Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
210–25K
3525–50K
2950–75K
2875–100K
36100–150K
21150K+
170 reports with mileage · 60 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 55 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports24 fire reports7 injury reports
What owners actually said
230 reports
Mileage unknown · Jan 7, 2024
Fuel/propulsion System
My car has the engine 3.1 L automatic. On January 4, I was going to go run errands so I went out to my car and cranked it to start the engine but instead, I heard a loud explosion, causing the front tires of the car to go up in the air and then land back on the ground. Smoke started coming out from the hood and a fire almost got…
Read full complaint
My car has the engine 3.1 L automatic. On January 4, I was going to go run errands so I went out to my car and cranked it to start the engine but instead, I heard a loud explosion, causing the front tires of the car to go up in the air and then land back on the ground. Smoke started coming out from the hood and a fire almost got started. I was scared to half to death causing me to almost have a heart attack. Morning inspection, I found that the intake manifold had exploded on the car and pieces of it were all over the engine. I feel that the pressure regulator may have been the culprit, but the plastic upper intake just literally blew up. Nobody was injured neighbors came out to see what the explosion had been, the window on my windshield cracked and major damage has been done to the Plenum. I have pictures but I’ve been unable to upload them but they are available. If you need them I went to Mission Chevrolet where I purchased the car but was referred to contact you in general. no recalls sent over this issue, but have I been driving when the explosion occurred it may have caused fatalities to myself, and perhaps other drivers on the freeway.
NHTSA ODI #11564051
180,000 miles · Apr 13, 2021
Electrical System
MY INSTRUMENT CLUSTER WILL RESET WHILE I AM DRIVING. THE GUAGES WILL SWEEP AND ALL THE WARNING LIGHTS COME ON AND THE CAR WILL DING AS IF IT WAS JUST STARTED HOWEVER THE CAR NEVER STALLS AND THE RADIO STAYS ON ALONG WITH EVERYTHING ELSE.
NHTSA ODI #11407830
96,000 miles · Apr 12, 2021
Fuel System, DieselFire
TL* THE CONTACT OWNED 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE VEHICLE WAS SERVICED AT APPLE VALLEY CHEVROLET (650 FOXCROFT AVE, MARTINSBURG, WV 25401) FOR A FUEL CONTROL SENSOR REPLACEMENT. THE VEHICLE WOULD NOT START AFTER IT WAS SERVICED AT THE DEALER THEN CAUGHT ON FIRE WHILE THE CONTACT'S HUSBAND WAS TRYING T…
Read full complaint
TL* THE CONTACT OWNED 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE VEHICLE WAS SERVICED AT APPLE VALLEY CHEVROLET (650 FOXCROFT AVE, MARTINSBURG, WV 25401) FOR A FUEL CONTROL SENSOR REPLACEMENT. THE VEHICLE WOULD NOT START AFTER IT WAS SERVICED AT THE DEALER THEN CAUGHT ON FIRE WHILE THE CONTACT'S HUSBAND WAS TRYING TO START IT UP. THE CONTACT'S HUSBAND WAS ABLE TO PUT OUT THE FIRE WITH A HOSE. NO POLICE REPORT WAS FILED. THE VEHICLE WAS STILL AT THE CONTACT'S RESIDENCE. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 96,000.
NHTSA ODI #11407573
126,000 miles · Mar 22, 2020
EngineFuel/propulsion SystemUnknown Or OtherFire
STARTED CAR AND HEARD A LOUD BOOM AND THEN SMOKE UNDER THE HOOD AND INTAKE COVER AND HARNESS ON FIRE
NHTSA ODI #11318928
240,000 miles · Nov 5, 2019
Electrical System
WAS GOING ABOUT 55-60 MPH DOWN THE HIGHWAY AND MY RPMS STARTED TO DROP AND I LET OFF GAS AND IT JUST DIED. IT CRANKS AND TURNS OVER BUT WILL NOT FIRE
NHTSA ODI #11278261
165,000 miles · May 11, 2019
EngineFuel/propulsion System
THE CAR'S FUEL GAGE STOPPED WORKING. THE CAR WOULDN'T TURN OVER WHEN I STARTED IT SO I GOT A NEW BATTERY SINCE IT SAID MY OLD ONE WAS BAD, BUT IT'S STILL NOT WORKING. THE SECURITY LIGHT IS ON AND I DON'T UNDERSTAND WHY AND IF THIS IS AFFECTING IT FROM TURNING ON
NHTSA ODI #11207045
Mileage unknown · Mar 11, 2019
Service Brakes
THE BRAKE LINES ARE RUSTED OUT CAR ONLY HAS 55,000 MILES IT IS SITTING OUTSIDE BUT ON BLACKTOP IN OUR DRIVE WAY. WE WENT TO USE IT AND THE DASH LIT LIKE MAD CHECKED BRAKE FLUID IT WAS LOW DROVE IT AND ALMOST DID,NT MAKE IT HOME WITH BRAKES.
