IllustrationCHECK ENGINE LIGHT CAME ON AT APPROXIMATELY 56,000 MILES, DIAGNOSTIC CHECK WAS PERFORMED BY THE DEALER. FINDINGS: GAS VAPOR POURING FROM THE SEAL, CORROSION AND MOISTURE. NEED TO REPLACE THE GAS TANK. *TR
2003 Chevrolet Trailblazer Ext
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Trailblazer Ext years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
250–25K
4825–50K
7150–75K
5475–100K
41100–150K
22150K+
261 reports with mileage · 52 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 80 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 77 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 49 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports6 fire reports9 injury reports
What owners actually said
313 reportsI HAVE A 2003 CHEVROLET TRAILBLAZER EXT AND THE SPEEDOMETER GAUGE QUIT WORKING ON ME. I HAVE DONE SOME RESEARCH ON THIS AND FIND THAT MANY TRAILBLAZER OWNERS HAVE EXPERIENCED SIMILAR PROBLEMS. APPARENTLY, CHEVROLET HAD A RECALL PROGRAM FOR DASHBOARD GAUGE ISSUES WITH OTHER MODELS BUT DID NOT INCLUDE THE TRAILBLAZER AS A COVERE…
Read full complaint
I HAVE A 2003 CHEVROLET TRAILBLAZER EXT AND THE SPEEDOMETER GAUGE QUIT WORKING ON ME. I HAVE DONE SOME RESEARCH ON THIS AND FIND THAT MANY TRAILBLAZER OWNERS HAVE EXPERIENCED SIMILAR PROBLEMS. APPARENTLY, CHEVROLET HAD A RECALL PROGRAM FOR DASHBOARD GAUGE ISSUES WITH OTHER MODELS BUT DID NOT INCLUDE THE TRAILBLAZER AS A COVERED MODELED UNDER THIS RECALL. OTHER TRAILBLAZER OWNERS WHO HAVE POSTED COMPLAINTS OR PROBLEMS ONLINE HAVE ADVISED FILING A COMPLAINT THROUGH THE NHTSA TO SEE IF ENOUGH COMPLAINTS CAN BE LODGED AGAINST CHEVROLET TO FORCE A RECALL. IT OBVIOUSLY IS A VERY DANGEROUS SITUATION TO HAVE A DEFECTIVE SPEEDOMETER. SOMETIMES MINE WORKS FINE, OTHER TIMES IT REGISTERS THE WRONG SPEED, AND STILL OTHER TIMES IT DOESN'T REGISTER A SPEED AT ALL. IF THIS IS A COMMON OCCURRENCE AMONG TRAILBLAZER OWNERS, THEN I WOULD THINK THAT CHEVROLET SHOULD COVER IT UNDER THEIR RECALL PROGRAM ALONG WITH THE OTHER MODELS OF CHEVROLET TRUCKS & CARS THAT HAVE EXPERIENCED SIMILAR PROBLEMS. THANK YOU. *TR
TRANSMISSION COOLING LINE CORROSION AND LEAK. *TR
2003 TRAILBLAZER TRANSMISSION LINES. COOLANT LINES RUSTED AT THE FACTORY CONNECTION. MAJOR FLUID LOSS, HAD TO REPAIR IMMEDIATELY. *TR
DESIGN FLAW OF THE CENTER HIGH MOUNTED STOP LAMP APPLIQUE (AKA - REAR UPPER LIFTGATE MOLDING) DURING THE WINTER MONTHS, ICE AND SNOW BUILDS UP BEHIND THE MOLDING, AND WHEN THE USER ATTEMPTS TO OPEN THE LIFTGATE, THE MOLDING IS SEPARATED FROM THE VEHICLE, SOMETIMES RESULTS IN PERMANENT BREAKAGE OF THE MOLDING, OR EVEN SHATTERING…
Read full complaint
DESIGN FLAW OF THE CENTER HIGH MOUNTED STOP LAMP APPLIQUE (AKA - REAR UPPER LIFTGATE MOLDING) DURING THE WINTER MONTHS, ICE AND SNOW BUILDS UP BEHIND THE MOLDING, AND WHEN THE USER ATTEMPTS TO OPEN THE LIFTGATE, THE MOLDING IS SEPARATED FROM THE VEHICLE, SOMETIMES RESULTS IN PERMANENT BREAKAGE OF THE MOLDING, OR EVEN SHATTERING OF THE REAR WINDOW. THIS IS A PROBLEM THAT THE COMPANY IS ALREADY AWARE OF, AS EVIDENCED BY A RELEASED TSB. AS EVIDENCED BY NUMEROUS REPORTS ON "TRAILVOY.COM", MANY GROUP MEMBERS HAVE REPORTED HAVING THIS EXACT PROBLEM. I HAVE READ REPORTS OF THIS PIECE MYSTERIOUSLY COMING OFF, TO THE SURPRISE OF THE DRIVER, WHILE DRIVING ON THE ROAD. IT SEEMS THAT WHEN THIS VEHICLE WAS DESIGNED, TOO MUCH OF THE LIFTGATE'S STRUCTURE WAS LEFT TO RELY ON THE STABILITY OF PLASTIC AND GLASS. FOR INSTANCE, ON MY VEHICLE, AFTER BREAKAGE OF THE MOLDING, THE FORCE EXERTED BY THE GLASS LIFT ARMS CAUSED THE ADHESIVE TO SEPARATE FROM THE WINDOWS HINGE, LEAVING IT "DANGLING BY A THREAD". I FEEL THAT THIS A PROBLEM THAT HAS OCCURRED IN TOO MANY CASES; A PROBLEM THAT COULD POTENTIALLY CAUSE SAFETY ISSUES WHILE DRIVING ON THE ROAD. IT IS AN EXPENSIVE PART TO REPLACE ($700-$1000, WITH LABOR). CHEVROLET HAS SINCE REDESIGNED THE TRAILBLAZER VEHICLES TO TAKE CARE OF THIS PROBLEM. I FEEL THAT CHEVROLET SHOULD BE HELD RESPONSIBLE TO CORRECT THEIR DESIGN ERROR ON THE OLDER VEHICLES, INSTEAD OF LEAVING IT UP TO THE CONSUMER TO PAY FOR IT OUT OF THEIR OWN POCKET.*TR
BEGINNING 2 WEEKS AGO THE SPEEDOMETER ON MY 2003 CHEVY TRAILBLAZER HAS NOT BEEN WORKING PROPERLY. THE NEEDLE WILL GO PAST 120 MPH AND WHEN YOUR STOPPED IT WILL BE AT 30-40 MPH. THIS IS EXTREMELY DANGEROUS SINCE MY SON HAS HIS LEARNERS PERMIT AND WAS DRIVING THE FIRST TIME THE SPEEDOMETER MALFUNCTIONED. WE WERE ON THE HIGHWAY.…
Read full complaint
BEGINNING 2 WEEKS AGO THE SPEEDOMETER ON MY 2003 CHEVY TRAILBLAZER HAS NOT BEEN WORKING PROPERLY. THE NEEDLE WILL GO PAST 120 MPH AND WHEN YOUR STOPPED IT WILL BE AT 30-40 MPH. THIS IS EXTREMELY DANGEROUS SINCE MY SON HAS HIS LEARNERS PERMIT AND WAS DRIVING THE FIRST TIME THE SPEEDOMETER MALFUNCTIONED. WE WERE ON THE HIGHWAY. I LOOKED ON-LINE AND FOUND SEVERAL PEOPLE WITH THE SAME PROBLEM. ONE SUGGESTED DISCONNECTING THE BATTERY FOR 5 MINUTES. I DID THIS AND IT WORKED FOR 1 WEEK. I DISCONNECTED IT 2 MORE TIMES SO FAR. TODAY I CALLED GM AT 800-630-2438 TO REPORT THE PROBLEM & SEE IF THERE WAS A RECALL. I WAS TOLD THERE WAS NO RECALL BUT THAT I SHOULD TAKE IT TO THE DEALER FOR DIAGNOSTIC TESTING. I ASKED IF I WOULD BE CHARGED AND SHE SAID YES. I TOLD HER THAT I CAN'T AFFORD TO PAY THEM JUST FOR DIAGNOSTICS AND THAT THEY ALREADY KNOW WHAT THE PROBLEM IS SINCE IT IS ALL OVER THE INTERNET ABOUT SO MANY OF THEIR VEHICLES DOING THIS. *TR
