Def pump and heater module had burned terminals. This caused failure to the def pump and heater module. This was the second instance of this happening on this truck in roughly 40,000 miles. Burned terminals can start electrical fires that are a danger to occupants and others in the vicinity. Failure of this system forc…
Read full complaint
Def pump and heater module had burned terminals. This caused failure to the def pump and heater module. This was the second instance of this happening on this truck in roughly 40,000 miles. Burned terminals can start electrical fires that are a danger to occupants and others in the vicinity. Failure of this system forces a drop in speed after so many miles that make you a danger on the road.
NHTSA ODI #11715205
Mileage unknown · Oct 29, 2025
Electrical SystemEngine
There is a common and very dangerous electrical wire routing problem on my vehicle, along with 3 dozen others and my dads (separate but same truck) i confirmed with (FB group for owners of 17-19 L5P GMC diesel trucks) where the alternator positive wire from the alternator to the battery is run right along and across a rather sha…
Read full complaint
There is a common and very dangerous electrical wire routing problem on my vehicle, along with 3 dozen others and my dads (separate but same truck) i confirmed with (FB group for owners of 17-19 L5P GMC diesel trucks) where the alternator positive wire from the alternator to the battery is run right along and across a rather sharp part of molding from the air intake tube. This routing location and rough intake plastic molding rubs through the alternator wire creating a possible electrical short/ corrosion problems that can lead to battery and electrical system compromise, as well as fire risk! A short-circuit condition can cause damage to engine components and, in rare cases, start a fire in the engine compartment. I have 92,000 miles on this 2019, my father has the problem starting on his at only 40,000 miles and may others have issues as well to very degrees of severity between 25 and 150k miles. I discovered this issue while performing routine air filter maintenance and happened to see the rub damage. no modifications have been done, this is the way the wire is routed from the factory. IMO and estimations This issue far supercedes the danger and severity of the recall that currently exists for the engine block heater cord for these models of trucks. 2 of the photos show the damage and exposed wire as soon as i found it. The last shows the location and the part that caused the rub damage along with a temporary mitigation method: electrical tape with a rubber hose installed as a buffer until a permanent fix can be installed.
1st incident: When driving the vehicle dashboard shut off, no indicators working such as speedometer, gauges etc and brakes were not working, luckily I was in a 60 miles an hour zone so I had to just let the vehicle come to a gravity stop. To turn off the engine and start it back up again. 2nd incident: when driving the dash lig…
Read full complaint
1st incident: When driving the vehicle dashboard shut off, no indicators working such as speedometer, gauges etc and brakes were not working, luckily I was in a 60 miles an hour zone so I had to just let the vehicle come to a gravity stop. To turn off the engine and start it back up again. 2nd incident: when driving the dash lights turned off and on like flickering on and off and all the gauges mentioned above did not work, and brakes did not work. This is very scary! All power in the truck is lost while driving and braking issue!
NHTSA ODI #11677598
Mileage unknown · Apr 25, 2024
Electrical System
Service trailer brake system appears and my trailer brake information doesn’t show up on the dashboard when I try to manually engage the electric trailer brakes.
NHTSA ODI #11585338
Mileage unknown · May 15, 2023
Electrical System
The electrical connector vibrated loose at the injector. The mechanic said he has seen this happen before and GM said its because those motors vibrate excessively. It caused my vehicle to run in reduced power mode. In that mode it was lurching forward uncontrollably and it felt like the transmission was banging. What damage will…
Read full complaint
The electrical connector vibrated loose at the injector. The mechanic said he has seen this happen before and GM said its because those motors vibrate excessively. It caused my vehicle to run in reduced power mode. In that mode it was lurching forward uncontrollably and it felt like the transmission was banging. What damage will that alone cause in the future? Also, if GM knows there is an issue, why isn't it fixed? Why is the consumer responsible for poor engineering or design flaws? It isn't normal wear and tear or neglect on my part. The repairs including the part and the rental car cost me $640.45! Oddly enough it wasn't covered under any extended warranty or recall so I had to pay out of pocket. Very dangerous and expensive!
General Motors, LLC (GM) is recalling certain 2018 Chevrolet Silverado 1500, GMC Sierra 1500, 2019 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500, and Sierra 3500 vehicles. The left-side or right-side roof rail air bag (RRAB) inflator end cap may detach from the inflator or the inflator sidewall may rupture.
Consequence & remedy
Consequence: A detached end cap or inflator rupture can allow compressed gas to escape and project the end cap or fragments of the inflator into the vehicle, increasing the risk of injury.
Remedy: Dealers will replace both RRAB modules, free of charge. Owner notification letters were mailed June 24, 2026. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N262557310. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 21, 2026. This recall expands previous NHTSA recall number 26V166.