NHTSA ODI #11185841
Mileage unknown · Aug 16, 2018
Air BagsService Brakes
ABS LIGHT TRACTION CONTROL LIGHT AND AIR BAG LIGHT ARE CONSTANTLY ON..,SINCE IVE OWNED IT
NHTSA ODI #11120458
60,000 miles · Nov 19, 2017
Electronic Stability Control (esc)Service BrakesVehicle Speed Control
ABOUT OCTOBER 10TH, 2017 I WAS COMING UP ON A TRAFFIC LIGHT AND WHEN I APPLIED THE BRAKES, THE PEDAL WOULD NOT GO DOWN. I WAS GOING ABOUT 45 MPH BY THE GRACE OF GOD I WAS ABLE TO BLAST THROUGH AN INTERSECTION AND MISS EVERYONE, EVERYTHING!. RATTLED I GUESS I SHUT THE CAR OFF WHEN I REGAINED MY COMPOSER I STARTED THE CAR AND EVER…
Read full complaint
ABOUT OCTOBER 10TH, 2017 I WAS COMING UP ON A TRAFFIC LIGHT AND WHEN I APPLIED THE BRAKES, THE PEDAL WOULD NOT GO DOWN. I WAS GOING ABOUT 45 MPH BY THE GRACE OF GOD I WAS ABLE TO BLAST THROUGH AN INTERSECTION AND MISS EVERYONE, EVERYTHING!. RATTLED I GUESS I SHUT THE CAR OFF WHEN I REGAINED MY COMPOSER I STARTED THE CAR AND EVERYTHING WAS FINE. I DID NOT WANT TO BELIEVE THIS HAPPENED! I THOUGHT I DID SOMETHING WRONG MAYBE HAD MY FOOT UNDER THE BRAKE PEDAL OR SOMETHING. HAVE BEEN DRIVING THE CAR SINCE 2 WEEKS AGO WAS STRANDED IN A PARKING LOT, WOULD NOT START. HAD THE CAR TOWED HOME, TRIED TO START IT AND STARTED RIGHT UP. NOW SERVICE TRACK LIGHT IS ON AND ANTI LOCK BRAKES IS ON AND SERVICE ENGINE LIGHT IS ON SOMETIME AND THE CRUISE LIGHT IS ON. YESTERDAY WIFE WAS DRIVING THE CAR AND SAME THING NO BRAKES, YOU COULD NOT PUSH THE PEDAL DOWN IT IS AS IF THERE IS SOMETHING UNDER THE PEDAL IT'S THAT SOLID. MY CONCERN FOR MY OWN SAFETY AS WELL AS OTHER MONTE CARLO OWNERS IS MOST IMPORTANT. IF EITHER TIME WE WOULD HAVE BEEN ON A EXPRESSWAY WHERE WE COULD NOT TURN TO A SHOULDER THIS WOULD BE CATASTROPHIC . CALLED THE SERVICE MANAGER WHERE THE CAR WAS PURCHASED, ALSO HARBOR CHEVY IN MICHIGAN CITY, IN AND GATES CHEVY IN SOUTH BEND, INDIANA, ALL SAID THEY HAVE NEVER HEARD OF THIS BEFORE. GOT ON THE INTERNET AND FOUND SIMILAR POSTS IN CAR COMPLAINTS WITHOUT ANY PROBLEM, SEEMS ODD GM DOES NOT KNOW ANYTHING ABOUT THIS. FOR EVERY ONES OWN SAFETY THIS SHOULD BE A REDUNDANT SYSTEM IN OLDER CARS YOU WOULD NOT LOSE ALL BRAKES. COULD UNDERSTAND IF YOU LOST ANTI LOCK PART BUT STILL COULD STOP. THIS HAS TO BE A OVERLOOKED FLAW IN DESIGN AND GM SHOULD BE MADE TO CORRECT THIS BEFORE SOMEONE GETS KILLED. IF SOMEONES BEEN KILLED BY THIS HOW COULD THEY TELL YOU THAT HE LOST HIS BRAKES? THANK YOU MIKE
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
2002 Chevrolet Monte Carlo Problems, Complaints & Recalls | Skip That Year
Illustration