DOORS WILL NOT LOCK OR UNLOCK. LOCKS MAKE SOUND THAT THEY ARE TRYING TO ENGAGE BUT HAVE TO BE MANUALLY LOCKED OR UNLOCKED. I HAVE SMALL CHILDREN THAT I AM AFRAID THAT WILL BE LOCKED INSIDE MY VEHICLE AND I WILL BE UNABLE TO OPEN DOORS WITHOUT BREAKING THE WINDOW. *TR
2009 Chevrolet Tahoe
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2009 Chevrolet Tahoe do not stand out strongly from the model-year median of 246.
About this comparison →How this year compares
Owner complaints by model year
Compare all Tahoe years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
189 reports with mileage · 95 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 97 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 52 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
284 reportsWE HAVE HAD NOTHING BUT PROBLEMS OUT OF THIS TAHOE. WHEN DRIVING THE DASH LIGHTS FLASH, DOOR LOCKS MOVE UP AND DOWN, SPEEDOMETER WILL GO TO ZERO THEN BACK UP TO SPEED AN SO FORTH, THE TAHOE WILL START GEARING DOWN ON ITS OWN, THE AIR WILL GO OFF, AND THE RADIO WILL FLASH ON AND OFF. THE VEHICLE HAS EVEN SHUT COMPLETELY OFF BEFOR…
Read full complaint
WE HAVE HAD NOTHING BUT PROBLEMS OUT OF THIS TAHOE. WHEN DRIVING THE DASH LIGHTS FLASH, DOOR LOCKS MOVE UP AND DOWN, SPEEDOMETER WILL GO TO ZERO THEN BACK UP TO SPEED AN SO FORTH, THE TAHOE WILL START GEARING DOWN ON ITS OWN, THE AIR WILL GO OFF, AND THE RADIO WILL FLASH ON AND OFF. THE VEHICLE HAS EVEN SHUT COMPLETELY OFF BEFORE WHEN GOING DOWN THE INTERSTATE. WE HAVE REPLACED THE NEGATIVE GROUND WIRES AND THE 175 AMP MEGA FUSE. SECOND VACATION WITH THIS TAHOE AND STILL HAVING PROBLEMS!!! *TR
DOORS DO NOT LOCK WHEN CAR MOVES OR WHEN THEY ARE LOCKED OR UNLOCKED WITH REMOTE. KIDS SITTING IN BACK SEAT COULD OPEN DOOR AND FALL OUT , FAULTY DOOR LOCK ACTUATOR. *TR
CRACKS IN THE DASHBOARD OF MY 2009 CHEVROLET TAHOE HAVE BEEN APPEARING OVER THE PAST 7 MONTHS. GM AND CHEVROLET REFUSE TO ACKNOWLEDGE A FLEETWIDE PROBLEM AND WILL ONLY PAY FOR PARTIAL REPAIRS. ONE OF THE CRACKS IS IN APPROXIMATION TO THE PASSENGER SIDE AIRBAG AND HOW THE AIRBAG DEPLOYMENT WILL AFFECT THE DASHBOARD (AND VICA VERS…
Read full complaint
CRACKS IN THE DASHBOARD OF MY 2009 CHEVROLET TAHOE HAVE BEEN APPEARING OVER THE PAST 7 MONTHS. GM AND CHEVROLET REFUSE TO ACKNOWLEDGE A FLEETWIDE PROBLEM AND WILL ONLY PAY FOR PARTIAL REPAIRS. ONE OF THE CRACKS IS IN APPROXIMATION TO THE PASSENGER SIDE AIRBAG AND HOW THE AIRBAG DEPLOYMENT WILL AFFECT THE DASHBOARD (AND VICA VERSA) IS UNKNOWN AND WORRISOME. GM AND CHEVROLET REFUSE TO PAY FOR A DEFECTIVE PART REPLACEMENT ON THEIR VEHICLES FOR THIS ISSUE THAT AFFECTS HUNDREDS, IF NOT THOUSANDS OF THEIR VEHICLES. *TR
BOTH THE FRONT DRIVER AND PASSENGER INSIDE DOOR HANDLES OF THIS VEHICLE, A 2009 CHEVY TAHOE LTZ, WHICH HAVE A CHROME COLORED PLASTIC COATING, HAVE BECOME SHARP AS A RESULT OF PEELING ON THE TOP OF THE HANDLE, CAUSING CUTS TO THE FINGERS OF THE DRIVER AND PASSENGERS OF THE OCCUPANTS. CALLS TO GENERAL MOTORS WERE MET WITH ACKNOWL…
Read full complaint
BOTH THE FRONT DRIVER AND PASSENGER INSIDE DOOR HANDLES OF THIS VEHICLE, A 2009 CHEVY TAHOE LTZ, WHICH HAVE A CHROME COLORED PLASTIC COATING, HAVE BECOME SHARP AS A RESULT OF PEELING ON THE TOP OF THE HANDLE, CAUSING CUTS TO THE FINGERS OF THE DRIVER AND PASSENGERS OF THE OCCUPANTS. CALLS TO GENERAL MOTORS WERE MET WITH ACKNOWLEDGEMENT OF AN EXISTING AND KNOWN PROBLEM WITH THIS PARTICULAR PART IN THIS MODEL VEHICLE AND TRIM LEVEL, HOWEVER ACCOMMODATIONS ARE ONLY BEING MADE TO REPLACE/REPAIR THOSE THAT WERE INSTALLED IN MODEL YEAR 2007. THE AREA OF THE PEELING "CHROME" IS IN AN