← New search

2013 Chevrolet Tahoe

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2013 Chevrolet Tahoe do not stand out strongly from the model-year median of 246.

About this comparison →

How this year compares

Owner complaints by model year

Other model years Selected year
Compare all Tahoe years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

All reported categories

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

162 reports with mileage · 70 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Structure. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Air Bags. Review the 51 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

4 crash reports0 fire reports2 injury reports

Structure complaints

56 reports
Clear category filter
114,212 miles · Dec 1, 2018
Structure

SPLIT DASH AT CORNER OF PASSENGER AIR BAG

NHTSA ODI #11155312

55,000 miles · Sep 18, 2018
Structure

THE DASHBOARD HAS A CRACK FROM THE WINDSHIELD AND IS SPREADING TOWARD THE STEERING COLUMN(ABOUT 8-10 INCH CRACK). THERE IS ALSO A SMALL CRACK NEAR THE AIRBAG ON THE PASSENGER SIDE. WE FIRST NOTICED THE CRACK IN AUGUST/2017. WE WERE TOLD OUR EXTENDED WARRANTY WOULD NOT COVER THE BILL. WHEN WE FIRST NOTICED THE CRACK WAS ABOUT …

Read full complaint

THE DASHBOARD HAS A CRACK FROM THE WINDSHIELD AND IS SPREADING TOWARD THE STEERING COLUMN(ABOUT 8-10 INCH CRACK). THERE IS ALSO A SMALL CRACK NEAR THE AIRBAG ON THE PASSENGER SIDE. WE FIRST NOTICED THE CRACK IN AUGUST/2017. WE WERE TOLD OUR EXTENDED WARRANTY WOULD NOT COVER THE BILL. WHEN WE FIRST NOTICED THE CRACK WAS ABOUT 4 INCHES. IT HAS NOW GROWN CLOSE TO 8-10 INCHES.

NHTSA ODI #11130270

120,000 miles · Jul 25, 2018
Structure

TL* THE CONTACT OWNS A 2013 CHEVROLET TAHOE. THE CONTACT STATED THAT THE DASHBOARD WAS CRACKED ALONG THE DRIVER'S SIDE OF THE VEHICLE. THE CONTACT WAS CONCERNED THAT THE AIR BAGS MAY NOT DEPLOY PROPERLY IN THE EVENT OF A CRASH, WHICH COULD LEAD TO SERIOUS INJURY OR DEATH. THE VEHICLE WAS TAKEN TO ASHEVILLE CHEVROLET (205 SMOKEY …

Read full complaint

TL* THE CONTACT OWNS A 2013 CHEVROLET TAHOE. THE CONTACT STATED THAT THE DASHBOARD WAS CRACKED ALONG THE DRIVER'S SIDE OF THE VEHICLE. THE CONTACT WAS CONCERNED THAT THE AIR BAGS MAY NOT DEPLOY PROPERLY IN THE EVENT OF A CRASH, WHICH COULD LEAD TO SERIOUS INJURY OR DEATH. THE VEHICLE WAS TAKEN TO ASHEVILLE CHEVROLET (205 SMOKEY PARK HIGHWAY, ASHEVILLE, NC 28806, (828) 348-7326) WHERE IT WAS DIAGNOSED THAT THE DASHBOARD NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

NHTSA ODI #11113540

110,000 miles · Jul 9, 2018
Structure

THE DASHBOARD IS CRACKING RIGHT ABOVE THE STEERING WHEEL. I DO NOT KNOW IT THE CRACK STARTING WHILE IN MOTION OR STATIONARY. I KNOW IT HAPPENED IN MAY 2018. IT IS CRACKING MORE EVERYDAY. THIS IS MY DREAM CAR AND I THINK IT'S A SHAME TO PAY THIS KIND OT MONEY FOR SUCH A EXPENSIVE CAR AND IT STARTS FALLING APART. MY HUSBAND AND…

