COMING HOME AFTER A NIGHT OF BOWLING WITH A TRUCK FULL OF KIDS. I COULD FEEL AND HEAR A GRINDING NOISE COMING FROM THE FRONT END. I THOUGHT IT WAS MY BRAKES UNTIL I GOT BACK INTO TOWN. WHEN I HIT THE BRAKES AND MOVED THE STEERING WHEEL BACK AND FORTH I COULD I KNEW IT WASN'T MY BRAKES. I TOOK THE FRONT TIRE OFF THE NEXT DAY AND …
Read full complaint
COMING HOME AFTER A NIGHT OF BOWLING WITH A TRUCK FULL OF KIDS. I COULD FEEL AND HEAR A GRINDING NOISE COMING FROM THE FRONT END. I THOUGHT IT WAS MY BRAKES UNTIL I GOT BACK INTO TOWN. WHEN I HIT THE BRAKES AND MOVED THE STEERING WHEEL BACK AND FORTH I COULD I KNEW IT WASN'T MY BRAKES. I TOOK THE FRONT TIRE OFF THE NEXT DAY AND I COULD WIGGLE THE WHEEL HUB BACK AND FORTH. VERY DANGEROUS. I FEEL LUCKY THAT NOBODY GOT HURT. THE ROAD I TRAVELED HOME WAS HWY 32 AND IT HAS ALOT OF CURVES. THIS SHOULD BE ADDRESSED. EVERY CHEVY THAT HAS THIS PROBLEM SHOULD BE NOTIFIED. IM A BACK YARD MECHANIC. I KNEW SOMETHING WAS WRONG. WHAT HAPPENS WITH THE SINGLE MOTHER WHO KNOWS NOTHING ABOUT THIS STUFF. SHE'S GOING TO BE LUCKY IF SHE DOESN'T GET IN AN ACCIDENT OR WORSE YET. KILLED! *TR
NHTSA ODI #10499881
31,000 miles · Dec 20, 2012
Steering
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. WHILE DRIVING APPROXIMATELY 25 MPH, THE CONTACT NOTICED A CLUNKING NOISE FROM THE STEERING WHEEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MECHANIC ADVISED THAT THE INTERMEDIATE STEERING SHAFT WOULD HAVE TO BE REPLACED. THERE WAS A RECALL UNDER …
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. WHILE DRIVING APPROXIMATELY 25 MPH, THE CONTACT NOTICED A CLUNKING NOISE FROM THE STEERING WHEEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MECHANIC ADVISED THAT THE INTERMEDIATE STEERING SHAFT WOULD HAVE TO BE REPLACED. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 05V018000 (STEERING:GEAR BOX:SHAFT SECTOR) THAT THE CONTACT BELIEVED WAS RELATED TO THE FAILURE. THE MANUFACTURER WAS CONTACTED AND ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 31,000.
NHTSA ODI #10489361
67,000 miles · Jul 20, 2011
Steering
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED WHILE DRIVING OVER A BUMP IN THE ROAD AND TURNING THE STEERING WHEEL THE VEHICLE MADE A LOUD CLANKING SOUND. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAI…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED WHILE DRIVING OVER A BUMP IN THE ROAD AND TURNING THE STEERING WHEEL THE VEHICLE MADE A LOUD CLANKING SOUND. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 67,000.