IDENTICAL LOCATION ON THE IDENTICAL PART ON THE IDENTICAL TRIM LEVEL OF THE IDENTICAL MODEL OF VEHICLE INCLUDED IN THE REPLACEMENT PROGRAM. IT SEEMS AS THOUGH GM HAS LIMITED ITS INCLUSION OF REPLACEMENT/REPAIR TO A LIMITED AMOUNT OF VEHICLES AS MANDATED/SUGGESTED BY NHTSA BASED UPON ITS INVESTIGATION, HOWEVER IT IS EVIDENT THAT THE SCOPE OF THE INVESTIGATION NEEDS TO BE WIDENED TO INCLUDE ALL VEHICLES AND OWNERS WHO ARE/WERE AFFECTED BY THE SAME PROBLEM. I HAVE DOCUMENTED THE INJURIES WITH PHOTOGRAPHS AND NUMEROUS COMPLAINTS TO GM REQUESTING REPLACEMENT/REPAIR HAVE PROVED UNSUCCESSFUL. *TR
THE FIRST THING THAT HAPPENED IS OUR RIGHT FRONT DOOR LOCK ACTUATOR WENT OUT AND WE JUST THOUGHT IT WAS BROKEN AND HAVE NOT HAD IT FIXED AND THEN THE SERVICE AIR BAG WARNING LIGHT HAS BEEN COMING ON FOR SEVERAL THOUSAND MILES. THEN THE TRUCK WOULD NOT START AND WE REPLACED THE BATTERY BUT EVEN AFTER DOING THAT THERE ARE TIMES …
Read full complaint
THE FIRST THING THAT HAPPENED IS OUR RIGHT FRONT DOOR LOCK ACTUATOR WENT OUT AND WE JUST THOUGHT IT WAS BROKEN AND HAVE NOT HAD IT FIXED AND THEN THE SERVICE AIR BAG WARNING LIGHT HAS BEEN COMING ON FOR SEVERAL THOUSAND MILES. THEN THE TRUCK WOULD NOT START AND WE REPLACED THE BATTERY BUT EVEN AFTER DOING THAT THERE ARE TIMES WHEN THE TRUCK ELECTRICAL SYSTEM JUST GOES DEAD AND WE CAN OPEN THE HOOD SHAKE THE WIRES OR JUST WAIT AND IT STARTS WORKING AGAIN. THEN IN THE LAST FEW THOUSAND MILES THE " WARNING LIGHT" COMES ON AND A BELL STARTS RINGING AND THEN THE DRIVE TRAIN DOES NOT OPERATE CORRECTLY. I WAS ON A PROJECT AND MY WIFE TOLD ME ALL THIS AND SHE PARKED THE TRUCK AND STARTED DRIVING MY TRUCK. WHEN I GOT HOME I TOOK IT TO ALLEN SAMUELS CHEVROLET AND THEY WORKED ON IT AND SAID THAT THE COMPUTER SHOWED THE AIR BAGS AND STABILITRAC SHOWED SOMETHING HAD HAPPENED AND THEY RESET IT OR SOMETHING. I DIDN'T GET DOWN THE ROAD 10 MILES AND THE "SERVICE AIR BAG WARNING LIGHT" CAME BACK ON. THEY THEN WANTED 112.50 AN HOUR TO TRY AND FIND OUT WHAT WAS WRONG. I TOOK IT HOME AND A FEW DAYS LATER I WAS DRIVING IT AND CAME TO A STOP AND THE DOOR LOCKS STARTED GOING UP AND DOWN QUICKLY, THE STABILITRAC LIGHT CAME ON, AND THE TRUCK WOULD NOT GO OVER ABOUT 2 - 3 MPH PER HOUR. I PULLED OVER TO THE SIDE OF THE ROAD AND AFTER A MILE OR TWO EVERYTHING STARTED WORKING AGAIN. WHEN WE GOT HOME I PARKED THE TAHOE AND TURNED IT OFF AND THE WHOLE ELECTRICAL SYSTEM WENT DEAD. WE COULDN'T LOCK THE DOORS. THIS HAS HAPPENED SEVERAL TIMES. I HAVE CALLED CHEVROLET AND THEY HAVE SAID THEY WOULD PAY FOR 1/2 OF THE PROBLEM BUT YOU CALL THE DEALER AND THEY WILL NOT GIVE YOU A PRICE, THEY JUST SAY IT MAY BE THIS AND IT MAY BE THAT. IT COULD COST THOUSANDS OF DOLLARS. ALL OF THESE ELECTRICAL PROBLEMS ARE SAFETY ISSUES AND COULD COST ONE OR BOTH OF OUR LIVES OR SOMEONE ELSE. ????? *TR
THE DOOR DOES NOT LOCK OR UNLOCK AT CERTAIN TIMES, YOU SEE THE LOCKS TRY TO MOVE UP YET IT DOESN'T HAPPEN. I NEED TO USE THE KEY. I'VE CHANGED THE BATTERIES ON THE REMOTE THINKING IT WAS THE REASON BUT IT DID NO GOOD. I KNOW A FEW OTHERS THAT HAVE A 2009 WITH SAME ISSUE TO INCLUDE THE CRACKING OF THE DASH BOARD. *TR
TL* THE CONTACT OWNS A 2009 CHEVROLET TAHOE. THE CONTACT STATED THAT THE POWER WINDOWS AND ALL FOUR DOOR LOCKS FAILED WHEN ATTEMPTING TO ENGAGE WITH THE AUTOMATIC KEY FOB AND THE CONTACT HAD TO MANUALLY LOCK AND UNLOCK DOORS. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS NOT INSPECTED. THE MANUFACTURER WAS MADE AWARE OF T…
Read full complaint