Read full complaint

THE DASHBOARD IS CRACKING RIGHT ABOVE THE STEERING WHEEL. I DO NOT KNOW IT THE CRACK STARTING WHILE IN MOTION OR STATIONARY. I KNOW IT HAPPENED IN MAY 2018. IT IS CRACKING MORE EVERYDAY. THIS IS MY DREAM CAR AND I THINK IT'S A SHAME TO PAY THIS KIND OT MONEY FOR SUCH A EXPENSIVE CAR AND IT STARTS FALLING APART. MY HUSBAND AND I ARE NOTHING BUT CHEVY BUYERS WE HAVE OWNED A NUMBER OF BLAZERS AND TAHOE AND HAVE NEVER HAD THIS PROBLEM . MY HUSBAND'S TAHOE IS A 2004 . LOOKS GREAT. ALSO ON THE 2013 TAHOE THE DOOR PULL IS BROKE AND THE DEALER SAID I HAD TO BUY THE HOLD DOOR PANEL THST WOULD BE OVER $500. I ONLY NEED THE THE PULL HANDLE NOT THE ENTIRE DOOR PANEL. THIS IS NONSENSE. IS CHEVROLET GETTING CHEAP ON THEIR QUALLTY . THIS WILL MAKE BE LOOK INTO OTHER VEHICLES (FORD, TOYOTA, JEEP , ETC. ## VIN PASSED ## CHEVY TAHOE 2013 ##

NHTSA ODI #11110388

84,000 miles · Jun 5, 2018
Air BagsStructure

DASH CRACKED FRONT PASSENGER SIDE, ABOVE AND INTO LEFT SIDE OF AIRBAG COMPARTMENT. VEHICLE HAS BEEN GARAGED OR SHADE IN WINDOW, WAS STATIONARY & UNOCCUPIED WHEN THE DASH CRACKED.

NHTSA ODI #11099989

75,000 miles · Apr 18, 2018
Structure

MY DASHBOARD HAS CRACKED IN TWO SEPARATE PLACES. THE FIRST CRACK IN THE DASHBOARD IS AT THE PASSENGER AIRBAG. THE SECOND CRACK IS LARGE IN SIZE AND RUNS FROM THE BACK OF THE DASHBOARD ALL THE WAY UP TO THE DASH THAT COVERS MY INSTRUMENT PANEL.

NHTSA ODI #11088855

40,000 miles · Apr 6, 2018
Air BagsStructureUnknown Or Other

THIS IS A SERIES OF CRACK ON THE FRONT DASHBOARD. STARTED FROM THE COWLING OVER INSTRUMENT PANELS AND HAS SPREAD TO A SECTION BY THE PASSENGER AIRBAG. THERE HAVE BEEN A NUMBER OF GM VEHICLES WITH THIS SAME DASHBOARD CRACKING BUT GM DOES NOTHING ABOUT IT. I'M ONLY A LITTLE OVER 50K MILES.

NHTSA ODI #11083578

Mileage unknown · Feb 28, 2018
StructureUnknown Or Other

THE DASH HAS CRACKED ON THE PASSENGER SIDE. THE CRACK STARTS ON THE LEFT SIDE OF PASSENGER AIR BAG AND CONTINUES UPWARD. STARTED SMALL AND SEEMED TO GET LARGER OVERNIGHT. VEHICLE IS GARAGE KEPT. NO REASON FOR THIS. SCARES ME IF AIRBAG DEPLOYS WILL PLASTIC EXPLODE INTO SOMEONE. FROM WHAT I HAVE READ , THIS SEEMS TO BE QUITE A PRO…

Read full complaint

THE DASH HAS CRACKED ON THE PASSENGER SIDE. THE CRACK STARTS ON THE LEFT SIDE OF PASSENGER AIR BAG AND CONTINUES UPWARD. STARTED SMALL AND SEEMED TO GET LARGER OVERNIGHT. VEHICLE IS GARAGE KEPT. NO REASON FOR THIS. SCARES ME IF AIRBAG DEPLOYS WILL PLASTIC EXPLODE INTO SOMEONE. FROM WHAT I HAVE READ , THIS SEEMS TO BE QUITE A PROBLEM WITH THESE DASHES.

