NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
80 reportsMileage unknown · May 7, 2001
Tires
VEHICLE STARTED VIBRATING WHILE DRIVING ON INTERSTATE 10 ON MAY 3, 2001. AT FIRST WE COULD NOT SEE ANY VISIBLE PROBLEM SO WE SLOWED OUR SPEED TO WELL UNDER 50 MPH. WE TOOK VEHICLE TO FIRESTONE STORE AND THE TREAD SEPARATION IS NOW VERY OBVIOUS. THE FIRESTONE STORE SAID THEY WILL REPLACE TIRE WITH ANOTHER FIRESTONE TIRE BUT TH…
Read full complaint
VEHICLE STARTED VIBRATING WHILE DRIVING ON INTERSTATE 10 ON MAY 3, 2001. AT FIRST WE COULD NOT SEE ANY VISIBLE PROBLEM SO WE SLOWED OUR SPEED TO WELL UNDER 50 MPH. WE TOOK VEHICLE TO FIRESTONE STORE AND THE TREAD SEPARATION IS NOW VERY OBVIOUS. THE FIRESTONE STORE SAID THEY WILL REPLACE TIRE WITH ANOTHER FIRESTONE TIRE BUT THEY CLAIM THE STEELTEX TIRE IS SAFE AND DOES NOT HAVE TREAD SEPARATION PROBLEMS. THIS VEHICLE IS A GM CUTWAY, MADE INTO A CLASS B MOTOR HOME BY ROADTREK (HOME AND PARK OF CANADA). IT IS ONE YEAR OLD AND HAS ORIGINAL FIRESTONE TIRES. WE HAVE NOT DRIVEN IT OFFROAD, OVER MEDIANS, CURBS OR SHOULDERS (THIS IS WHAT FIRESTONE HAS PREVIOUSLY CLAIMED WAS PROBLEM WITH EMERGENCY VEHICLES USING STEELTEX TIRES). WE DID NOT HAVE AN ACCIDENT BUT THE TV IN THE MOTOR HOME QUIT WORKING AS A RESULT OF THE VIBRATING.*AK (DOT NUMBER: DN11BIA299 TIRESIZE: LT24575R16)
NHTSA ODI #745037
Mileage unknown · Apr 30, 2001
Tires
TIRE BLEW FOR NO APPARANT REASON AT APPROX 70MPH ON INTERSTATE WHILE TOWING AN EMPTY UTILITY TRAILER. TIRE LOOKS SEPARATED AND BLEW INTO 2 PIECES. LOST SOME CONTROL OF VEHICLE ALMOST CAUSING CATASTROPHIC CRASH. DAMAGED VEHICLE AND TRAILER. *AK (DOT NUMBER: 379 TIRESIZE: 245/75R16)
NHTSA ODI #744753
Mileage unknown · Apr 2, 2001
Service Brakes, HydraulicVehicle Speed Control
HAD APPLIED GAS TO SPEED UP AND IT WOULD GO BACK. ENGINE KEPT REVVING, BUT REMAINED AT SAME SPEED. ABS WOULD KICK IN ON ANY SLIPPERY SURFACE. RIGHT FRONT TIRE GRABBED, HARD, AND THEN LOCKED UP WHEN BRAKES WERE APPLIED. AT DEALERSHIP ALL BRAKE PARTS WERE REPAIRED OR REPLACED. *AK
NHTSA ODI #884876
Mileage unknown · Mar 29, 2001
Tires
ORIGINAL TIRES ON A CHEVROLET, K3500, 2000, DOT AD11DOA449, AMERI 500 TR LT245/7516M+S LOAD RANGE E. SIDEWALLS DEVELOPED LARGE BUBBLES ABOUT 5 INCHES IN DIAMETER ON TWO REAR TIRES.*AK CONSUMER STATES THAT FOUR OF THE ORIGINAL GENERAL TIRES ON VEHICLE HAVE FAILED. *SLC
NHTSA ODI #884539
Mileage unknown · Feb 23, 2001
Service Brakes, HydraulicStructure
THE VEHICLE WAS WEIGHED WITH A MEDIUM SIZED VEHICLE IN TOW AND THE WEIGHT WAS 12140, AS PER GM THE TRUCKS MAX GVW RATING IS 11,000, THE VEHICLE WAS BEING USED OVERWEIGHT OF SPECS WHICH CAUSED PREMATURE BRAKE WEAR, THE VEHICLE WAS SOLD TO THE CONSUMER WITH THE UNDERSTANDING THAT THE VEHICLE WOULD BE USED AS A TOW TRUCK, THE CONSU…
Read full complaint
THE VEHICLE WAS WEIGHED WITH A MEDIUM SIZED VEHICLE IN TOW AND THE WEIGHT WAS 12140, AS PER GM THE TRUCKS MAX GVW RATING IS 11,000, THE VEHICLE WAS BEING USED OVERWEIGHT OF SPECS WHICH CAUSED PREMATURE BRAKE WEAR, THE VEHICLE WAS SOLD TO THE CONSUMER WITH THE UNDERSTANDING THAT THE VEHICLE WOULD BE USED AS A TOW TRUCK, THE CONSUMER BELIEVES THAT GM IS SELLING TRUCKS WITH WRECKER PROVISIONS BUT ARE TOO LIGHT TO BE TOW TRUCKS OR THEY ARE SELLING TRUCKS WITH DEFECTIVE BRAKE SYSTEMS, ON ONE OCCASION THE VEHICLE BRAKE PEDAL WENT TO THE FLOOR WHILE THE DRIVER WAS BRAKING AND FAILED CAUSING THE TRUCK TO REAR END ANOTHER VEHICLE. NLM
NHTSA ODI #559915
Mileage unknown · Feb 22, 2001
Electrical System