SERVICE ENGINE SOON LIGHT ON WHEN WE BOUGHT IT. HAD IT CHECKED INTO, ERROR CODE INDICATED A LEAK IN FUEL SYSTEM. SUGGESTED A NEW GAS CAP. THAT WAS NOT THE PROBLEM. THERE IS A CRACK IN THE NIPPLE ON THE GAS TANK WHERE THE FILL PIPE HOSE CONNECTS. NEED TO REPLACE THE WHOLE TANK. APPR. COST JUST FOR THE TANK $500 PLUS LABOR. …
Read full complaint
SERVICE ENGINE SOON LIGHT ON WHEN WE BOUGHT IT. HAD IT CHECKED INTO, ERROR CODE INDICATED A LEAK IN FUEL SYSTEM. SUGGESTED A NEW GAS CAP. THAT WAS NOT THE PROBLEM. THERE IS A CRACK IN THE NIPPLE ON THE GAS TANK WHERE THE FILL PIPE HOSE CONNECTS. NEED TO REPLACE THE WHOLE TANK. APPR. COST JUST FOR THE TANK $500 PLUS LABOR. *TR
TL*THE CONTACT OWNS A 2003 CHEVROLET TRAILBLAZER EXT. THE VEHICLE WAS REPAIRED ACCORDING TO A RECALL, BUT THE FAILURE HAS RECURRED. THE CONTACT STATED THAT THE DOORS CLOSE AND OPEN INTERMITTENTLY. IN ADDITION, THE LATCH DOES NOT LOCK PROPERLY ON THE REAR PASSENGER AND DRIVER'S SIDE DOORS, LEAVING THEM TO REMAIN UNSECURED. SH…
Read full complaint
TL*THE CONTACT OWNS A 2003 CHEVROLET TRAILBLAZER EXT. THE VEHICLE WAS REPAIRED ACCORDING TO A RECALL, BUT THE FAILURE HAS RECURRED. THE CONTACT STATED THAT THE DOORS CLOSE AND OPEN INTERMITTENTLY. IN ADDITION, THE LATCH DOES NOT LOCK PROPERLY ON THE REAR PASSENGER AND DRIVER'S SIDE DOORS, LEAVING THEM TO REMAIN UNSECURED. SHE PLACED HER SON IN THE CHILD SEAT AND CLOSED THE DOOR, BUT IT REMAINED OPEN. THE CONTACT HAD TO PUSH THE DOOR CLOSED SEVERAL TIMES. FOUR MONTHS LATER, THE FAILURE OCCURRED WITH THE OTHER DOOR. THE DEALER AND MANUFACTURER STATED THAT THEY COULD NOT ASSIST. THE NHTSA CAMPAIGN ID NUMBER WAS UNKNOWN. THE FAILURE MILEAGE WAS 113,000 AND CURRENT MILEAGE WAS 120,000.
POWER SEAT ON DRIVER'S SIDE HAS STOPPED WORKING. I AM TOLD THIS IS EITHER A SOFTWARE UPDATE/UPGRADE OR A REPAIR DEPENDING ON WHO YOU TALK TO. IF THE DEALER IS WILLING TO WORK WITH YOU AND NOT TAKE ADVANTAGE OF YOU THEY WILL DO THE SOFTWARE UPGRADE. IF NOT WILLING TO WORK WITH YOU THEY WILL SELL YOU A NEW SEAT MOTOR AND CHARGE YO…
Read full complaint
POWER SEAT ON DRIVER'S SIDE HAS STOPPED WORKING. I AM TOLD THIS IS EITHER A SOFTWARE UPDATE/UPGRADE OR A REPAIR DEPENDING ON WHO YOU TALK TO. IF THE DEALER IS WILLING TO WORK WITH YOU AND NOT TAKE ADVANTAGE OF YOU THEY WILL DO THE SOFTWARE UPGRADE. IF NOT WILLING TO WORK WITH YOU THEY WILL SELL YOU A NEW SEAT MOTOR AND CHARGE YOU AT LEAST $400.00 FOR INSTALLATION. *TR
HEAD LAMPS AND SOCKETS KEEP BURNING OUT. *TR
Official recalls
305V494000 · Latches/locks/linkages:doors:latch
Oct 27, 2005
CERTAIN SPORT UTILITY VEHICLES HAVE A REAR SIDE CLOSURE LATCH THAT MAY NOT LATCH OR UNLATCH DUE TO CORROSION CAUSED BY ROAD SPLASH, SUCH AS WATER AND ROAD SALT. THESE VEHICLES WERE ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA.
