Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 50 of 373 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine. Review the 145 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 104 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports6 fire reports2 injury reports
What owners actually said
373 reports
Mileage unknown · Jan 23, 2026
EngineService BrakesSteering
On 1/21/26 traveling on a 4 lane divided highway, vehicle stalled, several warning lights came on and vehicle came to a complete stop in driving lane. Vehicle locked in park and could not put vehicle in neutral to push it out of highway. Several vehicle swerved to avoid and until tow truck came blocked a lane. It was about 3:30…
Read full complaint
On 1/21/26 traveling on a 4 lane divided highway, vehicle stalled, several warning lights came on and vehicle came to a complete stop in driving lane. Vehicle locked in park and could not put vehicle in neutral to push it out of highway. Several vehicle swerved to avoid and until tow truck came blocked a lane. It was about 3:30pm fortunately. So vehicle was visible and no accidents to our knowledge occurred. Thai created a dangerous traffic situation. It was caused by a fuel pump control module Whig was repaired 2 days later at local Chevy dealer. We were advised there were no recalls on this part but it is a common problem. GM should somehow find a solution and repair said problem
NHTSA ODI #11713006
Mileage unknown · Jan 23, 2026
Engine
After have the engine tested it was determined that my vehicle will receive the 0W/40 oil. After that change I have notices a lot of rattling and the engine not behaving like it should.
NHTSA ODI #11712948
34,000 miles · Jan 23, 2026
Engine And Engine Cooling
The contact owns a 2023 Chevrolet Silverado 1500. The contact stated that the check engine warning light was illuminated. The vehicle was taken to the dealer, and the failure was associated with a coolant sensor failure; however, it was unknown whether the dealer had repaired the vehicle. The dealer then informed the contact tha…
Read full complaint
The contact owns a 2023 Chevrolet Silverado 1500. The contact stated that the check engine warning light was illuminated. The vehicle was taken to the dealer, and the failure was associated with a coolant sensor failure; however, it was unknown whether the dealer had repaired the vehicle. The dealer then informed the contact that the vehicle was safe to drive. However, while driving 65-70 MPH, the engine overheated and the vehicle stalled. Several unknown warning lights were illuminated. The contact was able to pull over to the side of the road, and the vehicle was towed to the dealer. The failure was initially related to a coolant sensor, and the dealer advised the contact that the part was ordered; however, upon following up, another technician advised the contact that a digital multivalve was ordered. The contact stated that upon returning to the dealer, the dealer advised the contact to sign the service documents. The contact stated that after insisting on reading the service documents prior to the signature, the dealer provided the documents to the contact; however, the dealer later snatched the documents from the contact while the contact was reading the documents. The contact stated that it was unknown whether the vehicle was serviced. The service manager later informed the contact that the vehicle could not be repaired because the contact and the dealer could not come to an agreement. The contact informed the dealer that the vehicle should be repaired under the warranty. The vehicle was picked up from the dealer unrepaired. The check engine warning light was illuminated. The manufacturer was notified of the dealer's denial by the dealer to repair the vehicle. The manufacturer informed the contact that there would be a follow-up with the dealer. The failure mileage was approximately 34,000.
NHTSA ODI #11712941
Mileage unknown · Jan 22, 2026
Engine
The motor blew with no notice, around 1000 miles after the recall inspection. My safety, along with the others around me was put at risk as I was in the fast lane during rush hour traffic with no motor to aid switching lanes to get to the shoulder. Finally died at one of the busiest intersections in the state, for the last tim…
Read full complaint
The motor blew with no notice, around 1000 miles after the recall inspection. My safety, along with the others around me was put at risk as I was in the fast lane during rush hour traffic with no motor to aid switching lanes to get to the shoulder. Finally died at one of the busiest intersections in the state, for the last time, as I was attempting to limp to the dealer via multiple restarts. leaving me stranded on the side of the road on a wonderful January day. The vehicle has been inspected by the dealer and slated for an engine replacement. No notice, I let off the gas, and when I went to accelerate again, the motor shut off.
NHTSA ODI #11712710
Mileage unknown · Jan 22, 2026
Engine
September 2025; the fuel control module failed at 75 mph in the left lane of I-45 requiring me to pull over on the shoulder in heavy traffic. I eas towed to my dealership 170 miles. At that time the recall test was performed on my 6.2 L L87 engine and passed inspection. The oil was upgraded at that time. Jan. 3, 2026 at 65 mph …
Read full complaint
September 2025; the fuel control module failed at 75 mph in the left lane of I-45 requiring me to pull over on the shoulder in heavy traffic. I eas towed to my dealership 170 miles. At that time the recall test was performed on my 6.2 L L87 engine and passed inspection. The oil was upgraded at that time. Jan. 3, 2026 at 65 mph the engine died, once again on the highway at over 65 mph. Again I struggled to get to the right shoulder in heavy traffic. At the moment of failure, the engine revved from 1500 rpm to 3900 rpm and instantly fell to zero rpm and died. A message on the dash read unable to put in vehicle neutral. Again, I had it towed to my dealership where it's been diagnosed with a seized engine and I'm waiting (three weeks so far) on an engine replacement. I'm told the manufacturer rep has been to the dealership to confirm the failure and approved a complete engine replacement. There was never any advanced warning appearing on the dash. I have thorough maintenance records on this vehicle.
