← New search

2013 Chevrolet Sonic

Owner reports · Recalls · Investigations

More warning signs than most Sonic years

Owner complaints for the 2013 Chevrolet Sonic are substantially higher than the model-year median of 42.5.

About this comparison →

When problems were reported

Mileage at the reported incident

165 reports with mileage · 52 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 55 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Power Train. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

24 crash reports4 fire reports15 injury reports

What owners actually said

217 reports
57,700 miles · Oct 7, 2016
Air BagsElectrical SystemCrashInjury

TL* THE CONTACT OWNS A 2013 CHEVROLET SONIC. WHILE PULLING OUT OF A PARKING LOT ONTO THE ROAD TO GET IN A TURNING LANE, ANOTHER VEHICLE CRASHED INTO THE FRONT DRIVER'S SIDE OF THE CONTACT'S VEHICLE. THE FRONT DRIVER'S SIDE WHEEL FRACTURED AND THE KEY WAS UNABLE TO BE REMOVED FROM THE IGNITION. THE DRIVER SUSTAINED WHIPLASH AND …

Read full complaint

TL* THE CONTACT OWNS A 2013 CHEVROLET SONIC. WHILE PULLING OUT OF A PARKING LOT ONTO THE ROAD TO GET IN A TURNING LANE, ANOTHER VEHICLE CRASHED INTO THE FRONT DRIVER'S SIDE OF THE CONTACT'S VEHICLE. THE FRONT DRIVER'S SIDE WHEEL FRACTURED AND THE KEY WAS UNABLE TO BE REMOVED FROM THE IGNITION. THE DRIVER SUSTAINED WHIPLASH AND MINOR BRUISING. THE FRONT PASSENGER FLEW INTO THE FRONT WINDSHIELD. THE GEAR SHIFTER FRACTURED WHEN THE FRONT PASSENGER WAS IMPACTED BY THE FORCE OF THE CRASH. AN ADULT PASSENGER IN THE REAR OF THE VEHICLE AND TWO CHILDREN PASSENGERS SUSTAINED WHIPLASH. MEDICAL ATTENTION WAS RECEIVED. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A YARD. THE MANUFACTURER INVESTIGATED THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 57,700. THE VEHICLE WAS TOTALED. UPDATED 11/16/16.*JB

NHTSA ODI #10914440

10,000 miles · Oct 3, 2016
Fuel/propulsion System

TL* THE CONTACT OWNS A 2013 CHEVROLET SONIC. AFTER THE VEHICLE WAS FUELED, IT FAILED TO START. THE DEALER STATED THAT THE VEHICLE WAS OUT OF WARRANTY. THE VEHICLE WAS NOT REPAIRED. THE CONTACT REPLACED THE FUEL TOP, BUT THE ISSUE STILL PERSISTED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 10,000.

NHTSA ODI #10911255

38,000 miles · Sep 12, 2016
Power Train

AUTOMATIC SHIFTER BUTTON REMAINS IN DEPRESSED POSITION, EVEN WHEN VEHICLE IS IN PARK, 1) PREVENTING REMOVAL OF KEY AND 2) ALLOWING FREE MOVEMENT FROM PARK TO REVERSE, DRIVE, NEUTRAL OR VICE VERSA. STATIONARY, WHENEVER I PARK. AFTER SOME MINUTES THE BUTTON MAY POP OUT, BUT PROBLEM IS GETTING WORSE.

NHTSA ODI #10905760

17,889 miles · Sep 6, 2016
Service Brakes

TL* THE CONTACT OWNS A 2013 CHEVROLET SONIC. THE CONTACT STATED THAT THE REAR FAILED TWICE. THE DEALER DIAGNOSED THAT THE REAR BRAKES NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 17,889. THE VIN WAS NOT AVAILABLE.

NHTSA ODI #10903914

65,000 miles · Aug 19, 2016
Electrical SystemElectronic Stability Control (esc)Steering

I'VE HAD THIS CAR FOR ONLY 2 YEARS AND THERE IS ALWAYS SOMETHING WRONG. FIRST I WAS DRIVING AND IT JUST SHUT OFF ALL THE LIGHT ON DASH BOARD WENT OFF AND FROM THAT POINT ON NOTHING ON THE STEERING WHEEL WORKS. NO HORN AND NONE OF THE CONTROLS OF IT ARE WORKING. MY PASSENGER AIR BAG LIGHT STAYS ON. BEEN IN THE SHOP 3 TIMES STILL …