NHTSA ODI #10413756
72,000 miles · Mar 26, 2009
Steering
CLUNKING NOISE AND VIBRATION IN STEERING WHEEL ON 2005 CHEVY SILVERADO. THIS HAPPENS EVERY TIME YOU TURN OR HIT A BUMP IN THE ROAD. GM STATES THAT THIS IS NOT CONSIDERED A SAFETY ISSUE, HOWEVER I DISAGREE. ANY UNEXPECTED VIBRATION OR CLUNK IN THE STEERING MECHANISM WHILE DRIVING PRESENTS A DANGEROUS SITUATION. GM KNOWS THIS …
Read full complaint
CLUNKING NOISE AND VIBRATION IN STEERING WHEEL ON 2005 CHEVY SILVERADO. THIS HAPPENS EVERY TIME YOU TURN OR HIT A BUMP IN THE ROAD. GM STATES THAT THIS IS NOT CONSIDERED A SAFETY ISSUE, HOWEVER I DISAGREE. ANY UNEXPECTED VIBRATION OR CLUNK IN THE STEERING MECHANISM WHILE DRIVING PRESENTS A DANGEROUS SITUATION. GM KNOWS THIS TO BE A WIDE SPREAD PROBLEM ON A NUMBER OF VEHICLES, HOWEVER THEY CONTINUE TO TURN A BLIND EYE. APPARENTLY THE INTERMEDIATE STEERING SHAFT IS THE CENTER OF THE PROBLEM AND GM NEEDS TO ISSUE A RECALL ON THIS PART AT ONCE. SO FAR NOTHING HAS BEEN DONE TO CORRECT THIS ISSUE ON MY VEHICLE AND GM SEEMS TO BE UNWILLING TO WORK WITH ME TO ATTAIN CORRECTIVE ACTION. I SINCERELY HOPE THAT THE NHTSA WILL REQUIRE GENERAL MOTORS TO FIX THIS PROBLEM BEFORE SOMEONE IS SERIOUSLY INJURED. *TR
NHTSA ODI #10263164
76,000 miles · Oct 7, 2008
Steering
TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO K1500. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT'S WIFE HEARD A CLUNKING SOUND AND NOTICED A DIFFERENCE IN THE STEERING COLUMN. THE CONTACT TOOK THE VEHICLE TO A REPAIR SHOP AND THEY REFERENCED NHTSA CAMPAIGN ID NUMBER 05V018000 (STEERING:GEAR BOX:SHAFT SECTOR). THE DEALER P…
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO K1500. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT'S WIFE HEARD A CLUNKING SOUND AND NOTICED A DIFFERENCE IN THE STEERING COLUMN. THE CONTACT TOOK THE VEHICLE TO A REPAIR SHOP AND THEY REFERENCED NHTSA CAMPAIGN ID NUMBER 05V018000 (STEERING:GEAR BOX:SHAFT SECTOR). THE DEALER PERFORMED A DIAGNOSTIC AND RECOMMENDED THAT THE INTERMEDIATE STEERING SHAFT BE REPLACED. THE VIN WAS NOT INCLUDED IN THE RECALL; THEREFORE, THE REPAIR WOULD NOT BE MADE FOR FREE. THE MANUFACTURER HAS NOT BEEN NOTIFIED. THE CURRENT MILEAGE WAS 80,943 AND FAILURE MILEAGE WAS APPROXIMATELY 76,000. UPDATED 1/6/09 *CN UPDATED 01/14/09.*JB
NHTSA ODI #10244661
23,000 miles · Oct 28, 2007
Steering
GM CONTINUES TO IGNORE THE FACT THAT CERTAIN MODEL VEHICLES HAVE A INTERMEDIATE STEERING SHAFT PROBLEM. IT IS A WELL KNOWN AND FAIRLY COMMON FACT. THEY CURRENTLY HAVE A REPLACEMENT PART THAT WILL REMEDY THE PROBLEM BUT REFUSE TO ISSUE A RECALL FOR THIS PROBLEM. *TR
NHTSA ODI #10207255
17,741 miles · Aug 23, 2007
Service Brakes, HydraulicSteering
2005 SILVERADO WITH BRAKE PROBLEMS CUSTOMER STATES THAT THIS IS A SAFETY DEFECT**CC THE CONSUMER STATED APPROACHED A STOP SIGN AND REALIZED THE BRAKES WERE NOT WORKING PROPERLY AND THE POWER ASSIST WAS NOT WORKING. THE CONSUMER LEFT THE VEHICLE WITH THE DEALER FOR 2 DAYS TO ASSESS THE PROBLEM BUT TO NO AVAIL. THE CONSUMER STAT…
Read full complaint
2005 SILVERADO WITH BRAKE PROBLEMS CUSTOMER STATES THAT THIS IS A SAFETY DEFECT**CC THE CONSUMER STATED APPROACHED A STOP SIGN AND REALIZED THE BRAKES WERE NOT WORKING PROPERLY AND THE POWER ASSIST WAS NOT WORKING. THE CONSUMER LEFT THE VEHICLE WITH THE DEALER FOR 2 DAYS TO ASSESS THE PROBLEM BUT TO NO AVAIL. THE CONSUMER STATED HE TOOK THE VEHICLE TO A DEALER WHERE HE HAD PREVIOUS WORK PERFORMED ON THE VEHICLE SUCH AS STEERING, BUT THEY WERE ALSO UNABLE TO DUPLICATE THE PROBLEM. *TR
NHTSA ODI #10201385
Mileage unknown · Jul 14, 2007
Steering