AN ELECTRICAL SHORT WITHIN HEAD LIGHT AND TAIL LIGHT ASSEMBLY BURNED OUT INSTALLATION, CAUSING INSUFFICIENT LIGHTING. CONSUMER HAS CONTACTED DEALER. *AK WIRING FOR THE TAIL LIGHTS AND DASH LIGHTS IS TOO SMALL, WHEN TOWING A TRAILER, WIRING IS INADEQUATE TO HANDLE EXTRA LIGHTS, WIRES AT HARNESS LIGHT SWITCH ARE CHARGED FROM…
Read full complaint
AN ELECTRICAL SHORT WITHIN HEAD LIGHT AND TAIL LIGHT ASSEMBLY BURNED OUT INSTALLATION, CAUSING INSUFFICIENT LIGHTING. CONSUMER HAS CONTACTED DEALER. *AK WIRING FOR THE TAIL LIGHTS AND DASH LIGHTS IS TOO SMALL, WHEN TOWING A TRAILER, WIRING IS INADEQUATE TO HANDLE EXTRA LIGHTS, WIRES AT HARNESS LIGHT SWITCH ARE CHARGED FROM GETTING HOT, CONSUMER FEELS WIRING NEEDS TO BE HEAVIER OR USE RELAYS TO SUPPORT THE TRAILER LIGHTS. *SLC
NHTSA ODI #881079
Mileage unknown · Jan 10, 2001
Service Brakes, HydraulicCrashInjury
WHEN APPLYING BRAKES AT 30MPH PEDAL WENT TO FLOOR ,RESULTING IN EXTENDED STOPPING DISTANCE, AND CAUSING A COLLISION AND INJURY. DEALER AND MANUFACTURER HAS BEEN NOTIFIED.*AK
NHTSA ODI #877849
Mileage unknown · Dec 29, 2000
Service Brakes, HydraulicCrash
REAR BRAKES WERE EXCESSIVELY WEARING OUT EVERY 3-4,000 MILES. BRAKE PEDAL WOULD GO TO FLOOR. WOULD HAVE NO REAR BRAKES WHEN THEY WERE APPLIED. HAD AN ACCIDENT DUE TO LACK OF REAR BRAKES, ON ONE OCCASION DEALER STATED THAT THE REAR BRAKES WERE METAL TO METAL, THE BRAKE PADS WERE SCORCHED, MASTER CYLINDER WAS REPLACED, AND THE B…
Read full complaint
REAR BRAKES WERE EXCESSIVELY WEARING OUT EVERY 3-4,000 MILES. BRAKE PEDAL WOULD GO TO FLOOR. WOULD HAVE NO REAR BRAKES WHEN THEY WERE APPLIED. HAD AN ACCIDENT DUE TO LACK OF REAR BRAKES, ON ONE OCCASION DEALER STATED THAT THE REAR BRAKES WERE METAL TO METAL, THE BRAKE PADS WERE SCORCHED, MASTER CYLINDER WAS REPLACED, AND THE BRAKE PROPORTIONING VALVE WAS REPLACED. CONTACTED MANUFACTURER & INFORMED CONSUMER THAT VIN INDICATED A TOW TRUCK, BUT VEHICLE WAS NOT HEAVY ENOUGH TO BE TOW TRUCK. MANUFACTURER COULD NOT GIVE EXPLAINATION FOR LABELING OF TOW TRUCK. IT COULD NOT BE USED AS A TOW TRUCK.BRAKES WOULD CONTINUE TO WEAR OUT DUE TO NOT BEING HEAVY ENOUGH, ACCORDING TO MANUFACTURER'S EXPLANATION. *AK CONSUMER IS REQUESTING A FIX TO THIS DANGEROUS PROBLEM OR A PRO-RATED REPLACEMENT OF THE VEHICLE. *SLC
NHTSA ODI #877210
Mileage unknown · Dec 26, 2000
Service Brakes, Hydraulic
BACK BRAKES DO NOT WORK PROPERLY, FRONT TIRES WERE REPLACED DUE TO FAULTY RIGHT FRONT BRAKES, CONSUMER STATES THAT THERE HAVE BEEN MANY CLOSE CALLS DUE TO THE FAULTY BRAKES. *SLC
NHTSA ODI #876999
Mileage unknown · Nov 24, 2000
Service Brakes, Hydraulic
THE VEHICLE HAS EXPERIENCED MULTIPLE BRAKE FAILURES, SEVERAL REPAIRS COMPLETED HOWEVER THE BRAKES FAILED RESULTING IN THE DRIVER HITTING THE VEHICLE IN FRONT, THE BRAKE SYSTEM IS NOT DESIGNED SUFFICIENTLY FOR THE WEIGHT OF THE VEHICLE. *MJS
NHTSA ODI #557924
NHTSA investigations
2EA04012 · Hydraulic Pump Failres
Opened Apr 30, 2004 · Closed Feb 28, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist; Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
PE04004 · Hydraulic Pump Shaft Failures
Opened Jan 8, 2004 · Closed Apr 30, 2004
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:hydraulic; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:pump
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Additional source detail variants (5)
Service Brakes, Hydraulic
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Service Brakes, Hydraulic:power Assist
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Service Brakes, Hydraulic:power Assist:hydraulic
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Steering:hydraulic Power Assist:pump
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Steering:hydraulic Power Assist System
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Illustration