Consequence & remedy
Consequence: IF THE DOOR IS NOT LATCHED PROPERLY AND IT GOES UNNOTICED, IT MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN UNBELTED OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL INSTALL A SEAL ALONG THE LOWER PART OF THE ROCKER PANEL TO PREVENT INTRUSION OF CORROSIVE MATERIAL, AND INSPECT THE REAR SIDE CLOSURE LATCHES. FUNCTIONAL LATCHES WILL BE CLEANED AND LUBRICATED. NON-FUNCTIONING LATCHES WILL BE REPLACED. THE RECALL BEGAN ON FEBRUARY 24, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR ISUZU AT 1-800-255-6727.
04V527000 · Exterior Lighting:brake Lights
Nov 1, 2004
ON CERTAIN SPORT UTILITY VEHICLES, VIBRATION AND HEAT MAY CAUSE THE TAIL LAMP/STOP LAMP BULB TO LOOSEN IN ITS SOCKET. IF THIS OCCURS, THE BULB MAY FLICKER AND EVENTUALLY BECOME INOPERATIVE.
Consequence & remedy
Consequence: AN INOPERATIVE BRAKE LAMP WILL NOT CONVEY THE DRIVER'S INTENTION OF STOPPING TO DRIVERS IN FOLLOWING VEHICLES, AND AN INOPERATIVE REAR TURN SIGNAL LAMP WILL NOT CONVEY THE DRIVER'S INTENTION TO TURN TO DRIVERS IN FOLLOWING VEHICLES. BOTH OF THESE FAILURES CAN INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE TAIL LAMP/STOP LAMP ASSEMBLIES, AND IF NECESSARY, REPLACE THEM. THE RECALL BEGAN ON NOVEMBER 22, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, BUICK AT 1-866-608-8080, OR GMC AT 1-866-996-9463.
04V046000 · Visibility:windshield Wiper/washer
Feb 4, 2004
CERTAIN SPORT UTILITY VEHICLES HAVE WINDSHIELD WIPER SYSTEMS THAT WILL NOT TURN ON, CEASE OPERATION WHILE IN USE, FAIL TO TURN OFF/ON BY THEMSELVES (MOISTURE SENSITIVE WIPER SYSTEM), OR HAVE CONTINUOUS WINDSHIELD WASHER PUMP OPERATION BECAUSE THE PRESENCE OF WATER WITHIN THE WIPER MODULES CAN EITHER CAUSE A SHORT CIRCUIT OR CAN LEAD TO THE CORROSION OF COMPONENTS WITHIN THE MODULE.
Consequence & remedy
Consequence: DEPENDING ON THE OCCURRENCE AND WEATHER SITUATION, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL COVER THE WINDSHIELD WIPER MODULE VENT HOLE WITH A PATCH. ALSO, THE WIPER MOTOR, CIRCUIT BOARD, AND ELECTRICAL CONNECTOR WILL BE INSPECTED TO SIGNS OF WATER INTRUSION AND/OR CORROSION AND BE REPLACED AS REQUIRED. THE RECALL BEGAN JULY 6, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR GMC AT 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6RQ17002 · Loss Of Headlights
Opened Apr 24, 2017 · Closed Mar 29, 2021
Status: closed (inferred from source dates) · Exterior Lighting:headlights
