WHILE DRIVING 50 MPH VEHICLE SKIDDED ON AN ICY PATCH ON THE ROAD, DRIVER LOST CONTROL, AND VEHICLE HIT AN EMBANKMENT HEAD ON. UPON IMPACT, DUAL AIRBAGS DID NOT DEPLOY. DRIVER SUSTAINED SEVERE INJURIES TO THE FACE AND NECK, AND PASSENGER SUSTAINED A CONCUSSION AND A BLACK EYE. DUE TO SEVERE DAMAGE THE VEHICLE WAS TOTALED. *A…
Read full complaint
WHILE DRIVING 50 MPH VEHICLE SKIDDED ON AN ICY PATCH ON THE ROAD, DRIVER LOST CONTROL, AND VEHICLE HIT AN EMBANKMENT HEAD ON. UPON IMPACT, DUAL AIRBAGS DID NOT DEPLOY. DRIVER SUSTAINED SEVERE INJURIES TO THE FACE AND NECK, AND PASSENGER SUSTAINED A CONCUSSION AND A BLACK EYE. DUE TO SEVERE DAMAGE THE VEHICLE WAS TOTALED. *AK *LA
NHTSA ODI #10065434
Mileage unknown · Apr 20, 2004
Air BagsService Brakes, HydraulicSteeringCrashInjury
WHILE DRIVING 55 MPH STEERING WHEEL LOCKED UP. CONSUMER TRIED TO UNLOCK IT BUT WAS UNABLE TO DO SO. CONSUMER APPLIED THE BRAKES AND PEDAL WENT TO THE FLOOR. CONSUMER LOST CONTROL OF THE VEHICLE, AND HIT A MEDIAN STEEL BARRIER. THEN, VEHICLE ROLLED THREE TIMES AND LANDED UPSIDE DOWN ON THE HIGHWAY. UPON IMPACT, BOTH FRONT…
Read full complaint
WHILE DRIVING 55 MPH STEERING WHEEL LOCKED UP. CONSUMER TRIED TO UNLOCK IT BUT WAS UNABLE TO DO SO. CONSUMER APPLIED THE BRAKES AND PEDAL WENT TO THE FLOOR. CONSUMER LOST CONTROL OF THE VEHICLE, AND HIT A MEDIAN STEEL BARRIER. THEN, VEHICLE ROLLED THREE TIMES AND LANDED UPSIDE DOWN ON THE HIGHWAY. UPON IMPACT, BOTH FRONTAL AIRBAG DID NOT DEPLOY. DRIVER SUSTAINED NECK AND BACK INJURIES AND WAS TRANSPORTED BY AMBULANCE, TO THE HOSPITAL. VEHICLE WAS TOTALED. *AK
NHTSA ODI #10067494
100,000 miles · Dec 10, 2003
Air BagsVehicle Speed ControlCrashInjury
WHILE WAITING AT A TRAFFIC LIGHT, THE VEHICLE WAS REAR ENDED. AS A RESULT, THE ACCELERATOR THROTTLE MALFUNCTIONED, CAUSING THE VEHICLE TO JUMP A CURB AND LAND IN A DITCH. UPON IMPACT, THE AIR BAGS DID NOT DEPLOY. THE DRIVER SUSTAINED SEVERE INJURIES TO HIS NECK AND BACK AND WAS TAKEN TO HOSPITAL FOR TREATMENT. *AK *SC …
Read full complaint
WHILE WAITING AT A TRAFFIC LIGHT, THE VEHICLE WAS REAR ENDED. AS A RESULT, THE ACCELERATOR THROTTLE MALFUNCTIONED, CAUSING THE VEHICLE TO JUMP A CURB AND LAND IN A DITCH. UPON IMPACT, THE AIR BAGS DID NOT DEPLOY. THE DRIVER SUSTAINED SEVERE INJURIES TO HIS NECK AND BACK AND WAS TAKEN TO HOSPITAL FOR TREATMENT. *AK *SC *JB
NHTSA ODI #10044835
67,158 miles · Sep 23, 2003
Air Bags
CONSUMER STATED THAT WHILE THE AUTOMOBILE WAS SITTING IN THE DRIVEWAY, THE AIR BAG BEGAN TO INFLATE ON THE DRIVER'S SIDE. HOWEVER, ON THE PASSENGER'S SIDE IT DID NOT INFLATE, IT IS STILL INTACT. THE VEHICLE WAS TOWED TO A DEALER, WHO STATED THAT THEY HAD NO ANSWER AS WHAT MADE THE AIR BAG INFLATE.*AK *TS *JB