NHTSA ODI #11075354

35,000 miles · Feb 21, 2018
Structure

TL* THE CONTACT OWNS A 2013 CHEVROLET TAHOE. THE CONTACT STATED THAT THE DASHBOARD WAS CRACKED FROM THE PASSENGER SIDE TO THE DIVER SIDE WINDSHIELD AREA. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE CRACKED AREAS COULD BE COVERED. THE DASHBOARD WAS NOT REPLACED. THE VEHICLE WAS NOT TAKEN TO A LOCAL DEALE…

Read full complaint

TL* THE CONTACT OWNS A 2013 CHEVROLET TAHOE. THE CONTACT STATED THAT THE DASHBOARD WAS CRACKED FROM THE PASSENGER SIDE TO THE DIVER SIDE WINDSHIELD AREA. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE CRACKED AREAS COULD BE COVERED. THE DASHBOARD WAS NOT REPLACED. THE VEHICLE WAS NOT TAKEN TO A LOCAL DEALER FOR INSPECTION OR REPAIRS. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 35,000.

NHTSA ODI #11074033

Mileage unknown · Feb 5, 2018
Structure

DASHBOARD HAS SEVERAL CRACKS. THREE AROUND THE AIRBAG BOX WHICH ARE EXTREMELY CONCERNING! I TRY TO ALWAYS HAVE MY TAHOE IN COOL PLACES TO PREVENT EXTREME TEMPERATURES AND FURTHER DAMAGE BUT STILL NOTICE THE CRACKS GROWING. I UNDERSTAND THERE HAVE BEEN MANY GM OWNERS HAVING TO DEAL WITH SIMILAR PROBLEMS.THERE MUST OBVIOUSLY BE A …

Read full complaint

DASHBOARD HAS SEVERAL CRACKS. THREE AROUND THE AIRBAG BOX WHICH ARE EXTREMELY CONCERNING! I TRY TO ALWAYS HAVE MY TAHOE IN COOL PLACES TO PREVENT EXTREME TEMPERATURES AND FURTHER DAMAGE BUT STILL NOTICE THE CRACKS GROWING. I UNDERSTAND THERE HAVE BEEN MANY GM OWNERS HAVING TO DEAL WITH SIMILAR PROBLEMS.THERE MUST OBVIOUSLY BE A DEFECT IN THE MATERIAL OR THE ASSEMBLY OF THIS PART. BEING BOTH A SAFETY CONCERN AND A CUSTOMER SATISFACTION ISSUE, I AM REALLY LOOKING FORWARD TO OPTIONS FOR RESOLVING THIS MATTER.

NHTSA ODI #11067056

Official recalls

4

21V053000 · Air Bags:frontal:passenger Side:inflator Module

Feb 5, 2021

General Motors, LLC (GM) is recalling certain 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2010 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Additionally, GM is recalling certain 2009 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C."

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 24, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on May 11, 2021. Owners may contact Cadillac customer service at 1-800-458-8006; Chevrolet customer service at 1-800-222-1020; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328790.

21V054000 · Air Bags:frontal:passenger Side:inflator Module

Feb 5, 2021

General Motors, LLC (GM) is recalling certain 2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of AL, CA, FL, GA, HI, LA, MS, SC, TX, PR, AS, GU, the MP, and VI or "Zone A." Additionally GM is recalling certain 2011-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, Yukon XL and 2011-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AZ, AR, DE, DC, IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV or "Zone B." Additionally, GM is recalling certain 2010-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL and 2010-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 25, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed to 40 VIN owners on May 11, 2021. A second owner notification letter was mailed to all other owners on January 24, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328800.

14V614000 · Electrical System

Oct 1, 2014

General Motors LLC (GM) is recalling certain model year 2013-2014 Cadillac CTS, Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, GMC Yukon, and Yukon XL, and 2014 Buick Enclave, Chevrolet Express, Impala, Silverado HD, Traverse, GMC Acadia, Savana, and Sierra HD vehicles. In the affected vehicles, the chassis electronic module may be internally contaminated, resulting in an electrical short.

Consequence & remedy

Consequence: If the module experiences an electrical short, the vehicle could stall, increasing the risk of a crash.

