← New search

2013 Chevrolet Tahoe

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2013 Chevrolet Tahoe do not stand out strongly from the model-year median of 246.

About this comparison →

How this year compares

Owner complaints by model year

Other model years Selected year
Compare all Tahoe years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

All reported categories

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

162 reports with mileage · 70 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Structure. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Air Bags. Review the 51 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

4 crash reports0 fire reports2 injury reports

Air Bags complaints

51 reports
Clear category filter
98,000 miles · Aug 22, 2017
Air BagsUnknown Or Other

CRACKED DASHBOARD BOUGHT MY 2013 CHEVY TAHOE LTZ. HAS ONLY 98000 MILES ON IT. JUST NOTICED A CRACK AT THE TOP LEFT CORNER OF THE DASHBOARD, RIGHT AT THE EDGE OF THE PASSENGER AIRBAG. TWO WEEKS LATER, ANOTHER CRACKED APPEARED ON THE DRIVER SIDE, FROM THE BOTTOM EDGE OF THE DASHBOARD AND CONTINUED UP AND OVER THE INSTRUMENT CLU…

Read full complaint

CRACKED DASHBOARD BOUGHT MY 2013 CHEVY TAHOE LTZ. HAS ONLY 98000 MILES ON IT. JUST NOTICED A CRACK AT THE TOP LEFT CORNER OF THE DASHBOARD, RIGHT AT THE EDGE OF THE PASSENGER AIRBAG. TWO WEEKS LATER, ANOTHER CRACKED APPEARED ON THE DRIVER SIDE, FROM THE BOTTOM EDGE OF THE DASHBOARD AND CONTINUED UP AND OVER THE INSTRUMENT CLUSTER HUMP. BOTH CRACKS APPEARED WHILE STATIONARY. THIS VEHICLE IS PRIMARILY GARAGED AND HAS A WINDSHIELD COVER. VERY DISAPPOINTED, SINCE THE NEW RETAIL OF THIS VEHICLE IS CLOSE $50,000 BRAND NEW AND COSTS OVER $1000 TO REPLACE AT THE DEALER. NOT TO MENTION, THIS IS OUR PRIMARY FAMILY VEHICLE, WHICH MY WIFE, 7 YO, 4 YO AND 6 MONTH OLD RIDE IN ON A DAILY BASIS.

NHTSA ODI #11019006

50,545 miles · Aug 22, 2017
Air BagsUnknown Or Other

DASHBOARD ON THE DRIVER SIDE IS CRACKING AND EXTENDING UPWARDS TOWARDS THE DRIVER. CONSISTENTLY RATTLES WHEN VEHICLE IS IN MOTION. CRACK IS ALSO VISIBLE ON THE PASSENGER SIDE LEADING TOWARDS THE AIRBAG. BOTH CRACKS WERE NOTICED WHEN VEHICLE WAS IN MOTION.

NHTSA ODI #11018874

Mileage unknown · Aug 7, 2017
Air BagsStructureUnknown Or Other

THE DASH OF MY 2013 TAHOE WHICH I PAID 48,000 CRACKED IN TWO PLACES SOON AS MY WARRANTY EXPIRED! ALL OF MY DOOR HANDLES ON OUTSIDE HAVE FALLEN OFF AND BEEN REPLACED ED AND THE DRIVER DOOR PANEL HAS BEEN REPLACED BECAUSE OF HANDLE BREAKING . TOO MUCH OTHER MESS TO EXPLAIN. JUST A VERY CHEAPLY MADE VEHICLE. VERY DISSATISFIED !I WO…

Read full complaint

THE DASH OF MY 2013 TAHOE WHICH I PAID 48,000 CRACKED IN TWO PLACES SOON AS MY WARRANTY EXPIRED! ALL OF MY DOOR HANDLES ON OUTSIDE HAVE FALLEN OFF AND BEEN REPLACED ED AND THE DRIVER DOOR PANEL HAS BEEN REPLACED BECAUSE OF HANDLE BREAKING . TOO MUCH OTHER MESS TO EXPLAIN. JUST A VERY CHEAPLY MADE VEHICLE. VERY DISSATISFIED !I WOULD LIKE TO FILE A FORMAL COMPLAINT FOLLOWED UP WITH A FORMAL INVESTIGATION

NHTSA ODI #11013579

64,000 miles · Aug 6, 2017
Air BagsUnknown Or Other

I OWN A 2013 CHEVROLET TAHOE LT. I TAKE GOOD CARE OF MY VEHICLE. LAST WEEK, I NOTICED MULTIPLE CRACKS IN MY DASHBOARD IN THE IMMEDIATE VICINITY OF MY PASSENGER SIDE AIRBAG; THEY SEEMED TO HAVE APPEARED OUT OF NOWHERE. THERE WAS NO INCIDENT BEFOREHAND THAT COULD HAVE CAUSED THE DAMAGE. MY VEHICLE WAS STATIONARY FROM THE LAST TIME…

Read full complaint

I OWN A 2013 CHEVROLET TAHOE LT. I TAKE GOOD CARE OF MY VEHICLE. LAST WEEK, I NOTICED MULTIPLE CRACKS IN MY DASHBOARD IN THE IMMEDIATE VICINITY OF MY PASSENGER SIDE AIRBAG; THEY SEEMED TO HAVE APPEARED OUT OF NOWHERE. THERE WAS NO INCIDENT BEFOREHAND THAT COULD HAVE CAUSED THE DAMAGE. MY VEHICLE WAS STATIONARY FROM THE LAST TIME I HAD USED IT, TO THE NEXT TIME I ENTERED MY VEHICLE AND NOTICED THE DASHBOARD CRACKS. I TOOK MY VEHICLE TO PRESTON CHEVROLET, A NEARBY GM DEALERSHIP, AND I WAS ADVISED BY THE SERVICE DEPT. MANAGER THAT THIS TYPE OF ISSUE IS NOT A COMMON OCCURRENCE, ALTHOUGH HE HAD SEEN IT IN THE PAST.. HE FURTHER ADVISED THAT HE WAS UNABLE TO OBTAIN OR PROVIDE ANY SORT OF FINANCIAL ASSISTANCE TO ME IN HAVING THE DEFECTIVE, DAMAGED DASHBOARD REPAIRED. AFTER RESEARCHING, I FOUND THAT IT IS QUITE A COMMON PROBLEM, AND WHAT'S MORE, THAT CHEVY TAHOE'S ARE THE 'COMMON DENOMINATOR.' I FEEL THAT I HAVE BEEN MISLEAD BY PRESTON CHEVROLET. I'VE SINCE CONTACTED GM AND I AM AWAITING A RESPONSE FROM A "SENIOR CASE ADVISOR." I AM PRIMARILY CONCERNED ABOUT MY SAFETY AND THE SAFETY OF MY PASSENGERS. IN THE EVENT OF A MOTOR VEHICLE COLLISION, I AM CERTAIN THAT SHARDS OF PLASTIC WOULD BE HURTLED INTO THE AIR, BECOMING DANGEROUS PROJECTILES THAT COULD CAUSE SERIOUS BODILY INJURY OR HARM, NOT TO MENTION THE POOR AESTHETIC APPEARANCE AND OVERALL DEVALUATION OF MY VEHICLE THAT THE FRACTURES HAVE CAUSED. THIS IS CLEARLY A MANUFACTURERS DEFECT. I FEEL I AM OWED REPAIR AND/OR RESTITUTION FROM GM AS A RESULT.

