The contact owns a 2005 Chevrolet Silverado 1500. The contact stated while driving approximately 50 mph, he lost control of the vehicle due to losing consciousness. The vehicle left the roadway and went airborne and crashed with a road sign landing in a field. None of the airbags deployed and only the seatbelt lap belt tensioned…
Read full complaint
The contact owns a 2005 Chevrolet Silverado 1500. The contact stated while driving approximately 50 mph, he lost control of the vehicle due to losing consciousness. The vehicle left the roadway and went airborne and crashed with a road sign landing in a field. None of the airbags deployed and only the seatbelt lap belt tensioned not the shoulder strap. The contact sustained injuries such as several lacerations across the face and inside the mouth, and broken L1 vertebrae. The contact mentioned he fractured the steering wheel with his face during the impact. A police report was filed and the vehicle was towed to a local lot then towed again to the contacts insurance lot where it was awaiting a diagnosis. The manufacturer was not informed of the failure. The failure mileage was approximately 281,000.
NHTSA ODI #11425653
50,250 miles · Jan 2, 2015
Air Bags
SRS WARNING CAME ON. HAD FAULT CODE. CALLED CHEVY DEALER AND THEY SAID I WOULD NEED A NEW AIRBAG. I RESEARCHED AND FOUND THAT GM DOES KNOW ABOUT THIS AND EVEN PUT OUT A TSB. IT IS A CONNECTOR TO THE AIRBAG ITSELF LOCATED IN THE LEFT KICK PANEL. THE FIX IS TO CLEAN THE CONNECTOR OR REPLACE IT. NO NEW AIRBAG IS NEEDED BUT IT DID R…
Read full complaint
SRS WARNING CAME ON. HAD FAULT CODE. CALLED CHEVY DEALER AND THEY SAID I WOULD NEED A NEW AIRBAG. I RESEARCHED AND FOUND THAT GM DOES KNOW ABOUT THIS AND EVEN PUT OUT A TSB. IT IS A CONNECTOR TO THE AIRBAG ITSELF LOCATED IN THE LEFT KICK PANEL. THE FIX IS TO CLEAN THE CONNECTOR OR REPLACE IT. NO NEW AIRBAG IS NEEDED BUT IT DID REOCCUR ABOUT A YEAR LATER. RECLEANED AND OK AGAIN. THIS IS A SAFETY ITEM AND SHOULD BE A RECALL. SINCE GM KNEW IT I MUST ASSUME THAT NHTSA KNEW IT ALSO. I CAN SEE WHERE A LOT OF PEOPLE WOULD NOT FIX THIS AND JUST DRIVE LIKE THIS SINCE A LOT OF TECHNICIANS THINK YOU NEED A NEW AIRBAG WHEN IT IS IN FACT POOR WIRING BY GM. *TR
NHTSA ODI #10669755
161,378 miles · Nov 10, 2014
Air Bags
WHEN I GOT IN THE TRUCK TO GO TO WORK, AIRBAG WARNING LIGHT ALONG WITH THE DIC NOTIFICATION WHERE ON. WITH A OSB II READER, GOT A CODE OR "B0104 FRONT RIGHT SENOR REPLACE". REPLACED THE SENOR AT OWNERS EXPENSE. WITH NEW PART INSTALLED THE WARNING LIGHT AND DIC MESSAGE CLEARED. *TR
NHTSA ODI #10654005
Mileage unknown · Oct 30, 2014
Air Bags
CHECK AIRBAG LIGHT STAYS ON.. DO I NEED TO DISENGAGE? PLEASE ADVISE. *TR
NHTSA ODI #10651480
77,000 miles · Oct 13, 2014
Air Bags
FOR NO APPARENT REASON, THE AIR BAG WARNING LIGHTS ON VEHICLE CAME ON WHEN STARTING THE VEHICLE. VEHICLE HAS NOT BEEN INVOLVED IN ANY ACCIDENT. VEHICLE WAS TAKEN IN FOR REPAIR AND REPAIR SHOP SAID THE FRONT SENSORS FOR NO APPARENT REASON HAD GONE DEFECTIVE DISABLING THE AIR BAGS ON VEHICLE. SENSORS HAD TO BE REPLACED AND I WA…
Read full complaint
