Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
240–25K
7025–50K
4050–75K
2875–100K
14100–150K
10150K+
186 reports with mileage · 122 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Structure. Review the 75 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 50 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
20 crash reports6 fire reports22 injury reports
What owners actually said
308 reports
Mileage unknown · Mar 2, 2005
Power TrainService Brakes, Hydraulic
HORRIBLE PROBLEM WITH THE SHIFTING OF TRANSMISSION. TRANSMISSION WAS REBUILT 6 MONTHS AGO DUE TO THE BURN OUT OF THE 2ND AND 3RD GEAR. SHIFTING HAS NOT CHANGED SINCE THE REBUILD. VEHICLE EASILY SLIPS OUT OF GEAR AND INCREASINGLY LOSES SPEED...NO MATTER IF THE GAS PEDAL IS TO THE FLOOR OR NOT. TRUCK WILL GO 65 MPH IN 2ND GEAR WIT…
Read full complaint
HORRIBLE PROBLEM WITH THE SHIFTING OF TRANSMISSION. TRANSMISSION WAS REBUILT 6 MONTHS AGO DUE TO THE BURN OUT OF THE 2ND AND 3RD GEAR. SHIFTING HAS NOT CHANGED SINCE THE REBUILD. VEHICLE EASILY SLIPS OUT OF GEAR AND INCREASINGLY LOSES SPEED...NO MATTER IF THE GAS PEDAL IS TO THE FLOOR OR NOT. TRUCK WILL GO 65 MPH IN 2ND GEAR WITH PEDAL TO THE FLOOR AND LOSE SPEED RAPIDLY STILL. SECOND, BRAKES LOCK UP GOING OVER SMALL BUMPS, AND THEN SEEM TO NOT WANT TO WORK PROPERLY ON OCCASION. LASTLY, TAILGATE CABLES HAVE SNAPPED AFTER I SAT ON THE TAILGATE (I'M 5'0" AND 100LBS!!). *AK
NHTSA ODI #10112415
30,000 miles · Mar 2, 2005
Structure
AFTER LOWERING THE TAILGATE CONSUMER NOTICED PASSENER SIDE TAILGTATE STRAP WAS BROKEN. *AK *TC
NHTSA ODI #10101149
Mileage unknown · Mar 1, 2005
Structure
THE GALVANIZED STEEL TAILGATE SUPPORT CABLES THAT RETAIN THE TAILGATE IN THE FULL OPEN HORIZONTAL POSITION CORRODED /WEAKENED, AND FRACTURED. THE TAILGATE SUDDENLY DROPPED, AND STRUCK THE TOP SURFACE OF THE REAR BUMPER.*AK
NHTSA ODI #10113229
92,000 miles · Feb 22, 2005
Electrical SystemEngine And Engine CoolingEquipment
2004 TAIL GATE ASS FAILED REPLACED AFTER MARKET PARTS 2004 BACK UP LIGHTS IN/OP;004 INTERRIOR LIGHT WILL NOT TURN OFF/ OVER RIDE BOTTON USED TO SAVE BATTERY2005 LEFT FRONT HUB ASS REPLACED. 004 RIGHT FRONT HUB ASS REPLACED;005 FRONT END REPLACED/PITTMAN/TIE RODS;2004 OIL FILTER LEAK / TIGHTENED 2004 REAR EMERGENCY BR…
Read full complaint
2004 TAIL GATE ASS FAILED REPLACED AFTER MARKET PARTS 2004 BACK UP LIGHTS IN/OP;004 INTERRIOR LIGHT WILL NOT TURN OFF/ OVER RIDE BOTTON USED TO SAVE BATTERY2005 LEFT FRONT HUB ASS REPLACED. 004 RIGHT FRONT HUB ASS REPLACED;005 FRONT END REPLACED/PITTMAN/TIE RODS;2004 OIL FILTER LEAK / TIGHTENED 2004 REAR EMERGENCY BRAKES IN/OP 5 LEFT EMERGENCY BRAKE DRUM REPLACED;005 RIGHT EMERGENCY BRAKE DRUM REPLACED 2005 GAS SENDING UNIT REPLACED ERADIC BEHAVIOR 2004 LEFT BRAKE SHOE REPLACED ;004 RIGHT BRAKE SHOE REPLACED;005 LEFT BRAKE SHOE REPLACED FRONT;005 RIGHT BRAKE SHOE REPLACED FRONT 2005 LEFT BRAKE SHOE REPLACED REAR;005 RIGHT BRAKE SHOE REPLACED REAR;005 U JOINTS REPLACED;04 BATTERY REPLACED 2005 TRANSMISSION SHOWING SIGNS OF WEAR;005 REAR END {3.42} LOCKER CLANGS BETWEEN 1ST AND REVVED. 