NHTSA ODI #11013129

65,000 miles · Jul 17, 2017
Air BagsUnknown Or Other

THE INSIDE DOOR PANEL ON THE DRIVERS SIDE BROKE WHERE HANDLE IS. VERY VERY DISGUSTED AT ALL THE PROBLEMS I HAVE HAD WITH MY VEHICLE WHILE IT WAS NEW

NHTSA ODI #11006036

40,000 miles · Jul 17, 2017
Air BagsUnknown Or Other

MY DOOR HANDLE FELL OFF ON DRIVER SIDE TWICE AND MY OTHER THREE HAVE BEEN REPLACED AS WELL. VERY CHEAPLY MADE. VERY DISAPPOINTED I DID NOT GET WHAT I PAID FOR THAT'S FOR SURE. THIS HAS BEEN THE WORST VEHICLE I HAVE EVER OWNED AND THE MOST EXPENSIVE AT 48,000!

NHTSA ODI #11006035

50,000 miles · Jul 17, 2017
Air BagsUnknown Or Other

MY DASH BOARD CRACKED IN THE TWO PLACES MY AIR BAGS ARE LOCATED. IT JUST CRACKED FOR NO REASON ON BOTH PASSENGER AND DRIVER SIDES

NHTSA ODI #11006033

71,000 miles · Jun 12, 2017
Air BagsStructure

TL* THE CONTACT OWNS A 2013 CHEVROLET TAHOE. THE CONTACT STATED THAT THE DASHBOARD WAS FRACTURED ALONG THE PASSENGER SIDE FRONTAL AIR BAG HOUSING. THE CONTACT WAS CONCERNED ABOUT THE SAFETY OF THE VEHICLE IN THE EVENT OF A CRASH NECESSITATING THE DEPLOYMENT OF THE AIR BAG. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR REPAIRED. T…

Read full complaint

TL* THE CONTACT OWNS A 2013 CHEVROLET TAHOE. THE CONTACT STATED THAT THE DASHBOARD WAS FRACTURED ALONG THE PASSENGER SIDE FRONTAL AIR BAG HOUSING. THE CONTACT WAS CONCERNED ABOUT THE SAFETY OF THE VEHICLE IN THE EVENT OF A CRASH NECESSITATING THE DEPLOYMENT OF THE AIR BAG. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 71,000.

NHTSA ODI #10994493

76,000 miles · Jun 7, 2017
Air BagsStructure

CRACKED DASH BY PASSENGER AIR BAG NOT LONG AFTER I PURCHASED THE VEHICLE I WOKE UP GOT INTO MY TAHOE AND SAW A CRACK.

NHTSA ODI #10993712

Mileage unknown · May 29, 2017
Air BagsUnknown Or Other

DASHBOARD CRACKING NEXT TO AIRBAG.

NHTSA ODI #10992037

Official recalls

4

21V053000 · Air Bags:frontal:passenger Side:inflator Module

Feb 5, 2021

General Motors, LLC (GM) is recalling certain 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2010 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Additionally, GM is recalling certain 2009 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C."

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 24, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on May 11, 2021. Owners may contact Cadillac customer service at 1-800-458-8006; Chevrolet customer service at 1-800-222-1020; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328790.

21V054000 · Air Bags:frontal:passenger Side:inflator Module

Feb 5, 2021

General Motors, LLC (GM) is recalling certain 2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of AL, CA, FL, GA, HI, LA, MS, SC, TX, PR, AS, GU, the MP, and VI or "Zone A." Additionally GM is recalling certain 2011-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, Yukon XL and 2011-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AZ, AR, DE, DC, IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV or "Zone B." Additionally, GM is recalling certain 2010-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL and 2010-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 25, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed to 40 VIN owners on May 11, 2021. A second owner notification letter was mailed to all other owners on January 24, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328800.

14V614000 · Electrical System

Oct 1, 2014

General Motors LLC (GM) is recalling certain model year 2013-2014 Cadillac CTS, Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, GMC Yukon, and Yukon XL, and 2014 Buick Enclave, Chevrolet Express, Impala, Silverado HD, Traverse, GMC Acadia, Savana, and Sierra HD vehicles. In the affected vehicles, the chassis electronic module may be internally contaminated, resulting in an electrical short.

Consequence & remedy

Consequence: If the module experiences an electrical short, the vehicle could stall, increasing the risk of a crash.