FOR NO APPARENT REASON, THE AIR BAG WARNING LIGHTS ON VEHICLE CAME ON WHEN STARTING THE VEHICLE. VEHICLE HAS NOT BEEN INVOLVED IN ANY ACCIDENT. VEHICLE WAS TAKEN IN FOR REPAIR AND REPAIR SHOP SAID THE FRONT SENSORS FOR NO APPARENT REASON HAD GONE DEFECTIVE DISABLING THE AIR BAGS ON VEHICLE. SENSORS HAD TO BE REPLACED AND I WAS TOLD PARTS WERE ONLY AVAILABLE FROM A CHEVROLET DEALERSHIP. AFTER REPAIR I CHECKED ONLINE AND FOUND NUMEROUS OTHER OWNERS OF CHEVROLET VEHICLES HAVE EXPERIENCED THE SAME PROBLEM. I AM CONCERNED WITH THE SAFETY ISSUE OF DISABLED AIR BAGS WHEN THIS PART GOES DEFECTIVE FOR NO REASON. *TR
NHTSA ODI #10644270
22,775 miles · Sep 23, 2014
Air Bags
SERVICE AIR BAG WARNING LIGHT HAS BEEN ON SINCE 2007, WHEN VEHICLE WAS STILL UNDER WARRANTY. HAS BEEN TO BOB GRIMM CHEVROLET IN MORTON, IL FOR THIS SAME PROBLEM APPROX 9 TIMES. I NO LONGER LIVE IN THE VICINITY OF THIS DEALER, AND WOULDN'T WANT THEM WORKING ON IT AGAIN SINCE THEY HAVE BEEN UNABLE TO REPAIR MULTIPLE TIMES. WRIT…
Read full complaint
SERVICE AIR BAG WARNING LIGHT HAS BEEN ON SINCE 2007, WHEN VEHICLE WAS STILL UNDER WARRANTY. HAS BEEN TO BOB GRIMM CHEVROLET IN MORTON, IL FOR THIS SAME PROBLEM APPROX 9 TIMES. I NO LONGER LIVE IN THE VICINITY OF THIS DEALER, AND WOULDN'T WANT THEM WORKING ON IT AGAIN SINCE THEY HAVE BEEN UNABLE TO REPAIR MULTIPLE TIMES. WRITTEN COMMUNICATION TO GM ALL THE WAY UP TO CEO HAS NOT RESOLVED THIS ISSUE. JACK SCHMITT CHEVROLET IN O'FALLON, IL DID A DIAGNOSTIC AND REPORTED THE AIR BAG IN MY VEHICLE IS USED. NOBODY HAS EVER WORKED ON THE TRUCK REGARDING THE AIR BAG EXCEPT BOB GRIMM CHEVROLET. MY UNDERSTANDING IS WHEN THIS LIGHT IS ON, THE AIR BAG WILL NOT DEPLOY, ENDANGERING MY LIFE. *TR
NHTSA ODI #10638496
72,568 miles · Sep 13, 2014
Air Bags
WHILE DRIVING DOWN THE ROAD MY SERVICE AIR BAG LIGHT WHEN ON, WAS TOLD AIR BAGS AND SAFETY PRODUCTS WOULD NOT WORK UNLESS FIXED,$500.00 LATER DONE 2YRS LATER 08/22/14 LIGHT IS ON AGAIN?? 30,000 MORE MILES? I NEVER OFF ROAD AND KEEP MY STUFF VERY NICE. *TR
NHTSA ODI #10632924
64,535 miles · Sep 7, 2014
Air Bags
AS I WAS DRIVING THE "SERVICE AIR BAG" WARNING APPEARED IN THE INFORMATION CENTER OF THE DASH AND THE AIR BAG LIGHT STARTED TO BLINK. THERE WAS NO REASON FOR THE WARNING LIGHT. I RE-SET THE INFORMATION CENTER AND THE WARNING REAPPEARED. VERY DISAPPOINTING AS THERE ARE ONLY 64,537 MILES ON THE VEHICLE. I CHECKED ON THE INTERNE…
Read full complaint
AS I WAS DRIVING THE "SERVICE AIR BAG" WARNING APPEARED IN THE INFORMATION CENTER OF THE DASH AND THE AIR BAG LIGHT STARTED TO BLINK. THERE WAS NO REASON FOR THE WARNING LIGHT. I RE-SET THE INFORMATION CENTER AND THE WARNING REAPPEARED. VERY DISAPPOINTING AS THERE ARE ONLY 64,537 MILES ON THE VEHICLE. I CHECKED ON THE INTERNET TO SEE IF THERE WAS A RECALL FOR THIS PROBLEM FOR MY VEHICLE, AS THE MILES ARE VERY LOW ON MY VEHICLE. OF COURSE THERE WAS NONE FOR MY VEHICLE. IT APPEARS THIS IS A COMMON PROBLEM WITH GM VEHICLES AND AN EXTRA EXPENSE TO THE OWNERS. I'M VERY DISAPPOINTED AT THIS POINT. I COULD NOT LOCATE ANY RECALLS FOR MY VEHICLE VIN, BUT THERE WERE OTHER RECALLS INVOLVING THE AIR BAGS WITH OTHER GM VEHICLES. I'M LOST FOR WORDS. *TR
NHTSA ODI #10631391
120,000 miles · Aug 20, 2014
Air Bags
AIR BAG LIGHT STAYS ON. *TR
NHTSA ODI #10626838
35,300 miles · Aug 18, 2014
Air BagsElectrical System
TURNED KEY ON AND LIGHT SAYING SERVICE AIRBAG CAME ON. LOCAL MECHANIC SAID HE READ THAT THERE WAS GOING TO BE A RECALL ON IT. *TR
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Consequence & remedy
Consequence: IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC TRUCKS AT 1-866-996-9463.