004 4 TIRES 005 4 TIRES 2004 DOOR HINGES FREEZE UP LUBE;005 TAIL GATE HINGES SHOW WEAR 2005 PARTS 4 EA TIE RODS/O/RING TYPE BRAKE SHOESAND DRUMS/U JOINTS. I HAVE FOR INSPECTION.*AK
NHTSA ODI #10111922
36,500 miles · Feb 21, 2005
Unknown Or Other
BOTH TAILGATE STRAPS BROKE WHILE OPENING TAILGATE ON MY 2001 CHEVROLET S10 XTREME. BOTH STRAPS ARE COMPLETLY RUSTED THROUGH. TRUCK HAS A TONOU COVER TO PROTECT BED AND TAILGATE FROM WEATHERING AND ELEMENTS. DENTED TAILGATE DUE TO FAILURE.
NHTSA ODI #10111872
Mileage unknown · Feb 9, 2005
Fuel System, Gasoline
THE FUEL TANK LEAKED GAS, AND HAS BEEN REPLACED TWICE, BUT THE PROBLEM RECURRED. THIS IS DANGEROUS BECAUSE THE VEHICLE CAN CATCH ON FIRE. MANUFACTURER HAS BEEN CONTACTED BY CONSUMER.*AK
NHTSA ODI #10111228
24,880 miles · Jan 29, 2005
Structure
ON JAN 29,2005 WE WERE PREPARING TO LOAD GROCERIES INTO THE BED OF THE TRUCK. WE OPENED THE TAILGATE AND BOTH OF THE SUPPORT CABLES SNAPPED CAUSING THE TAILGATE TO FALL ONTO THE BUMPER. WE HAVEN'T MADE ARRANGEMENTS FOR REPAIR YET AS I WAS CHECKING TO SEE IF THERE HAS BEEN ANY TYPE OF RECALL. I HAD KNOWN OF THE RECALL FOR THE SI…
Read full complaint
ON JAN 29,2005 WE WERE PREPARING TO LOAD GROCERIES INTO THE BED OF THE TRUCK. WE OPENED THE TAILGATE AND BOTH OF THE SUPPORT CABLES SNAPPED CAUSING THE TAILGATE TO FALL ONTO THE BUMPER. WE HAVEN'T MADE ARRANGEMENTS FOR REPAIR YET AS I WAS CHECKING TO SEE IF THERE HAS BEEN ANY TYPE OF RECALL. I HAD KNOWN OF THE RECALL FOR THE SILVERADO AND THOUGHT THE S-10 MAY BE INCLUDED.*AK
NHTSA ODI #10108222
34,455 miles · Jan 27, 2005
Structure
TAILGATE CABLES BROKE WHEN LOWERING TAILGATE. *AK
NHTSA ODI #10108056
40,000 miles · Jan 27, 2005
Structure
TAILGATE WAS PLACED IN DOWN POSITION AND WEIGHT WAS PLACED ON TAILGATE. TAILGATE STRAP ON LEFT SIDE FAILED. OAD ON TAILGATE SHIFTED AND WAS CAUGHT BY ME BEFORE IT HIT THE GROUND. AILURE HAS NOT BEEN REPAIRED. WILL HAVE TO FIX SOON.*AK
NHTSA ODI #10108018
103,000 miles · Jan 13, 2005
Structure
THE TAILGATE CABLES SNAPPED WHILE I WAS STANDING ON THE TAILGATE. THE TAILGATE DROPPED A FEW INCHES, UNTIL STOPPED BY THE BUMPER. I FELL OFF AND THE TAILGATE WAS SLIGHTLY DENTED. I WAS NOT SERIOUSLY HURT. *NM
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA05008 · Tailgate Support Cables
Opened Apr 14, 2005 · Closed May 19, 2006
Status: closed (inferred from source dates) · Latches/locks/linkages:tailgate:latch