The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV. The original scope of this investigation was expanded to include all vehicles equipped with the subject Headlight Driver Module (HDM). The focus of the investigation was to determine whether actions performed by General Motors adequately addressed any unreasonable risk to motor vehicle safety in the subject vehicles concerning the headlights and the HDM that controls them.Under normal electrical load and environmental conditions, the HDM can overheat inside the Underhood Electrical Center (UEC). This can cause the module to fail and result in a simultaneous loss of both low beam headlights and both daytime running lights (DRLs), often with no warning or prior detectability to the driver. This failure can be intermittent or permanent. No other exterior lights are affected. High beams, turn signals, brake lights, and reverse lights are still operational.General Motors addressed this issue with 2 recalls (14V755 & 15V519) and a special coverage program (N172091910). In view of the recalls and special coverage program implemented by GM and the vehicle high beams continuing to operate, ODI has tentatively concluded that the actions taken by GM mitigate any unreasonable risk to safety posed by HDM failure in the subject vehicles.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
EA07009 · Fuel Pump Module Leaks Gasoline
Opened Jul 10, 2007 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump
DURING THE COURSE OF THIS EA INVESTIGATION, ODI OBSERVED THAT THE MAJORITY OF THE COMPLAINTS (88%) AND WARRANTY CLAIMS (94%) WERE REPORTED FOR VEHICLES THAT ARE REGISTERED FOR USE IN THE SALT BELT REGION OF THE US.THIS AREA INCLUDES 20 STATES IN THE NORTHEAST, MID ATLANTIC AND THE MIDWEST REGIONS AND THE DISTRICT OF COLUMBIA.CONSUMERS IN THE SALT BELT REGION REPORTED TO ODI THAT THEY COULD SMELL FUEL VAPORS IN THEIR VEHICLES WHILE DRIVING.UPON FURTHER EXAMINATION OF THEIR VEHICLES, THEY DISCOVERED THAT FUEL VAPORS WERE COMING OUT OF THE TOP OF THE FUEL TANK. THIS CONDITION IS CAUSED BY CORROSION OF THE RETURN AND SENDER LINES OF THE FUEL PUMP MODULE.WATER AND ROAD SALT COLLECT ON TOP OF THE FUEL PUMP LEADING TO SMALL PINHOLES APPEARING ON THE FUEL LINES.FUEL MAY LEAK AND COLLECT ON TOP OF THE MODULE AND/OR SPILL ONTO THE GROUND.THE DATA EVALUATED UNDER THIS INVESTIGATION REFLECT A RELATIVELY LOW FREQUENCY OF OCCURRENCE THAT LARGELY ARISES IN SALT BELT STATES.GM HAS EXTENDED THE WARRANTY ON THE SUBJECT COMPONENT TO TEN YEARS OR 120,000 MILES.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED AT THIS TIME; ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION SELECT DOCUMENT SEARCH.
PE07014 · Fuel Tank Leak
Opened Mar 13, 2007 · Closed Jun 12, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:delivery:hoses, Lines/piping, And Fittings
