE A LOT OF OTHER PEOPLE ON THE INTERNET STATING THE SAME PROBLEM. GOING TO GET RID OF CAR IF THE PROBLEM CAN NOT BE FIX BEFORE I GET IN AN ACCIDENT WITH MY KIDS. CHEVY SHOULD INVESTIGATE THE PROBLEM AND CREATE A RECALL TO CORRECT THE PROBLEM BEFORE SOMEONE ENDS UP GETTING KILLED FROM IT . IT IS A HUGE SAFETY ISSUE AND DO NOT UNDERSTAND WHY NOTHING IS BEING DONE ABOUT THE PROBLEM.
NHTSA ODI #11161844
136,184 miles · Nov 14, 2018
Service Brakes
TL* THE CONTACT OWNS A 2012 CHEVROLET TRAVERSE. WHILE DRIVING 20 MPH, THE CONTACT WAS UNABLE TO BRING THE VEHICLE TO A COMPLETE STOP WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT ALSO HEARD AN ABNORMAL NOISE COMING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO VALLEY AUTO CENTER (43555 SIERRA HWY, LANCASTER, CA 93534, (661) 951-1…
Read full complaint
TL* THE CONTACT OWNS A 2012 CHEVROLET TRAVERSE. WHILE DRIVING 20 MPH, THE CONTACT WAS UNABLE TO BRING THE VEHICLE TO A COMPLETE STOP WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT ALSO HEARD AN ABNORMAL NOISE COMING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO VALLEY AUTO CENTER (43555 SIERRA HWY, LANCASTER, CA 93534, (661) 951-1100) WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE DID NOT HAVE A WARRANTY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 136,184.
NHTSA ODI #11151573
Official recalls
5Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2010-2015, 2017 Buick Enclave, 2010-2019 Chevrolet Traverse, and 2011-2016 GMC Acadia vehicles. The side curtain air bags may not be properly attached.
Consequence & remedy
Consequence: Unsecured side curtain air bags may not perform as intended, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and, if necessary, realign or replace the weld nuts, free of charge. Owner notification letters were mailed on May 24, 2021. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N202321200.
Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
Apr 9, 2012
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011-2012 CHEVROLET TRAVERSE, BUICK ENCLAVE, AND GMC ACADIA VEHICLES CURRENTLY REGISTERED IN ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, WYOMING AND THE DISTRICT OF COLUMBIA. SNOW OR ICE BUILDUP ON THE WINDSHIELD OR ON THE WIPER MAY RESTRICT THE MOVEMENT OF THE WIPER ARM, CAUSING THE WIPER ARM TO LOOSEN AND CAUSE THE WIPER TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IF THIS OCCURS, DRIVER VISIBILITY COULD BE REDUCED, INCREASING THE RISK OF A CRASH.
Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL TIGHTEN THE WIPER ARM NUTS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 20, 2012.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Illustration