Remedy: GM will notify owners, and dealers will replace the chassis electronic module, free of charge. The recall began on December 26, 2014. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-458-006 (Cadillac), 1-800-222-1020 (Chevrolet), and 1-800-462-8782 (GMC). GM’s number for this recall is 14515.

13V001000 · Power Train:automatic Transmission; Steering:column LOCKING:ANTI-THEFT Device

Jan 2, 2013

General Motors (GM) is recalling certain model year 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT; Chevrolet Avalanche, Express, Silverado HD, Silverado LD, Suburban, and Tahoe; and GMC Savana, Sierra HD, Sierra LD, Yukon, and Yukon XL vehicles, manufactured between November 7, 2012, through December 18, 2012, for failing to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect", and FMVSS No. 114, "Theft Protection and Rollaway Prevention." The vehicles may have been built with a fractured park lock cable or a malformed steering column lock actuator gear in the lock module assembly.

Consequence & remedy

Consequence: As a result, the vehicle may shift from Park with the ignition key removed or the ignition key in the OFF position. The vehicle may also shift out of Park without application of the brake pedal while the key is off. Either of these scenarios may cause the vehicle to roll away after the driver has exited the vehicle, resulting in a possible vehicle crash and/or injury.

Remedy: GM will notify owners, and dealers will inspect the affected vehicles and replace the steering column as necessary, free of charge. The recall began on January 21, 2013. Chevrolet owners may call 1-800-630-2438. Cadillac owners may call 1-866-982-2339. GMC owners may call 1-866-996-9463.

Additional source detail variants (2)

Power Train:automatic Transmission

General Motors (GM) is recalling certain model year 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT; Chevrolet Avalanche, Express, Silverado HD, Silverado LD, Suburban, and Tahoe; and GMC Savana, Sierra HD, Sierra LD, Yukon, and Yukon XL vehicles, manufactured between November 7, 2012, through December 18, 2012, for failing to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect", and FMVSS No. 114, "Theft Protection and Rollaway Prevention." The vehicles may have been built with a fractured park lock cable or a malformed steering column lock actuator gear in the lock module assembly.

Consequence: As a result, the vehicle may shift from Park with the ignition key removed or the ignition key in the OFF position. The vehicle may also shift out of Park without application of the brake pedal while the key is off. Either of these scenarios may cause the vehicle to roll away after the driver has exited the vehicle, resulting in a possible vehicle crash and/or injury.

Remedy: GM will notify owners, and dealers will inspect the affected vehicles and replace the steering column as necessary, free of charge. The recall began on January 21, 2013. Chevrolet owners may call 1-800-630-2438. Cadillac owners may call 1-866-982-2339. GMC owners may call 1-866-996-9463.

Steering:column LOCKING:ANTI-THEFT Device

General Motors (GM) is recalling certain model year 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT; Chevrolet Avalanche, Express, Silverado HD, Silverado LD, Suburban, and Tahoe; and GMC Savana, Sierra HD, Sierra LD, Yukon, and Yukon XL vehicles, manufactured between November 7, 2012, through December 18, 2012, for failing to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect", and FMVSS No. 114, "Theft Protection and Rollaway Prevention." The vehicles may have been built with a fractured park lock cable or a malformed steering column lock actuator gear in the lock module assembly.

Consequence: As a result, the vehicle may shift from Park with the ignition key removed or the ignition key in the OFF position. The vehicle may also shift out of Park without application of the brake pedal while the key is off. Either of these scenarios may cause the vehicle to roll away after the driver has exited the vehicle, resulting in a possible vehicle crash and/or injury.

Remedy: GM will notify owners, and dealers will inspect the affected vehicles and replace the steering column as necessary, free of charge. The recall began on January 21, 2013. Chevrolet owners may call 1-800-630-2438. Cadillac owners may call 1-866-982-2339. GMC owners may call 1-866-996-9463.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

1

EA21002 · Desiccated Air Bag Inflator Rupture

Opened Sep 17, 2021 · No close date supplied

Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Additional source detail variants (2)

Air Bags:frontal:driver Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.