IN JUNE 2007, GM WILL EXPAND ITS SPECIAL POLICY TO ADDRESS FUEL TANK INLET CHECK VALVE (ICV) FRACTURES ON CERTAIN MODEL YEAR (MY) TRAILBLAZER EXT AND GMC ENVOY XL VEHICLES.THE EXPANDED POLICY COVERS MY 2002-2004 TRAILBLAZER EXT, GMC ENVOY XL, AND GMC ENVOY XUV VEHICLES AND WILL EXTEND FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER COMES FIRST).GM WILL PROVIDE FREE REPAIR OF THE FUEL TANK. IT IS SENDING LETTERS TO OWNERS BEGINNING IN JUNE OF 2007.THIS ACTION SUPERSEDES GM'S PREVIOUS 7 YEAR/70,000 MILE SPECIAL POLICY FOR MY 2002 TRAILBLAZER EXT AND ENVOY XL VEHICLES.THE CONDITION IS MOST OFTEN REPORTED AS ILLUMINATION OF THE SERVICE ENGINE SOON (SES) LIGHT.THE VEHICLE'S DIAGNOSTIC SYSTEM DETECTS THE PRESENCE OF A FUEL SYSTEM PRESSURE LEAK AND ILLUMINATES THE SES LIGHT.OTHER OWNERS REPORT SMELLING GASOLINE FUMES. THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline:storage:tank Assembly
IN JUNE 2007, GM WILL EXPAND ITS SPECIAL POLICY TO ADDRESS FUEL TANK INLET CHECK VALVE (ICV) FRACTURES ON CERTAIN MODEL YEAR (MY) TRAILBLAZER EXT AND GMC ENVOY XL VEHICLES.THE EXPANDED POLICY COVERS MY 2002-2004 TRAILBLAZER EXT, GMC ENVOY XL, AND GMC ENVOY XUV VEHICLES AND WILL EXTEND FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER COMES FIRST).GM WILL PROVIDE FREE REPAIR OF THE FUEL TANK. IT IS SENDING LETTERS TO OWNERS BEGINNING IN JUNE OF 2007.THIS ACTION SUPERSEDES GM'S PREVIOUS 7 YEAR/70,000 MILE SPECIAL POLICY FOR MY 2002 TRAILBLAZER EXT AND ENVOY XL VEHICLES.THE CONDITION IS MOST OFTEN REPORTED AS ILLUMINATION OF THE SERVICE ENGINE SOON (SES) LIGHT.THE VEHICLE'S DIAGNOSTIC SYSTEM DETECTS THE PRESENCE OF A FUEL SYSTEM PRESSURE LEAK AND ILLUMINATES THE SES LIGHT.OTHER OWNERS REPORT SMELLING GASOLINE FUMES. THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:delivery:hoses, Lines/piping, And Fittings
IN JUNE 2007, GM WILL EXPAND ITS SPECIAL POLICY TO ADDRESS FUEL TANK INLET CHECK VALVE (ICV) FRACTURES ON CERTAIN MODEL YEAR (MY) TRAILBLAZER EXT AND GMC ENVOY XL VEHICLES.THE EXPANDED POLICY COVERS MY 2002-2004 TRAILBLAZER EXT, GMC ENVOY XL, AND GMC ENVOY XUV VEHICLES AND WILL EXTEND FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER COMES FIRST).GM WILL PROVIDE FREE REPAIR OF THE FUEL TANK. IT IS SENDING LETTERS TO OWNERS BEGINNING IN JUNE OF 2007.THIS ACTION SUPERSEDES GM'S PREVIOUS 7 YEAR/70,000 MILE SPECIAL POLICY FOR MY 2002 TRAILBLAZER EXT AND ENVOY XL VEHICLES.THE CONDITION IS MOST OFTEN REPORTED AS ILLUMINATION OF THE SERVICE ENGINE SOON (SES) LIGHT.THE VEHICLE'S DIAGNOSTIC SYSTEM DETECTS THE PRESENCE OF A FUEL SYSTEM PRESSURE LEAK AND ILLUMINATES THE SES LIGHT.OTHER OWNERS REPORT SMELLING GASOLINE FUMES. THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE07013 · Fuel Pump Module Leaks Gasoline
Opened Mar 12, 2007 · Closed Jul 10, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump
ODI HAS RECEIVED REPORTS THAT THE FUEL PUMP MODULE LEAKS FUEL AND OR VAPOR UNDERNEATH THE VEHICLE.GM STATES, THE FAILURE MECHANISM IS CORROSION OF THE FUEL PUMP MODULE FLANGE WHICH MAY LEAD TO A FUEL LEAK.CORROSION OF THE FUEL PUMP MODULE FLANGE IS THE RESULT OF THE VEHICLE OPERATING IN A CORROSIVE ENVIRONMENT.ODI HAS UPGRADED THIS PE TO ENGINEERING ANALYSIS (EA07-009) TO FURTHER ASSESS THIS ISSUE.