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS AND BUILT WITH EITHER PBR PARKING BRAKE SYSTEMS OR TRW PARKING BRAKE SYSTEMS, THE PARKING BRAKE FRICTION LININGS MAY WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.
Consequence & remedy
Consequence: IF THE PARKING BRAKE DOES NOT HOLD, UNINTENDED VEHICLE MOVEMENT COULD OCCUR, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH A PBR PARKING BRAKE SYSTEM. ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM, DEALERS WILL INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY. THE RECALL BEGAN ON JULY 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK AND TRANSMISSION BRAKING EFFECT." UNDER CERTAIN VEHICLE STARTING CONDITIONS, THE SHIFT LEVER POSITION INDICATOR LOCATED IN THE INSTRUMENT PANEL CLUSTER MAY NOT ILLUMINATE. IF THE SHIFT LEVER POSITION INDICATOR DOES NOT ILLUMINATE, THE DRIVER MAY NOT KNOW WHICH GEAR THE VEHICLE IS IN.
Consequence & remedy
Consequence: THE VEHICLE MAY MOVE IN AN UNINTENDED DIRECTION RESULTING IN POSSIBLE INJURY TO OTHERS OUTSIDE OF THE VEHICLE.
Remedy: DEALERS WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 14, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, AND GMC AT 1-866-996-9463.
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
ON CERTAIN TRUCKS, THE BOLT THAT ATTACHES THE INTERMEDIATE STEERING SHAFT TO THE STEERING GEAR MAY NOT MEET SPECIFICATION. THE BOLT MAY FRACTURE RESULTING IN THE LOSS OF STEERING.
Consequence & remedy
Consequence: IF THIS HAPPENS WHILE THE VEHICLE IS MOVING, A CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE THE INTERMEDIATE STEERING SHAFT BOLT FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 24, 2005. OWNERS MAY CONTACT GMC AT 1-866-996-9463 AND CHEVROLET AT 1-800-630-2438.
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH 5.3L (RPO L59) V8 ENGINES, THE ENGINE FUEL RAIL CROSSOVER TUBE RETAINER SCREWS WERE NOT MANUFACTURED TO SPECIFICATIONS AND MAY BREAK.
Consequence & remedy
Consequence: IF THE TUBE RETAINER SCREW BREAKS, FUEL COULD LEAK FROM THE FUEL RAIL CROSSOVER JOINT, THE ENGINE MAY STALL AND, IF AN IGNITION SOURCE WERE PRESENT, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE FUEL RAIL CROSSOVER TUBE AND, IF NECESSARY, REPLACE THE RETAINER SCREWS. OWNERS WERE NOTIFIED BY TELEPHONE ON JULY 30, 2004, WITH A FOLLOWUP OWNER LETTER BEGAN AUGUST 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463. NOTE: THE GM BULLETIN LISTS THE TAHOE AND YUKON MODELS BECAUSE CANADIAN VEHICLES ARE INCLUDED IN THE BULLETIN. NO U.S. TAHOE OR YUKON VEHICLES ARE INCLUDED IN THE U.S. CAMPAIGN.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration