IllustrationPOWER STEERING STIFFENS WHEN PARKING OR GOING AROUND CURBS AT LOW SPEEDS. ALMOST HIT VEHICLES IN A PARKING GARAGE CAUSED BY THIS ISSUE. THIS ISSUE HAS BEEN OCCURRING SINCE THE TRAVERSE HAD 52K MILES.
2010 Chevrolet Traverse
Owner reports · Recalls · Investigations
More warning signs than most Traverse years
Owner complaints for the 2010 Chevrolet Traverse are substantially higher than the model-year median of 302.
About this comparison →How this year compares
Owner complaints by model year
Compare all Traverse years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
390–25K
6925–50K
17250–75K
15575–100K
111100–150K
30150K+
576 reports with mileage · 93 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 331 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 178 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 66 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
17 crash reports6 fire reports11 injury reports
What owners actually said
669 reports2010 CHEVY TRAVERSE. CHECK ENGINE LIGHT CODE P0017. DEALER IS STATING IT IS A TIMING CHAIN, COST AROUND $2700. TRAVERSE ONLY HAS 101,000 MILES ON IT. MY CHEVY TRAVERSE SHOULD NOT BE NEEDING A TIMING CHAIN REPLACED AT SUCH LOW MILEAGE. GM IS NOT BEING COOPERATIVE WITH ALL THE COMPLAINTS OF THIS PROBLEM ONLINE. THERE ARE SPE…
Read full complaint
2010 CHEVY TRAVERSE. CHECK ENGINE LIGHT CODE P0017. DEALER IS STATING IT IS A TIMING CHAIN, COST AROUND $2700. TRAVERSE ONLY HAS 101,000 MILES ON IT. MY CHEVY TRAVERSE SHOULD NOT BE NEEDING A TIMING CHAIN REPLACED AT SUCH LOW MILEAGE. GM IS NOT BEING COOPERATIVE WITH ALL THE COMPLAINTS OF THIS PROBLEM ONLINE. THERE ARE SPECIFIC AREAS IN THE COUNTRY WHERE GM IS PAYING FOR THIS REPAIR BUT IT IS VIN SPECIFIC. GM IS STATING THAT IF MANUFACTURED IN CERTAIN PLANTS, TIMING CHAIN IS A PROBLEM, EVEN THOUGH IT IS THE SAME ENGINE! I HAVE HAD MORE RECALLS ON THIS VEHICLE THAN ANY OTHER VEHICLE I HAVE OWNED. I ONCE LOVED THIS VEHICLE AND THOUGHT GM WOULD TAKE CARE OF KNOWN PROBLEMS, NOW I KNOW THAT I AM WRONG. I WILL NOT BUY ANOTHER GM VEHICLE.
I BOUGHT THIS TRAVERSE USED WITH ONLY 7,000 MILES. AFTER ABOUT A YEAR, THE RADIO AND SCREEN WOULD NOT TURN OFF AFTER TURNING THE CAR OFF AND OPENING THE DOOR. IT WOULD REMAIN ON EVEN AFTER TURNING THE IGNITION ON AND OFF OR OPENING THE DRIVERS DOOR SEVERAL TIMES. THE FRONT PASSENGER WINDOW DOES NOT GO DOWN USING THE DRIVER SIDE …
Read full complaint
I BOUGHT THIS TRAVERSE USED WITH ONLY 7,000 MILES. AFTER ABOUT A YEAR, THE RADIO AND SCREEN WOULD NOT TURN OFF AFTER TURNING THE CAR OFF AND OPENING THE DOOR. IT WOULD REMAIN ON EVEN AFTER TURNING THE IGNITION ON AND OFF OR OPENING THE DRIVERS DOOR SEVERAL TIMES. THE FRONT PASSENGER WINDOW DOES NOT GO DOWN USING THE DRIVER SIDE CONTROLS, DESPITE MULTIPLE ATTEMPTS TO FIX IT. I HAVE LEARNED TO LIVE WITH THE ISSUES WHEN RECENTLY ADDITION PROBLEMS HAVE APPEARED. FOR SOME REASON IT FEELS LIKE I AM DRIVING WITH THE EMERGENCY BRAKE ENGAGED OR PULLING A HEAVY TRAILER. MOST OF THE TIME I HAVE TO PRESS HARDER ON THE GAS JUST TO MAKE THE VEHICLE GO. AS A RESULT, THE GAS MILEAGE HAS DROPPED SIGNIFICANTLY. ALSO, SUDDENLY THE AIR CONDITIONER FOR THE DRIVER BLOWS ONLY WARM AIR WHILE ALL THE OTHER VENTS BLOW COLD. THERE IS A CONSTANT CLICKING SOUND BEHIND THE DASH AND I AM ABOUT TO REPLACE A SECOND ACTUATOR. FINALLY, THERE IS A LOUD NOISE FROM THE ENGINE LIKE IT IS STILL RUNNING AFTER IT IS TURNED OFF AND THE KEY IS OUT OF THE IGNITION. I HAVE TO TURN THE IGNITION ON AND OFF AGAIN FOR IT TO STOP. EVEN THEN, THE ENGINE FAN REMAINS ON, WHICH IT NEVER DID BEFORE. ALL THESE STARTED JUST AS IT WAS ABOUT TO HIT 80,000 MILES.
