TL* THE CONTACT OWNS A 1997 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHILE DRIVING 85 MPH, THE STEERING WHEEL BECAME LOOSE AND CAUSED THE CONTACT TO TEMPORARILY LOSE CONTROL OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN ADVISED THAT THE LOWER PINION BEARING FOR THE STEERING RACK NEEDED TO BE REPL…
Read full complaint
TL* THE CONTACT OWNS A 1997 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHILE DRIVING 85 MPH, THE STEERING WHEEL BECAME LOOSE AND CAUSED THE CONTACT TO TEMPORARILY LOSE CONTROL OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN ADVISED THAT THE LOWER PINION BEARING FOR THE STEERING RACK NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 03V527000 (STEERING:RACK AND PINION) HOWEVER, THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 220,000.
NHTSA ODI #10488701
Mileage unknown · Mar 16, 2008
Electrical SystemExterior LightingFuel System, Other
MY 97 CHEVY MONTE CARLO HAS HAD NO LOWER BRAKE LIGHTS FOR SOME TIME . I HAD MY CAR CHECKED BY AN AUTO ELECTRICIAN AND WAS TOLD THAT THE PROBLEM WAS SO SEVERE AND IT WOULD PROBABLY NEVER FIND THE SOURCE OF THE PROBLEM. I AM VERY CONCERNED WITH THIS ISSUE BEING IT MAY CAUSE SERIOUS INJURY TO MY SELF/FAMILY OR OTHERS. AS I DRIVE O…
Read full complaint
MY 97 CHEVY MONTE CARLO HAS HAD NO LOWER BRAKE LIGHTS FOR SOME TIME . I HAD MY CAR CHECKED BY AN AUTO ELECTRICIAN AND WAS TOLD THAT THE PROBLEM WAS SO SEVERE AND IT WOULD PROBABLY NEVER FIND THE SOURCE OF THE PROBLEM. I AM VERY CONCERNED WITH THIS ISSUE BEING IT MAY CAUSE SERIOUS INJURY TO MY SELF/FAMILY OR OTHERS. AS I DRIVE ON THE ROAD I NOTICE MANY AUTOS OF THE SAME YEAR AND TYPE HAVE THE SAME PROBLEM SO I KNOW ITS NOT ONLY MY VEHICLE .I THOUGHT IT COULD OF BEEN THE FACTORY INSTALLED SECURITY SYSTEM SO I HAD IT UNINSTALLED TO COME TO THE FACT THAT IT WAS NOT THE SECURITY SYSTEM AFTER ALL. PLEASE HELP WITH THIS ISSUE . THIS IS MY ONLY SOURCE OF TRANSPORTATION AS I AM DISABLED AND CANNOT AFFORD ANOTHER VEHICLE . I HAVE PUT CONSTANT REPAIRS ON THIS CAR , FUEL INJ TANK, ETC. AGAIN PLEASE ADDRESS THIS URGENT ISSUE. *TR
NHTSA ODI #10221331
127,000 miles · Jul 5, 2005
Steering
DT: CONSUMER HAD RECALL 03V527000 REPAIRS DONE IN FEBRUARY WHICH WAS SUPPOSE TO BE PREVENTIVE RECALL WORK. VEHICLE WAS STILL EXPERIENCING LOSS OF POWER STEERING. CONSUMER SAID WHEN SHE TURNED LEFT THE VEHICLE DEMONSTRATED HIGH RESISTANCE. TOOK VEHICLE TO DEALER AFTER MANUFACTURER ADVISED HER TO TAKE IT TO ANY DEALER. THE …
Read full complaint
DT: CONSUMER HAD RECALL 03V527000 REPAIRS DONE IN FEBRUARY WHICH WAS SUPPOSE TO BE PREVENTIVE RECALL WORK. VEHICLE WAS STILL EXPERIENCING LOSS OF POWER STEERING. CONSUMER SAID WHEN SHE TURNED LEFT THE VEHICLE DEMONSTRATED HIGH RESISTANCE. TOOK VEHICLE TO DEALER AFTER MANUFACTURER ADVISED HER TO TAKE IT TO ANY DEALER. THE DEALER INSISTED THAT SHE GO BACK TO DEALER WHO DID THE ORIGINAL RECALL REPAIRS. DEALER CHECKED VEHICLE AFTER SHE AGREED TO PAY FOR THE LABOR. MECHANIC CHECKED VEHICLE AND CLAIMED IT WAS RACK AND PINION PROBLEM. *AK
NHTSA ODI #10127552
121,000 miles · Sep 13, 2004
SteeringCrash
WHILE MAKING A RIGHT TURN AT 5 MPH, THE VEHICLE LOST POWER, CAUSING THE CONSUMER'S VEHICLE TO HIT A POLE. *AK THE CONSUMER STATED THE PROBLEM WAS DUE TO STEERING RACK FAILURE. *JB
NHTSA ODI #10083913
120,000 miles · Sep 10, 2004
EquipmentExterior LightingSteering