TL* THE CONTACT OWNS A 2009 CHEVROLET TAHOE. THE CONTACT STATED THAT THE POWER WINDOWS AND ALL FOUR DOOR LOCKS FAILED WHEN ATTEMPTING TO ENGAGE WITH THE AUTOMATIC KEY FOB AND THE CONTACT HAD TO MANUALLY LOCK AND UNLOCK DOORS. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS NOT INSPECTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 57,000. THE CURRENT MILEAGE WAS 60,000.
DOOR LOCK ON THE DRIVER'S SIDE REAR DOESN'T NOT WANT TO LOCK. CANNOT LOCK THE DOOR BY PUSHING THE DOOR LOCK BUTTON ON THE KEY FOB OR LOCK BUTTON INSIDE THE CAR. *TR
THE DASHBOARD ON MY 2009 TAHOE HAS CRACKED IN THREE DIFFERENT PLACES AND TWO OF THESE CRACKS ARE LOCATED NEAR THE PASSENGER AIRBAG. I HAVE CONCERNS ABOUT EXPANDED CRACKING AND ULTIMATELY A PROBLEM OCCURRING WITH THAT AIRBAG. *TR
Official recalls
521V050000 · Air Bags:frontal:passenger Side:inflator Module
Feb 5, 2021
General Motors, LLC (GM) is recalling certain 2007-2011 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL, and 2009-2011 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500 and Sierra 3500 vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2007-2008 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 22, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on March 1, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328760.
21V052000 · Air Bags:frontal:passenger Side:inflator Module
Feb 5, 2021
General Motors, LLC (GM) is recalling certain 2009 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500, Sierra 3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Additionally, GM is recalling certain 2007-2008 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 23, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on September 20, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020, Cadillac customer service at 1-800-458-8006, and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328780.
21V053000 · Air Bags:frontal:passenger Side:inflator Module
Feb 5, 2021
General Motors, LLC (GM) is recalling certain 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2010 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Additionally, GM is recalling certain 2009 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C."
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 24, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on May 11, 2021. Owners may contact Cadillac customer service at 1-800-458-8006; Chevrolet customer service at 1-800-222-1020; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328790.
10V240000 · Electrical System
Jun 4, 2010
GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.
Consequence & remedy
Consequence: IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.
Remedy: DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
09V154000 · Fuel System, Gasoline
May 6, 2009
GM IS RECALLING 27,188 MY 2009 CADILLAC ESCALADE, ESCALADE HYBRID, ESCALADE ESV, AND ESCALADE EXT; CHEVROLET AVALANCHE, SUBURBAN, TAHOE, TAHOE HYBRID, AND COLORADO; AND GMC YUKON, YUKON HYBRID, YUKON XL, AND CANYON VEHICLES. THE FUEL SYSTEM CONTROL MODULES MAY HAVE A CONDITION IN WHICH AN ADHESIVE SEPARATION OF THE ROOM TEMPERATURE VULCANIZING (RTV) SEAL BETWEEN THE SEAL AND THE HOUSING MAY ALLOW WATER TO SEEP INTO THE MODULE.
Consequence & remedy
Consequence: WATER IN THE MODULE COULD CAUSE A SHORT OR OPEN CIRCUIT, ILLUMINATION OF THE SERVICE ENGINE SOON LAMP, SETTING OF DIAGNOSTIC TROUBLE CODES OR THE ENGINE MAY BE HARD TO START, MAY NOT START OR MAY STALL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A NEW FUEL SYSTEM CONTROL MODULE FREE OF CHARGE. THE RECALL BEGAN ON MAY 18, 2009. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463 OR AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Illustration