2005 Chevrolet Silverado 1500

The contact owns a 2005 Chevrolet Silverado 1500. The contact stated while driving at various speeds, the vehicle started to leak fuel and the brake line would leak causing the brakes to lose power whenever the brake pedal was depressed. The contact also stated that the fuel tank strap fractured due to rust causing the fuel tank to detach from the vehicle. The contact stated that the rear leaf spring fractured due to rust as well. The contact also stated that the entire sub-frame of the vehicle was rusted causing pieces of metal to fall off from the frame while driving. The brake warning light was illuminated. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the brake lines, fuel lines, the rear leaf shackle, and the fuel tank needed to be replaced. The vehicle was repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 58,000.

WE TOOK OUR 2005 CHEVY Z71 SILVERADO IN FOR THE INSPECTION AND IT WOULDN'T PASS DUE TO ROTTED FRAME. SO NOW WE HAVE A USELESS TRUCK THAT LOOKS AND DRIVES FINE BUT WON'T PASS INSPECTION. NOW WE'RE HEARING ABOUT SEVERAL SAME MODEL TRUCK ARE HAVING THE SAME ISSUE. WE HAVE ALWAYS TAKEN THE BEST CARE OF ALL OUR VEHICLES AND HAVE BEEN LOYAL GM CUSTOMERS. BUT IT SURE SEEMS THE QUALITY OF GM PRODUCTS ARE NOT WHAT THEY USED TO BE. ESPECIALLY FOR THE AMOUNT OF MONEY THAT WE INVEST IN THEM.

RUST CORROSION HAS WORN THROUGH TO AFFECT ELECTRICAL LINES - REAR LIGHTS NO LONGER WORK. HAVE ALREADY REPLACED THE DASHBOARD CONSOLE ELECTRICAL. GAS FUEL LIGHT STAYS ON WHICH IS RELATED TO THE CIRCUITRY ELECTRICAL SYSTEM AND AFFECTS "SMOG" SYSTEM. MAIN PROBLEM IS, RIGHT NOW, THE SAFETY AND DRIVEABILITY OF THIS TRUCK DUE TO RUSTING THROUGH UNDERBODY TO THE DRIVE SHAFT AND AXEL/BRAKE SYSTEM (NEVERMIND THE REAR LIGHTS NOT WORKING) WILL THIS TRUCK FAIL ON THE ROAD WHEN DRIVING? *TR

WHEN I PURCHASED MY TRUCK THE DEALERSHIP PROMISED TO HAVE IT FIXED,I THEN WENT TO THE NC DMV WHO HANDLES VEHICLE. I HAD BEEN RECEIVING THE RUNAROUND FROM EVERYONE. I AM SURE IT HAS BEEN IN A FLOOD THAT I WAS NOT INFORMED ABOUT DUE TO ALL THE RUST UNDERNEATH THE VEHICLE. WHEN I PURCHASED IT WAS STATIONARY AT A PRIVATE DEALERSHIP IN A CITY NEXT TO A HIGHWAY. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. WHILE DRIVING AT VARIOUS SPEEDS, AN ABNORMAL NOISE EMITTED UNDERNEATH THE VEHICLE. THE CONTACT INSPECTED THE VEHICLE AND DISCOVERED THAT THE FRAME WAS CORRODED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHERE IT WAS DIAGNOSED THAT THE FRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000. MA 10/1

TAIL LIGHT HOUSING LEAKS WATER INTO TAIL LIGHT AREA WHICH CAUSES TAIL AND BRAKE LIGHT BULB BASES TO CORRODE , LOSE CONTACT AND FAIL TO OPERATE. I REPLACE TAIL LAMPS EVERY 3 TO 6 MONTHS. INSTRUMENT PANEL FAILED AT 65000 MILES AND DESPITE EXTENDED WARRANTY GM WOULD NOT REPAIR. I WAS NEVER CONTACTED ABOUT GM SETTLEMENT CONCERNING THIS FACTORY DEFECT. *TR

DROVE INTO THE GARAGE AND PARKED. A LOUD EXPLOSIVE NOISE CAME FROM THE TRUCK AND FUMES BEGAN FUNNELING THROUGH THE HOOD OF TRUCK. QUICKLY TURNED OFF IGNITION AND GOT OUT OF VEHICLE. IN A FEW MINUTES GARAGE WAS FULL OF INTENSE FLAMES. THE HEAT WAS SO INTENSE IT BLEW OPEN THE DOOR INTO THE HOUSE AND BURNED/MELTED THE LAUNDRY EQUIPMENT AND THREE ROOMS, AND THE SECOND CAR IN THE GARAGE, SENDING SMOKE DAMAGE THROUGHOUT THE ENTIRE HOUSE. VEHICLES MELTED AND EVERYTHING IN THEM AND IN THE GARAGE- MOWER, SNOW BLOWER, SMALL EQUIPMENT AND MORE, WAS TOTALLY DESTROYED. THE FIREFIGHTERS WERE ABLE TO CONTAIN THE FIRE TO AREAS IDENTIFIED ABOVE. THERE WAS EXTREME SMOKE DAMAGE THROUGHOUT THE ENTIRE HOUSE. *TR

I STARTED SEEING RUST SPOTS AROUND THE BOTTOM THE CAB AND HAD TO PUT IT IN THE SHOP BECAUSE RUST HAD EATEN THROUGH, THE REPAIRMAN SAID IT LOOK AS IF THE AREA HAD NEVER BEEN TREATED FOR CORROSION, THIS VEHICLE SHOULD NOT BE DOING THIS AND HE SAID HE COULD NOT GUARANTEE THAT IT WANT CONTINUE. I FEEL GM SHOULD PAY FOR THE REPAIR AND MAKE SURE IT DOSE NOT HAPPEN AGAIN. *TR

THE BRAKE LINES ,FUEL LINES AND THE FRAME CROSSMEMBERS ARE ALL SEVERELY RUSTED. IT JUST IS A MATTER OF TIME BEFORE I LOOSE MY BRAKES, GO UP IN FLAMES OR DROP MY GAS TANK ONTO THE HIGHWAY. THE BODY ON THIS TRUCK IS NOT TOO BAD. IT HAS 92,000 MILES ON IT, AND IT IS CLEANED QUITE OFTEN. THE UNDERCARRIAGE IS RUSTED VERY BADLY. I EXPECTED MORE FROM SOMETHING THAT COSTS SO MUCH. CANT AFFORD A NEW ONE AND IF I COULD IT WOULDN'T BE A GM. HAVE ALWAYS OWNED GM IN THE PAST. *TR