Read full complaint

I'VE HAD THIS CAR FOR ONLY 2 YEARS AND THERE IS ALWAYS SOMETHING WRONG. FIRST I WAS DRIVING AND IT JUST SHUT OFF ALL THE LIGHT ON DASH BOARD WENT OFF AND FROM THAT POINT ON NOTHING ON THE STEERING WHEEL WORKS. NO HORN AND NONE OF THE CONTROLS OF IT ARE WORKING. MY PASSENGER AIR BAG LIGHT STAYS ON. BEEN IN THE SHOP 3 TIMES STILL NOT WORKING. NOW THE WARNING LIGHT OF OVER HEATING COME ON EVERYTIME I HAVE TO STILL IN TRAFFIC ON MY WAY HOME OR DRIVING FOR A OVER AN HOUR, HAVE TO TURN THE HEATER ON, ON HIGH TO GET THE LIGHT AND WARNING BEEPING TO STOP. IT'S ALREADY 90, BUT IF I DON'T THE CAR START SHAKING. THE REASON I BOUGHT A NEWER CAR WAS TO NOT HAVE TO PUT IT ON THE SHOP EVERY 4 MONTHS. SO NO HORN, CRUISE CONTROL, NOT SURE IF AIR BAG WORK ON PASSENGER SIDE AND TO TOP IT OFF HAVE TO RIDE WITH THE HEAT ON WHILE IT'S 90OUTSIDE TO MAKE IT HOME SAFE, ,(I THINK,,).. I CALL GM CUSTOMER SERVICES OVER AND OVER AGAIN, AND THEY TELL ME THERE IS NOT OTHER PROBLEMS WITH OTHER CARS. MY WARRANTY IS EXPIRED. SO IT'S ON ME.

NHTSA ODI #10897297

67,000 miles · Aug 11, 2016
Electrical System

TL* THE CONTACT OWNS A 2013 CHEVROLET SONIC. THE CONTACT STATED THAT THE RADIO AND THE AUDIBLE TURN INDICATOR FAILED TO OPERATE WHEN ACTIVATED. DUE TO THE FAILURES, THE BATTERY BECAME INOPERABLE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 12V454000 (ELECTRICAL SYSTEM, EXTERIOR LIGHT…

Read full complaint

TL* THE CONTACT OWNS A 2013 CHEVROLET SONIC. THE CONTACT STATED THAT THE RADIO AND THE AUDIBLE TURN INDICATOR FAILED TO OPERATE WHEN ACTIVATED. DUE TO THE FAILURES, THE BATTERY BECAME INOPERABLE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 12V454000 (ELECTRICAL SYSTEM, EXTERIOR LIGHTING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 67,000.

NHTSA ODI #10895093

45,245 miles · Aug 9, 2016
Unknown Or Other

SHIFT BUTTON STICKING. KEY STUCK IN THE IGNITION UNABLE TO REMOVE . CAR CAN NOT BE PUT ON FULL PARK WHICH IS CAUSING ENGINE AND BATTERY TO FAIL. ELECTRONIC KEY RELEASE NOT WORKING. THIS IS A HUGE SAFETY ISSUE AS THE PARK CAN EASILY MOVE BECUASE IT'S NOT FULLY PARKED DUE TO IGNITION KEY FAILIURE. THIS IS A MANUFACTURER DEF…

Read full complaint

SHIFT BUTTON STICKING. KEY STUCK IN THE IGNITION UNABLE TO REMOVE . CAR CAN NOT BE PUT ON FULL PARK WHICH IS CAUSING ENGINE AND BATTERY TO FAIL. ELECTRONIC KEY RELEASE NOT WORKING. THIS IS A HUGE SAFETY ISSUE AS THE PARK CAN EASILY MOVE BECUASE IT'S NOT FULLY PARKED DUE TO IGNITION KEY FAILIURE. THIS IS A MANUFACTURER DEFECT BUT THERE HASN'T BEEN A RECALLED SO WE HAD TO PAY OUT OF POCKET TO FIX.

NHTSA ODI #10894335

Mileage unknown · Aug 8, 2016
Electronic Stability Control (esc)EngineUnknown Or Other

WHILE DRIVING MY CAR FOR THE PAST YEAR NOW I HAVE NOTICED MY RPM GAUGE STICKING AND REVVING ON ITS OWN. IT IS STARTING TO HAPPEN MORE CONSISTENTLY. WHEN I'M DRIVING DOWNHILL THE RPM GAUGE WILL REV HIGH AND STAY STUCK HIGH. THEN WHEN I PUT THE CAR IN PARK IT WILL REV HIGH ON ITS OWN AND STAY STUCK AND EVENTUALLY COME BACK DOWN. S…

