1999 Chevrolet Silverado 2500

VEHICLE HAD BEEN RUNNING POORLY FOR ABOUT 2 WEEKS MAYBE MORE. FUEL PUMP ALSO WAS SOUNDING FUNNY. INSTEAD OF THE NORMAL QUICK WHIRRING FOR A FEW SECONDS THE PUMP SOUNDED LIKE IT WAS LABORING AND HAD A SLOWER, DEEPER PITCH. I THOUGHT MAYBE IT WAS TIME FOR TUNE UP BUT MY RECORDS SHOWED OTHERWISE. ( I KEEP PRETTY EXTENSIVE VEHICLE NOTES ON ALL WORK/MAINTENANCE PERFORMED.) ON THE MORNING THE ACTUAL PROBLEM FINALLY WAS DISCOVERED I HAD STARTED MY TRUCK AFTER A LITTLE MORE CRANKING EFFORT THAN USUAL. ENGINE RAN FOR ABOUT 20 SECONDS OR SO AND THAN SHUT DOWN. TRIED TO RESTART BUT THE FUEL PUMP DIDN'T POWER UP AND THEN THE SMELL OF FRESH GASOLINE WAS EVERYWHERE. AFTER GETTING OUT OF THE TRUCK I TOOK A LOOK ON THE GROUND AND YES THERE WAS GAS ON THE GROUND AND STILL DRIPPING FROM UP UNDER THE TRUCK. TOOK OUT MY FLASHLIGHT AND CAREFULLY PEEKED UNDERNEATH AND RIGHT AWAY SAW THE MAIN FUEL LEAK. FUEL LINES ON BOTH THE SUPPLY AND RETURN SIDES ARE RUSTED PRETTY BADLY IN MULTIPLE AREAS. GAS WAS LEAKING AT LEAST 4 POINTS FROM WHAT I COULD SEE AT THAT MOMENT. SEEMS THAT THE PLASTIC HOLD DOWNS FOR THESE FUEL LINES AND THE BRAKE LINES ARE THE CULPRIT WITH THESE ISSUES. THIS PUMP BURNED OUT DO THESE LEAKS SO NOW I HAVE TO REPLACE THE FUEL PUMP MODULE AGAIN, AS WELL AS THE COMPLETE FUEL LINE SYSTEM FRONT TO BACK. I REMOVED THE 34 GALLON FUEL TANK AND THE TANK ALSO NEEDS TO BE REPLACED AS IT IS SEVERELY RUSTED. I MENTION ALL OF THIS BECAUSE I HAVE REPLACED THE FUEL PUMP TWICE BEFORE DUE TO FAILURE AND NOW IT SEEMS THAT THE ETHANOL BLENDS ARE RUINING THESE PUMP MODULES ALSO. EACH TIME I HAD REMOVED THE FUEL TANK I INSPECTED THE EXTERIOR/INTERIOR AND CLEANED, PREPPED, AND APPLIED RUST DETERRENT PRODUCTS AS NEEDED. I HAVE OWNED VEHICLES FROM THE 1950'S AND 60'S AND NEVER HAD THESE ANY OF THESE TYPE OF ISSUES. *TR

COMPLETE REAR BRAKE FAILURE IN PARKING LOT JUST AS I WAS LEAVING WORK. HAD TO QUICKLY PUMP BRAKES TO KEEP TRUCK FROM MOVING. BRAKE PEDAL WENT TO FLOOR IN AN INSTANT. I PUT TRUCK IN PARK GOT OUT AND THERE WAS FLUID ALL OVER THE PLACE ON THE GROUND,AND ON THE DRIVERS SIDE UNDER CARRIAGE JUST BEHIND THE CAB DOOR. LOOKED UNDERNEATH WITH FLASHLIGHT AND COULD SEE THAT THE BRAKE LINE HAD SEVERE RUSTING WHERE EACH PLASTIC HOLD DOWN IS LOCATED AND ONE HAD RUSTED TO POINT OF FAILURE. GLAD I HADN'T PULLED OUT AND ONTO THE HIGHWAY AT THAT POINT. HAD TO HAVE MOST OF THE LINE REPLACED ALONG THE FRAME RAIL,( ABOUT 15'). *TR

JUST DRIVING HOME FROM WORK AND THE BRAKES WERE NOT WORKING AS WELL AS NORMAL WHEN APPLYING THEM. LIGHT CAME ON IN THE DASHBOARD INDICATING BRAKE PROBLEM. WHEN I ARRIVED AT HOME CHECKED FLUID AND WAS OUT OF BRAKE FLUID. STARTED LOOKING FOR THE PROBLEM AND FOUND A BROKEN BRAKE LINE BADLY CORRODED. LOOKING AT THE REST OF THE LINES THEY ARE ALL IN A BAD WAY. I'M A PLUMBER AND HAVE WORKED WITH STAINLESS STEEL TUBING MY EXHAUST IS ORIGINAL NEVER HAD A PROBLEM OR LEAK. IT SEEMS STRANGE TO INSTALL SUCH A GREAT EXHAUST SYSTEM AND NOT THE SAME ON A LITTLE MORE IMPORTANT SYSTEM. *TR

TL* THE CONTACT OWNS A 1999 CHEVROLET SILVERADO 2500. THE CONTACT STATED WHEN HE DEPRESSED THE BRAKES, THE PEDAL EXTENDED TO THE FLOOR ABNORMALLY. HE THEN INSPECTED THE VEHICLE AND FOUND BRAKE FLUID LEAKING ONTO THE GROUND. THE VEHICLE WAS TOWED TO THE DEALER WHO PERFORMED A DIAGNOSTIC TEST WHICH INDICATED THAT THE BRAKE LINES WERE CORRODED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 80,000.

TL*THE CONTACT OWNS A 1999 CHEVROLET SILVARADO 2500. WHILE DRIVING APPROXIMATELY 25 MPH THE BRAKE PEDAL EXTENDED TO THE FLOOR MORE THAN USUAL AND THE VEHICLE BECAME DIFFICULT TO STOP WHILE APPLYING PRESSURE TO THE BRAKE PEDAL. THE BRAKE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT ONE OF THE SHOCKS WERE WET AND COVERED WITH OIL. THE CONTACT NOTICED THAT THE REAR BRAKE LINE WHICH CONNECTS TO THE REAR AXLE WAS ALSO LEAKING OIL. THE VEHICLE WAS INSPECTED BY A DEALER OR LOCAL MECHANIC. THERE WAS AN OPEN INVESTIGATION; NHTSA ACTION NUMBER EA11001 (SERVICE BRAKES, HYDRAULIC SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS). THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

1999 CHEVY SILVERADO 2500 EXT CAB LONG BOX 2WD PICKUP WITH 155,000 KLM HAD TWO BRAKE LINES EXPLODE UPON APPLYING THE BRAKES. TRUCK WAS PULLING A FULL LOAD AT THE TIME AND AN ACCIDENT COULD HAVE BEEN MAJOR. LUCKILY THE TRAILER BEING TOWED HAD ELECTRIC BRAKES ON IT. INSPECTION OF THE BRAKE LINES SHOWS THEM ALL VERY RUSTY. SHOULD NOT BE OCCURRING. I DRIVE AN OLDER ASTRO VAN AND THERE ARE NO PROBLEMS WITH IT. GM SHOULD BE REPLACING ALL THE BRAKE LINES. *TR