GENERAL MOTORS IS CONDUCTING A SPECIAL POLICY PROGRAM FOR 903,464 OWNERS OF 2000 - 2003 MODEL S/T VEHICLES THROUGH WHICH OWNERS MAY, AT THEIR OPTION, EITHER (1) PERIODICALLY INSPECT THE TAILGATE SUPPORT CABLES INSTALLED IN THEIR VEHICLE AND HAVE THE CABLES REPLACED IF THE CABLE COATING EXHIBITS ANY INDICATIONS OF DAMAGE OR DETERIORATION OR (2) REQUEST THAT THE TAILGATE SUPPORT CABLES BE REPLACED FREE OF CHARGE. GM WILL HONOR ALL REQUESTS BY OWNERS WHO OPT FOR REPLACEMENT WITHOUT QUESTION REGARDLESS OF THE CONDITION OR APPEARANCE OF THE CABLES. GM HAS AGREED TO MAIL REMINDER NOTIFICATIONS TO OWNERS EVERY TWO YEARS UNTIL THE TAILGATE SUPPORT CABLES HAVE BEEN REPLACED OR UNTIL THE VEHICLE IS 12 YEARS OLD.ODI'S INVESTIGATION INDICATES THAT A SIGNIFICANT MAJORITY OF THE REPORTED COMPLAINTS (87%) AND INJURIES (94%) HAVE OCCURRED IN MY 2000 - 2003 S/T VEHICLES.
RQ04012 · Tailgate Support Cable(s) Break
Opened Nov 22, 2004 · Closed Apr 14, 2005
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut
ODI IS UPGRADING RQ04-012 AND OPENING AN EA TO INVESTIGATE THE TAILGATE SUPPORT CABLES INSTALLED IN 1998 - 2004 MODEL YEAR SONOMA AND S10 MODEL VEHICLES.GENERAL MOTORS IS CONDUCTING RECALL CAMPAIGN 04V-129 TO REPLACE THE TAILGATE SUPPORT CABLES ORIGINALLY INSTALLED IN CERTAIN MODEL YEAR 2000-2004 SIERRAS AND SILVERADOS AND CERTAIN MODEL YEAR 2002-2004 AVALANCHES AND ESCALADE EXTS (C/K MODELS).GENERAL MOTORS HAS ADVISED ODITHAT THE TAILGATE SUPPORT CABLES INSTALLED IN THE SUBJECT VEHICLES WERE FABRICATED USING IDENTICAL OR SIMILAR SHEATHING MATERIAL AS THE RECALLED VEHICLES.HOWEVER,GENERAL MOTORS HAS ADVISED ODI THAT SONOMA AND S-10 VEHICLES DIFFER FROM C/K MODELS IN SEVERAL WAYS: THE VEHICLE HEIGHT IS LOWER; THE TAILGATE DISPLACEMENT (DROP) WHEN NOT SUPPORTED BY THE CABLES IS SMALLER AND THE TAILGATE COMES TO REST AT A LESS SEVERE TIP ANGLE WHEN NOT SUPPORTED BY THE CABLES; THE TAILGATE MASS IS SMALLER; AND THE SIZE, PAYLOAD, AND USAGE CHARACTERISTCIS ARE LESS DEMANDING THAN C/K MODEL VEHICLES.GM ALSO STATED THAT SONOMA AND S-10 WARRANTY CLAIM INFORMATION INDICATES A LOWER CLAIM COUNT AND A LOWER CLAIM RATE THAN RECALLED C/K MODELS.NOTWITHSTANDING THE ABOVE INFORMATION, ODI HAS RECEIVED AN ADDITIONAL 73 NON-INJURY COMPLAINTS AND 10 INJURY COMPLAINTS ON THE SUBJECT VEHICLES DURING RQ04-012 (SINCE NOVEMBER 2004 TO DATE), WHICH JUSTIFIES OPENING AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS ISSUE.
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Additional source detail variants (4)
Fuel System, Gasoline:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Gasoline
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Other:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Other
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
2001 Chevrolet S10 Problems, Complaints & Recalls | Skip That Year
Illustration