NHTSA ODI #10032287
132,013 miles · Jan 27, 2003
Air BagsCrash
DURING A SNOW STORM I WAS IN A CAR ACCIDENT WHERE THE CAR IN FRONT OF ME ABRUPTLY STOPPED AND BECAUSE OF THE ROAD CONDITIONS I WAS UNABLE TO DECELERATE FAST ENOUGH AND I TRIED TO PULL TO THE SHOULDER OF THE ROAD TO AVOID HITTING THE OTHER CAR BUT I STILL SLID INTO THE OTHER CAR AND THEN HIT A TREE. THERE WAS EXTENSIVE DAMAGE…
Read full complaint
DURING A SNOW STORM I WAS IN A CAR ACCIDENT WHERE THE CAR IN FRONT OF ME ABRUPTLY STOPPED AND BECAUSE OF THE ROAD CONDITIONS I WAS UNABLE TO DECELERATE FAST ENOUGH AND I TRIED TO PULL TO THE SHOULDER OF THE ROAD TO AVOID HITTING THE OTHER CAR BUT I STILL SLID INTO THE OTHER CAR AND THEN HIT A TREE. THERE WAS EXTENSIVE DAMAGE(APPROX $5,000) DONE TO THE FRONT END OF MY CAR AND MY AIR BAGS NEVER DEPLOYED.
NHTSA ODI #10003502
Mileage unknown · Oct 9, 2001
Air BagsCrash
CONSUMER WAS TRAVELING ABOUT 60MPH ON HIGHWAY WHEN ANOTHER VEHICLE VEERED INTO CONSUMER'S LANE. UPON IMPACT, DRIVER'S SIDE AIRBAG DIDN'T DEPLOY. DEALERSHIP WAS AWARE OF PROBLEM. *AK
NHTSA ODI #897521
Mileage unknown · Mar 1, 2001
Air BagsCrash
VEHICLE INVOLVED IN A FRONTAL COLLISION OF 20-25 MPH WITH A STONE WALL. UPON IMPACT, BOTH AIR BAGS DID NOT DEPLOY. DEALER / MANUFACTURER WERE NOT NOTIFIED AT THIS TIME. PLEASE FEEL FREE TO PROVIDE ANY FURTHER DETAILS ON THIS MATTER. *AK
NHTSA ODI #881877
Mileage unknown · Aug 16, 2000
Air Bags
TECHNICAL SERVICE BULLETIN APPLIES:# 98839010/ SEQ# 228/ NHTSA ITEM # SB602269///WOODARD CHEVROLET; IN FAIRFIELD, CA. (707) 4227777 ( WHERE I TOOK IT FOR REPAIR ) REPORTS THAT THE PROBLEM IS A FAILED AIR BAG HARNESS.
NHTSA ODI #728112
Mileage unknown · May 20, 1999
Air Bags
AT 36,000 MILE THE AIR BAG LIGHT CAME ON, AND CONSUMER PULLED THE FUSE AND CHECKED FOR BLOWN FUSES. ONCE HE PUT FUSES BACK THE LIGHT WENT OFF. .AGAIN AT 37,000 MILES THE LIGHT CAME BACK ON AND STAYED ON. *AK
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA03019 · Power Rack And Pinion Steering Failure
Opened Sep 15, 2003 · Closed Dec 18, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
Additional source detail variants (2)
Steering
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
Steering:rack And Pinion
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA98019 · Degraded Braking Performance
Opened Aug 31, 1998 · Closed Dec 13, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE98023 · Degraded Braking Performance
Opened Apr 23, 1998 · Closed Aug 31, 1998
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
No summary supplied.
1997 Chevrolet Monte Carlo Problems, Complaints & Recalls | Skip That Year
Illustration