NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
230 reports32,000 miles · Jun 27, 2017
Fuel/propulsion SystemFire
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. WHILE DRIVING 2 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO ACCELERATE. THE CONTACT OBSERVED FLAMES UNDER THE VEHICLE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE FIRE DEPARTMENT STATED THAT THE FIRE OCCURRED DUE TO A FUEL LEAK. PRIOR TO THE FIRE, THER…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. WHILE DRIVING 2 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO ACCELERATE. THE CONTACT OBSERVED FLAMES UNDER THE VEHICLE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE FIRE DEPARTMENT STATED THAT THE FIRE OCCURRED DUE TO A FUEL LEAK. PRIOR TO THE FIRE, THERE WERE NO LEAKS PRESENT. THE CONTACT ALSO STATED THAT THE FIRE OCCURRED AFTER THE VEHICLE WAS FUELED. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT A CASE MANAGER WOULD BE ASSIGNED TO THE CASE. THE FAILURE MILEAGE WAS APPROXIMATELY 32,000.
NHTSA ODI #11001693
121,000 miles · Jun 25, 2017
Electrical System
PASSLOCK SYSTEM; CAR WILL RANDOMLY (TEMPERATURE BASED?) REFUSE TO START DUE TO POORLY CONSTRUCTED PASSLOCK SENSOR. I KEEP MY DASH APART SO I CAN POKE AT THE CONTACTS (CORRODED? CHEAP TIN PLATING) TO HOTWIRE MY CAR WHEN IT LOCKS OUT. TOOK 20 MINUTES TO GO SEE IF MY WIFE WAS OK AT THE ER, THANKS CHEVY!
NHTSA ODI #11001289
Mileage unknown · Jun 8, 2017
Engine
2002 CHEVROLET MONTE CARLO. CONSUMER WRITES IN REGARDS TO ENGINE FAILURE AND REQUESTS REIMBURSEMENT FOR ENGINE REPAIRS. *SMD THE CONSUMER STATED THE ENGINE FAILED WHEN OIL GOT ONTO THE ENGINE AND CAUGHT FIRE. THE CONSUMER HAD NOT RECEIVED A RECALL UNTIL AFTER THE FAILURE. THE CONSUMER HAD THE ENGINE REPLACED. THE CONSUMER W…
Read full complaint
2002 CHEVROLET MONTE CARLO. CONSUMER WRITES IN REGARDS TO ENGINE FAILURE AND REQUESTS REIMBURSEMENT FOR ENGINE REPAIRS. *SMD THE CONSUMER STATED THE ENGINE FAILED WHEN OIL GOT ONTO THE ENGINE AND CAUGHT FIRE. THE CONSUMER HAD NOT RECEIVED A RECALL UNTIL AFTER THE FAILURE. THE CONSUMER HAD THE ENGINE REPLACED. THE CONSUMER WOULD LIKE TO BE REIMBURSED FOR THE COST OF THE ENGINE REPLACEMENT. *JS
NHTSA ODI #10955888
170,000 miles · May 22, 2017
EngineFire
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. WHEN THE VEHICLE WAS STARTED, THE CONTACT HEARD A LOUD POPPING SOUND. THE CONTACT STATED THAT THE VEHICLE CAUGHT ON FIRE FROM THE ENGINE COMPARTMENT. THE FIRE DEPARTMENT WAS NOTIFIED AND WAS ABLE TO EXTINGUISH THE FIRE. THERE WERE NO INJURIES AND A FIRE REPORT WAS NOT FILED. THE…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. WHEN THE VEHICLE WAS STARTED, THE CONTACT HEARD A LOUD POPPING SOUND. THE CONTACT STATED THAT THE VEHICLE CAUGHT ON FIRE FROM THE ENGINE COMPARTMENT. THE FIRE DEPARTMENT WAS NOTIFIED AND WAS ABLE TO EXTINGUISH THE FIRE. THERE WERE NO INJURIES AND A FIRE REPORT WAS NOT FILED. THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED PER NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.
NHTSA ODI #10990882
Mileage unknown · May 16, 2017
Unknown Or Other
I TOOK MY VEHICLE TO HAVE SERVICE DONE ON A RECALL INVOLVING POTENTIAL UNDER HOOD FIRE TO REPLACE VALVE COVERS. THE OIL WAS/IS LEAKING ONTO THE MANIFOLD AND CAUSING THE CAR TO SMOKE. I BARELY DRIVE THIS CAR AND IT IS STILL LEAKING OIL ONTO THE MANIFOLD AND SMOKING. NOW THE DEALERSHIP WILL NOT FIX WHAT THEY SUPPOSEDLY FIXED.
NHTSA ODI #10985900
Mileage unknown · Apr 25, 2017
Electrical System
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THERE WERE VARIOUS ELECTRICAL SHORTS IN THE VEHICLE, WHICH PREVENTED THE WINDOWS FROM GOING UP AND DOWN. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND SEVERAL INDEPENDENT MECHANICS FOR DIAGNOSTIC TESTING. THE MANUFACTURER PROVIDED NO SOLUTION AND THE …
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THERE WERE VARIOUS ELECTRICAL SHORTS IN THE VEHICLE, WHICH PREVENTED THE WINDOWS FROM GOING UP AND DOWN. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND SEVERAL INDEPENDENT MECHANICS FOR DIAGNOSTIC TESTING. THE MANUFACTURER PROVIDED NO SOLUTION AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS NOT AVAILABLE.
NHTSA ODI #10980421
140,000 miles · Dec 23, 2016
Electrical System
HAD ISSUES WITH ELECTRICAL IN 2015 IN WHICH GAS GAUGE AND OTHER GAUGES, SPEEDOMETER WERE "BOUNCING". AUTO REPAIR DETERMINED IT WAS THE FUEL PUMP AND REPLACED IT TO THE TUNE OF $600. THIS YEAR, WHILE DRIVING AT HIGHWAY SPEEDS WHEN CAR SUDDENLY LOOSES ALL POWER AND TURNS OFF. BROUGHT BACK TO SAME REPAIR SHOP WHO STATED BATTERY CAB…
Read full complaint
HAD ISSUES WITH ELECTRICAL IN 2015 IN WHICH GAS GAUGE AND OTHER GAUGES, SPEEDOMETER WERE "BOUNCING". AUTO REPAIR DETERMINED IT WAS THE FUEL PUMP AND REPLACED IT TO THE TUNE OF $600. THIS YEAR, WHILE DRIVING AT HIGHWAY SPEEDS WHEN CAR SUDDENLY LOOSES ALL POWER AND TURNS OFF. BROUGHT BACK TO SAME REPAIR SHOP WHO STATED BATTERY CABLES WERE LOOSE AND TIGHTENED THEM FREE OF CHARGE. NOW 4-5 MONTHS LATER AND SAME ISSUE IS OCCURRING WHICH HAPPENED 4 TIMES TODAY. TWICE WHILE MAKING A HARD TURN. TERMINALS ARE COMPLETELY TIGHT. EARLIER THIS YEAR COULD NOT TURN IGNITION KEY AND TAPPED IT WITH A HAMMER TO GET IT TO TURN. I HAVE BEEN READING QUITE A BIT ABOUT AN IGNITION SWITCH RECALL, BUT NO MENTION OF IT BY THE DEALER FOR TWO RECALL FIXES THIS YEAR REGARDING THE IGNITION KEY AND FOB, AND SOME COVER ON THE ENGINE. *TR
NHTSA ODI #10937285
21,571 miles · Nov 15, 2016
Engine
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. WHILE THE VEHICLE WAS UNDERGOING A ROUTINE INSPECTION, THE TECHNICIAN NOTICED THAT THE BACK COVER GASKET WAS LEAKING OIL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 21,571.
NHTSA ODI #10926128
170,000 miles · Aug 15, 2016
Electrical System
ISSUES WITH THE BCM AND PASSLOCK SYSTEM. THE CAR WHILE ON AND DRIVING WILL DISPLAY SECURITY ALONGSIDE THE BATT GAUGE QUITS WORKING. IF SHUT OFF CAR WILL NOT START, AND LIGHT STAY ON. I HAVE TO DISCONNECT THE BATT FOR SOME TIME. WITH THE THE AUTO LIGHTS SOMETIMES COME ON DURING MID DAY WITH THE SUN SHINING. THIS IS BECOMING A HAS…
Read full complaint
ISSUES WITH THE BCM AND PASSLOCK SYSTEM. THE CAR WHILE ON AND DRIVING WILL DISPLAY SECURITY ALONGSIDE THE BATT GAUGE QUITS WORKING. IF SHUT OFF CAR WILL NOT START, AND LIGHT STAY ON. I HAVE TO DISCONNECT THE BATT FOR SOME TIME. WITH THE THE AUTO LIGHTS SOMETIMES COME ON DURING MID DAY WITH THE SUN SHINING. THIS IS BECOMING A HASSLE. I'D RATHER PURCHASE ANOTHER CAR THAN GO THREW DEALERSHIP HOOPS.
NHTSA ODI #10895843
57,000 miles · Jun 6, 2016
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. WHILE DRIVING AT ANY SPEED, THE CONTACT NOTICED A BURNING ODOR INSIDE THE VEHICLE CAUSED BY THE EMITTING OIL FROM THE ENGINE. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THEY WERE UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFI…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. WHILE DRIVING AT ANY SPEED, THE CONTACT NOTICED A BURNING ODOR INSIDE THE VEHICLE CAUSED BY THE EMITTING OIL FROM THE ENGINE. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THEY WERE UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 57,000. .....UPDATED 08/11/16 *BF
NHTSA ODI #10872816
Official recalls
4Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration