IllustrationTHE VEHICLE AT 125,000 THE CHECK ENGINE LIGHT TURNED ON AND THERE IS A PROBLEM WITH THE TIMING CHAIN STRETCHING. IT IS THE CRANK SHAFT/CAM SHAFT. IT IS OVER A $2,000.00 REPAIR AND THE MECHANIC SAID THIS IS A COMMON PROBLEM WITH CHEVY TRAVERSE'S.
2012 Chevrolet Traverse
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2012 Chevrolet Traverse do not stand out strongly from the model-year median of 302.
About this comparison →How this year compares
Owner complaints by model year
Compare all Traverse years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
260–25K
3125–50K
5650–75K
6975–100K
82100–150K
21150K+
285 reports with mileage · 69 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 115 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electronic Stability Control (esc). Review the 84 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 62 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
10 crash reports2 fire reports10 injury reports
Power Train complaints
46 reportsMY VEHICLE HAS 99,000 MILES ON IT AND IS OUTSIDE OF THE 5 YEAR WARRANTY PERIOD. MY TIMING CHAIN AND ACTUATORS ARE BEING REPLACED. I HAVE READ THAT THIS IS AN ON GOING ISSUE WITH MY SPECIFIC MOTOR. I HAVE ALWAYS HAD THE OIL CHANGED AT THE DEALERSHIP IN THE TIME AND MILEAGE THAT IS RECOMMENDED. THE TIMING CHAIN PROBLEM CAUSED MY V…
Read full complaint
MY VEHICLE HAS 99,000 MILES ON IT AND IS OUTSIDE OF THE 5 YEAR WARRANTY PERIOD. MY TIMING CHAIN AND ACTUATORS ARE BEING REPLACED. I HAVE READ THAT THIS IS AN ON GOING ISSUE WITH MY SPECIFIC MOTOR. I HAVE ALWAYS HAD THE OIL CHANGED AT THE DEALERSHIP IN THE TIME AND MILEAGE THAT IS RECOMMENDED. THE TIMING CHAIN PROBLEM CAUSED MY VEHICLE TO NOT DRIVE CORRECTLY AND BOG DOWN AND NOT GET POWER WHEN APPLYING THE GAS. WHEN DRIVING HOME ON THE HIGHWAY I APPLIED THE GAS AND THE TRAVERSE SPUTTERED AND WOULD NOT GET UP TO SPEED TO KEEP UP WITH TRAFFIC.
TL* THE CONTACT OWNS A 2012 CHEVROLET TRAVERSE. THE CONTACT STATED THE WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE STALL LASTED FOR A FEW SECONDS BEFORE THE VEHICLE RESUMED NORMAL OPERATION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE CONTACT WAS INFORMED THAT THE STALL WAS DUE TO AN EL…
Read full complaint
TL* THE CONTACT OWNS A 2012 CHEVROLET TRAVERSE. THE CONTACT STATED THE WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE STALL LASTED FOR A FEW SECONDS BEFORE THE VEHICLE RESUMED NORMAL OPERATION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE CONTACT WAS INFORMED THAT THE STALL WAS DUE TO AN ELECTRICAL ISSUE. THE CONTACT THEN TOOK THE VEHICLE TO ANOTHER INDEPENDENT MECHANIC WHO INFORMED HIM THAT HIS VEHICLE HAD A DEFECTIVE BATTERY. THE CONTACT REPLACED THE BATTERY HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT HAD NOT NOTIFIED A DEALER NOR THE MANUFACTURER OF THE FAILURE. THE FAILURE MILEAGE WAS 139,000.
THE TIMING CHAIN NEEDS TO BE REPLACED AND IS A KNOWN PROBLEM WITH CHEVROLET EVEN THOUGH THEY HAVE NOT DONE A RECALL. EATS OIL, TICKS AND MY CHECK ENGINE LIGHT IS ON. MY MECHANIC LOOKED AT IT AND SAID IT WAS THE TIMING CHAIN. I DON'T HAVE 3K TO FIX MY CAR.
WAS BRINGING MY CHILDREN HOME FROM SCHOOL AND ENGINE LIGHT AND TRACTION CONTROL LIGHT CAME ON, REDUCED MY SPEED AND I COULDN'T KEEP UP WITH TRAFFIC SO QUICKLY GOT OFF THE ROAD. LOOKED AT THE DASH AND SAW IT SAID ENGINE POWER REDUCED. TURNED OFF THE CAR FEW SECONDS AND I WAS ABLE TO DRIVE HOME LUCKILY I WASN'T TO FAR.
