2005 Chevrolet Silverado 1500

WITH THE HEATER ON HIGH (SETTING 5), THE FAN STOPPED BLOWING HEAT. I THEN SET THE BLOWER TO SETTING 4, AND THE FAN WORKED FINE. AS SOON AS I THEN PUT THE FAN BACK TO 5, I WOULD HEAR A CLICK BUT THE FAN WOULD NOT WORK AT ALL. I THEN BEGAN TO FIDDLE AROUND WITH THE CONNECTOR THAT IS UNDER THE PASSENGER SIDE DASH WHICH POWERS THE FAN. IF I MOVE THE ONE WIRE AROUND, THE FAN WOULD INTERMITTENTLY WORK WHILE ON SETTING 5. I UNPLUGGED THIS CONNECTOR FROM THE BLOWER MOTOR, NOTICED THAT THE ONE WIRE SEEMS AS IF IT WAS CAUSING A SHORT (THE WIRE WAS SOMEWHAT BLACK FROM OVER CURRENT). I REMOVED THE PIN FROM THE CONNECTOR, RECRIMPED AND SOLDERED IT. WORKED FINE UNTIL A FEW WEEKS AGO WHEN THE FAN ONCE AGAIN BEGAN TO STOP ONLY ON SETTING 5. I AM ASSUMING THAT THE PROBLEM IS ONCE AGAIN THE CONNECTOR THAT GOES TO THE BLOWER MOTOR POWERING THE FAN RESISTOR. I SAW A FEW REPORTS OF THIS ON HERE ABOUT VEHICLE FIRES ALL OF WHICH POINT TO THIS CONNECTION BEING BAD. SO I THOUGHT I WOULD SUBMIT THIS AS WELL DUE TO THE VAST AMOUNT OF ISSUES I HAVE HAD WITH THIS TRUCK. *TR

THE HEATER BLOWER WOULD NOT TURN OFF WHICH DRAINED THE BATTERY. NOW BOTH PARTS NEED TO BE REPLACED. ACCORDING TO CHEVROLET, THIS PART WAS A RECALL ITEM IF MADE FROM A CERTAIN MANUFACTURE. APPARENTLY, OUR PART WAS A DIFFERENT MANUFACTURER WHICH IS WHY WE DIDN'T GET THE RECALL NOTICE. SINCE OUR PART FAILED, PERHAPS, IT IS A DESIGN DEFECT OR THE OTHER MANUFACTURERS WERE DELINQUENT DURING THE ASSEMBLY PROCESS AS WELL. PLEASE INVESTIGATE TO SEE IF WE MAY QUALIFY FOR A RECALL ON THIS PART. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH WITH THE HEATER ACTIVATED WHEN HE NOTICED A BURNING ODOR COMING FROM THE CONNECTOR FOR THE HEATER BLOWER. THE VEHICLE WAS MANEUVERED TO THE SIDE OF THE ROAD WHERE THE ENGINE WAS TURNED OFF AS THE CONTACT INSPECTED THE HEATER BLOWER, WHICH HE DISCOVERED WAS MELTED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 88,000.

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE DRIVING 5 MPH, HE NOTICED THAT THE HEATER/COOLER HAD BECOME INOPERABLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO INFORMED THE CONTACT THAT HE WOULD NEED TO REPLACE THE HEATER RELAY AND THE WIRING HARNESS BECAUSE THE FINGERS WERE MELTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 40,000. UPDATED 2/28/11 *CN THE CONSUMER STATED THE HEATER RELAY MELTED AND PART OF THE WIRING HARNESS AS WELL. UPDATED 04/27/11

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE DUAL CLIMATE CONTROL ON THE AIR CONDITIONING/ HEATING SYSTEM FAILED ON AN INTERMITTENT BASIS; WHEN HE HAD THE HEAT ON, ONE SIDE WOULD BLOW HOT AIR AND THE OTHER SIDE COLD AIR AND THE SAME FAILURE OCCURRED WHEN THE AIR CONDITIONER WAS ON. HE HAD TO DRIVE ONTO THE EMERGENCY LANE, TURN OFF THE ENGINE, AND RE-START THE VEHICLE. THE DEALER REFUSE TO INSPECT THE VEHICLE SINCE THE WARRANTY WAS NO LONGER VALID. THE ELECTRICAL CONNECTOR ON THE FLOORBOARD WOULD ALSO FAIL CAUSING THE FAN TO STOP WORKING; THE HEATING SYSTEM/AIR CONDITIONING SYSTEM WOULD NOT FUNCTION WITHOUT THE FAN. HE REPLACED THE CONNECTORS AT HIS EXPENSE TWICE AND THE CONNECTOR FAILED AGAIN. HE CALLED THE MANUFACTURER AND A REPRESENTATIVE TOLD HIM THAT THEY COULD NOT ASSIST HIM. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE CURRENT MILEAGE WAS APPROXIMATELY 61,000. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000.

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE INSTRUMENT PANEL FAILED ALONG WITH THE HEAT IN THE VEHICLE. SHE CITED IT AS AN ELECTRICAL PROBLEM; NONE OF THE GAUGES WERE FUNCTIONING. SHE NOTICED THAT THE SPEEDOMETER SEEMED TO HAVE BEEN REPLACED PREVIOUSLY. SHE TOOK THE VEHICLE TO THE DEALER AND SHE WAS TOLD THAT THE ENTIRE INSTRUMENT PANEL NEEDED TO BE REPLACED. SHE CALLED THE MANUFACTURER AND WAS INFORMED THAT THEY COULD NOT ASSIST HER. THE VEHICLE HAD NOT BEEN REPAIRED TO-DATE. THE CURRENT MILEAGE WAS 31,015. THE FAILURE MILEAGE WAS APPROXIMATELY 29,000. UPDATED 01/1410 *BF UPDATED 01/20/10.*JB

2005 CHEVY 1500 SILVERADO - HEATER BLOWS HOT AIR ON DRIVERS SIDE, COLD ON PASSENGER SIDE - HAPPENS WITHOUT NOTICE - HAVE SPENT AROUND $300.00 (+) DOLLARS TRYING TO FIX THIS. WAS TOLD BY GM SERVICE TECH IT WAS THE HEATER MOTOR RESISTOR WIRING HARNESS, IT BURNS OUT THE RESISTOR. I REPLACED BOTH, THE RESISTOR BURNED OUT AGAIN AND THE WIRING HARNESS WAS FRIED AGAIN. THE INTERNET IS FULL OF THESE REPORTS - A RECALL IS NEEDED - THIS CONDITION IS NOT SAFE. THANK YOU FOR YOUR HELP. *TR