NHTSA ODI #11712646
Mileage unknown · Jan 21, 2026
Engine
General Motors sent me a letter regarding a safety recall regarding my 6.2L V8 gas engine (ROP L87). Safety recall N252494000. I learned that my truck has the potential to have a complete engine failure. I took my truck to the dealership and all they did was an inspection and changed the oil on it. I'm not a mechanic, but to…
Read full complaint
General Motors sent me a letter regarding a safety recall regarding my 6.2L V8 gas engine (ROP L87). Safety recall N252494000. I learned that my truck has the potential to have a complete engine failure. I took my truck to the dealership and all they did was an inspection and changed the oil on it. I'm not a mechanic, but total engine failure is concerning to say the least. I doubt simple change in oil thickness remedies serious recall. I learned there is an open lawsuit regarding this issue. I need Chevy to take this matter more serious, Im driving my family around in a ticking time bomb. I demand more than a band-aid. I want Chevy to replace my engine with a new reliable one.
NHTSA ODI #11712547
Mileage unknown · Jan 21, 2026
EngineFuel/propulsion SystemPower Train
Can shaft and lifters failed
NHTSA ODI #11712495
Mileage unknown · Jan 21, 2026
Electrical System
Dear Sir or Madam, I am writing to formally report a safety-related defect involving the power unlatching tailgate switch on my Chevrolet 1500 truck and to request that this make and model be added to the current safety recall affecting Chevy HD vehicles. The power tailgate unlatching switch malfunctioned and would repeatedly …
Read full complaint
Dear Sir or Madam, I am writing to formally report a safety-related defect involving the power unlatching tailgate switch on my Chevrolet 1500 truck and to request that this make and model be added to the current safety recall affecting Chevy HD vehicles. The power tailgate unlatching switch malfunctioned and would repeatedly attempt to open and close the tailgate while the truck was parked. On one occasion, this occurred continuously overnight. The following morning, my key fob was completely unresponsive, and the truck had zero battery life. The battery would not accept a charge, and the vehicle had to be towed to the dealership. Upon inspection, the dealership confirmed that the battery had been fully depleted and permanently damaged due to a short in the power tailgate switch. The faulty switch continuously drew power as it attempted to actuate the tailgate, ultimately destroying the battery. This failure created a serious safety and reliability concern, leaving me stranded with a completely inoperable vehicle. Given that this issue resulted from an electrical short and caused total battery failure, I believe it represents a significant safety defect. Based on the similarity to issues addressed in the current Chevy HD safety recall, I strongly believe this make and model should be included in that recall. I respectfully request that this matter be reviewed and addressed to prevent other owners from experiencing the same hazardous situation. Thank you for your time and attention to this matter. I look forward to your response. Sincerely, Charles Senn
NHTSA ODI #11712365
Mileage unknown · Jan 19, 2026
Engine
While driving at 70mph, my vehicle spontaneously shifted into Neutral and therefore dropped power to the transmission. I was unable to shift out of Neutral and therefore had to coast to the shoulder. Upon coming to a complete stop, my truck independently shifted into Park. Again, I was unable to shift out of Park. I turned my tr…
Read full complaint
While driving at 70mph, my vehicle spontaneously shifted into Neutral and therefore dropped power to the transmission. I was unable to shift out of Neutral and therefore had to coast to the shoulder. Upon coming to a complete stop, my truck independently shifted into Park. Again, I was unable to shift out of Park. I turned my truck off, let it sit for a few seconds before unsuccessfully attempting to restart my vehicle. Multiple attempts to restart my vehicle continued to be unsuccessful and the vehicle system would reboot then shut off.
NHTSA ODI #11711957
38,000 miles · Jan 14, 2026
Back Over PreventionElectrical SystemLatches/locks/linkages
The contact owns a 2023 Chevrolet Silverado 1500. The contact stated that the tailgate was constantly opening unintendedly. The failure also occurred while the vehicle was parked overnight, causing the battery to drain. Additionally, the contact stated that the rearview camera was inoperable. The vehicle was taken to the dealer,…
Read full complaint
The contact owns a 2023 Chevrolet Silverado 1500. The contact stated that the tailgate was constantly opening unintendedly. The failure also occurred while the vehicle was parked overnight, causing the battery to drain. Additionally, the contact stated that the rearview camera was inoperable. The vehicle was taken to the dealer, where it was diagnosed, and determined that the tailgate switch and rearview camera had failed due to water intrusion. The dealer replaced the tailgate switch; however, the rearview camera was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 38,000.
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash.
Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist:electric:control Module:software
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Service Brakes, Hydraulic:brake Fluid Low Warning: Lamp
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
Remedy: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Aug 20, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Jan 16, 2026 · Closed Aug 20, 2026
Status: closed (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
2023 Chevrolet Silverado 1500 Problems, Complaints & Recalls | Skip That Year
Illustration