RECALL 03V527000 CONCERNING STEERING GEAR BEARINGS. CONSUMER HAD A CONCERN WHILE MAKING A LEFT TURN THE VEHICLE LOST STEERING CONTROL. ALSO, AIR CONDITIONER/ HAZARD LIGHTS, AND DRIVER'S SIDE POWER WINDOW FAILED TO OPERATE. DEALER WAS NOT NOTIFIED. *AK
NHTSA ODI #10091815
Mileage unknown · Jul 19, 2004
Steering
VEHICLE'S STEERING WENT OUT ALL OF A SUDDEN WHILE DRIVING. *MR RECALL #750283. THE CONSUMER REQUESTED HER MONEY BACK. *SC IN JAN. 2004 A RECALL WAS ISSUED ON THE STEERING RACK AND PINION. THE CONSUMER WAS TOLD TO SEND IN HER PAPERWORK AND A REIMBURSEMENT CHECK WOULD BE SENT TO HER, BUT INSTEAD THE CONSUMER RECEIVED A DEN…
Read full complaint
VEHICLE'S STEERING WENT OUT ALL OF A SUDDEN WHILE DRIVING. *MR RECALL #750283. THE CONSUMER REQUESTED HER MONEY BACK. *SC IN JAN. 2004 A RECALL WAS ISSUED ON THE STEERING RACK AND PINION. THE CONSUMER WAS TOLD TO SEND IN HER PAPERWORK AND A REIMBURSEMENT CHECK WOULD BE SENT TO HER, BUT INSTEAD THE CONSUMER RECEIVED A DENIAL LETTER. THE MANUFACTURER STATED THE REASON FOR THE DENIAL OF REIMBURSEMENT WAS BECAUSE THE CONSUMER DID NOT HAVE THE VEHICLE SERVICED AT A GM DEALER. *JB
NHTSA ODI #10083751
64,897 miles · May 4, 2004
Steering
CONSUMER'S CLAIM WAS DENIED FOR REIMBURSEMENT SINCE THE REPAIRS WERE DONE PRIOR TO RECEIVING THE RECALL NOTICE. *PH
NHTSA ODI #10072107
Mileage unknown · Apr 21, 2004
Steering
STEERING WHEEL DID NOT TURN UPON STARTING THE VEHICLE. CONSUMER TOOK VEHICLE TO A MECHANIC, AND HE DETERMINED THE RACK AND PINION STEERING NEEDED TO BE REPLACED. *AK
NHTSA ODI #10068620
Mileage unknown · Apr 20, 2004
Air BagsService Brakes, HydraulicSteeringCrashInjury
WHILE DRIVING 55 MPH STEERING WHEEL LOCKED UP. CONSUMER TRIED TO UNLOCK IT BUT WAS UNABLE TO DO SO. CONSUMER APPLIED THE BRAKES AND PEDAL WENT TO THE FLOOR. CONSUMER LOST CONTROL OF THE VEHICLE, AND HIT A MEDIAN STEEL BARRIER. THEN, VEHICLE ROLLED THREE TIMES AND LANDED UPSIDE DOWN ON THE HIGHWAY. UPON IMPACT, BOTH FRONT…
Read full complaint
WHILE DRIVING 55 MPH STEERING WHEEL LOCKED UP. CONSUMER TRIED TO UNLOCK IT BUT WAS UNABLE TO DO SO. CONSUMER APPLIED THE BRAKES AND PEDAL WENT TO THE FLOOR. CONSUMER LOST CONTROL OF THE VEHICLE, AND HIT A MEDIAN STEEL BARRIER. THEN, VEHICLE ROLLED THREE TIMES AND LANDED UPSIDE DOWN ON THE HIGHWAY. UPON IMPACT, BOTH FRONTAL AIRBAG DID NOT DEPLOY. DRIVER SUSTAINED NECK AND BACK INJURIES AND WAS TRANSPORTED BY AMBULANCE, TO THE HOSPITAL. VEHICLE WAS TOTALED. *AK
NHTSA ODI #10067494
Mileage unknown · Mar 11, 2004
Steering
NHTSA RECALL# 03V527000 SUBJECT:STEERING GEAR BEARINGS. CONSUMER RECEIVED THE NOTICE FOR THE RECALL THE FIRST PART OF FEBRUARY. CONSUMER CALLED THE DEALER SIX TIMES. DEALER DID NOT HAVE THE TOOLS TO FIX THE RECALLED PART, AND TOLD THE CONSUMER TO CALL BACK IN APRIL. THE VEHICLE WAS HAVING STEERING PROBLEMS.*AK
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA03019 · Power Rack And Pinion Steering Failure
Opened Sep 15, 2003 · Closed Dec 18, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
Additional source detail variants (2)
Steering
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
Steering:rack And Pinion
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA98019 · Degraded Braking Performance
Opened Aug 31, 1998 · Closed Dec 13, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE98023 · Degraded Braking Performance
Opened Apr 23, 1998 · Closed Aug 31, 1998
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
No summary supplied.
1997 Chevrolet Monte Carlo Problems, Complaints & Recalls | Skip That Year
Illustration