AT SLOW SPEED ATTEMPTING TO TURN THE STEERING GET SO STIFF YOU NEED TWO HAND TO TURN THE STEERING WHEEL. MOST TIME NOTICE THE PROBLEM AT 5-10 MPH. TURNING BOTH RIGHT AND LEFT INTO A PARKING SPACE OR FROM A STOP TO TURN ONTO A STREET.
I HAVE HAD TO REPLACE MY DIM HEAD LIGHTS 3 TIMES IN A YEAR AND A HALF. FIRST THE PASSENGER SIDE GOES THEN WITHIN A FEW DAYS THE DRIVERS SIDE BLOWS. I ONLY NOTICE WHEN IT HAPPENS AT NIGHT SO NOT SURE EXACTLY WHEN THEY BURN OUT BUT ALWAYS ONE AND THEN THE OTHER LESS THAN A WEEK APART. I BUY PREMIUM BULBS SO I KNOW IT IS NOT AN ISS…
Read full complaint
I HAVE HAD TO REPLACE MY DIM HEAD LIGHTS 3 TIMES IN A YEAR AND A HALF. FIRST THE PASSENGER SIDE GOES THEN WITHIN A FEW DAYS THE DRIVERS SIDE BLOWS. I ONLY NOTICE WHEN IT HAPPENS AT NIGHT SO NOT SURE EXACTLY WHEN THEY BURN OUT BUT ALWAYS ONE AND THEN THE OTHER LESS THAN A WEEK APART. I BUY PREMIUM BULBS SO I KNOW IT IS NOT AN ISSUE WITH THE BULB MANUFACTURER..
CAR STEERING FAILURE AT STOPPED OR LOW SPEED (10 MPH) TURNS. NO ISSUE WITH TURN WHILE AT HIGH OR CRUISING SPEEDS. OCCURS ON BOTH LEFT AND RIGHT TURNS.
UNDER 35MPH, THE STEERING GETS VERY DIFFICULT, MAKING THE CAR VERY DIFFICULT TO CONTROL. IT HAPPENS FREQUENTLY, IN PARKING LOTS, EXITING AND ENTERING LOTS. AND YOU NEVER KNOW WHEN, UNTIL YOU ARE MID-TURN, CAUSING YOU TO USE EXTREME EFFORT TO MANEUVER. IT MADE ME VERY FEARFUL AND A BIT PANICKED THAT I WOULD NOT BE ABLE TO PREVENT…
Read full complaint
UNDER 35MPH, THE STEERING GETS VERY DIFFICULT, MAKING THE CAR VERY DIFFICULT TO CONTROL. IT HAPPENS FREQUENTLY, IN PARKING LOTS, EXITING AND ENTERING LOTS. AND YOU NEVER KNOW WHEN, UNTIL YOU ARE MID-TURN, CAUSING YOU TO USE EXTREME EFFORT TO MANEUVER. IT MADE ME VERY FEARFUL AND A BIT PANICKED THAT I WOULD NOT BE ABLE TO PREVENT AN ACCIDENT, IF ONE WERE PENDING. IT HAS BEEN INCREASINGLY DIFFICULT AND MORE FREQUENT SINCE THE DATE LISTED BELOW
TL* THE CONTACT'S MOTHER OWNS A 2010 CHEVROLET TRAVERSE. WHILE THE CONTACT'S MOTHER WAS DRIVING 40 MPH, THE STEERING WHEEL BECAME EXTREMELY LOOSE AND THE VEHICLE MADE A SQUEALING SOUND. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIM…
Read full complaint
TL* THE CONTACT'S MOTHER OWNS A 2010 CHEVROLET TRAVERSE. WHILE THE CONTACT'S MOTHER WAS DRIVING 40 MPH, THE STEERING WHEEL BECAME EXTREMELY LOOSE AND THE VEHICLE MADE A SQUEALING SOUND. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.
AFTER DRIVING THE VEHICLE AT LOW SPEEDS NOTICED WHINING NOISE AND HARD TO TURN. AFTER INSPECTION BY AUTO SHOP THEY STATED THE SUV HAD A LEAK IN THE POWER STEERING RACK AND IT NEEDED TO BE REPLACED. VEHICLE HAS LESS THEN 55,000 MILES WITH NO OTHER ISSUES.
CHECK ENGINE LIGHT CAME ON IN MY 2010 CHEVY TRAVERSE. THE DEALERSHIP INDICATED THE TIMING CHAIN HAD STRETCHED AND IF LEFT UNREPAIRED COULD LEAD TO CATASTROPHIC FAILURE OF THE ENGINE. THE REPAIR COST IS $3500. THE VEHICLE ONLY HAS 67000 MILES ON IT, AND HAS ALWAYS HAD ROUTINE MAINTENANCE AND OIL CHANGES CONDUCTED. FURTHER INV…
Read full complaint
CHECK ENGINE LIGHT CAME ON IN MY 2010 CHEVY TRAVERSE. THE DEALERSHIP INDICATED THE TIMING CHAIN HAD STRETCHED AND IF LEFT UNREPAIRED COULD LEAD TO CATASTROPHIC FAILURE OF THE ENGINE. THE REPAIR COST IS $3500. THE VEHICLE ONLY HAS 67000 MILES ON IT, AND HAS ALWAYS HAD ROUTINE MAINTENANCE AND OIL CHANGES CONDUCTED. FURTHER INVESTIGATION REVEALED THAT 2007-2009 MODELS OF THE SAME ENGINE ON SIMILAR MODELS HAD THE EXACT SAME ISSUE. ADDITIONALLY, A SIMPLE GOOGLE SEARCH REVEALS MANY FORUMS THAT HAVE COMPLAINTS OF THE SAME ISSUE ON THEIR 2010 MODELS. IT APPEARS THAT THE PROBLEM WAS NOT CORRECTED IN THE 2010 MODEL YEAR, OR AT LEAST NOT IN CERTAIN RUN OF THE ENGINE. WHETHER THE SAME BAD CHAIN WAS USED IN 2010 ENGINES OR THE PROBLEM THAT WAS DISCOVERED IN THE 2007-2009 MODEL YEARS, WAS NOT DISCOVERED UNTIL AFTER THE 2010 MODELS WERE BUILT, AND THEY WERE JUST NOT INCLUDED IN THE SERVICE BULLETIN IS THE QUESTION. BECAUSE A WELL MAINTAINED VEHICLE WITH ONLY 67000 MILES TO HAVE A BAD TIMING CHAIN IS RARE, AS MANY DIFFERENT REPAIR SHOPS HAVE CONFIRMED. THOSE SAME SHOPS ALSO CONFIRMED THEY HAVE SEEN MANY OF THE TRAVERSE. ACADIA, AND ENCLAVE MODELS WITH THE SAME TIMING CHAIN ISSUE.
Official recalls
521V246000 · Air Bags:critical Fasteners
Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2010-2015, 2017 Buick Enclave, 2010-2019 Chevrolet Traverse, and 2011-2016 GMC Acadia vehicles. The side curtain air bags may not be properly attached.
Consequence & remedy
Consequence: Unsecured side curtain air bags may not perform as intended, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and, if necessary, realign or replace the weld nuts, free of charge. Owner notification letters were mailed on May 24, 2021. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N202321200.
15V415000 · Structure:body:hatchback/liftgate
Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
14V266000 · Seat Belts
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
14V118000 · Air Bags:side/window
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
10V375000 · Seat Belts
Aug 12, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2009-2010 CHEVROLET TRAVERSE, BUICK ENCLAVE, GMC ACADIA, AND SATURN OUTLOOK VEHICLES. THE SECOND ROW SEAT SIDE TRIM SHIELD RESTRICTS THE UPWARD ROTATION OF THE SAFETY BELT BUCKLE WHEN THE SEAT BACK IS RETURNED TO A SEATING POSITION AFTER BEING FOLDED FLAT. IF THE BUCKLE CONTACTS THE SEAT FRAME, ADDITIONAL EFFORT IS REQUIRED TO RETURN THE SEAT TO A SEATING POSITION. IF SUFFICIENT FORCE IS APPLIED, THE BUCKLE COVER COULD BE PUSHED DOWN THE STRAP, EXPOSING AND PARTIALLY DEPRESSING THE RED RELEASE BUTTON.
Consequence & remedy
Consequence: THE SAFETY BELT MAY NOT RESTRAIN THE OCCUPANT AS INTENDED DURING A CRASH, INCREASING THE RISK OF INJURY TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL MODIFY THE SECOND ROW SEAT SIDE TRIM SHIELDS. IF A SAFETY BELT BUCKLE IS DAMAGED, DEALERS WILL REPLACE IT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, BUICK AT 1-866-608-8080, GMC AT 1-866-996-9463, AND SATURN AT 1-800-972-8876, OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648