EA04021 · Brake Lamp Failure
Opened Aug 3, 2004 · Closed Nov 4, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights
GM STATES THAT SOME BRAKE/TAIL LAMP BULBS CAN PREMATURELY BECOME INOPERATIVE DUE TO MALFUNCTIONING BRAKE/TAIL LAMP SOCKETS.ON MARCH 2, 2004, GM INITIATED A 6-YEAR/72,000 MILE SPECIAL POLICY FOR 989,487 SUBJECT VEHICLES TO INSPECT AND REPLACE THE REAR BRAKE/TAIL LAMP BULB SOCKET ASSEMBLIES.ON APRIL 4, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE04-032) BASED ON CONSUMER COMPLAINTS ALLEGING BRAKE LIGHTS NOT OPERATING WHEN THE BRAKE PEDAL IS DEPRESSED.ON AUGUST 3, 2004 ODI UPGRADED PE04-032 TO AN ENGINEERING ANALYSIS (EA04-021).BY LETTER DATED OCTOBER 27, 2004 GM NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA # 04V527) COVERING SUBJECT VEHICLES THAT WERE NOT ALREADY REPAIRED UNDER GM'S SPECIAL POLICY.MY 2004 SUBJECT VEHICLES BUILT AFTER AUGUST 8, 2003 CONTAIN IMPROVED BRAKE LAMP ASSEMBLIES AND ARE NOT INCLUDED IN THE RECALL.GM DEALERS WILL INSTALL THE IMPROVED BRAKE LAMP ASSEMBLY ON SUBJECT VEHICLES BUILT ON AUGUST 8, 2003 AND EARLIER.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE04001 · Fuel Spillage During Refueling
Opened Jan 5, 2004 · Closed May 7, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
THIS INVESTIGATION WAS OPENED ON THE MODEL YEAR (MY) 2003 CHEVROLET TRAILBLAZER.BASED ON GM'S INFORMATION REQUEST (IR) RESPONSE, ODI ADDED TO ITS ANALYSIS THE MY 2003 GMC ENVOY AND OLDSMOBILE BRAVADA VEHICLES.THESE VEHICLES SHARE THE SAME VEHICLE PLATFORM (GM 360/370) AND FUEL FILL COMPONENTS.INCIDENT SUMMARY NUMBERS REPORTED ABOVE INCLUDE THESE VEHICLES.EPA REGULATES THE FUEL DISPENSING RATES AT FILLING STATIONS AND GM STATES THAT THE REPORTS OF SPITBACK FOR THE SUBJECT VEHICLES ARE PRINCIPALLY CAUSED BY FUEL DISPENSING PUMPS EXCEEDING THE RATE SPECIFIED BY EPA.ODI FINDS THAT THE RATE OF COMPLAINTS, FIELD REPORTS AND WARRANTY IS LOW COMPARED TO OTHER VEHICLES THAT HAVE BEEN RECALLED FOR A SPITBACK ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (2)
Fuel System, Gasoline:storage
THIS INVESTIGATION WAS OPENED ON THE MODEL YEAR (MY) 2003 CHEVROLET TRAILBLAZER.BASED ON GM'S INFORMATION REQUEST (IR) RESPONSE, ODI ADDED TO ITS ANALYSIS THE MY 2003 GMC ENVOY AND OLDSMOBILE BRAVADA VEHICLES.THESE VEHICLES SHARE THE SAME VEHICLE PLATFORM (GM 360/370) AND FUEL FILL COMPONENTS.INCIDENT SUMMARY NUMBERS REPORTED ABOVE INCLUDE THESE VEHICLES.EPA REGULATES THE FUEL DISPENSING RATES AT FILLING STATIONS AND GM STATES THAT THE REPORTS OF SPITBACK FOR THE SUBJECT VEHICLES ARE PRINCIPALLY CAUSED BY FUEL DISPENSING PUMPS EXCEEDING THE RATE SPECIFIED BY EPA.ODI FINDS THAT THE RATE OF COMPLAINTS, FIELD REPORTS AND WARRANTY IS LOW COMPARED TO OTHER VEHICLES THAT HAVE BEEN RECALLED FOR A SPITBACK ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
THIS INVESTIGATION WAS OPENED ON THE MODEL YEAR (MY) 2003 CHEVROLET TRAILBLAZER.BASED ON GM'S INFORMATION REQUEST (IR) RESPONSE, ODI ADDED TO ITS ANALYSIS THE MY 2003 GMC ENVOY AND OLDSMOBILE BRAVADA VEHICLES.THESE VEHICLES SHARE THE SAME VEHICLE PLATFORM (GM 360/370) AND FUEL FILL COMPONENTS.INCIDENT SUMMARY NUMBERS REPORTED ABOVE INCLUDE THESE VEHICLES.EPA REGULATES THE FUEL DISPENSING RATES AT FILLING STATIONS AND GM STATES THAT THE REPORTS OF SPITBACK FOR THE SUBJECT VEHICLES ARE PRINCIPALLY CAUSED BY FUEL DISPENSING PUMPS EXCEEDING THE RATE SPECIFIED BY EPA.ODI FINDS THAT THE RATE OF COMPLAINTS, FIELD REPORTS AND WARRANTY IS LOW COMPARED TO OTHER VEHICLES THAT HAVE BEEN RECALLED FOR A SPITBACK ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.