Read full complaint

WHILE DRIVING MY CAR FOR THE PAST YEAR NOW I HAVE NOTICED MY RPM GAUGE STICKING AND REVVING ON ITS OWN. IT IS STARTING TO HAPPEN MORE CONSISTENTLY. WHEN I'M DRIVING DOWNHILL THE RPM GAUGE WILL REV HIGH AND STAY STUCK HIGH. THEN WHEN I PUT THE CAR IN PARK IT WILL REV HIGH ON ITS OWN AND STAY STUCK AND EVENTUALLY COME BACK DOWN. SOMETHING NEW I HAVE STARTED TO EXPERIENCE IS WHEN I'M AT A COMPLETE STOP THE RPM GAUGE WILL START REVVING UP AND DOWN ON IT'S OWN WHILE MY CAR LIGHTS BRIGHTEN AND DIM AND MY WARNING LIGHT COMES ON THAT I'M SLIDING WHICH IS IMPOSSIBLE SINCE I'M AT A COMPLETE STOP. I HAVE ALSO NOTICED THE TRANSMISSION HAS STARTED TO FEEL JERKY LATELY WITH EVERYTHING ELSE. I JUST PURCHASED THIS VEHICLE ALMOST 2 YEARS AGO AND I ONLY HAVE 58,000 MILES ON IT.

NHTSA ODI #10894186

Mileage unknown · Aug 8, 2016
Power Train

WHEN SHIFTING GEARS, THE BUTTON MECHANISM WILL NOT RELEASE ONCE THE LEVER IS IN THE DESIRED GEAR, MAKING THE SHIFT ITSELF PRONE TO SLIDING BETWEEN THE DIFFERENT GEARS AND PUTTING THE DRIVER AT RISK FOR ACCIDENTS. THERE IS ALSO A SPECIFIC ISSUE WITH THE SHIFT WHEN THE LEVER IS PLACED IN "PARK" POSITION; THE KEY CANNOT BE RELEASED…

Read full complaint

WHEN SHIFTING GEARS, THE BUTTON MECHANISM WILL NOT RELEASE ONCE THE LEVER IS IN THE DESIRED GEAR, MAKING THE SHIFT ITSELF PRONE TO SLIDING BETWEEN THE DIFFERENT GEARS AND PUTTING THE DRIVER AT RISK FOR ACCIDENTS. THERE IS ALSO A SPECIFIC ISSUE WITH THE SHIFT WHEN THE LEVER IS PLACED IN "PARK" POSITION; THE KEY CANNOT BE RELEASED BY THE IGNITION.

NHTSA ODI #10893884

44,000 miles · Jul 28, 2016
EngineService BrakesSuspension

CAR SHAKES VERY BAD WHEN DRIVING AND APPROACHING A STOP.

NHTSA ODI #10889356

Official recalls

6

23V516000 · Air Bags:frontal:driver Side:inflator Module

Jul 27, 2023

General Motors, LLC (GM) is recalling certain 2013 Buick Verano, Chevrolet Camero, Sonic, and Volt vehicles. The driver-side air bag inflator may explode during deployment due to a manufacturing defect.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy: Dealers will replace the driver-side air bag module, free of charge. On some 2013 Volt vehicles, the steering wheel will be replaced as well, free of charge. Owner notification letters were mailed October 23, 2023. Owners may contact Buick customer service at 1-800-521-7300 and Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N232413120.

16V257000 · Electrical System:software; Equipment:electrical:radio/tape Deck/cd Etc.

Apr 28, 2016

General Motors LLC (GM) is recalling certain model year 2013-2016 Chevrolet Sonic and Trax vehicles and 2013-2015 Chevrolet Spark vehicles equipped with a Bring Your Own Media radio. The affected radios may fail to provide an audible warning chime when the driver, after turning off the ignition and leaving the key in the cylinder, waits 10 minutes or longer to open the door. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114 "Theft Protection."

Consequence & remedy

Consequence: Without audible indicators, the driver may leave the key in the ignition, increasing the risk of theft.

Remedy: GM will notify owners, and dealers will update the radio software, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 17130.

Additional source detail variants (2)

Electrical System:software

General Motors LLC (GM) is recalling certain model year 2013-2016 Chevrolet Sonic and Trax vehicles and 2013-2015 Chevrolet Spark vehicles equipped with a Bring Your Own Media radio. The affected radios may fail to provide an audible warning chime when the driver, after turning off the ignition and leaving the key in the cylinder, waits 10 minutes or longer to open the door. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114 "Theft Protection."

Consequence: Without audible indicators, the driver may leave the key in the ignition, increasing the risk of theft.

Remedy: GM will notify owners, and dealers will update the radio software, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 17130.

Equipment:electrical:radio/tape Deck/cd Etc.

General Motors LLC (GM) is recalling certain model year 2013-2016 Chevrolet Sonic and Trax vehicles and 2013-2015 Chevrolet Spark vehicles equipped with a Bring Your Own Media radio. The affected radios may fail to provide an audible warning chime when the driver, after turning off the ignition and leaving the key in the cylinder, waits 10 minutes or longer to open the door. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114 "Theft Protection."

Consequence: Without audible indicators, the driver may leave the key in the ignition, increasing the risk of theft.

Remedy: GM will notify owners, and dealers will update the radio software, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 17130.

14V417000 · Equipment:electrical

Jul 2, 2014

General Motors LLC (GM) is recalling certain model year 2013-2014 Buick Encore all-wheel-drive vehicles manufactured August 23, 2012, to September 9, 2013; Verano vehicles manufactured August 8, 2012, to June 20, 2013; Chevrolet Cruze vehicles manufactured August 7, 2012, to August 16, 2013, and 2012-2014 Chevrolet Sonic vehicles manufactured May 10, 2011, to August 16, 2012 equipped with a Calix oil pan/block heater. In cold temperatures, the insulation on the engine block heater cord can become damaged, allowing the wires to be exposed.

Consequence & remedy

Consequence: Exposed wires increase the risk of electrical shock and personal injury if the cord is handled while it is plugged in.

Remedy: GM will notify owners, and dealers will replace the engine oil pan/block heater cord with a new cord that is rated for temperatures of minus 40 degree Celsius. The recall began in August 2014. Owners may contact Buick customer service at 1-800-521-7300 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14257.

13V464000 · Fuel System, Gasoline:storage:tank Assembly:mounting

Sep 26, 2013

General Motors (GM) is recalling certain model year 2013 and 2014 Chevrolet Sonic vehicles manufactured August 2, 2013, through August 12, 2013. Due to insufficient welds, the front fuel tank strap bracket may separate from the vehicle.

Consequence & remedy

Consequence: If the front fuel tank strap bracket separates, the increased load may lead to the failure of the other tank support. As a result, the fuel tank may come loose from the vehicle causing a fuel leak. A fuel leak, in the presence of an ignition source, may result in a fire.

Remedy: GM will notify owners, and dealers will inspect the front fuel tank strap bracket, and repair it as necessary, free of charge. The recall began on November 7, 2013. Owners may contact GM at 1-800-521-7300. GM's recall campaign number is 13296.

13V220000 · Electrical System; Exterior Lighting:brake Lights

May 24, 2013

General Motors LLC (GM) is recalling certain model year 2013 Cadillac ATS and model year 2013 Cadillac XTS; model year 2014 Chevrolet Impala; and 2013 Chevrolet Sonic vehicles. Originally, in May 2013, GM recalled 1,627 model year 2013 Cadillac ATS and model year 2013 Cadillac XTS; and model year 2014 Chevrolet Impala vehicles. In October 2013, GM informed the agency that it was adding model year 2013 Chevrolet Sonic vehicles to this campaign , representing an additional 8,050 units. The total number of vehicles being recalled is now 9,677. On the affected vehicles, the brake lamps may intermittently flash without the brakes being applied and the cruise control may disengage. Thus, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, reflective devices, and associated equipment."

Consequence & remedy

Consequence: If the brake lamps flash when the vehicle is not slowing, a following driver may not adjust vehicle speed when the vehicle is in fact braking, and the brake lamps are illuminating as intended, increasing the risk of a crash.

Remedy: GM will notify owners, and dealers will reprogram the body control module. The recall began on June 13, 2013. Owner's may contact Chevrolet at 1-800-630-2438 or Cadillac at 1-866-982-2339. GM's recall number is 13158.

Additional source detail variants (2)

Exterior Lighting:brake Lights

General Motors LLC (GM) is recalling certain model year 2013 Cadillac ATS and model year 2013 Cadillac XTS; model year 2014 Chevrolet Impala; and 2013 Chevrolet Sonic vehicles. Originally, in May 2013, GM recalled 1,627 model year 2013 Cadillac ATS and model year 2013 Cadillac XTS; and model year 2014 Chevrolet Impala vehicles. In October 2013, GM informed the agency that it was adding model year 2013 Chevrolet Sonic vehicles to this campaign , representing an additional 8,050 units. The total number of vehicles being recalled is now 9,677. On the affected vehicles, the brake lamps may intermittently flash without the brakes being applied and the cruise control may disengage. Thus, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, reflective devices, and associated equipment."

Consequence: If the brake lamps flash when the vehicle is not slowing, a following driver may not adjust vehicle speed when the vehicle is in fact braking, and the brake lamps are illuminating as intended, increasing the risk of a crash.

Remedy: GM will notify owners, and dealers will reprogram the body control module. The recall began on June 13, 2013. Owner's may contact Chevrolet at 1-800-630-2438 or Cadillac at 1-866-982-2339. GM's recall number is 13158.

Electrical System

General Motors LLC (GM) is recalling certain model year 2013 Cadillac ATS and model year 2013 Cadillac XTS; model year 2014 Chevrolet Impala; and 2013 Chevrolet Sonic vehicles. Originally, in May 2013, GM recalled 1,627 model year 2013 Cadillac ATS and model year 2013 Cadillac XTS; and model year 2014 Chevrolet Impala vehicles. In October 2013, GM informed the agency that it was adding model year 2013 Chevrolet Sonic vehicles to this campaign , representing an additional 8,050 units. The total number of vehicles being recalled is now 9,677. On the affected vehicles, the brake lamps may intermittently flash without the brakes being applied and the cruise control may disengage. Thus, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, reflective devices, and associated equipment."

Consequence: If the brake lamps flash when the vehicle is not slowing, a following driver may not adjust vehicle speed when the vehicle is in fact braking, and the brake lamps are illuminating as intended, increasing the risk of a crash.

Remedy: GM will notify owners, and dealers will reprogram the body control module. The recall began on June 13, 2013. Owner's may contact Chevrolet at 1-800-630-2438 or Cadillac at 1-866-982-2339. GM's recall number is 13158.

12V454000 · Electrical System; Exterior Lighting:turn Signal

Sep 17, 2012

General Motors LLC (GM) is recalling certain model year 2013 Chevrolet Sonic vehicles manufactured from May 29, 2012, through August 29, 2012. When a turn signal lamp fails to operate, the Body Control Module (BCM) in these vehicles does not detect this condition and will not indicate the condition to the driver. Thus, These vehicles fail to conform to Federal Motor Vehicle Safety Standard No. 108, "Lamps, Reflective Devices, and Associated Equipment."

Consequence & remedy

Consequence: If the driver is not aware that the turn signal is not functioning and does not have the light repaired, other drivers may not be alerted that the vehicle is turning, increasing the risk of a crash.

Remedy: GM will notify owners, and dealers will reprogram the BCM and the vehicle's key fobs, free of charge. The safety recall began on October 3, 2012. Owners may contact the Chevrolet owner center at 1-866-694-6546.

Additional source detail variants (2)

Exterior Lighting:turn Signal

General Motors LLC (GM) is recalling certain model year 2013 Chevrolet Sonic vehicles manufactured from May 29, 2012, through August 29, 2012. When a turn signal lamp fails to operate, the Body Control Module (BCM) in these vehicles does not detect this condition and will not indicate the condition to the driver. Thus, These vehicles fail to conform to Federal Motor Vehicle Safety Standard No. 108, "Lamps, Reflective Devices, and Associated Equipment."

Consequence: If the driver is not aware that the turn signal is not functioning and does not have the light repaired, other drivers may not be alerted that the vehicle is turning, increasing the risk of a crash.

Remedy: GM will notify owners, and dealers will reprogram the BCM and the vehicle's key fobs, free of charge. The safety recall began on October 3, 2012. Owners may contact the Chevrolet owner center at 1-866-694-6546.

Electrical System

General Motors LLC (GM) is recalling certain model year 2013 Chevrolet Sonic vehicles manufactured from May 29, 2012, through August 29, 2012. When a turn signal lamp fails to operate, the Body Control Module (BCM) in these vehicles does not detect this condition and will not indicate the condition to the driver. Thus, These vehicles fail to conform to Federal Motor Vehicle Safety Standard No. 108, "Lamps, Reflective Devices, and Associated Equipment."

Consequence: If the driver is not aware that the turn signal is not functioning and does not have the light repaired, other drivers may not be alerted that the vehicle is turning, increasing the risk of a crash.

Remedy: GM will notify owners, and dealers will reprogram the BCM and the vehicle's key fobs, free of charge. The safety recall began on October 3, 2012. Owners may contact the Chevrolet owner center at 1-866-694-6546.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

1

EA21002 · Desiccated Air Bag Inflator Rupture

Opened Sep 17, 2021 · No close date supplied

Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Additional source detail variants (2)

Air Bags:frontal:driver Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.