STEERING PROBLEM FREEPLAY OF 1 1/2" OR BETTER AT THE STEERING WHEEL.A CONSTANT CHALLENGE TO KEEP THIS TRUCK BETWEEN THE LINES IN WINDY WEATHER, AND IN HEAVY TRAFFIC. DEALER SAYS THEY HAVE CHANGED PART AFTER PART WITH NO CHANGE. NOW SERVICE MANAGER SAYS THIS IS CHARACTERISTIC OF THE HYDROBOOST STEERING SYSTEM. GM WONT GO PAST WH…
Read full complaint
STEERING PROBLEM FREEPLAY OF 1 1/2" OR BETTER AT THE STEERING WHEEL.A CONSTANT CHALLENGE TO KEEP THIS TRUCK BETWEEN THE LINES IN WINDY WEATHER, AND IN HEAVY TRAFFIC. DEALER SAYS THEY HAVE CHANGED PART AFTER PART WITH NO CHANGE. NOW SERVICE MANAGER SAYS THIS IS CHARACTERISTIC OF THE HYDROBOOST STEERING SYSTEM. GM WONT GO PAST WHAT THIS SERVICE MANAGER IS SAYING. CAN YOU PLEASE HELP!!! *TR
NHTSA ODI #10196368
49,161 miles · May 5, 2007
Steering
VERY HARD TO STEER AT LOW RPM. *TR
NHTSA ODI #10189859
35,000 miles · Feb 15, 2007
Steering
THE EVENTS LEADING UP TO THE REPLACEMENT WERE NOISE IN THE FRONT END WHILE TURNING. NO FAILURE JUST HAD IT CHECKED OUT AND WAS DETERMINED THAT THE STEERING COLUMN SHAFT HAD TO BE REPLACED. *JB
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Consequence & remedy
Consequence: IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC TRUCKS AT 1-866-996-9463.
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS AND BUILT WITH EITHER PBR PARKING BRAKE SYSTEMS OR TRW PARKING BRAKE SYSTEMS, THE PARKING BRAKE FRICTION LININGS MAY WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.
Consequence & remedy
Consequence: IF THE PARKING BRAKE DOES NOT HOLD, UNINTENDED VEHICLE MOVEMENT COULD OCCUR, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH A PBR PARKING BRAKE SYSTEM. ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM, DEALERS WILL INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY. THE RECALL BEGAN ON JULY 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK AND TRANSMISSION BRAKING EFFECT." UNDER CERTAIN VEHICLE STARTING CONDITIONS, THE SHIFT LEVER POSITION INDICATOR LOCATED IN THE INSTRUMENT PANEL CLUSTER MAY NOT ILLUMINATE. IF THE SHIFT LEVER POSITION INDICATOR DOES NOT ILLUMINATE, THE DRIVER MAY NOT KNOW WHICH GEAR THE VEHICLE IS IN.
Consequence & remedy
Consequence: THE VEHICLE MAY MOVE IN AN UNINTENDED DIRECTION RESULTING IN POSSIBLE INJURY TO OTHERS OUTSIDE OF THE VEHICLE.
Remedy: DEALERS WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 14, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, AND GMC AT 1-866-996-9463.
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
ON CERTAIN TRUCKS, THE BOLT THAT ATTACHES THE INTERMEDIATE STEERING SHAFT TO THE STEERING GEAR MAY NOT MEET SPECIFICATION. THE BOLT MAY FRACTURE RESULTING IN THE LOSS OF STEERING.
Consequence & remedy
Consequence: IF THIS HAPPENS WHILE THE VEHICLE IS MOVING, A CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE THE INTERMEDIATE STEERING SHAFT BOLT FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 24, 2005. OWNERS MAY CONTACT GMC AT 1-866-996-9463 AND CHEVROLET AT 1-800-630-2438.
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH 5.3L (RPO L59) V8 ENGINES, THE ENGINE FUEL RAIL CROSSOVER TUBE RETAINER SCREWS WERE NOT MANUFACTURED TO SPECIFICATIONS AND MAY BREAK.
Consequence & remedy
Consequence: IF THE TUBE RETAINER SCREW BREAKS, FUEL COULD LEAK FROM THE FUEL RAIL CROSSOVER JOINT, THE ENGINE MAY STALL AND, IF AN IGNITION SOURCE WERE PRESENT, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE FUEL RAIL CROSSOVER TUBE AND, IF NECESSARY, REPLACE THE RETAINER SCREWS. OWNERS WERE NOTIFIED BY TELEPHONE ON JULY 30, 2004, WITH A FOLLOWUP OWNER LETTER BEGAN AUGUST 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463. NOTE: THE GM BULLETIN LISTS THE TAHOE AND YUKON MODELS BECAUSE CANADIAN VEHICLES ARE INCLUDED IN THE BULLETIN. NO U.S. TAHOE OR YUKON VEHICLES ARE INCLUDED IN THE U.S. CAMPAIGN.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration