2005 Chevrolet Silverado

ATTEMPTED TO STOP AT STOP SIGN AND BAKE LINE BETWEEN MASTER CYLINDER AND PROP VALVE RUPTURED INSTANTLY DRAINING BRAKE FLUID RESULTING IN NO BRAKING. STOPPED VEHICLE WITH PARKING BRAKE. UPON INSPECTION, DETERMINED THAT BRAKE LINE HAD RUSTED OUT AS A RESULT OF BEING MOUNTED ON TOP OF FRAME RAIL WHERE DIRT, SALT AND MOISTURE COLLECT FROM FRONT WHEEL SPRAY. *TR

WHILE DOING AN OIL CHANGE ON MY 2005 PU I NOTICED ENOUGH BUILDUP OF RUST ON THE BRAKE LINES THAT I STOPPED DRIVING THE TRUCK. I HAVE HAD PU TRUCKS (FORD) SINCE 1972 AND NEVER HAD AN ISSUE WITH BRAKE LINES ALTHOUGH I HAD THE TRUCKS FOR 10 YRS. THIS IS A SERIOUS ISSUE OF NEGLIGENCE OF GM. I AM 75 AND NEVER HAD THIS ISSUE ALTHOUGH I HAD CARS AND TRUCKS (AND MOTORCYCLES) SINCE I WAS 16. I BELIEVE THIS IS MORE SERIOUS THAN IGNITION SWITCH. THANK YOU *JS

APPROACHING A TRAFFIC LIGHT AT THE BOTTOM OF A STEEP GRADED HIGHWAY, I NOTICED THE BRAKE PEDAL FELT SPUNGEY AND NEAR THE BOTTOM THE BRAKE PEDAL WENT CLEAR TO THE FLOOR BOARD. I WAS FORCED TO LEAVE THE HIGHWAY TO PREVENT A REAR END COLLISION WITH THE STOPPED VEHICLE IN FRONT OF ME RESULTING IN NO REAL DAMAGE TO THE VEHICLE ITSELF. IT COULD HAVE BEEN MUCH WORSE. THE BRAKE LINES (4 OF THEM) HAVE RUSTED OUT SO MUCH THAT THEY COULD NOT CONTAIN PRESSURE OF THE FLUID WHEN APPLYING THE BRAKE AND BURSTED. MY MECHANIC TELLS ME THIS WILL BE IN EXCESS OF $600.00 TO REPAIR DO TO THE CAB HAVING TO BE UNBOLTED AND LIFTED FROM THE CHASSIS TO ACCESS THE LINES FOR REPLACING. HE ALSO TELLS ME THAT MANY GM MODELS, NEW AND OLD HAVE THIS PROBLEM WITH RUSTING BRAKE LINES. GM IS AWARE OF THESE PROBLEMS. WHY HAS THIS NOT BEEN ADDRESSED? WHY HAVE THESE MODELS NOT BEEN RECALLED? SUBARU RECENTLY RECALLED OVER 660,000 VEHICLES FOR THE SAME PROBLEM; #DOINGTHERIGHTTHING. I AM NOT AT ALL HAPPY ABOUT THIS. *JS

WHILE DOING AN OIL CHANGE ON MY 2005 PU SILVERADO I NOTICED LARGE RUST BUILD UP ON THE BRAKE LINES' THIS IS NOT THROUGH NEGLECT ON MY PART, BUT IS SUFFICIENT ENOUGH TO CAUSE SERIOUS CONCERN. MY SON IN LAW WITH CHEVY 2002 HAD A SIMILAR PROBLEM WHEN HIS BRAKES FAILED ON A HILL WHICH CAUSED ME TO CHECK MINE.THIS IS EXTREMELY DANGEROUS AND GM SHOULD BEAR THE RECALL EXPENSE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

DRIVING DOWN HIGHWAY ROAD WHEN SEVERAL DEER RAN IN FRONT OF VEHICLE. SLAMMED ON BRAKES AND THE PEDAL, AFTER A FEW SECONDS, WENT TO THE FLOOR. NOTICED BIG PUDDLE OF FLUID THE NEXT DAY UNDER CAB OF TRUCK. STARTED TRUCK AND HAD NO BRAKES AT ALL. HAD THE TRUCK INSPECTED BY LOCAL REPAIR SHOP AND WAS INFORMED THAT ALL OF THE BRAKE LINES WERE RUSTY BEYOND THE POINT OF REPAIR. HAD TO HAVE A WHOLE NEW BRAKE LINE KIT INSTALLED. *TR

THE TRUCK HAS 110K MILES ON THE DURAMAX / ALLISON DRIVE TRAIN. THE DIESEL FUEL INJECTION PUMP FAILED UNEXPECTEDLY AND WITHOUT WARNING. THIS POWERTRAIN COMBINATION SHOULD BE CAPABLE OF 500K MILES WITHOUT PROBLEMS LIKE THIS. THIS PUMP SHOULD NOT FAIL AFTER NORMAL USE IN ONLY 110K MILES. NOTHING BUT EXCUSES AND OTHER NOT POSSIBLE REASONS FOR THE POOR ENGINEERING AND MANUFACTURING EXHIBITED IN THEIR PRODUCT. THEY SAID THE METHANOL WATER INJECTION SYSTEM CAUSED THE FUEL INJECTION PUMP TO FAIL. METHANOL (NON CAUSTIC FLUID) IS INJECTED AIR SIDE OF THE ENGINE AND DOES NOT MIX WITH THE INJECTED FUEL UNTIL THE ENGINE CYLINDER. THE FUEL INJECTION PUMP SUPPLIES FUEL TO THE INDIVIDUAL INJECTORS THAT THEN IN TURN SUPPLIES THE HIGH PRESSURE FUEL TO THE CYLINDERS. IF THIS CONDITION WAS TO HAPPEN ON THE ROAD PULLING A TRAILER / HEAVY LOAD IN HILLS OR OTHER CONFINED ROADWAYS PEOPLE COULD BE INJURED OR KILLED BY THE SUDDEN LOSS OF POWER AND CONTROL. GM BUSINESS PRACTICES ARE GOING TO CONTINUE TO KILL AND HURT PEOPLE. *TR

HAD TO ADD COOLANT OVER A TIME.....NO EVIDENCE OF A LEAK ON MY DRIVEWAY OR ANY OTHER PLACE. STARTED TRUCK ONE MORNING AND HEARD CLICKING NOISE COMING FROM ENGINE. I OBSERVED WATER COMING FROM THE MUFFLER. TOOK VEHICLE TO DEALER ON APRIL 22, 2014. ( MILEAGE 84241) DEALER FOUND BLOWN HEAD GASKET AND SEALS, ONE CRACKED HEAD AND WATER IN OIL. REPAIRS DONE: COMPLETE VALVE JOB (REPLACE HEAD GASKET, SEALS & OTHER ASSOCIATED PARTS), REPLACE BROKEN BOLTS, REPLACE COOLANT HOSES, RADIATOR & HEATER HOSES AND THERMOSTAT ETC.. WAS NOT ADVISED BY SERVICE CONSULTANT OF ANY RECALLS OR BULLETINS FOR 2005 SILVERADO. THIS IS LOW MILEAGE FOR THIS KIND OF ENGINE PROBLEM. REPAIR COST: $3683.92 MARTIN CHEVROLET *** TORRANCE, CALIF. *TR