General Motors, LLC (GM) is recalling certain 2018 Chevrolet Silverado 1500, GMC Sierra 1500, 2019 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500, and Sierra 3500 Crew Cab vehicles. The left or right-side roof rail air bag (RRAB) inflator end cap may detach from the inflator or the inflator sidewall may rupture.
Consequence & remedy
Consequence: A detached end cap or inflator rupture can allow compressed gas to escape and project the end cap or fragments of the inflator into the vehicle, increasing the risk of injury.
Remedy: Dealers will replace the left and right-side RRAB modules, free of charge. Owner notification letters were mailed April 16, 2026. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N262549710. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 19, 2026.
General Motors (GM) is recalling certain 2018 GMC Sierra 1500, 2019 Sierra 2500, 3500, Chevrolet Silverado 3500, and Chevrolet Silverado 2500 and 2018 Chevrolet Silverado 1500 Crew Cab vehicles. The left or right-side roof-rail air bag (RRAB) inflator end cap may detach from the inflator or the inflator sidewall may rupture.
Consequence & remedy
Consequence: A detached end cap or inflator rupture can allow compressed gas to escape and project the end cap or fragments of the inflator into the vehicle, increases the risk of injury or crash.
Remedy: Dealers will replace the left and right side RRAB modules, free of charge. Owner notification letters were mailed July 23, 2025. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252513060.
General Motors, LLC (GM) is recalling certain 2018 Chevrolet Silverado 1500, GMC Sierra 1500, 2018-2019 Chevrolet Silverado 2500, 3500, and GMC Sierra 2500, 3500 Crew Cab trucks. The left or right-side roof-rail air bag (RRAB) inflator end cap may detach from the inflator or the inflator sidewall may rupture.
Consequence & remedy
Consequence: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.
Remedy: Dealers will replace the left and right side RRAB modules, free of charge. Owner notification letters were mailed November 8, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC Customer Service at 888-988-7267. GM's number for this recall is N242474500.
General Motors, LLC (GM) is recalling certain 2017-2019 Chevrolet Silverado 2500, 3500, and GMC Sierra 2500, 3500 vehicles equipped with a dual fuel tank option. The rear fuel tank may collapse and prevent the fuel pump from transferring fuel to the front tank, resulting in an engine stall.
Consequence & remedy
Consequence: An engine stall increases the risk of a crash.
Remedy: Dealers will inspect the fuel tank and fuel pump module, replacing them as necessary. Dealers will also add a vent hose to the rear tank assembly. Repairs will be performed free of charge. An interim owner notification letter informing owners of the safety risk was mailed on March 15, 2023. Owner notification letters were mailed June 21, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N222368030.
General Motors, LLC (GM) is recalling certain 2017-2019 Chevrolet Silverado 2500, 3500 and 2017-2019 GMC Sierra 2500 and 3500 vehicles equipped with a Duramax diesel 6.6 liter engine and an optional engine-block heater cord. An electrical short-circuit may occur in the engine-block heater cable or in the terminals that connect the heater cable to the block heater.
Consequence & remedy
Consequence: An electrical short-circuit can increase the risk of a fire.
Remedy: Dealers will replace engine block heaters and heater cords. Vehicles that have this feature disabled as a remedy to the safety condition will be contacted and offered replacement block heaters and heater cords under a separate customer satisfaction program, free of charge. GM will provide free replacement block heaters and cords under a separate customer satisfaction campaign. For vehicles previously included in recall 19V-328, the heater cord will be replaced and rerouted, free of charge. Interim owner notifications were mailed on August 13, 2021. Owner notification letters are expected to be mailed on April 4, 2022. Customers may call GMC customer service at 1-800-462-8782. GM's number for this recall is 212329840.
General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 4500, 5500 and 6500 vehicles and 2017-2019 Chevrolet Silverado 2500 and 3500 vehicles and GMC Sierra 2500 and 3500 vehicles equipped with Duramax 6.6 liter diesel engines and an optional engine-block heater. The engine block heater cord or the terminals that connect the heater cord to the block heater may short circuit and fail.
Consequence & remedy
Consequence: A short-circuit may damage the engine components and increase the risk of fire.
Remedy: GM will contact owners, dealers will replace the engine block heater, free of charge. Additionally, in Chevrolet Silverado 2500 and 3500 vehicles, dealers will install a new rerouted heater cord. The recall began December 11, 2019. Owners may contact GM customer service at 1-586-596-1733. GM's number for this recall is N182206310.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2019 Chevrolet Silverado 3500 Problems, Complaints & Recalls | Skip That Year
Illustration