WHINING AND WINDING SOUND ON ACCELERATION AT ALL SPEEDS..RUMBLING NOISE FROM ENGINE. STRUT LEAKING AND FRONT SUSPENSION ISSUES. THIS TURNED OUT TO BE TRANSMISSION AND TORQUE CONVERTER. ALONG WITH PTO PINION SEAL, CRANKSHAFT SEAL, WATER PUMP, HARMONIC BALANCER, STRUTS, SWAY BAR LINKS, AND DRIVE BELT.
THE BRAKES HAVE NEVER BEEN FIXED EVEN THOUGH THEY SAID (THERE TIMES) THAT THEY HAVE BEEN REPLACED. THERE IS A LEAK IN THE SUSPENSION, STRUTS, CV/U JOINTS, OIL LEAKS, AND POSSIBLY THE COOLANT. THE ALIGNMENT IS OFF EVEN THOUGH THE DEALERSHIP STATED THEY FIX THE ALIGNMENT, BUT THEY CAN'T IF THERE'S A LEAK THEY WOULDN'T BE ABLE TO P…
Read full complaint
THE BRAKES HAVE NEVER BEEN FIXED EVEN THOUGH THEY SAID (THERE TIMES) THAT THEY HAVE BEEN REPLACED. THERE IS A LEAK IN THE SUSPENSION, STRUTS, CV/U JOINTS, OIL LEAKS, AND POSSIBLY THE COOLANT. THE ALIGNMENT IS OFF EVEN THOUGH THE DEALERSHIP STATED THEY FIX THE ALIGNMENT, BUT THEY CAN'T IF THERE'S A LEAK THEY WOULDN'T BE ABLE TO PROPERLY FIX IT. THE CHECK ENGINE LIGHT HAS NEVER GONE OFF EVEN THOUGH THEY SAID THEY FIXED IT BUT SAID THEY COULD NOT REPLICATE THE ISSUE. EVEN THOUGH EVERYTHING WAS SUPPOSED TO BE COVERED UNDER WARRANTY THEY NO LONGER RETURN OUR CALLS EVEN WHEN WE GO DOWN THERE, THEY'RE NOT AVAILABLE TO TALK TO US ABOUT THE WARRANTY. IT WAS NEVER DISCLOSED TO US THAT THIS WAS A PREVIOUS RENTAL VEHICLE. NOW THE BRAKES MAKE SOUNDS WHILE WE DRIVE AND WHILE PRESSING DOWN THE WHOLE VEHICLE SHAKES.
FOR NO REASON THE SERVICE STABILTRAK LIGHT COMES ON. THE GAGES START GOING ON THEIR OWN. THE VEHICLE GOES INTO LIMP MODE WHILE DRIVING. IT HAS HAPPENED ON HIGHWAYS, CITY ROADS. I HAVE TAKEN IT TO A DEALERSHIP "WHO SAID I CANT MAKE IT RECIPROCATE SO I JUST REPROGRAMMED THE TCM, AND IF THAT DOESNT WORK I WILL RECOMMEND ANEW TCM." …
Read full complaint
FOR NO REASON THE SERVICE STABILTRAK LIGHT COMES ON. THE GAGES START GOING ON THEIR OWN. THE VEHICLE GOES INTO LIMP MODE WHILE DRIVING. IT HAS HAPPENED ON HIGHWAYS, CITY ROADS. I HAVE TAKEN IT TO A DEALERSHIP "WHO SAID I CANT MAKE IT RECIPROCATE SO I JUST REPROGRAMMED THE TCM, AND IF THAT DOESNT WORK I WILL RECOMMEND ANEW TCM." IN SHORT THEY HAVE NO IDEA. I HAVE TAKEN IT TO AN INDEPENDENT MECHANIC WHO WAS ABLE TO TROUBLE SHOOT IT BACK TO THE FUEL CONTROL SYSTEM MODULE VS COMM MODULE. HOWEVER. I THINK THERE IS MORE TO IT THAN THAT. CHEVY NEEDS TO FIX THIS ISSUE IT'S A VERY COMMON ISSUE ON TRAVERSE FORUMS. NHSTA PLEASE DO SOMETHING ABOUT THIS ISSUE SOMEONE IS GOING TO DIE.
THE ENGINE STARTED RUNNING LIKE A OLD, OLD TRACTOR. I WAS TOLD THE MOTOR KEEPS LOSING OIL PRESSURE KNOWN THAT TYPE ENGINE HAS PROBLEMS BUT YET NO RECALL. I SPENT THOUSANDS OF DOLLARS TO PAY FOR A NEW MOTOR AND INSTALLATION ON THIS. JUST GOT THAT FIXED AND NOW THE TRANSMISSION WENT ANOTHER EXPENSE ON MY PART. WHAT NEXT!! THIS CA…
Read full complaint
THE ENGINE STARTED RUNNING LIKE A OLD, OLD TRACTOR. I WAS TOLD THE MOTOR KEEPS LOSING OIL PRESSURE KNOWN THAT TYPE ENGINE HAS PROBLEMS BUT YET NO RECALL. I SPENT THOUSANDS OF DOLLARS TO PAY FOR A NEW MOTOR AND INSTALLATION ON THIS. JUST GOT THAT FIXED AND NOW THE TRANSMISSION WENT ANOTHER EXPENSE ON MY PART. WHAT NEXT!! THIS CAR IS A LEMON LAW PROBLEM!! WHAT CAN I DO ABOUT IT? PLEASE HELP!! WHERES THE RECALLS?? THIS 2012 TRAVERSE IS SCARY TO DRIVE NOT KNOWN WHATS NEXT GOING TO HAPPEN ON THE ROAD. CANT GO ANYWHERE THAT INVOLVES DISTANCE.. I WAS STALLED IN THE INTERSECTIONS IN TOWN ON A BUSY STREET WITH LITTLE CHILDREN AND AN ELDERLY LADY.
WITHOUT ANY WARNING GOT THE FOLLOWING MESSAGES: TRACTION CONTROL OFF, SERVICE STABILITY TRAK,SERVICE TRACTION CONTROL, ENGINE POWER IS REDUCED. THEN THE CHECK ENGINE LIGHT WENT ON AND I WAS TOLD IT WAS THE CAMSHAFT CORRELATION. I'VE LOOKED ON LINE AND HAVE NOTICED MANY TRAVERSE OWNERS ARE HAVING THIS PROBLEM WHERE THE CAR SLOWS…
Read full complaint
WITHOUT ANY WARNING GOT THE FOLLOWING MESSAGES: TRACTION CONTROL OFF, SERVICE STABILITY TRAK,SERVICE TRACTION CONTROL, ENGINE POWER IS REDUCED. THEN THE CHECK ENGINE LIGHT WENT ON AND I WAS TOLD IT WAS THE CAMSHAFT CORRELATION. I'VE LOOKED ON LINE AND HAVE NOTICED MANY TRAVERSE OWNERS ARE HAVING THIS PROBLEM WHERE THE CAR SLOWS DOWN TO A HALT IN THE MIDDLE OF THE ROAD OR REFUSES TO GO FASTER THAN 25 MILES PER HOUR. WE PURCHASED THIS VEHICLE AS A CERTIFIED PRE-OWNED 4 YEARS AGO AND IT DOES'NT EVEN HAVE 100,000 MILES ON IT. I WAS ON THE ROAD WHEN THE MESSAGES CAME ON AND I HAD TO QUICKLY PULL IN TO A GAS STATION BECAUSE I WAS DRIVING ON A 55 MILE AN HOUR ROAD AND THE CAR QUICKLY SLOWED DOWN TO AROUND 25MPH.
Official recalls
521V246000 · Air Bags:critical Fasteners
Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2010-2015, 2017 Buick Enclave, 2010-2019 Chevrolet Traverse, and 2011-2016 GMC Acadia vehicles. The side curtain air bags may not be properly attached.
Consequence & remedy
Consequence: Unsecured side curtain air bags may not perform as intended, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and, if necessary, realign or replace the weld nuts, free of charge. Owner notification letters were mailed on May 24, 2021. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N202321200.
15V415000 · Structure:body:hatchback/liftgate
Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
14V266000 · Seat Belts
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
14V118000 · Air Bags:side/window
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
12V151000 · Visibility:windshield Wiper/washer:linkages
Apr 9, 2012
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011-2012 CHEVROLET TRAVERSE, BUICK ENCLAVE, AND GMC ACADIA VEHICLES CURRENTLY REGISTERED IN ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, WYOMING AND THE DISTRICT OF COLUMBIA. SNOW OR ICE BUILDUP ON THE WINDSHIELD OR ON THE WIPER MAY RESTRICT THE MOVEMENT OF THE WIPER ARM, CAUSING THE WIPER ARM TO LOOSEN AND CAUSE THE WIPER TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IF THIS OCCURS, DRIVER VISIBILITY COULD BE REDUCED, INCREASING THE RISK OF A CRASH.
Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL TIGHTEN THE WIPER ARM NUTS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 20, 2012.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648