Remedy: GM will notify owners, and dealers will replace the chassis electronic module, free of charge. The recall began on December 26, 2014. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-458-006 (Cadillac), 1-800-222-1020 (Chevrolet), and 1-800-462-8782 (GMC). GM’s number for this recall is 14515.

13V001000 · Power Train:automatic Transmission; Steering:column LOCKING:ANTI-THEFT Device

Jan 2, 2013

General Motors (GM) is recalling certain model year 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT; Chevrolet Avalanche, Express, Silverado HD, Silverado LD, Suburban, and Tahoe; and GMC Savana, Sierra HD, Sierra LD, Yukon, and Yukon XL vehicles, manufactured between November 7, 2012, through December 18, 2012, for failing to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect", and FMVSS No. 114, "Theft Protection and Rollaway Prevention." The vehicles may have been built with a fractured park lock cable or a malformed steering column lock actuator gear in the lock module assembly.

Consequence & remedy

Consequence: As a result, the vehicle may shift from Park with the ignition key removed or the ignition key in the OFF position. The vehicle may also shift out of Park without application of the brake pedal while the key is off. Either of these scenarios may cause the vehicle to roll away after the driver has exited the vehicle, resulting in a possible vehicle crash and/or injury.

Remedy: GM will notify owners, and dealers will inspect the affected vehicles and replace the steering column as necessary, free of charge. The recall began on January 21, 2013. Chevrolet owners may call 1-800-630-2438. Cadillac owners may call 1-866-982-2339. GMC owners may call 1-866-996-9463.

Additional source detail variants (2)

Power Train:automatic Transmission

General Motors (GM) is recalling certain model year 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT; Chevrolet Avalanche, Express, Silverado HD, Silverado LD, Suburban, and Tahoe; and GMC Savana, Sierra HD, Sierra LD, Yukon, and Yukon XL vehicles, manufactured between November 7, 2012, through December 18, 2012, for failing to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect", and FMVSS No. 114, "Theft Protection and Rollaway Prevention." The vehicles may have been built with a fractured park lock cable or a malformed steering column lock actuator gear in the lock module assembly.

Consequence: As a result, the vehicle may shift from Park with the ignition key removed or the ignition key in the OFF position. The vehicle may also shift out of Park without application of the brake pedal while the key is off. Either of these scenarios may cause the vehicle to roll away after the driver has exited the vehicle, resulting in a possible vehicle crash and/or injury.

Remedy: GM will notify owners, and dealers will inspect the affected vehicles and replace the steering column as necessary, free of charge. The recall began on January 21, 2013. Chevrolet owners may call 1-800-630-2438. Cadillac owners may call 1-866-982-2339. GMC owners may call 1-866-996-9463.

Steering:column LOCKING:ANTI-THEFT Device

General Motors (GM) is recalling certain model year 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT; Chevrolet Avalanche, Express, Silverado HD, Silverado LD, Suburban, and Tahoe; and GMC Savana, Sierra HD, Sierra LD, Yukon, and Yukon XL vehicles, manufactured between November 7, 2012, through December 18, 2012, for failing to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect", and FMVSS No. 114, "Theft Protection and Rollaway Prevention." The vehicles may have been built with a fractured park lock cable or a malformed steering column lock actuator gear in the lock module assembly.

Consequence: As a result, the vehicle may shift from Park with the ignition key removed or the ignition key in the OFF position. The vehicle may also shift out of Park without application of the brake pedal while the key is off. Either of these scenarios may cause the vehicle to roll away after the driver has exited the vehicle, resulting in a possible vehicle crash and/or injury.

Remedy: GM will notify owners, and dealers will inspect the affected vehicles and replace the steering column as necessary, free of charge. The recall began on January 21, 2013. Chevrolet owners may call 1-800-630-2438. Cadillac owners may call 1-866-982-2339. GMC owners may call 1-866-996-9463.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

1

EA21002 · Desiccated Air Bag Inflator Rupture

Opened Sep 17, 2021 · No close date supplied

Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Additional source detail variants (2)

Air Bags:frontal:driver Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.